Soto OD-2AL User manual

OD-2AL
Two Burner Stove for Family Camping

GENERAL SAFETY INFORMATION
This manual contains important information about the assembly, use and maintenance of this propane stove. Keep
this manual for future reference. Be sure to read this manual completely before using the OD-2AL. Keep this
manual and review it regularly to maintain awareness of procedures and warnings. This manual should be read in
conjunction with the warnings on the unit.
Failure to follow the warnings printed here and on the stove may result in fire, property damage, injury or death.
Particular attention should be paid to information accompanied by the safety alert words: DANGER, WARNING,
and CAUTION
FOR YOUR SAFETY
If you smell gas:
1. Do not attempt to light appliance.
2. Extinguish any open flame.
3. Disconnect from fuel supply.
WARNING!
Do not store or use gasoline or any liquids with flammable vapors in the vicinity of this or any other heat producing
appliance.
CARBON MONOXIDE HAZARD
This appliance can produce carbon monoxide which has not odor.
Using it in an enclosed space can result in serious injury or death.
Never use this appliance in an enclosed space such as a camper, tent, car or home.
DANGER
EXPLOSION −FIRE HAZARD
An imminent hazardous situation will result in death or serious injury if the following situations are not avoided.
●Never store propane near high heat, open flames, pilot lights, direct sunlight, or other ignition sources or where
temperatures exceed 120 degrees F (49 degrees C).
●Propane is heavier than air and can accumulate in low places. If you smell gas, leave the area immediately.
●Never install or remove propane tank while outdoor stove is lighted, near flame, pilot lights, other ignition
sources or while outdoor stove is hot to touch.
●During operation, this product can be a source of ignition. Never use the stove in spaces that contain or may
contain volatile or airborne particles or unknown chemicals. Minimum clearances from combustible materials: 12
inches from the sides and 48 inches from the top
WARNING
A potentially hazardous situation could result in death or serious injury if the following situations are not avoided
●Never leave stove unattended when hot or in use.
●Keep out of the reach of children.
●Not for use inside home, tent, RV or any area with poor ventilation.
1

2
WARNING (continued)
●Use the preset regulator that came with the stove. Do not attempt to adjust this regulator.
●This product is fueled by propane gas. Propane gas is invisible, odorless, and flammable. An odorant is normally
added to help detect leaks and can be described as a "rotten egg" smell. The odorant can fade over time so leaking
gas is not always detectable by smell alone.
●Propane gas is heavier than air and leaking propane will sink to the lowest level possible. It can ignite by ignition
sources including matches, lighters, sparks or open flames of any kind many feet away from the original leak. Use
only propane gas set up for vapor withdrawal.
●Propane gas should be stored or used in compliance with local ordinances and codes or with ANSI/NFPA 58.
Turn off propane when not in use.
●This fuel, and byproducts of combustion of this fuel, contain chemicals known to the state of California to cause
cancer, birth defects, or other reproductive harm. (CALIFORNIA PROPOSITION 65)
CAUTION
A potentially hazardous situation may result in minor or moderate personal injury or property damage if the
following situations are not avoided.
●This stove is a combustion appliance. All combustion appliances produce carbon monoxide (CO) during the
combustion process. This product is designed to produce extremely minute, non-hazardous amounts of CO if used
and maintained in accordance with tall warnings and instructions. Do not block air flow into our out of the stove. CO
produces flu-like symptoms, watery eyes, headaches, dizziness, fatigue and possibly death. If these symptoms are
present during operation of this product get fresh air immediately!
●Keep all connections and fittings clean. Inspect propane cylinder and stove propane connections for damage
before attaching.
●During set up, check all connections and fittings for leads using soapy water. Never use a flame. Bubbles
indicate a leak. Check that the connection is not cross-threaded and that it is tight. Perform another leak check. If
there is still a leak, remove the cylinder and contact SOTO for service.
●Use as a cooking appliance only. Never alter in any way or use with any device or part not expressly approved
by SOTO.
●Clean stove frequently to avoid grease accumulation and possible grease fires.
FOR OUTDOOR USE ONLY

3
■PREPARING THE RANGE FOR USE
■SPECIFICATIONS
1. Place the range on a flat, stable surface making sure that the
main unit (burner side with handle and control knobs) of the
range is on the bottom.
2. Unlock both buckles.
When opening the unit, the main unit (burner side) must be
placed on the bottom. If opening the unit when the main unit
is on top, the hinges connecting the main unit and storage
box may be dislocated and the parts contained in the main
unit may fall and cause damage.
CAUTION
Size: Width 43" x Depth 15" x Height 7.5" (The height
includes use of the windscreen.)
Size when closed: Width 21.5" x Depth 15" x Height 7"
Weight: 23.4 LB
Materials: Body -Aluminum/Stainless Steel,
Grill - Steel with chrome,
Windscreen-Stainless Steel, Cutting board-Polyethylene.
Fuel: LP gas (Propane)
Output: 15,000 BTU per burner head
■PARTS
3. Open the storage box (the box with attached buckles) as
shown in the picture.
MAIN UNIT
(BURNER SIDE) BUCKLES
STORAGE
UNIT
HOSE
WIND SCREEN
BURNER HEAD CYLINDER
NOZZLE
CONNECTION
WINDOWS
FUEL CONTROL KNOBS
GRILL
CUTTING BOARD
STORAGE UNIT
BURNER UNIT

4
CAUTION
■PREPARING THE RANGE FOR USE
4. Open the unit flat as shown.
6. Pull the grill up and forward.
7. Hold both burner heads with your hands. Then, lift and pull
forward as shown in the picture.
8. Remove pouch containing the hose/regulator unit and the
windscreen.
9. Return the heat shield plate to the burner unit.
When returning the heat shield plate back into the stove unit, make
sure that the opening of the fuel pipes and the fuel injection jets are
firmly connected. You should be able to observe and inspect the
connections by looking through the two windows placed on the heat
shield plate located directly above the fuel injection jet area for
visual inspections.
10. Place the grill as shown.
Make sure that the four
corners of the grill are
firmly secured as
shown in the picture.
5. If you wish to use the burner unit alone,lift the strage unit to
remove it from themain unit.
CAUTION
BURNER HEAD
HEAT SHIELD
PLATE
WINDOWS TO VIEW JET CONNECTIONS

5
CAUTION
■CONNECTING THE HOSE
11. Open the cover located at the side of the main unit to connect
the hose.
12. Connect the adapter located at the end of the hose to the
threaded pipe located on the main unit, then turn the adapter
clockwise until it is firmly secured.
CAUTION FOR GAS LEAKS
Make sure there is no damage to the hose, fittings, and all other
hose components. Use soapy water to detect gas leakage. Apply
soapy water to the hose and fittings after they are connected and
open the gas valve located at the cylinder. If you detect any
bubbles, there is a leak. DO NOT use the unit. Replace the
hose/regulator unit immediately.
■CONNECTING TO LARGE TANK
13. Securely connect hose unit to the propane gas cylinder.
Please note that the hose unit threads to the cylinder are to be
turned counter-clock wise.
■CONNECTING TO SMALL DISPOSABLE CYLINDER
ONLY USE CYLINDERS IN UPRIGHT POSITION. Using
upside down or on side will result in feeding liquid propane into
the system and result in a fire hazard.
■INSTALLING THE WINDSCREEN
16. There are four sections of the windscreen. Place the windscreen
section(s) as shown in the picture.
Insert the rod attached to
the windscreen into the
hole located at the corner of
the main unit as shown.
When installing the backside
windscreen, insert the tongue in the
slot located between the wall of the
main unit and the heat shield plate.
Then do the same for the other side.
CAUTION
14. Hand tighten adapter on
to disposable cylinder (either
14.1 oz tall or 16.4 oz short).
15. Securely connect hose
to adapter. Check for leaks.
17. Install the back windscreens first.

6
CAUTION
■INSTALLING THE WINDSCREEN
■IGNITING THE STOVE
■CONTROLLING THE FLAME
■EXTINGUISHING THE FLAME
■REMOVING THE CUTTING BOARD
■USING TOWEL/ACCESSORY BAR
■STOWING AND MAINTENANCE
■STOWING THE HOSE
18. Then, place the side windscreens.
1. Insert the side screen's hole
onto the pole located at the
end of the front-end
windscreen.
2. Then, place the side
windscreen firmly into the slot
located between the buckle
hooks.
Do the same for the other side
screen.
When the main unit is used in conjunction with the storage
unit, place the side windscreen located between the main
unit and the storage unit.
19. Make sure that all components are appropriately connected.
Turn the cylinder valve on. Turn the fuel control knob counter-
clockwise, while lighting with an ignition source such as a lighter
or match.
20. Control flame by turning the fuel control knob and observing
flame.
21. Turn the fuel control knob clockwise until it stops. Observe to
see that the flame is completely extinguished.
22. Lift both locking handles as shown.
23. Pull the cutting board toward you with both hands. LIft as shown.
24. Attach the towel / accessory bar as shown. Be sure to detach
bar before closing range for storage.
25. Stow the stove unit after it is completely cooled. When stowing,
wipe off the unit with a dry cloth and keep the unit in a dry area.
When stowing this stove, keep out of reach of children.
26. Insert the hose regulator and adapter into the slot located in the
pouch, stow under the heat shield plate located in the main unit.

2 burner stove. Ideal for long-term camping and various outdoor events. Built
tough yet beautifully crafted. Carry just like a suit case. Comes with resin cutting
board. The unit contains towel and cooking utensil rack, and foldable windscreen.
2 burner stove. Ideal for long-term camping and various outdoor events. Built
tough yet beautifully crafted. Carry just like a suit case. Comes with resin cutting
board. The unit contains towel and cooking utensil rack, and foldable windscreen.
OUTPUT : 3780kcal/hX2 4400WX2 15000BTUX2
Weight : 10.6kg(23.4 lb.)
Dimensions when in use : 109 x 38 x 19cm( 43 x 15 x 7.5inch)
Dimensions when stowed : 54.6 x 38 x 17.8cm(21.5 x 15 x 7inch)
OUTPUT : 3780kcal/hX2 4400WX2 15000BTUX2
Weight : 10.6kg(23.4 lb.)
Dimensions when in use : 109 x 38 x 19cm( 43 x 15 x 7.5inch)
Dimensions when stowed : 54.6 x 38 x 17.8cm(21.5 x 15 x 7inch)
OD-2AL
Two Burner Stove for Family Camping
Patent Pending
Shinfuji Burner CO.,LTD.
e-mail:hiroshi-y[email protected] (Hiroshi Yamamoto)
1-1-3 Miyukihama, Mito-cho, toyokawa-city 441-0314 Japan
Phone:[phone] FAX:[phone] URL:sotooutdoors.com