Punto Fit 6m User manual

1
Multifunctional sports complex «PUNTO FIT»
OPERATION MANUAL
PUNTO FIT 6.0 m

2
This operation manual is intended
to familiarize users with the rules of assembly, use
and maintenance of the sports complex
1. PURPOSE AND TECHNICAL CHARACTERISTICS
1.1 The complex is intended to be usedoutdoors or indoorsin a room with a ceiling height of at
least 3.5 meters, for people older than 14 years old and at least 1.4 meters tall, for the
following sports: crossfit, workout, yoga, weightlifting, boxing.
1.2 Main technical characteristics of the Complex are given in Table 1.
Table 1
Multifunctional sports complex Punto Fit
Characteristics
Overall dimensions, mm
Length
Width
Height
Net weight (no more than), kg
Service life (at least), years
КРОС6000-00.000E
6000
1800
2800
1430
5

3
2. COMPLETENESS
2.1. Completeness of the Complex is given in table 2. Table 2:
№
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
43
44
Name
КРОС01-05.000E beam assembly
КРОС01-07.000E base beam assembly
КРОС01-20.000EСБ side panel
КРОС01-00.001E trim panel
КРОС01-00.002E trim panel
КРОС01-16.000E crossbeam
КРОС01-15.000E crossbeam
КРОС01-17.000E crossbeam
КРОС01-60.000E transition crossbeam
Bolt М10х25 ГОСТ 7805-70
КРОС01-150.000Еstraight bracket
КРОС01-200.000Еcorner bracket
КРОС01-50.000Еcorner bracket, small
КРОС01-170.000Еhorizontal bar, attached
КРОС01-400.000Еsuspension parallel bars
КРОС01-250.000Еbracket for rings
Bolt М8х20 ГОСТ 7805-70
Washer 8 ГОСТ 11371-78
КРОС01-185.000 portable bracket
КРОС01-30.000Еprofile assembly
КРОС01-30.000-01Еprofile assembly
КРОС01-30.000-02Еprofile assembly
КРОС01-30.000-03Еprofile assembly
Boxing bag "Tent-master" (60 kg, h-130 сm)
Plastic end cap for bolt /screw-nut М10, black (TPD10)
Carabine with nut Ф10,0 (to suspend boxing bag)
Bolt М16х40 ГОСТ7805-70
Nut М16 ГОСТ 5915-70
Washer 16 ГОСТ 11371-78
Bolt М10х25 ГОСТ 7802-70
Nut М10 ГОСТ 5915-70
Washer 10 ГОСТ 11371-78
Chemical fixing + threaded pins M24
Nut М24 ГОСТ 5915-70
Washer 24 ГОСТ 11371-78
Bolt М12х30 ГОСТ 7805-70
Nut М12 ГОСТ 5915-70
Washer 12 ГОСТ 11371-78
Screw М5х20 with internal hexagon
Set of stickers
Operation manual
Expanding anchor
Quantity
Pcs.
КРОС6000-00.000
14
4
2
36
2
2
2
3
4
16
2
4
2
1
1
2
44
44
1
6
2
2
2
1
40
1
48
64
112
136
152
168
8
16
8
16
16
32
156
1
1
4

4
3. INSTALLATION AND ASSEMBLY INSTRUCTIONS
3.1 The assembly and installation of the Complex should be performed by at least 3 adults, with the use
of lifting-transport device with a lifting capacity of at least 1500 kg, a set of wrenches and heads №
17,19,24,36, hex key number 4, perforator.
3.2 Install on prepared concrete surfacing according to the scheme Fig.1 with the use of anchored
reinforcements № 35, 36, 37, 44. Concrete grade used in the manufacture of concrete surfacing
should be at least M250.
Fig. 1
3.3 Unpack the Complex and place component parts and assembly units on the flat surface.
3.4 Make sure that completeness of the package corresponds with the nomenclature, specified in
paragraph 2 of this operation manual.
Shock absorbing material cover 3.14

5
3.5 Assemble the side panels, see fig.2 consisting of assembly units № 1, 2, 7 (see table 2) and metal
items № 32, 33, 34, №29, 30, 31. Do not tighten the threaded connections. Install vertically on
prepared concrete pads according to fig.1
Fig. 2
3.6 On the flat surface assemble the upper part of Complex (see fig. 3) consisting of the assembly units -
positions 1, 6, 8, 9, 3 (see Table 2) and metal hardware № 32, 33, 34, №29, 30, 31. Do not tighten
the threaded connections.

6
Fig. 3
3.7 Using lifting-transport device install the upper part of complex on the previously assembled side
panels, see fig. 4 and fix it with the help of metal hardware № 12, 33, 34. Perform a final tightening
of all threaded connections 25...30Н*m. Additionally in places “A”install bolted connections №38,
39, 40.

7
Fig. 4
3.8 In places "Б" with the help of anchor connections №34 and metal hardware № 35, 36, see Fig.4 and
Fig.1 secure the construction to the prepared concrete surfacing.
3.9 Install the equipment included in delivery according to Fig.5

8
Fig. 5

9
3.10 In places "B" (fig.5) with the help of anchors №44 secure assembly units №15 to the
prepared concrete pads (fig.1)
3.11 Install trim panels №4, 5 with the help of screws №41 (see fig.6).
3.12 In places "H" set stickers with the logo, in places "P" - stickers with QR codes.
3.13 On protruding bolt heads install items №27.
3.14 Put shock absorbing material on the surface under the assembled complex (not included in
delivery). Protrusion of the items position 2 on outer sides must be at least 2500 mm. Total
protection cover on the plan and safety zones are 11000 x 8050 mm (see fig.7). Other types of cover
material and foundation shall conform to EN 16630:2015.
Fig 6.

10
Fig.7

11
4. SAFETY MEASURES
4.1 Total pressure on the complex should not exceed the values listed in table 1.
4.2 To avoid bruises and injuries when exercising on the Complex it is recommended to use soft mats of
appropriate sizes, located under the complex.
4.3 The complex is designed for sports activities for people aged 14+.
4.4 It is not recommended to exercise on the complex in windy and rainy weather.
4.5 Outdoor sports activities should be held in calm weather or with a light wind (at a speed of no
more than 1.5 - 2 m/s.) and temperature at least 20 °С.
4.6 In case of severe frost, it is necessary to instruct those who are involved in doing sports to watch
one another and control the first signs of frostbite, in the summer - avoid overheating and heat
stroke, as well as exercising in the drought.
4.7 Performing self-repair of sports equipment and fixtures is strictly prohibited.
4.8 Every day before exercising it is necessary to:
-inspect the structures of the complex and attached equipment, check integrity and stability, ensure
correct functioning of sports equipment, safety of construction and fastening of equipment;
-carry out a check of units reliability, make sure there is no rope abrasion or damage and check
reliability of anchor brackets;
-conduct a thorough inspection of the place where the training is held for compliance with sanitary
and hygienic conditions placed on the training area.
-If any shortcomings are detected take measures to address them. In case of impossibility to do the
repairs do not use the complex for exercising and inform the administration responsible for the
sports playground and take action to prevent uncontrolled use of broken sports equipment.

12
5. USE AND MAINTENANCE
5.1 People under the age of 14 years old are allowed to use the Complex in the presence of their parents or
those who are responsible for the safety of children.
5.2 If the user has diseases in the field of the cardiovascular or musculoskeletal system using the Complex is
possible only after the consultation with a doctor.
5.3 If the user suffers from chronic diseases of the endocrine system or has a malfunction of the central
nervous system he is obliged to train only in the mode permitted by the doctor.
5.4. If the user has any other restrictions related to his state of health it is forbidden to perform exercises
which are not recommended by the doctor.
5.5 If the user takes medicines that can slow down his reaction or can cause loss of consciousness and / or
movement disorder, the user is obliged to notify relatives (friends) before starting his training and to
conduct training under their control.
5.6 All of the above information is placed on a special stand, see fig. 8.
Fig. 8

13
6. Maintenance and operation
6.1 It should be checked periodically:
- At least 1 time per month check the tightness of the fixing units and threaded connections of the Complex
and the attachment to the surface.
6.2 The administration in the authority of which the sports ground is, obliged:
- to appoint those responsible for the technical inspection of sports equipment and suppliers located on the
sports ground;
- to conduct a scheduled technical inspection at least once every 3 months;
- to conduct a complete technical inspection at least 1 time per year;
- to record in the journal all the data on the conduct of scheduled and capital inspections. Identified
malfunctions should be eliminated with the preparation of the relevant act. If it is impossible to eliminate
the malfunction, the sports equipment should be replaced with the new one.
7. Warranty
7.1 Subject to compliance by the buyer or user with the requirements of these operating instructions, the
manufacturer guarantees the reliability of the Complex for 12 months from the date of sale but no more
than 18 months from the date of manufacture.
7.2 The service life of the complex–see table 1.
8. ACCEPTANCE INFORMATION
8.1 Date______________________________________________
8.2 Person responsible __________________________________

14
9. Examples of exercises