Poulan Pro 412525 User manual

REPAIR PARTS MANUAL
MODEL:
CO20H46YT
LAWN TRACTOR
ALWAYS WEAR EYE PROTECTION DURING OPERATION
Visit our website: www.poulan-pro.com
WARNING:
Read this Manual and follow all Warnings
and Safety Instructions. Failure to do so can
result in serious injury.
IMPORTANT MANUAL Do Not Throw Away
Printed in U.S.A.
412525 01.20.07TH
03076

2
M
FUSE
STARTER
SOLENOID
BATTERY
CLUTCH/BRAKE
(PEDAL UP)
REVERSE SWITCH
(NOT IN REVERSE)
SEAT SWITCH
(NOT OCCUPIED)
SHORTING
CONNECTOR
CHASSIS
HARNESS
IGNITION
UNIT
HOUR
METER
CHASSIS HARNESS
CONNECTOR
(MATING SIDE)
DASH HARNESS
CONNECTOR
(MATING SIDE)
LIGHT
SWITCH
HEADLIGHTS
FUEL
LINE
FUEL SHUT-OFF
SOLENOID
(IF SO EQUIPPED)
JUNCTION
CONNECTOR
S
M
B
G
L
2
3
1
6
A2
A1
M
63
52
41
6
5
4
3
2
1
SPARK
PLUGS GAP
(2 PLUGS ON
TWIN CYL. ENGINES)
(OPTIONAL)
NON-REMOVABLE
CONNECTIONS
REMOVABLE
CONNECTIONS
WIRING INSULATED CLIPS
NOTE: IF WIRING INSULATED
CLIPS WERE REMOVED FOR
SERVICING OF UNIT, THEY
SHOULD BE REPLACED TO
PROPERLY SECURE YOUR
WIRING.
03094-194276_Manual-Tex
IGNITION SWITCH
CIRCUITPOSITION
OFF
B+A1
RUN/OVERRIDE
B+S+A1START
M+G+A1
B+A1RUN
“MAKE”
L+A2
03094
LIGHTING SYSTEM
OUTPUT
5 AMP AC @ 3600 RPM
ALTERNATOR
14 VOLTS AC MIN. @ 3600 RPM (LIGHTS OFF)
DIODE
28 VOLTS AC MIN. @ 3600 RPM
(CHARGING SYSTEM DISCONNECTED)
CHARGING SYSTEM OUTPUT
3 AMP DC @ 3600 RPM
ATTACHMENT CLUTCH
(CLUTCH OFF)
BLACK
BLACK /WHITE
ORANGE
BROWN
BLUE
BLUE
BLACK
BLACK
BLACKBLACK
BLACK
BLACK
BLACK
BLACK
BLACK
RED RED
WHITE
WHITE
GRAY
GRAY
BLACK
BLACK
POWER OUTLET
(IF SO EQUIPPED)
12V
TRACTOR - MODEL NO. CO20H46YT (96042004900), PRODUCT NO. 960 42 00-49
SCHEMATIC

3
TRACTOR - MODEL NO. CO20H46YT (96042004900), PRODUCT NO. 960 42 00-49
DECALS
NOTE: All component dimensions given in U.S. inches
1 inch = 25.4 mm
KEY PART
NO. NO. DESCRIPTION
6
2
1
3
11
4
10
5
9
8
7
wheel_art_1-vgt
WHEELS AND TIRES
KEY PART
NO. NO. DESCRIPTION KEY PART
NO. NO. DESCRIPTION
7
1
1 59192 Cap, Valve, Tire
2 65139 Stem, Valve
3 106732X421 Rim Assembly, Front
4 59904 Tube, Front
5 106222X Tire, Front
6 278H Fitting, Grease
7 9040H Bearing, Flange
8 104757X421 Cap, Axle (Front Wheel Only)
9 138468 Tire, Rear
10 7152J Tube, Rear
11 106108X421 Rim Assembly, Rear
- - 144334 Sealant, Tire (10 oz. Tube)
3
2
1 186163 Decal, Hood RH
2 186164 Decal, Hood LH
3 408795 Decal, Side Panel
4 172740 Decal, Fender
5 409713 Decal, Engine
6 402104 Decal, Fender Operator's
7 411180 Decal, Lower Dash
8 170563 Decal, Warning
9 145005 Decal, Battery Dnge/Poi
6
10 408948 Decal, Fender RH
11 412515 Decal, Replacement
12 408949 Decal, Fender LH
13 172743 Decal, Steering Wheel
14 160396 Decal, Mower Schematic
- - 400981X428 Pad, Pedal
- - 166960 Decal, Bypass
- - 193226X428 Pad, Footrest, LH
- - 412523 Manual, Operator's (Eng/French)
- - 412525 Manual, Parts (Eng/French)
3
13
5
14
8
11
4
7
9
10 12

4
TRACTOR - MODEL NO. CO20H46YT (96042004900), PRODUCT NO. 960 42 00-49
ELECTRICAL
30
33
42
40
26
28
71
400449A
29
94
93
92
34
43
25
27
41
24
22
21




55
4646
16

5
TRACTOR - MODEL NO. CO20H46YT (96042004900), PRODUCT NO. 960 42 00-49
ELECTRICAL
KEY PART
NO. NO. DESCRIPTION
1 144927 Battery
2 74760412 Bolt Hex Head 1/4-20 x 3/4
8 193228 Box Battery
16 176138 Switch Interlock Push-In
21 183759 Harness Socket Light W/4152J
22 4152J Bulb Light
25 401662 Cable Starter
26 175158 Fuse
27 73510400 Nut Keps Hex 1/4-20 unc
28 198885 Cable, Black Rear Battery
29 401545 Switch, Seat
30 193350 Switch, Ign
33 140401 Key, Ignition
34 110712X Switch Light / Reset
40 400449 Harness Chassis
41 17720408 Screw Thd Cut 1/4-20 x 1/2
42 131563 Cover, Terminal
43 192507 Solenoid
46 401763 Service Reminder Hourmeter
55 17060512 Screw Thdrol 5/16-18 x 3/4 TYTT
71 401098 Harness Ign. Dash
72 197802 Switch Interlock Clutch Cable
90 400725 Cover Terminal
NOTE: All component dimensions given in U.S. inches
1 inch = 25.4 mm

6
TRACTOR - MODEL NO. CO20H46YT (96042004900), PRODUCT NO. 960 42 00-49
CHASSIS
37
181
194
36

235
183
152 159
2
180
162
196
230
68
222
CHASSISTEX??ELITEªSVªPRO
217
138
99
182
176
175
5
137
177
130
151
14
18
208
207
15
25
186
176
176
176
130
150
159
159
181

194


7
TRACTOR - MODEL NO. CO20H46YT (96042004900), PRODUCT NO. 960 42 00-49
CHASSIS
KEY PART
NO. NO. DESCRIPTION
2 194263 Drawbar
5 199646X428 Dash Upper
14 183393X428 Hood
15 183834X599 Lens Grille LH
18 183828 Grille Asm (Included Key #'s 15,25,191)
25 183835X599 Lens Grille RH
36 17060512 Screw 5/16-18 x 3/4
37 402969X428 Fender
68 17490508 Screw THDROL 5/16-18 x 1/2
99 405092 Rod Bypass Asm
130 191611 Screw 10 x 3/4 Single Lead-Hex
137 184921 Bumper Hood
138 193224X428 Cupholder
150 189350 Duct Heat Hood
151 407807 Bracket Pivot
152 194329 Shield Browning/Debris
159 17000612 Screw Hexwsh Thdrol 3/8-16 x 3/4
162 142432 Screw Hex Wsh Hi-Lo 1/4 x 1/2 UNC
175 193243 Crossmember
176 400776 Screw 10-24 x 5/8 Wshd Qdrx
177 195227 Bushing Steering
180 194260 Chassis
181 193102X428 Bushing Mtg. Fender Crgo.
182 193057 Dash Lower
183 74780520 Bolt Fin Hex 5/16-18 x 1-1/4
186 183829X428 Insert Grille
194 73900500 Nut Lock Hex Flange 5/16-18
196 410584 Console Asm. Deck Lift
207 183833 Bezel RH
208 183832 Bezel LH
217 156524 Rod Pivot Chassis
222 137729 Screw thd Roll 1/4-20 x 5/8
228 195161 Stud Fastener
230 170165 Bolt Shoulder 5/16-18
235 406129 Spacer Fender
236 73930500 Nut Center Lock 5/16-18 UNC
NOTE: All component dimensions given in U.S. inches
1 inch = 25.4 mm

8
TRACTOR - MODEL NO. CO20H46YT (96042004900), PRODUCT NO. 960 42 00-49
DRIVE





















 







ª





DRIVETEX?















 
 









9
TRACTOR - MODEL NO. CO20H46YT (96042004900), PRODUCT NO. 960 42 00-49
DRIVE
KEY PART
NO. NO. DESCRIPTION KEY PART NO. NO. DESCRIPTION
NOTE: All component dimensions given in U.S. inches
1 inch = 25.4 mm
1 - - - - - - Transaxle, Hydro HG-0510
(Order Parts from Transaxle
Manufacturer)
2 123583X Key
15 19131316 Washer 13/32 x 13/16 x 16 Ga.
17 197296 Spring, Brake
26 199679 Spring Return Cruise
29 197659 Rod, Brake
33 12000001 Ring E #5133-75
35 197722 Rod, Brake, Park
37 121749X Washer 25/32 x 1-1/4 x 16 Ga.
42 8883R Cover, Foot Pedal
49 72110614 Bolt
50 194327 Pulley Idler Flat
51 73900600 Lock Nut 3/8-16
52 194326 Idler V-Groove 910" Offset
56 140218 V-Belt, Drive
64 197865 Shaft Asm. Pedal Brake Control
73 74490544 Bolt Hex FLGHD 5/16-18 Gr 5
80 400507 Bracket Strp. Trq.
92 74760520 Bolt Fin Hex 5/16-18 unc x 1.25
116 73900500 Nut Lock Hex Flange 5/16-18
125 17000512 Screw 5/16-18 x 3/4
153 4497H Retainer Spring 1"
159 76020412 Pin Cotter 1/8 x 3/4
160 169484 Retainer Clip
161 195403 Spring, Return, Clutch
163 199000 Rod Pedal Control
166 197290 Nut Push .625
167 405257 Latch Brake Parking
170 194322 Keeper Belt Centerspan
171 72110616 Bolt
183 137057 Spacer
184 198403X505 Handle Parking Brake
185 72110620 Bolt
186 194321 Spacer Retainer
187 19133210 Washer
188 194323 Link Clutch Ground Drive
189 194317 Bellcrank Ground Drive
190 194318 Keeper Bellcrank Ground Drive
203 19111116 Washer 11/32 x 11/16 x 16 Ga.
205 121748X Washer 25/32 x 1-5/8 x 16 Ga.
206 197867 Bracket Mount Latch Cruise
207 197868 Latch Control Cruise
208 197869 Gear Sector Control Cruise
209 400769 Rod Control Cruise
210 400980 Rocker Asm. Pedal Control
211 120183X Bearing Nylon Blk .629
213 400799X428 Knob Control Cruise
214 197302X428 Pedal Forward
215 197301X428 Pedal Reverse
221 403187 Retainer Spring Clip Handle
222 19212010 Washer 21/32 x 1-1/4 x 10 Ga.

10
TRACTOR - MODEL NO. CO20H46YT (96042004900), PRODUCT NO. 960 42 00-49
STEERING ASSEMBLY





 



































STEERINGTEX?VGT


 








