Sandleford Pandora Multi Play Cubby User manual

Customer Support: [phone]
Pandora Multi Play Cubby (MCH119)
Thank you for purchasing the Pandora Multi Play Cubby (MCH119)
Warning:Only for domestic outdoor use.
This play cubby satises all the requirements of the Australian Standard AS/NZS ISO 8124 and has been certied by an
independent laboratory. To guarantee safety, please give special attention to the assembly, safety, and care instruc-
tions detailed in this document.
ASSEMBLY ADVICE
- Follow the instructions exactly.
- This product must be assembled by adults.
- Once assembly has been completed, keep the instructions in a safe place for future reference. This can be particularly
handy for identication of parts if any after sales service is required.
- Before commencing assembly, check that none of the parts are missing. If you nd that you are missing a part please
contact our after sales service department.
- Retain extra parts to use as spares in the future if necessary.
- Pre-Drill timber before xing with screws to avoid cracks in the timber.
The dimensions given in the instructions are indicative only, they may vary according to the assembly method.
SAFETY ADVICE
- Warning: This product is only to be used by children between the ages of 3 and 7.
- Warning: Not to be used by anyone weighing over 45kgs. simultaneously, not to exceed a combined weight of 270kgs.
- Warning: Choking hazard-small parts can be dangerous for children .
- Warning: This play set must be used under adult supervision.
- This product is for private use at home only. Under no circumstances is it to be used in parks, schools, camp sites,
hotels, public leisure areas etc.
- The Play Set should be set up on a at surface and 2 metres away from any structures or obstacles (walls, fences, trees,
washing lines, cables etc).
- To avoid eye damage, we advise that the slide should not be setup directly facing the sun.
- The Play Set should be installed over impact absorbing surfaces such as sand, wood-bark chips, rubber and foam and
must NOT be set up on a hard surface (concrete, tarmac etc). For detailed information about surfaces please refer to the
attached consumer information sheet.
-We recommend to secure your swing set rmly into the ground using cement
- Please note this is a natural product and as such should be checked for any rough surfaces before use, if
required these should be lightly sanded in order to prevent injure.
- The anchorage must be checked regularly.
- Dispose of packaging thoughtfully.
- Do not allow children to play with packaging.
-Please see below diagram for maximum fall height of swing.
CAUTION ! This Product includes timber and/or fabric, Please Keep away from re.
FIXING INTO THE GROUND
IMPORTANT ! For safety reasons, your cubby must be embedded into the ground.
- Place your Play Set in the desired position and mark a square area 350mm x 350 mm around each of the feet. Dig holes
350 mm deep. (The feet must be in the center of the square)
- Fill the holes with concrete. Do not exceed the ground level. Fit the embedding piece into the center of the concrete
so that xtures for screwing the posts into place rise out of the concrete.
- When the concrete is dry, screw the posts to the embedding pieces.
- Anchors shall be placed level with or under ground in order to reduce tripping hazards.
IMPORTANT ! Wait until the concrete is set before using and check anchorages regularly.
MAINTENANCE
- All parts should be checked at least once a month.
- Check all nuts and bolts for tightness and tighten when required.
- Check for signs of wear to bolt coverings. If sharp edges are found, replace as required.
- In certain regions (seaside areas), certain coatings could be prone to damage. In this case, it is advised to use a rust
prevention treatment.
- Check climbing rod, ropes and other means of attachment for evidence of deterioration; replace when required in
accordance with the manufacturer's instructions.
- All parts that are under constant friction should be oiled regularly using a suitable lubricant.
- The ground on which the play centre is set up should be cleared regularly. All objects such as stones or anything else
that could cause injury in the case of a fall should be removed.
- It is recommended that during the winter period when the equipment is not in use, all apparatus are removed to
prevent deterioration due to bad weather.
- Sand rusted areas and tubular members and repaint using a non-lead based paint when required
- Modications to the original activity toy should only be carried out under instructions from the manufacturer.
- Defective parts should only be replaced in accordance with the manufacturer's instructions
- As timber is a natural product, It will deteriorate in the weather over time. For maximum longevity of your timber, it is
highly recommended to apply an initial 3 coats of a timber protectant such as an exterior grade oil before rst use of
the play set.
All outdoor wooden products require routine inspection and regular maintenance. After installation, a follow-up
inspection should take place after one week and twice a month thereafter for the remaining life of your play products.
Maintenance should be performed at any time it is deemed necessary. As a general rule, major maintenance (wood
renishing) should be performed at twelve month intervals from the date of installation. Inspect and perform mainte-
nance based on the following checklist.
Major wooden parts: Inspect for splintering and structure defects at regular intervals. For very minor splinters or chipping,
lightly sanding and renish with an exterior water repellent stain can assist. If timber has cracked or split signicantly,
replacement parts may be required, please contact national customer service centre for any replacement requirements
At regular intervals, the application of a penetrating oil based sealer stain to all wooden components is essential. Please
consult your local hardware or home improvement store for recommendation of an appropriate product.
Ensure the product does not contain hazardous chemicals once dry that can pose a potential health risk to children.
We hope you have a safe and enjoyable time using the Cubby Play Set.
SL 806058-1_IM.indd 1 2013-7-18 8:30:01

H51 x1 H245 x1 H246 x1 H251 x1 H252 x1
H253 x2 H254 x1 H255 x1 H309 x1 H310 x1 H311 x2
H244 x2
1250x50x50
H20 x1
1022x90x22
H73 x1
1022x90x22
H74 x2
1000x90x22
H78 x1
1044x18x140
H79 x2
1044x90x18
H80 x7
1022x90x22
H82 x1
772x90x18
H164 x4
1020x35x30
H219 x1
630x100x30
H249 x1
630x60x28
H250 x2
1022x90x22
H256 x1
1000x90x22
H257 x1
1000x100x30
H259 x1
1000x60x28
H260 x2
1700x100x40
H261 x2
790x30x15
H262 x1
660x90x22
H263 x15
1347x65x45
H264 x2
1360x80x22
H296 x2
1005x18x80
H297 x1
1005x18x80
H298 x2
1000x18x140
H301 x1
1000x18x140
H302 x1
905x50x45
H400 x2
520x90x22
H422 x2
300x60x60
H423 x2
840x90x22
H424 x1
1000x22x140
H425 x1
240x15x30
H434 x1
B76 x2 B176 x1 B192 x1
B285 x1 B286 x1 B287 x1
B288 x1 B289 x1 B290 x1
B196 x4 B201 x5 B265 x2
H283 x3 H284 x2B281 x2 B282 x2
B310 x2 B311 x1 B313 x1B312 x1
I26 x1 I36 x1 C6 x1 C7 x2 C15 x4
C16 x4 C23 x6 C24 x1 C31 x1 C33 x6 C56 x4
I31 x1
K5 x1
Ø8x40/M6
N3 x12
Ø8x25/M6
K6 x8
Ø6x35
E1 x8
Ø6x74
E13 x24
Ø6x80
E14 x4
Ø6x30
E15 x2
Ø6x95
E17 x8
Ø6x90
E18 x28
Ø6x13
E19 x10
Ø6x78
E22 x8
Ø6x85
E25 x2
Ø8x30
E26 x12
Ø6x20
E29 x4
Ø6x100
E43 x18
Ø6x105
E44 x2
Ø6x16
E54 x16
Ø6x12
G5 x28
Ø6x20
G13 x114
Ø6
G7 x8 G8 x12
Ø8
G15 x2
Ø6
D10 x143
Ø8
D11 x44
Ø8
D35 x12
Ø8
G2 x2
Ø8
L1 x54
Ø6
L2 x112
Ø4.5x40
J1 x64
Ø4.5x50
J2 x30
Ø5x25
J3 x41
Ø4.5x45
J4 x4
Ø4.5x20
J8 x47
Ø4.5x35
J10 x102
Ø4.5x30
J12 x4
Ø6x50
J11 x2
Ø6x40
J18 x20
Ø6x30
J19 x4 A4 x2 A5 x1
S=4
A6 x1
K6 x2 D16 x10 D39 x1 D46 x2 D47 x3 D48 x1 D49 x4
SL 806058-1_IM.indd 2 2013-7-18 8:30:01

H51 x1 H245 x1 H246 x1 H251 x1 H252 x1
H253 x2 H254 x1 H255 x1 H309 x1 H310 x1 H311 x2
H244 x2
1250x50x50
H20 x1
1022x90x22
H73 x1
1022x90x22
H74 x2
1000x90x22
H78 x1
1044x18x140
H79 x2
1044x90x18
H80 x7
1022x90x22
H82 x1
772x90x18
H164 x4
1020x35x30
H219 x1
630x100x30
H249 x1
630x60x28
H250 x2
1022x90x22
H256 x1
1000x90x22
H257 x1
1000x100x30
H259 x1
1000x60x28
H260 x2
1700x100x40
H261 x2
790x30x15
H262 x1
660x90x22
H263 x15
1347x65x45
H264 x2
1360x80x22
H296 x2
1005x18x80
H297 x1
1005x18x80
H298 x2
1000x18x140
H301 x1
1000x18x140
H302 x1
905x50x45
H400 x2
520x90x22
H422 x2
300x60x60
H423 x2
840x90x22
H424 x1
1000x22x140
H425 x1
240x15x30
H434 x1
B76 x2 B176 x1 B192 x1
B285 x1 B286 x1 B287 x1
B288 x1 B289 x1 B290 x1
B196 x4 B201 x5 B265 x2
H283 x3 H284 x2B281 x2 B282 x2
B310 x2 B311 x1 B313 x1B312 x1
I26 x1 I36 x1 C6 x1 C7 x2 C15 x4
C16 x4 C23 x6 C24 x1 C31 x1 C33 x6 C56 x4
I31 x1
K5 x1
Ø8x40/M6
N3 x12
Ø8x25/M6
K6 x8
Ø6x35
E1 x8
Ø6x74
E13 x24
Ø6x80
E14 x4
Ø6x30
E15 x2
Ø6x95
E17 x8
Ø6x90
E18 x28
Ø6x13
E19 x10
Ø6x78
E22 x8
Ø6x85
E25 x2
Ø8x30
E26 x12
Ø6x20
E29 x4
Ø6x100
E43 x18
Ø6x105
E44 x2
Ø6x16
E54 x16
Ø6x12
G5 x28
Ø6x20
G13 x114
Ø6
G7 x8 G8 x12
Ø8
G15 x2
Ø6
D10 x143
Ø8
D11 x44
Ø8
D35 x12
Ø8
G2 x2
Ø8
L1 x54
Ø6
L2 x112
Ø4.5x40
J1 x64
Ø4.5x50
J2 x30
Ø5x25
J3 x41
Ø4.5x45
J4 x4
Ø4.5x20
J8 x47
Ø4.5x35
J10 x102
Ø4.5x30
J12 x4
Ø6x50
J11 x2
Ø6x40
J18 x20
Ø6x30
J19 x4 A4 x2 A5 x1
S=4
A6 x1
K6 x2 D16 x10 D39 x1 D46 x2 D47 x3 D48 x1 D49 x4
SL 806058-1_IM.indd 3 2013-7-18 8:30:02

1
3 4
5
2
6
8 9
11
7
10
SL 806058-1_IM.indd 4 2013-7-18 8:30:03

1
3 4
5
2
6
8 9
11
7
10
SL 806058-1_IM.indd 5 2013-7-18 8:30:04

12
14 15
17
13
16
1
1
1
2
2
18
19 20
2221
1
2
3
4
SL 806058-1_IM.indd 6 2013-7-18 8:30:04

12
14 15
17
13
16
1
1
1
2
2
18
19 20
2221
1
2
3
4
SL 806058-1_IM.indd 7 2013-7-18 8:30:05

23
25 26
28
24
27
1
1
1
2
2
2
32
1
3
3
29
31 32
34
30
33
1
1
1
2
2
2
3
3
4
2
1
SL 806058-1_IM.indd 8 2013-7-18 8:30:06

23
25 26
28
24
27
1
1
1
2
2
2
32
1
3
3
29
31 32
34
30
33
1
1
1
2
2
2
3
3
4
2
1
SL 806058-1_IM.indd 9 2013-7-18 8:30:07

J10
H296
H298 B265 G13
D10
L2
E54
E15
H297
D10
J8
35
37 38
36
1
1
2
2
3
4
5
6
40mm
39
40
SL 806058-1_IM.indd 10 2013-7-18 8:30:09

J10
H296
H298 B265 G13
D10
L2
E54
E15
H297
D10
J8
35
37 38
36
1
1
2
2
3
4
5
6
40mm
39
40
SL 806058-1_IM.indd 11 2013-7-18 8:30:10

2
8
3
c
m
6
0
6c
m
152 cm
246 cm
Warning: Maximum fall heights 152 cm
SL 806058-1_IM.indd 12 2013-7-18 8:30:11