SportsPlay HERCULES CLIMBER VI User manual

Sheet 2 of 2
Sheet 2 of 2Sheet 2 of 2
Sheet 2 of 2
INSTRUCTIONS:
Layout footings as shown in the footing diagram and1.
dig. Using a transit le el make sure all holes are the
same depth.
Set the 2 center posts, le el and concrete. Let stand2.
24 hrs. or set the 2 center posts with "hot mix" and
let stand the recommended time as specified on the
concrete label.
Once main posts are set then begin building unit per3.
dwg. Install the plastic walls by attaching the brackets
with tabs to the panel as shown in Detail A. Once
the brackets are in place, attach them to the post with
self tapping screws as shown in Detail B. Be sure
to raise panel so that the bottom of panel is located
at the top of the safety surfacing. Finish attaching
the brackets on the main post then set the next
structure post in footing and attach it to the brackets.
Attach the 4-hole pipe brackets to the rope wall 4.
brackets (tighten set screws) and begin attaching
it to the post with self tapping screws as show in
Detail D. Again be sure to raise the brackets so
that the rope is just abo e the safety surfacing.
Begin installing the rope wall by pulling threaded5.
rods through the holes on the brackets and placing
the plastic bolts caps o er the rod and nut as
shown in Detail D.
Attach the 2 climbing ladders as shown per Detail6.
C with self tapping screws.
Finally make sure all posts and ladders are le el7.
and in line with each other and concrete. Allow 48
hrs before allowing play.
4321
HERCULES CLIMBER VI
HERCULES CLIMBER VIHERCULES CLIMBER VI
HERCULES CLIMBER VI
5
902-301
902-301902-301
902-301

"25
"25
29'
27'
56-1/2" 65"
65"
82"72" 72"
72"
72"
HERCULES CLIMBER VI
HERCULES CLIMBER VIHERCULES CLIMBER VI
HERCULES CLIMBER VI
54321
902-301
902-301902-301
902-301
D
DD
D
C
CC
C
A
AA
A
3
2
1
4
15
Sheet 1 f 2
Sheet 1 f 2Sheet 1 f 2
Sheet 1 f 2
FOOTING DIAGRAM
FOOTING DIAGRAMFOOTING DIAGRAM
FOOTING DIAGRAM
3
DETAIL B
7
8
15
16
B
BB
B
56-1/2"
15
DETAIL C
11
10
14
17
4
99
6
2 12
13
DETAIL A
8
DETAIL D
37
6
2
ITEM NO. PART
NUMBER DESCRIPTION QTY.
1 903-302 Arch Ladder Hercules Climbers 2
2 903-301 Plastic Panel Hercules Climbers 2
3 913-108 5" OD P st 11'-4" 2
4 905-302 Net f r Hercules Climbers 4
5 913-402 4 H le Attachment Brackets 8
6 913-417 Panel Attachment Bracket 16
7 905-208 Gasket f r Attachment Brackets 24
8 905-526 Self-Tapping Tamper Resistant T rx
#27 Screw 110
9 316-601 3/8" Flat Washer SS 46
10 216-601 3/8" Hex Nut SS 14
11 905-847 B lt Caps 14
12 216-512 5/16" x 1" Butt n Head Nut SS 16
13 116-530BPS 5/16" x 1" Butt n Pin SS 16
14 326-501 5/16" L ck Washer SS 16
15 903-307 R pe Brackets Hercules Climber 2
16 196-807 3/8" x 3/8" S cket Set Screw 8
17 905-261 T rx Driver w/C llar #27 Tamper
Resistant 2
18 105-015 1-5/8" Alum Pipe Plug 4
19 416-350 3/16" S cket Key 1