PepperBall LifeLite User manual

USER MANUAL
PBLIFELITE.COM

32 | LIFELITE™MOBILE
WARNINGS AND SAFETY ....................................................................................................................... PAGE 3
OPERATIONAL INSTRUCTIONS................................................................................................................ PAGE 7
BATTERY INSTALLATION........................................................................................................................ PAGE 8
LOADING/REPLACING CO2CARTRIDGES.................................................................................................. PAGE 9
LOADING PROJECTILES.........................................................................................................................PAGE 10
FIRING THE LIFELITE™MOBILE ..............................................................................................................PAGE 11
LASER ADJUSTMENT............................................................................................................................PAGE 12
CLEANING AND MAINTENANCE .............................................................................................................PAGE 13
WARRANTY AND DISCLAIMER...............................................................................................................PAGE 16
WARRANTY AND SERVICE INFO ............................................................................................................PAGE 17
TROUBLESHOOTING..............................................................................................................................PAGE 18
PRODUCT REGISTRATION......................................................................................................................PAGE 19
TABLE OF CONTENTS WARNINGS AND SAFETY
THIS LAUNCHER IS NOT A TOY AND IS INTENDED FOR SELF-DEFENSE ONLY. THIS PRODUCT LAUNCHES PROJECTILES
FROM THE BARREL. MISUSE MAY CAUSE SERIOUS INJURY OR DEATH. IMPROPER USE COULD ALSO RESULT IN
CRIMINAL PROSECUTION, FINES, IMPRISONMENT, AS WELL AS CIVIL LIABILITY. EXCEPT WHEN THE LAUNCHER IS IN
USE, ALWAYS MAKE SURE THAT THE TRIGGER SAFETY IS IN “SAFE MODE”. SEE ADDITIONAL SAFETY GUIDELINES AND
USER INSTRUCTIONS IN THIS MANUAL.
!WARNING
Congratulations on your purchase of the PepperBall®LifeLite™Mobile.
This launcher has been designed and manufactured by United Tactical Systems, LLC (UTS) to be reliable,
accurate and durable. When properly handled, the LifeLite™Mobile will give many years of dependable service.
Please take the time to read through this manual and become familiar with the LifeLite™Mobile parts,
operation, maintenance, and safety precautions before you attempt to load or fire this launcher. This manual
should be used as a reference when performing maintenance or re-familiarizing yourself with the launcher.
By purchasing this launcher, you assume total responsibility for its safe and lawful use. You must observe the
same safety precautions as you would with any firearm to ensure the safety of not only yourself, but everyone
around you. The operator should use caution at all times when maintaining and firing this launcher.
LIMITATIONS AND USAGE
There may be state or local limitations on purchase, possession, and use of the LifeLite™Mobile. Verify
local legal requirements in your state and locality to ensure you adhere to all legal requirements. The
user assumes the liability from unsafe or improper use or any action which constitutes a violation of any
applicable law or regulation.
The LifeLite™Mobile may be prohibited from certain premises, including government buildings, airports,
courthouses, schools, or other public spaces. Possessing a LifeLite™Mobile in a prohibited area may subject
user to criminal liability.
WARNING: If misused, this PepperBall®launcher can cause serious injury.
UTS shall not be liable for personal injury, loss of property, or loss of life resulting from the use of this weapon
under any circumstances, including any intentional, reckless, negligent or accidental discharges. By using
this PepperBall®launcher, you release UTS of any and all liability associated with its use.
All information in this manual is subject to change without notice. UTS reserves the right to make changes
and improvements to products without incurring any obligation to incorporate such improvements in
products previously sold.
IF YOU DO NOT ACCEPT LIABILITY, DO NOT USE THIS OR ANY PEPPERBALL®LAUNCHER.
WARNING: This product contains chemicals known to the State of California to cause cancer and birth
defects or other reproductive harm.
SAFETY IS YOUR RESPONSIBILITY!
The following safety information contains important warnings related to the proper use of the launcher, and
projectiles. Do not load, discharge or otherwise use this launcher until you have completely read this manual
and are familiar with its safety features, mechanical operation, and handling characteristics.

54 | LIFELITE™MOBILE
SAFETY SAFETY
PEPPERBALL®LIFELITE™Mobile
•Danger: Never aim or shoot at the head, face, eyes, ears, throat or spine. Impact in these areas could result
in unintended severe or permanent injury or death.
•Danger: Never look down the launch chamber of the launcher. Accidental discharge into the eyes may cause
permanent injury or death.
• Eye, face and ear protection should be worn when utilizing this system in training.
• Handle this launcher as if it were loaded at all times.
• Keep your finger off the trigger until ready to fire.
• Keep this launcher on “Safe Mode” until ready to fire.
• Always keep the launch chamber pointed down or in a safe direction.
• Never point or discharge your launcher at anything you do not intend to shoot.
• Never discharge your launcher at the personal property of others.
• Do not attempt to disassemble the launcher. Doing so will void the warranty.
• Keep exposed skin away from any escaping gas when in use and when installing or removing air supply.
• Use only PepperBall®authorized projectiles in this launcher. The use of any unauthorized projectiles in this
launcher will void all warranties.
• Any unauthorized modifications to the function of this launcher will void all warranties.
• Never point the laser directly at eyes and observe all safety warnings associated with the equipped laser.
• Always verify launcher is in “Safe Mode” and stored in a safe and secure location when not in use.
• USE CAUTION when engaging beyond 60 feet as accuracy is reduced beyond that distance.
WARNING! NEVER USE GAS CARTRIDGES OTHER THAN WHAT IS SPECIFIED IN THIS MANUAL.
WARNING! KEEP OUT OF REACH OF CHILDREN.
PEPPERBALL®INERT™AND LIVE SD™PROJECTILES
WARNING: FOR SELF-DEFENSE ONLY. The use of PepperBall®projectiles is for self-defense only. The contents
are dangerous — use with care.
PEPPERBALL LIVE SD™- The active ingredient in PepperBall®LIVE SD™projectiles (Red / Red Shell) is PAVA, a
pepper powder which is approximately 2.0% (LIVE).
PEPPERBALL INERT - Active ingredient in PepperBall®INERT™NONE (Purple / Purple shell) however contain
barium sulfate, and non-crystallineamorphous precipitated Silica powder and MAY CAUSE IRRITATION UPON
CONTACT OR INHALATION.
READ ENTIRE WARNING INCLUDED IN THIS PACKAGE PRIOR TO USE
Handle PepperBall®projectiles with care and follow proper cleanup procedure. PepperBall®projectiles
cause skin irritation, serious eye irritation, and may cause serious respiratory irritation. Exposure may result
in copious tears, temporary blindness, burning sensation, and difficulty breathing. The projectile should
never be ingested.
In case of accidental exposure, exit the exposure area. Remove contact lenses and contaminated clothing.
Flush eyes and affected areas with cool water. Do not rub or use creams, salves, lotions or oils which can
trap irritant on the skin. Discard contact lenses and wash exposed clothing before reuse. If exposure or
ingestion occurs, get medical advice/attention.
Keep all PepperBall®projectiles out of the reach of children. Store in a secure location with temperatures
not to exceed 150° F or below -15° F. PepperBall®projectiles have a shelf life of 2 years and should be safely
disposed of aer this period.
Please note that the LifeLite™Mobile operational use temperature is limited by the gas used. The LifeLite™
Mobile should only be used when the device temperature range is between 20° F and 120° F.
LIMITATIONS AND LIABILITY
PepperBall®launchers and projectiles cannot be carried on commercial airlines where they are accessible.
PepperBall®launchers and projectiles may also be prohibited at certain public buildings, such as schools,
courthouses and government offices.
There are some state or local limitations on purchase, possession, and use of PepperBall®launchers and
projectiles. Verify local legal requirements in your state and city to ensure possession and use is proper. The
user assumes the liability from unsafe or improper use or any action which constitutes a violation of any
applicable law or regulation.
Purchase and use of PepperBall®launchers and projectiles is limited to individuals who are at least 18 years
old. Also, possession of PepperBall®projectiles by anyone who has been convicted of a felony is illegal in
some states.
WARNING! CO2GAS CONTENTS UNDER PRESSURE
WARNING! - Do not puncture or incinerate container.
WARNING! - Do not heat or store at temperatures above 120°F.
WARNING! - Do not expose cylinder to corrosive materials
CAUTION! - Keep out of the reach of children.
WARNING! This unit is designed for use with CO28 gram cartridges only. Do not use N2(Nitrogen-filled)
canisters or any other gas filled canister in this unit. Use of any canister other than CO28 gram
cartridges will void the warranty and may cause damage to the unit beyond repair.
Find product information, safety data sheets (SDS) and more at www.pblifelite.com.

76 | LIFELITE™MOBILE
SIZE: 9" L x 2-5/16" W x 2-9/16" H WEIGHT: 1.40 LBS LUMENS: 350 CAPACITY: 3 ROUNDS
MAXIMUM LAUNCH DISTANCE: 40 FT ACTION: SEMI-AUTOMATIC POWER: CO2
INCLUDES: 6 LIVE SD™ PEPPERBALLS • 12 INERT PEPPERBALLS • 3 CO2CARTRIDGES • 3 AAA BATTERIES
SPECIFICATIONS
TRIGGER – SEMI-AUTOMATIC ACTION
LAUNCH CHAMBER
INTERNAL AIR SOURCE SAFETY
LASER SIGHT
BATTERY COMPARTMENT
FOR USE WITH PEPPERBALL®ROUND PROJECTILES
PEPPERBALL®QUICK ACCESS PORT
3 ROUND CAPACITY
FLASHLIGHT
PUSH BUTTON
FLASHLIGHT OPERATION
OPERATIONAL INSTRUCTIONS
OVERVIEW
SAFETY
Max. output power: 4.99 milliwatts
Wavelength: 400-700 nanometers (visible light)
Min. divergence: 1 milliradian
Output: Continuous (CW)
Laser hazard classification: Class 3R
DO NOT STARE INTO BEAM OR VIEW DIRECTLY WITH OPTICAL INSTRUMENTS;
CAN CAUSE EYE INJURY UPTO 52 Ft (16M) AWAY
Laser hazards
Eye injury from beam
AVOID DIRECT EYE EXPOSURE: Do not look into the direct or reflected
beam; can cause eye injury up to 52  (16 m) away.
Visual interference (glare) with pilots and drivers
Interferes with vision up to 1200  (366 m) away. Can be a distraction up
to 2.2 miles (3.5 km) away. NEVER point any laser towards aircra or
vehicles; it is unsafe and illegal.
Safe use guidance
Class 3R lasers are safe when handled carefully. Do not look into the
beam. Avoid accidental exposure to eyes. Do not aim at aircra. This is
not a toy. Always supervise children. Additional safety information online
Manufacturer:
United Tactical Systems LLC
Fort Wayne, Indiana 46809
Made in the China | PBLifelite.com
US patents 5.965.839, 6.393.992, 6.543.365, 6.546.874
EMC Compliance Complies with 21 CFR 1040.10

98 | LIFELITE™MOBILE
BATTERY INSTALLATION
1. PLACE THE LIFELITE™MOBILE IN SAFE MODE - Slide
the safety back towards the rear of the launcher.
(Fig 1)
2. REMOVE THE BATTERY COVER - To install non-
rechargeable batteries, place three AAA batteries
in the Battery Tray, following the correct placement
of + and -. If the unit is new, make sure to pull the
white tab to make sure the battery is connected.
3. REPLACE THE BATTERY COVER - Ensure the Battery
Door is closed, by pushing the latch forward until
it clicks. (Fig 3)
OPERATIONAL INSTRUCTIONS
Fig 1
Fig 2
Fig 3
NOTE: Launcher fires projectile with CO2cartridge
installed and does not require batteries to fire projectiles.
*CLICK*
INSERTING CO2CARTRIDGE
1. Make sure the LifeLite™ Mobile has NOT been loaded
with projectiles.
2. Unscrew Puncture Ram from cartridge chamber
located in the front of the LifeLite™Mobile. (Fig 1)
3. Insert 8 gram CO2cartridge (skinny end first) into
the cartridge chamber where you removed the
Puncture Ram. (Fig 2)
4. Re-install Puncture Ram into cartridge chamber
and tighten until Puncture Ram is flush with the
front of the unit.
NOTE: PepperBall®recommends the user only install 8
gram CO2cartridges that have been ASTM certified to
meet size standards.
PUNCTURE RAM PART NO. B90-0013
WARNING: Do not point launcher towards yourself or
others while performing this procedure.
REPLACING SPENT CO2 CARTRIDGE
1. To replace the spent CO2cartridge, ensure the launcher is empty of projectiles.
2. Unscrew the Puncture Ram from the launcher.
NOTE: It is normal to hear a hissing sound as excess CO2gas is released.
3. Point the launcher in a safe direction and at a downward angle.
4. Disengage the safety and press the trigger.
5. The spent CO2cartridge should release and fall free of the launcher. Never hit the launcher against
a hard surface to release a spent CO2cartridge.
6. Engage safety prior to installing a fresh CO2cartridge then replace the Puncture Ram on an empty chamber
for storage.
7. Properly dispose of the spent CO2cartridge.
OPERATIONAL INSTRUCTIONS
Fig 1
Fig 2

1110 | LIFELITE™MOBILE
LOADING PROJECTILES
1. Remove Projectile Plunger from the rear of
the LifeLite™Mobile by pushing in and turning
approximately 1/8 turn counterclockwise. A tab
on the Projectile Plunger will line up with a notch
in the body of the LifeLite™Mobile so it can be
removed. (Fig 1)
2. Place three PepperBall®projectiles in the projectile
load chamber where you removed the Projectile
Plunger. Reinsert the Projectile Plunger and turn it
approximately 1/8 turn clockwise until it locks back
into place. (Fig 2)
NOTE: Never place more than three PepperBall®
projectiles in the LifeLite™Mobile.
The projectiles are designed to fracture easily to ensure
effectiveness on a variety of surfaces and distances. If
the unit is ever dropped on a hard surface, the projectiles
should be removed and inspected for damage.
CAUTION: Minimal force should be required to re-insert
the projectile plunger. If resistance is felt, remove and
inspect projectiles for damage.
NOTE: Remember to always keep LifeLite™ Mobile pointed
in a safe direction while loading.
OPERATIONAL INSTRUCTIONS
Fig 1
Fig 2
FIRING THE LIFELITE™Mobile
1. The LifeLite™Mobile is now ready to fire. Aim the
LifeLite™Mobile at the intended target and slide the
safety to the forward position. This will activate the
laser. Aim the laser on the target and firmly press
the red trigger straight down with your thumb until
projectile is launched. (Fig 1)
2. Replace the CO2cartridge aer firing five
projectiles or any time the LifeLite™Mobile will be
stored. NOTE: CO2cartridge will be pierced only at
first trigger push each time the LifeLite™Mobile
is reloaded with a new cartridge. To ensure the
LifeLite is ready for defensive use, only stage with a
fresh, unused CO2cartridge.
WARNING:
- Never point laser direct into eyes
- Do not shoot at head, neck or spine
- Do not shoot LifeLite™ Mobile at unintended target
STORING THE LIFELITE™
If storing the LifeLite™Mobile for an extended period and it is not intended to be used, replace
the Puncture Ram without a CO2cartridge in the chamber and ensure the launcher is free of
projectiles. Place the LifeLite™Mobile in its case, restore the safety to the ON position, and store
in a safe location.
OPERATIONAL INSTRUCTIONS
Fig 1
Firing multiple magazines in rapid succession
may cause the launcher to freeze. If this occurs,
allow launcher to thaw to room temperature prior
to continued use.

1312 | LIFELITE™MOBILE
ADJUSTING LASER SIGHT
1. The LifeLite™Mobile comes with the laser aligned
properly. Only adjust the laser if the projectiles
are not hitting at the same point where the laser
is projected.
2. Secure the LifeLite™Mobile in a horizontal position
with the trigger pointing up.
3. Once secure, shoot one round from the LifeLite™
Mobile at a target from 15 feet away. The projectile
should hit within a 1.5" square from where the laser
is projecting.(Fig 1)
4. If the projectile did not hit within the specified
range, use the two adjustment screws at the front
of the launcher to adjust the laser until it is within
range. The le screw adjusts the elevation. The
right screw adjusts windage. (Fig 2)
X
Laser
1.5"
1.5"
Projectile hit
OPERATIONAL INSTRUCTIONS
NOTE: Adjustment is delicate and only light pressure
should be applied to the adjustment screws. Attempting
to force the screws past the designed limits could
damage the unit.
ELEVATION ADJUSTMENT: Turn clockwise to move up
— counter clockwise to move down.
WINDAGE ADJUSTMENT: Turn clockwise to shi le —
counter clockwise to shi right.
Fig 1
Fig 2
SAFETY NOTES
• Remove all projectiles and the CO2cartridge from the LifeLite™Mobile
prior to doing any cleaning or maintenance.
• Keep the launch chamber of the launcher completely dry.
• Never use petroleum-based cleaning solvents or lubricants.
• Never use cleaning solvents that come in aerosol cans.
CLEANING AND MAINTENANCE
WARNING: Never perform cleaning or maintenance on a
loaded or pressurized launcher.

1514 | LIFELITE™MOBILE
CLEANING AND MAINTENANCE
LIFELITE™Mobile CLEANING PROCEDURE
1. Clear LifeLite of all projectiles and CO2cartridge
before attempting to clean launcher. If the LifeLite™
Mobile needs to be cleaned for any reason including
a broken projectile, follow the below instructions to
decontaminate.
2. In a well-ventilated environment, preferably
outdoors, position LifeLite™Mobile barrel in
downward direction and gently tap side of launcher
to
remove large shell fragments and powder from
barrel opening.
3. Using a damp swab, clean remaining powder out
of magazine tube by gently inserting swab in a
rotating motion. (Fig 1)
4. Rotate launcher around and repeat process
by inserting a damp swab into the barrel of
the launcher in a rotating motion. Dispose of
contaminated swabs. (Fig 2)
Fig 1
Fig 2
WARNING: Never perform cleaning or maintenance on a
loaded or pressurized launcher.
CLEANING AND MAINTENANCE
5. Immediately aer damp swabbing (to prevent
wet powder from drying inside of launcher)
follow normal procedure of loading CO2cartridge
into LifeLite™Mobile and dry fire launcher
without projectiles. Dry fire launcher until CO2is
deplenished. Place the launcher in safe mode.
(Fig 3)
6. While still in well-ventilated area, aim LifeLite™
Mobile barrel in safe direction and spray
compressed air into magazine slot (front of
launcher) to blow excess projectile powder out of
barrel. (Fig 4) 7. Rotate launcher around and repeat
process by spraying compressed air into barrel
(front of launcher) to blow remaining projectile
powder out of magazine tube. (Fig 5)
8. Wipe entire launcher with damp towel to complete
cleaning process.
Fig 3
Fig 4
Fig 5

1716 | LIFELITE™MOBILE
WARRANTY, DISCLAIMER OF WARRANTY AND LIMITATION OF REMEDIES
United Tactical Systems, LLC (UTS) warrants, solely to the end user, that the product is delivered
free from defects in materials and workmanship for a period of one (1) year from the original date
of purchase.
Within the one-year warranty period, UTS’ liability and the buyer’s sole and exclusive remedy hereunder
for all claims shall be limited to a refund or credit to buyer of the purchase price, or replacement of
this product, at UTS’s option, provided that the non-conforming product is (1) returned during the
warranty period and (2) properly packaged and shipped to UTS’s designated facility in accordance with
UTS’s Return Merchandise Authorization (RMA) Policy.
THE REMEDY SET FORTH ABOVE SHALL BE THE SOLE AND EXCLUSIVE REMEDY FOR
BREACH OF THE FOREGOING WARRANTY.
Products which have been improperly handled, stored or shipped, or which have been subject to
abuse, misuse, alteration and or neglect are not covered by the warranty. Aermarket products
and the use of non-authorized projectiles are strictly prohibited by UTS and any indication of their
installation or use shall void all warranties.
DISCLAIMER OF WARRANTY: Except for the express limited warranty set forth above, UTS makes no
warranties or representations of any kind, whether express or implied, with respect to the product,
including any (a) warranty of merchantability; or (b) warranty of fitness for a particular purpose; or
(c) warranty against infringement of intellectual property rights of a third-party, whether express or
implied by law, course of dealing, course of performance, usage of trade or otherwise. There are no
warranties which extend beyond the description of the face hereof. Buyer shall make no warranty or
representation regarding the products that is inconsistent with the warranty set forth above. UTS shall
not be liable for any injury, loss, or damage, direct or consequential, arising out of the use or the inability
to use this product. Warranty does not cover damage caused by abuse, misuse, loss, improper handling,
alterations, accident, neglect, or disassembly.
Before use, the user shall determine the suitability of the product and be fully trained for its intended
use, and user assumes all risks and liability whatsoever in connection therein. In no event shall UTS be
liable or obligated to buyer or to any third party in any manner for any (a) special, non-compensatory,
consequential, indirect, incidental, statutory, or punitive damages of any kind, including, without
limitation, lost profits and/or lost revenue, regardless of the form of action, whether in contract, tort,
negligence, strict product liability, or otherwise, even if informed of or aware of the possibility of any
such damages in advance, (b) in an amount greater than the amounts paid to UTS by buyer for the
products, or (c) damage or injury caused by the products, unless due to the gross negligence or willful
misconduct of UTS. The limitations set forth above shall be deemed to apply to the maximum extent
permitted by applicable law and notwithstanding the failure of the essential purpose of any limited
remedies. The parties acknowledge and agree that they have fully considered the foregoing allocation
of risk and find it reasonable, and that the foregoing limitations are an essential basis of the bargain
between the parties.
WARRANTY AND DISCLAIMER
When returning product:
• Make sure the RA Number is clearly marked on the outside of the shipping package.
• Include a brief statement regarding the requested repair
• Include your name, return address and a telephone number where you can be reached during normal
business hours inside the shipping package.
• CAUTION: ALWAYS UNLOAD AND REMOVE AIR SOURCE, BATTERIES AND PROJECTILES BEFORE SHIPPING A LAUNCHER.
• CAUTION: DO NOT SHIP BACK THE AIR SOURCE OR BATTERIES.
• All in warranty products will be repaired or exchanged at the factories discretion and will be shipped back to
the Customer via ground shipping at no-charge.
• You may request expedited shipping at your expense with charges paid prior to return shipment.
• All out of warranty returns are subject to part and labor charges and require a pre-payment of shipping
charges prior to product being returned to the Customer by PepperBall®.
PepperBall®strives to complete the necessary repair work within a reasonable amount of time.
PepperBall®A Division of United Tactical Systems, LLC
28101 Ballard Drive, Suite F
Lake Forest, IL 60045
[phone]
www.pblifelite.com
[email protected]
WARRANTY AND SERVICE INFO

1918 | LIFELITE™MOBILE
TROUBLESHOOTING REGISTRATION
Q: I can’t remove the CO2cartridge.
A: With the CO2cartridge exposed, tilt opening towards down and simultaneously
pull the trigger.
Q: Projectiles do not come out of the barrel when shooting.
A: Put LifeLite™Mobile on SAFE and remove projectile cap. Hold hand over opening and tilt
launcher towards ground and catch projectiles that have been loaded. Place on FIRE
and “dry” fire the LifeLite™Mobile twice. Replace projectiles and cap and try again.
Q: My LifeLite™Mobile has air leaking out of the barrel when I pull the trigger.
A: Contact warranty/tech support at [email protected] or visit pblifelite.com.
NAME:
ADDRESS:
DATE OF PURCHASE:
SERIAL NUMBER:
Please detach from product manual,
place in stamped envelope and send to:
PepperBall®Warranty Support
28101 Ballard Dr. Ste. F
Lake Forest, IL 60045
LIFELITE™MOBILE WARRANTY REGISTRATION CARD:
"

103020
PepperBall®A Division of United Tactical Systems, LLC
www.PBLifelite.com | [phone]
28101 Ballard Drive, Suite F
Lake Forest, IL 60045