red lion RAM-6000 Series User manual

CONNECT. MONITOR. CONTROL. © 2014 Red Lion Controls. All Rights Reserved 1
QUICKSTARTGUIDE
RAM‐6000SeriesRouter
GSM,CDMAorHSPAwithModbus
UNPACKINGINSTRUCTIONS
1. UnpacktheRedLionunitandverifythefollowingcomponentsare
enclosedfortheRAM‐6000Router:
RAM‐6xxx:ACadaptrewitheitherbarrelconnec‐
tor(AC)orMolex(MX),or15ftMolexcable(DC)
canbeorderedinakit(ieRAM‐6600‐xx‐ACor‐
MX)ororderedspearately.(RAM‐6400notavail‐
able)
RAM‐6x01‐4:pinplugwithscrewterminalsto
connecttoanexternalDCpowersource.Available
wthACadaperwithbarrelconnector(AC).
RAM‐6x21‐4:pinplugwithscrewterminalsto
connecttoanexternalDCpowersource.Available
withACadapterwithbarrelconnector(AC).
Antennassoldseparately.
2. Contactyourcellularprovider(carrier)andrequestadataaccount.
ForCDMAmodels(RAM‐66xx),givetheESNnumberoftherouter
tothecarriertoactivatethedataaccount.ForGSMandHSPA
models(RAM‐64xx&SN‐68xx)thecarriershouldprovideyouwith
aSIMcardtoinsertintotherouter,alongwiththeAPN,username
&passwordfordataconnectivity.
3. InserttheSIMcard(GSMandHSPAmodelsonly):
•LocatetheSIMslotontherightsideoftheunit.
•Insertthecardwithitscutsidefacingforwardandontheleft.
•Usingthetipofapen,pushitinuntilitclicks.
4. AnantennawithanSMAconnectorshouldbeconnectedtothe
router.Thisantennashouldmeetthefollowingspecifications:
•DualBand800&1900MHZ
•Nominal50ohmimpedance
•VoltageStandingWaveRatio(VSWR)lessthan2.5:1
5. Thereare4methodstoprovidepowertotherouter:
•4‐pinMolexconnector‐availableonRAM‐6x00
•4‐pinscrewterminal‐availableonRAM‐6xx1/EB
•Sidemounted2.5mmbarrelconnector‐allmodels
•Power‐over‐Ethernet‐availableonRAM‐6x01EB
Themodemrequiresapowersourcebetween8and30VDCto
operate.
6. Pleaseallow2‐4minutesfortheunittorecognizethecellulardata
cardandconnecttothecellularnetwork.Whenthishasoccured,
theSignalStrengthLEDsshouldlightup(seetableonback).Ifsig‐
nalstrengthisnotlitorflashesslowly,pleaserefertotheUser
Manualatwww.redlion.net
ACCESSINGTHEWEBUSERINTERFACE
1. ConnectPCtotheRAM‐6000Router
ConnectaCAT‐5EthernetcablebetweenthelocalPCandthe
unit’sEthernetport.VerifythatthegreenLEDislit.
2. SetupPCIPAddress
PCtoEthernetInterfaces
Select“UsethefollowingIPaddress”andfillintheblankfields
withtheinformationbelow:
3. AccessWebUserInterface
Openawebbrowserandenterthefollowingintheaddressbar:
http://192.168.0.1:10000/
LOGININSTRUCTIONS
•UserName:admin(lowercaseletters)
•Password:lastsixdigitsoftheunit’sserialnumber
Uponsuccessfullyloggingin,thewebUIwilllaunch.
Note:Forsecuritypurposes,itisrecommendedthattheadminpass‐
wordbechangedaccordingtoyourinternalpolicies.
Tochangepassword,goto:Admin‐>AccessSettings.
WebUI:
LABEL DESCRIPTION
GND Ground
PWR+ Power8to30VDC(12or24VDCnominal)
IN Digitalandanaloginput
OUT Digitaloutput
ForassistancewithconfiguringyourPC,seetheappropri‐
ateMicrosoftsupportwebpagelistedat:
http://support.microsoft.com
Ethernet0
IPAddress 192.168.0.2
SubnetMask 255.255.255.0
DefaultGateway 192.168.0.1
PreferredDNS 192.168.0.1

CONNECT. MONITOR. CONTROL. © 2014 Red Lion Controls. All Rights Reserved 2
Quick Start Guide
Youarenowconnectedtothewebinterface.Ifyoushouldseeanything
otherthanthescreenshownabove,pleaserefertotheRAM‐6021User
Manual,locatedonourwebsite:www.redlion.net.
FormoreinformationtosetupModbusfeatures,pleaserefertothe
RAM‐6021UserManual.
HARDWARESTATUSLEDs
REDLIONCONTROLSTECHNICALSUPPORT
Ifyouhavefollowedalloftheinstructionsuptothispoint,are
satisfiedthatyouarenothavinganauthenticationproblemand
yourunitisstillnotcommunicating,thenititistimetocontact
RedLionTechnicalSupportat[email protected]or1‐877‐
432‐9908.
INSTALLATIONANDHAZARDOUSAREAWARNINGS
SuitableforuseinClassI,Division2,GroupsA,B,CandDhazardous
locations,ornon‐hazardouslocationsonly.Allpower,inputandoutput
(I/O)wiringmustbeinaccordancewithClassI,Division2wiringmeth‐
odsandinaccordancewiththeauthorityhavingjurisdiction.
WARNING‐EXPLOSIONHAZARD‐DONOTDISCONNECTEQUIPMENT
UNLESSPOWERHASBEENSWITCHEDOFFORTHEAREAISKNOWNTO
BENON‐HAZARDOUS.
WARNING‐EXPLOSIONHAZARD‐SUBSTITUTIONOFCOMPONENTS
MAYIMPAIRSUITABILITYFORCLASSI,DIVISION2.
WARNING‐EXPLOSIONHAZARD‐BATTERIESMUSTONLYBE
CHANGEDINANAREAKNOWNTOBENON‐HAZARDOUS.
WARNING‐EXPOSURETOSOMECHEMICALSMAYDEGRADETHESEAL‐
INGPROPERTIESOFMATERIALSUSEDINTHERELAYS.
AVERTISSEMENTSPOURINSTALLATIONET
ENDROITSDANGEREUX
CetéquipementestadaptépouruneutilisationenClasseI,Division2,
GroupesA,B,CetDpourendroitsdangereux,ouendroitsnon‐dan‐
gereuxseulement.Toutcâblageélectrique,entréeetsortie(I/O)doi‐
ventêtreenconformitéavecClasseI,Division2méthodesdecâblage
etconformémentàl'autoritécompétente.
AVERTISSEMENT‐RISQUED'AVERTISSEMENT‐NEDÉBRANCHEZPAS
L'ÉQUIPEMENTPENDANTQUELECIRCUITESTDIRECTOUÀMOINS
QUEL'ENVIRONNEMENTSOITCONNUPOURÊTRENON‐DANGEREUX.
AVERTISSEMENT‐RISQUED'EXPLOSION‐LASUBSTITUTIONDETOUT
COMPOSANTPEUTNUIREÀLACONFORMITÉDECLASSEI,DIVISION2.
AVERTISSEMENT‐RISQUED'EXPLOSION‐LESBATTERIESDOIVENT
SEULEMENTÊTREREMPLACÉESDANSUNEZONERECONNUECOMME
ÉTANTNON‐DANGEREUSE.
AVERTISSEMENT‐L'EXPOSITIONÀCERTAINSPRODUITSCHIMIQUES
PEUTDÉGRADERLESPROPRIÉTÉSD'ÉTANCHÉITÉDESMATÉRIAUXUTIL‐
ISÉSDANSLESRELAISÉTANCHEPÉRIPHÉRIQUE.
LED State Description
Power ON Powerisappliedtotherouter
Signal
ON Excellentsignalstrength
FLASH Flashesfasterassignalisstonger
OFF Veryweakornosignal(lessthan‐100dBm)
WAN
ON Wirelesslinkestablished,butnodataactivity
FLASH Datatransmitted/receivedonwirelessnetwork
RS232
ON Linkestablishedwithserialdevicebutnodata
activity
FLASH Datatransmitted/receivedwithattachedserial
device
Ethernet
ON LinkestablishedwithEthernetdevice
FLASH Datatransmitted/received