PumpSpy CV-150 User manual

USE AND CARE GUIDE
CV-150
QUIET SUMP PUMP CHECK VALVE

Safety Goggles
TOOLS REQUIRED:
Hacksaw or PVC Cutter
Tape Measure
Flathead Screwdriver
SAFETY INFORMATION:
WARNING
ALWAYS DISCONNECT POWERTOYOUR
PUMP AND RELEASE PRESSURE BEFORE
SERVICING.

INSTALLATION:
Note: For use in residential sump pump applications only.
MAXIMUM 12 PSI.
1. Unplug your pump.
2. Disconnect the pump’s discharge pipe from
below your existing check valve.
3. Drain the discharge pipe above the check
valve into your basin or a bucket and
remove the old check valve.
4. Loosen all four hose clamps on your new
check valve.
5. Ensure the spacing between the two
discharge pipes is 5 1/8”. Cut the discharge
pipe as necessary.
6. Install your new check valve with the ow
arrow pointing away from the pump by
inserting the two pipe ends into the exible
rubber adapters
7. Position the check valve assembly as shown
and tighten all four hose clamps. Do not
exceed 20 in-lbs. Do not over-tighten.
8. Plug in your pump and ll basin with
water to cycle your system a few times
checking for leaks. Retighten hose clamps if
necessary. Do not over-tighten.

Limited Two-Year Warranty
WHAT THIS WARRANTY COVERS
When used and maintained in normal use and in accordance with the Installation and
Operating Instructions, your PumpSpy® product is warranted against original defects in
material and workmanship for a full two years from date of purchase (the “Warranty Period”).
During the warranty period, PumpSpy will repair or replace at no cost to you, to correct
such defects in products found upon examination by PumpSpy to be defective in materials or
workmanship.
WHAT THIS WARRANTY DOES NOT COVER
This warranty does not cover use of the product in a non-residential application, improper
installation and/or improper maintenance of the product, damage due to misuse, acts of God,
nature, vandalism or other acts beyond the control of PumpSpy, owner’s acts or omissions, use
outside the country in which the product was initially purchased and resales of the product
by the original owner.This warranty does not cover pick up, delivery, transportation or house
calls. However, if you mail your product to PumpSpy for warranty service, cost of shipping will
be paid one way.This warranty does not cover products purchased from a party that is not an
authorized retailer, dealer, or distributor of PumpSpy products.
OTHER IMPORTANT TERMS
This warranty is not transferable and may not be assigned.This warranty shall be
governed and construed under the laws of the state of Michigan.The warranty period
will not be extended by any replacement or repair performed under this warranty.THIS
WARRANTY IS THE EXCLUSIVE WARRANTY AND REMEDY PROVIDED BY PumpSpy.
ALL OTHER WARRANTIES, EXPRESSED OR IMPLIED, INCLUDING WARRANTIES OR
MERCHANTABILITY OR FITNESS FOR PARTICULAR PURPOSE ARE DISCLAIMED. IN
NO EVENT WILL PumpSpy BE LIABLE FOR ANY SPECIAL, INDIRECT, INCIDENTAL OR
CONSEQUENTIAL DAMAGES OF ANY KIND OR NATURE TO OWNER OR ANY PARTY
CLAIMING THROUGH OWNER WHETHER BASED IN CONTRACT, NEGLIGENCE,TORT
OR STRICT PRODUCTS LIABILITY OR ARISING FROM ANY CAUSE WHATSOEVER. Some
states do not allow for the exclusion of consequential damages, so the above exclusion may
not apply to you. This warranty gives you specic rights. You may also have others that vary
state to state.
2723 Kersten Court Kalamazoo, Michigan 49048
www.PumpSpy.com
© 2021 PumpSpy.All Rights Reserved. 93103-01