Sony PXW-X500 User manual

SOLID-STATE MEMORY CAMCORDER
PXW-X500
SERVICE MANUAL
1st Edition

警告
このマニュアルは， サービス専用です。
お客様が， このマニュアルに記載された設置や保守， 点検， 修理などを行うと感電や火災，
人身事故につながることがあります。
危険をさけるため， サービストレーニングを受けた技術者のみご使用ください。
WARNING
This manual is intended for qualified service personnel only.
To reduce the risk of electric shock, fire or injury, do not perform any servicing other than that
contained in the operating instructions unless you are qualified to do so. Refer all servicing to
qualified service personnel.
WARNUNG
Die Anleitung ist nur für qualifiziertes Fachpersonal bestimmt.
Alle Wartungsarbeiten dürfen nur von qualifiziertem Fachpersonal ausgeführt werden. Um die
Gefahr eines elektrischen Schlages, Feuergefahr und Verletzungen zu vermeiden, sind bei
Wartungsarbeiten strikt die Angaben in der Anleitung zu befolgen. Andere als die angegeben
Wartungsarbeiten dürfen nur von Personen ausgeführt werden, die eine spezielle Befähigung
dazu besitzen.
AVERTISSEMENT
Ce manual est destiné uniquement aux personnes compétentes en charge de l’entretien. Afin
de réduire les risques de décharge électrique, d’incendie ou de blessure n’effectuer que les
réparations indiquées dans le mode d’emploi à moins d’être qualifié pour en effectuer d’autres.
Pour toute réparation faire appel à une personne compétente uniquement.
PXW-X500

CAUTION
Danger of explosion if battery is incorrectly replaced.
Replace only with the same or equivalent type rec-
ommended by the manufacturer.
When you dispose of the battery, you must obey the
law in the relative area or country.
ATTENTION
Il y a danger d’explosion s’il y a remplacement incor-
rect de la batterie. Remplacer uniquement avec
une batterie du même type ou d’un type équivalent
recommandé par le constructeur.
Lorsque vous mettez la batterie au rebut, vous devez
respecter la législation en vigueur dans le pays ou la
région où vous vous trouvez.
VORSICHT
Explosionsgefahr bei Verwendung falscher Batterien.
Batterien nur durch den vom Hersteller empfohlenen
oder einen gleichwertigen Typ ersetzen.
Wenn Sie die Batterie entsorgen, müssen Sie die
Gesetze der jeweiligen Region und des jeweiligen
Landes befolgen.
注意
指定以外の電池に交換すると，破裂する危険があり
ます。
必ず指定の電池に交換してください。
使用済みの電池は，国または地域の法令に従って
処理してください。
FÖRSIKTIGHET!
Fara för explosion vid felaktigt placerat batteri.
Byt endast mot samma eller likvärdig typ av batteri,
enligt tillverkarens rekommendationer.
När du kasserar batteriet ska du följa rådande lagar
för regionen eller landet.
PAS PÅ
Fare for eksplosion, hvis batteriet ikke udskiftes
korrekt.
Udskift kun med et batteri af samme eller tilsvarende
type, som er anbefalet af fabrikanten.
Når du bortskaffer batteriet, skal du følge
lovgivningen i det pågældende område eller land.
HUOMIO
Räjähdysvaara, jos akku vaihdetaan virheellisesti.
Vaihda vain samanlaiseen tai vastaavantyyppiseen,
valmistajan suosittelemaan akkuun.
Noudata akun hävittämisessä oman maasi tai
alueesi lakeja.
FORSIKTIG
Eksplosjonsfare hvis feil type batteri settes i.
Bytt ut kun med samme type eller tilsvarende
anbefalt av produsenten.
Kasser batteriet i henhold til gjeldende avfallsregler.
⌞ᝅ
⌞ᝅ
ྸ󰵳ᴪᦘⲺ⭫⊖у↙⺤θቧՐᴿ⠼⛮Ⲻধ䲟Ⱦ
ᴪᦘж㊱ශᡌ࡬䙖୼᧞㦆Ⲻ⭫⊖ශȾ
༺⨼⭫⊖ᰬθᗻ亱䚫ᆾ⴮ީ൦ᡌളᇬⲺ⌋ᗁȾ
PXW-X500

Table of Contents
Manual Structure
Purpose of this manual....................................................................................................................5
Related manuals ..........................................................................................................................5
Trademarks...............................................................................................................................5
1. Service Overview
1-1. Location of Printed Circuit Boards............................................................................................1-1
1-2. Circuit Description............................................................................................................1-2
1-2-1. CCD Block.............................................................................................................1-2
1-2-2. Camera Block...........................................................................................................1-2
1-2-3. Video Signal Block.....................................................................................................1-2
1-2-4. Media Recording and Playback Block.................................................................................1-4
1-2-5. System Control Block..................................................................................................1-6
1-2-6. Audio Block............................................................................................................1-7
1-2-7. Power Supply Block...................................................................................................1-12
1-2-8. Wireless Block........................................................................................................1-13
1-2-9. Camera Adapter (CA) Connection Block.............................................................................1-14
1-3. Connectors/Cables...........................................................................................................1-15
1-4. Connector Input/Output Signals.............................................................................................1-16
1-5. Functions of Onboard Switches and LEDs..................................................................................1-25
1-5-1. RE-326 Board.........................................................................................................1-25
1-6. Note for Replacement of IC or Board........................................................................................1-26
1-7. Description of CCD Block Number.........................................................................................1-27
1-8. Replacing Lithium Battery...................................................................................................1-28
1-9. Fixtures/Measuring Equipment List .........................................................................................1-30
1-9-1. Fixtures................................................................................................................1-30
1-9-2. Measuring Equipment.................................................................................................1-30
1-10. Circuit Protection Parts ......................................................................................................1-31
1-10-1. Fuse....................................................................................................................1-31
1-10-2. Circuit Protection Element............................................................................................1-31
1-11. Lead-free Solder.............................................................................................................1-32
1-12. Firmware Upgrade...........................................................................................................1-33
1-12-1. Upgrade Firmware for Camcorder....................................................................................1-33
1-12-2. Upgrade of Proxy Recording/Wireless LAN Connection Function..................................................1-35
1-13. Electrical Adjustment........................................................................................................1-37
1-14. Flexible Card Wire and Fine-Wire Coaxial Cable...........................................................................1-38
1-14-1. Disconnecting/Connecting Flexible Card Wire.......................................................................1-38
1-14-2. Disconnecting/Connecting Fine-Wire Coaxial Cable.................................................................1-38
1-15. Periodic Maintenance and Inspection........................................................................................1-40
1-15-1. Periodic Check/Replacement Parts List...............................................................................1-40
1-15-2. Notes on Replacement of the Battery Terminal.......................................................................1-40
1-15-3. Precaution on Hanging Bracket of Handle ...........................................................................1-40
1-15-4. Recommended Replacement Parts....................................................................................1-40
1-16. Installation of the Guard.....................................................................................................1-43
PXW-X500 1

2. Replacement of Main Parts
2-1. General Information for Parts Replacement..................................................................................2-1
2-1-1. Basic Knowledge.......................................................................................................2-1
2-1-2. Tightening Torque......................................................................................................2-2
2-2. Outside Panel Assembly......................................................................................................2-3
2-3. Inside Panel Section...........................................................................................................2-4
2-3-1. Inside Panel Assembly..................................................................................................2-4
2-3-2. FP-208 Board...........................................................................................................2-5
2-3-3. LCD Assembly........................................................................................................2-10
2-3-4. 3.5 inch LCD Assembly...............................................................................................2-15
2-3-5. DET-50 Board.........................................................................................................2-19
2-4. Front Section.................................................................................................................2-22
2-4-1. Front Assembly........................................................................................................2-22
2-4-2. CCD Block Assembly.................................................................................................2-25
2-5. DC Fan (30 Square)..........................................................................................................2-29
2-6. Wi-Fi Module/SD-58 Board.................................................................................................2-32
2-7. RE-326 Board................................................................................................................2-37
2-8. AU-360 Board...............................................................................................................2-38
2-9. DCP-67 Board...............................................................................................................2-39
2-10. HPR-53 Board...............................................................................................................2-41
2-11. DPR-362 Board..............................................................................................................2-45
2-12. EC-82 Board.................................................................................................................2-49
2-13. DC Fan (40 Square)..........................................................................................................2-52
2-14. IO-275 Board, DIF-232 Board...............................................................................................2-56
2-15. Connector Box Section......................................................................................................2-59
2-15-1. Connector Box Assembly.............................................................................................2-59
2-15-2. SW-1632 Board, AXM-52 Board.....................................................................................2-62
2-16. MB-1210 Board..............................................................................................................2-66
2-17. GP-1019 Board, CN-3723 Board............................................................................................2-69
2-18. SW-1652 Board..............................................................................................................2-70
2-19. LED-529 Board..............................................................................................................2-72
2-20. Handle Assembly............................................................................................................2-76
2-21. HN-415 Board...............................................................................................................2-78
2-22. KY-736 Board...............................................................................................................2-80
2-23. CI-50 Board..................................................................................................................2-81
3. Error Code
3-1. Main Code 91.................................................................................................................3-1
3-2. Main Code 92.................................................................................................................3-3
3-3. Main Code 95.................................................................................................................3-4
3-4. Main Code A0.................................................................................................................3-5
3-5. Main Code 01.................................................................................................................3-6
4. SERVICE Menu
4-1. Service Menu List.............................................................................................................4-1
4-1-1. Description of SERVICE Menu .......................................................................................4-1
4-2. Description of Menu..........................................................................................................4-4
4-2-1. Basic Menu Operation..................................................................................................4-4
PXW-X500 2

4-2-2. Service Menu...........................................................................................................4-4
4-2-3. How to Display the Service Menu......................................................................................4-4
4-3. Description of SERVICE Menu...............................................................................................4-5
4-3-1. SERVICE Menu........................................................................................................4-5
5. Spare Parts
5-1. Note on Repair Parts..........................................................................................................5-1
5-2. Exploded Views...............................................................................................................5-2
5-3. Supplied Accessories........................................................................................................5-22
6. Diagrams
Overall..................................................................................................................................6-1
Frame Wiring...........................................................................................................................6-2
PXW-X500 3

Manual Structure
Purpose of this manual
This manual describes the information items that premise the service based on the block parts assuming use of system
and service engineers.
Related manuals
The following manuals are available in this model.
If this manual is required, please contact your local Sony Sales Office/Service Center.
• Operation Guide (Supplied with the unit)
This manual is necessary for application and operation of the unit.
• Factory Service Manual
This manual describes the information items that premise the service based on the components parts.
Trademarks
Trademarks and registered trademarks used in this manual are as follows.
• SxS is the registered trademarks or trademarks of the Sony Corporation.
Other system names and product names written in this manual are usually registered trademarks or trademarks of
respective development manufacturers.
PXW-X500 5