Snapper CSLT23460 (7800344) User manual

Parts Manual fo
r
HYDRO DRIVE ELECTRIC CLUTCH
LT-100 SERIES
LAWN TRACTOR
Revision E, TP 400-5400-E-TC-N6/2/2008
Briggs & Stratton Yard Power Products Group
Manual No. 7102341
535 Macon Road
McDonough, GA, 30253 U.S.A.
800-935-2967
MODEL
CSLT23460 (7800344)
CSLT24520 (7800345)
LT23460 (7800207)
LT23460 (7800315)
LT24520 (7800212)
LT24520 (7800317)
SLT23460 (7800342)
SLT24520 (7800343)

Table Of Content
s
TP 400-5400-E-TC-N
HYDRO DRIVE ELECTRIC CLUTCH
LT-100 SERIES 3
Manual No. 7102341
PAGE GROUP
4Hood / Seat Group
8Steering Group
10 Main Frame Group
14 Motion Drive Group
18 Fuel Tank Group
20 Engine Group
22 Housing Suspension Group
24 46" Mower Housing Assembly
28 46" Mower Deck Group
32 52" Mower Housing Assembly
34 52" Deck Blade Drive Assembly
36 52" Deck Housing Suspension Assembly
38 Decals
40 Electrical Group (23 & 24 H.P.)
42 Wiring Schematic (7101446)

TP 400-5400-E-TC-N
Manual No. 7102341 HYDRO DRIVE ELECTRIC CLUTCH
LT-100 SERIES
4

Hood / Seat Group
Footnotes:
TP 400-5400-E-TC-N
Manual No. 7102341HYDRO DRIVE ELECTRIC CLUTCH
LT-100 SERIES 5
Part No Descri
p
tionItem Qt
y
Note
1 7091016 4 SCREW, 1/4-20 x 5/8” Hex Washer Self-Tap w/loose captured washer
2 721487 1 BEARING, Steering
3 7101355 1 CONSOLE, Tractor
4 1929477 2 SCREW, #10-24 x 1/2” Hex Washer Head (Taptite) or 1960392
5 1732031 1 HOOD GUIDE, RH
5 1732030 1 HOOD GUIDE, LH (not shown)
7 1933896 2 NUT, #10-24 Hex Nyloc, BZ
8 7090952 4 SCREW, 1/4-20 Thread Cutting
9 7101493 1 CUTTING HEIGHT INDICATOR
10 7101770 1 POD, W/ DETENT
11 7101771 1 POD, W/ COMPARTMENT
12 725181 1 CONTAINER, Battery
13 722858 16 CAPSCREW, 5/16-18 Hex Washer Face
14 722411 2 SPRING, Compression 2.43 Length
15 7300677D 1 SEAT DECK
16 1727294D 1 PANEL, Hood RH Side
17 1727295D 1 PANEL, Hood LH Side
18 1722110D 1 HOOD, w/ Louvers
19 7102326 1 AIR DUCT, Plastic or 1731891
20 1960295 12 SCREW, 1/4-20 x 5/8” Hex Whiz Lock Flange, Black
21 1930641 12 NUT, 1/4-20 Large Hex Flange Lock, Black
22 7102076 1 LINK, Cruise Rod
23 7400261 1 WELDMENT, Latch Arm or 7300820
24 7101894 1 ROD, Pivot Cruise
25 7300805 1 CHANNEL, CRUISE
26 7101891 1 ACTUATOR, CRUISE
27 7102074 1 PULL KNOB, 1/4-20 Thread
28 7300696Z 1 BRACKET, Dash Support, RH
29 7300697Z 1 BRACKET, Dash Support, LH
30 7300810Z 1 BRACKET, Support Cruise
31 7400252Z 1 WELDMENT, Clutch Rod Support
32 7101860 1 SEAT, Hi Back
33 7300875D 1 SUPPORT, Seat
34 720102 2 BOLT, 5/16-18 Shoulder
35 720360 2 CAP, Push On (for .375 dia. Stud)
36 721259 1 ROD, Pivot
37 721214 1 SPRING, Leaf

Hood / Seat Group
TP 400-5400-E-TC-N
Manual No. 7102341 HYDRO DRIVE ELECTRIC CLUTCH
LT-100 SERIES
6

Hood / Seat Group
Footnotes:
TP 400-5400-E-TC-N
Manual No. 7102341HYDRO DRIVE ELECTRIC CLUTCH
LT-100 SERIES 7
Part No Descri
p
tionItem Qt
y
Note
38 722851 4 SCREW, 1/4-14 x 3/8” Hex Washer Self-Tap
39 720163 2 WASHER, .34 x .62 x 16 GA Flat
40 721425 2 WING BOLT, 5/16-18 UNC 2A
41 720101 1 BOLT, 1/4-20 x 3.652 2A Shoulder
42 721258 1 WASHER, Cup, 1.50 OD x 0.344 ID
43 727614 1 SPRING, Compression, 4.57 Free Length
44 7300794D 1 BRACKET, Seat Pivot
45 7091298 3 NUT, 5/16-18 Hex Nyloc
46 720146 1 NUT, 1/4-20 Hex Flange Lock
47 7300865Z 1 PLATE, Index
48 720182 12 FASTENER, Panel
49 7101772 1 MAT, Left
50 7101773 1 MAT, Right
51 7300818Z 1 STIFFENER, Steering
52 7300772Z 1 BULKHEAD
53 7300658Z 1 HOOD, Pivot LH
54 7300657Z 1 HOOD, Pivot RH
55 720097 2 BOLT, 3/8-16 Shoulder or 7101657
56 720142 2 NUT, 3/8-16 Hex Flange Lock, NC
57 7101458 1 HARNESS, Headlight, TCT, 1/4 Terminals
58 1727296 1 HEADLIGHT ASSY, (Includes #'s 59, 60, 61, & 62)
59 1728973 1 REFLECTOR, Headlight
60 1728974 1 LENS, Headlight
61 1723451 2 SOCKET, Light
62 1677371 2 BULB, 12.8V (1141)
63 1728059D 1 GRILLE, Snapper
64 7101810 1 INSERT, Light Bar
65 1732007 1 HOLE PLUG, Plastic for 7/8” dia. Hole
66 7102404 1 STRIP, Trim

Steering Group
TP 400-5400-E-TC-N
Manual No. 7102341 HYDRO DRIVE ELECTRIC CLUTCH
LT-100 SERIES
8

Steering Group
Footnotes:
TP 400-5400-E-TC-N
Manual No. 7102341HYDRO DRIVE ELECTRIC CLUTCH
LT-100 SERIES 9
Part No Descri
p
tionItem Qt
y
Note
1 729275 1 COVER, Integra
2 727628 1 STEERING WHEEL, (Soft Rim)
3 720973 1 BELLOWS, Steering Post
4 7101525 1 STEERING POST, 24.56 Long
5 722867 2 CAPSCREW, 5/16-18 Hex Washer Face
6 721242 1 BEARING, Lower
7 725138 1 GEAR PINION
8 720119 1 SNAP RING, 0.543 ID
9 722620 2 FLAT WASHER, 1.862 x .765 x 16 GA
10 721318 2 HUB CAP
11 7101563 2 WHEEL & TIRE ASSY, 20 x 10-8 used on 46” Deck (Calif.)
11 7101566 2 WHEEL & TIRE ASSY, 18 x 6.50-8 used on 52” Deck (Domestic 49-
State & Calif.)
12 720042 1 SCREW, 1/4-20 x 1” Hex Washer Self-Tap
13 722593 1 WASHER, .34 - 1.2 Flat
14 722598 2 WASHER, .76 - 1.2 Flat

Main Frame Group
TP 400-5400-E-TC-N
Manual No. 7102341 HYDRO DRIVE ELECTRIC CLUTCH
LT-100 SERIES
10

Main Frame Group
Footnotes:
TP 400-5400-E-TC-N
Manual No. 7102341HYDRO DRIVE ELECTRIC CLUTCH
LT-100 SERIES 11
Part No Descri
p
tionItem Qt
y
Note
1 7300869Z 1 RAIL, Frame LH
2 7300870Z 1 RAIL, Frame RH
3 722858 54 CAPSCREW, 5/16-18 Hex Washer Face
4 7091286 5 SCREW, #10-24 x 1/2” Hex Washer Self-Tap SEMS or 729075
5 7300876Z 1 TOP, Rear Plate
6 7300866Z 1 PLATE, Rear
7 7300864Z 1 PLATE, Hitch
8 7300689 1 PLATE, Idler Pulley Hydro Gear
9 7300741Z 1 BRACKET, Battery Support
10 722616 1 WASHER, .406 x 2.25 Plain
11 7300819Z 1 BRACKET, Pivot
12 720099 1 BOLT, 3/8-16 x 1.563 Shoulder
13 7300877Z 1 LINK, Handle Lift
14 7091809 5 PIN, 1/8 x 1-1/4” Cotter, YZ
15 7091619 6 NUT, 3/8-16 Hex Flange Lock, YZ
16 722603 2 WASHER, .391 ID x 1-1/4” OD or 7013866
17 725131 2 SPACER, Lifter Pivot
18 7500525Z 1 WELDMENT, Lifter
19 7300868Z 2 PLATE, Stiffening
20 721221 3 PIN, Threaded Shoulder (3/8-16)
21 7300863Z 1 PLATE, Engine
22 7300817Z 1 BRACKET, Muffler Mounting
23 7300830Z 1 BRACKET, Transaxle LH
24 7091008 2 BOLT, 3/8-16 x 2-1/2” Round Head Short Square Neck
25 7500601Z 1 ASSY, Idler Brkt (Secondary)
26 7300831Z 1 BRACKET, Transaxle RH
27 7400237Z 1 WELDMENT - Brake Lever
28 7092081 4 NUT, 5/16-24 Hex Flange Lock, BZ
29 7300751Z 1 BRACKET, Hanger Rear
30 725130 4 BEARING, SPINDLE
31 7010935 4 WASHER, .77 x 1.13 x .06
32 729160Z 1 GT AXLE, Cast Iron
33 7400232Z 1 WELDMENT, Spindle LH
34 7400231Z 1 WELDMENT, Spindle RH
35 720142 2 NUT, 3/8-16 Hex Flange, NC
36 720166 2 FLAT WASHER, .41 x .82 x 16 GA
37 720192 2 BOLT, 3/8-16 x 1-1/2” Hex, GR 5

Main Frame Group
TP 400-5400-E-TC-N
Manual No. 7102341 HYDRO DRIVE ELECTRIC CLUTCH
LT-100 SERIES
12

Main Frame Group
Footnotes:
TP 400-5400-E-TC-N
Manual No. 7102341HYDRO DRIVE ELECTRIC CLUTCH
LT-100 SERIES 13
Part No Descri
p
tionItem Qt
y
Note
38 722580 2 FLAT WASHER, 25/64 ID x 1” OD x 14 GA.
39 7300861Z 1 HANGER, Deck RH
40 7300860Z 1 HANGER, Deck LH
41 7300742Z 1 HANGER, Axle
42 720211 2 BOLT, 5/16-24 x 2-3/4” Hex Head
43 7500524 1 ASSY, Sector Gear (Gear Drive - LT)
44 7090585 5 NUT, 5/16-18 Hex Flange Lock, BZ
45 720103 2 BOLT, 3/8-16 Shoulder
46 7300867Z 1 PLATE, Steering Mount
47 721293 2 SCREW, Guide (5/16-18)
48 721240 1 GEAR, Sector
49 721241 1 BEARING, Sector Gear
50 7027168 1 SCREW, 5/16-18 x 1” Hex Head Cap, GR 5, YZ
51 7101805Z 1 DRAG LINK, LH
52 7101806Z 1 DRAG LINK, RH
53 7091619 2 NUT, 3/8-16 Hex Flange Lock, YZ
54 721095 2 FITTING, Lubrication (1/4-28 Self-Tap)
55 7300796Z 1 BRACKET, Bellcrank
56 720353 2 SCREW, 3/8-16 x 3/4 Hex Washer Self-Tap
57 7300960 1 GUIDE, Hydro Belt
58 720018 1 BOLT, 5/16-18 x 5/8 Hex Head, GR 5
59 7090951 1 NUT, 5/16-18 Hex Flange Center Lock or 720139
60 7091601 4 NUT, 5/16-18 Hex Flange Lock, GR 5

Motion Drive Group
TP 400-5400-E-TC-N
Manual No. 7102341 HYDRO DRIVE ELECTRIC CLUTCH
LT-100 SERIES
14

Motion Drive Group
Footnotes:
TP 400-5400-E-TC-N
Manual No. 7102341HYDRO DRIVE ELECTRIC CLUTCH
LT-100 SERIES 15
Part No Descri
p
tionItem Qt
y
Note
1 7101332 1 TRANSAXLE, Hydro Gear #310-0510 used on 23 HP models
1 7101669 1 TRANSAXLE, Hydro Gear #310-0610 used on 24 HP models
2 7101569 2 ASSY, Wheel & Tire, 22 x 9.50-12 (incl. next 3 items) used on 24 HP models
7101568 1 TIRE, 22 x 9.50-12 2 Ply K358
7101567 1 RIM, 12x x7 Int W/3 5 Lg Hub Silver
7012234 1 VALVE STEM, TR 412
3 7101563 2 ASSY, Wheel & Tire, 20 x 10-8 (incl. next 3 items) used on 23 HP models
7101562 1 TIRE, 20 x 10-8 2 Ply K358
7101558 1 RIM, 8 x 7 Broached Hub Wheel Silver
7012234 1 VALVE STEM, TR 412
4 720215 4 BOLT, 5/16-18 x 2-1/2” Hex Head, GR 5
5 727761 1 BOLT, 3/8-16 x 2 Square Neck Carriage
6 722440 1 SPRING, Extension Lift
7 721204 1 STUD, Spring Mounting (5/16-18)
8 725137 1 STUD, Swivel (3/8-16)
9 720145 4 NUT, 5/16-18 Hex Flange Lock, NC or 7091601
10 722620 2 FLAT WASHER, 1.862 x .765 x 16 GA
11 720010 2 E-RING, .750D x .050 T
12 721318 2 HUB CAP
13 720142 1 NUT, 3/8-16 Hex Flange, NC
14 2860694 2 NUT, 1/4-20 Hex Flange Lock (Nyloc) or 722393, 1/4-20 Hex Nyloc Nut
15 7300888Z 1 PLATE, Forward Stop
16 7091495 2 SCREW, 1/4-20 x 3/4 Hex Head Cap, GR 5
17 7900057 3 SCREW, #12-24 x 1/2” Hex Washer Self-Tap
18 7101653 1 FAN, 7.0 (Ten Blade)
19 7035500 1 BELT, Dual Spindle Brake HA Sect.; 85.4 Effective Length
20 720258 2 KEY, 3/16” Square x 2” long - Rear Wheels
21 720139 8 NUT, 5/16-18 Hex Flange Ser YZ
22 720018 4 BOLT, 5/16-18 x 5/8 Hex Head, GR 5 or 7091811
23 7300684Z 1 TORQUE BRACKET, Hydro
24 7300701Z 1 BRACKET, Roll Release
25 7101542 1 LEVER, Roll Release
26 720069 5 HAIR PIN, .092 Dia.
27 7101453 1 ROD, Rear Drive
28 7102053 1 ROD, Pivot Drive
29 7046451 1 SWIVEL, Adjustment (3/8-24)
30 7300682Z 1 BRACKET, Support

Motion Drive Group
TP 400-5400-E-TC-N
Manual No. 7102341 HYDRO DRIVE ELECTRIC CLUTCH
LT-100 SERIES
16

Motion Drive Group
Footnotes:
TP 400-5400-E-TC-N
Manual No. 7102341HYDRO DRIVE ELECTRIC CLUTCH
LT-100 SERIES 17
Part No Descri
p
tionItem Qt
y
Note
31 7200130 2 SPACER, Axle
32 722598 4 WASHER, 3/4 I.D. x 1-1/4 Flat
33 7400248Z 1 WELDMENT, Foot Control
34 1721675 1 PAD, Forward Foot
35 720049 3 BOLT, 5/16-18 x 5/8” Square Neck Carriage, GR 5
36 727933 1 SPRING, Extension
37 7101454 1 ROD, Front Drive (3/8-24)
38 7500602Z 1 WELDMENT, Idler Arm
39 722451 1 SPRING, Clutch
40 721419 1 PIVOT BUSHING
41 725178 1 IDLER PULLEY, 3 Dia.
42 725167 1 SPACER, 1/2 to 17mm
43 725177 1 IDLER PULLEY, 2.75 Dia.
44 720148 2 NUT, 3/8-16 Hex Flange, Zinc Plated
45 721420 1 NUT-Tee, (3/8-16)
46 7300934 1 LINK, Clutch
47 720100 1 SHOULDER BOLT, 1/4-20 x 3-3/4”
48 7101801 1 SPRING, Hydro Brake
49 720164 2 WASHER, .390 ID x .75 OD Flat
50 720387 1 PIN, .090 x 3/4 Cotter
51 7300940 1 LATCH - Parking Brake
52 7101489 1 ROD, Clutch Drive (3/8-16)
53 7101455 1 ROD, Parking Brake
54 720870 1 GRIP
55 720257 1 PEDAL, Clutch/Brake
56 7300960 1 GUIDE, Hydro Belt, Black Gloss

Fuel Tank Group
TP 400-5400-E-TC-N
Manual No. 7102341 HYDRO DRIVE ELECTRIC CLUTCH
LT-100 SERIES
18

Fuel Tank Group
Footnotes:
TP 400-5400-E-TC-N
Manual No. 7102341HYDRO DRIVE ELECTRIC CLUTCH
LT-100 SERIES 19
Part No Descri
p
tionItem Qt
y
Note
1 7101521 1 FUEL TANK, Tractor w/Cap (Snapper)
2 727333 1 FUEL CAP or 721049
3 7300653Z 1 BRACKET, Tank
4 7091016 2 SCREW, 1/4-20 x 5/8” Hex Washer Self-Tap
5 7091579 2 SCREW, 1/4-20 x 1/2” Hex Washer Self-Tap or 722866
6 721403 2 HOSE CLAMP, Yellow
7 1734981 1 HOSE, Fuel, Low Perm, 1/4” I.D. x 17” long

Engine Group
TP 400-5400-E-TC-N
Manual No. 7102341 HYDRO DRIVE ELECTRIC CLUTCH
LT-100 SERIES
20