Tatoma MV-30D User manual

MV-30D
VERTICAL MIXER
TWO AUGERS
SIDE DISCHARGE
MVL-30D (1059 cu.ft.)
FRONT DISCHARGE
MV-30D (1059 cu.ft.)
OWNER’S MANUAL
EDITION: JAN/2020
TATOMA AGRICULTURAL EQUIPMENTS CORP.
6238 HWY 412
COLCORD, OK 74338
PH. [phone]
-0-

VERTICAL TOWED MIXER - TWO AUGERS
MV-30D SERIES
INDEX
PREVIOUS INSTRUCTIONS ...................................................................................... - 4 -
SERIAL NUMBER PLATE ................................................................................................. - 5 -
RECEPTION AND IDENTIFICATION OF THE MIXER .......................................................... - 6 -
WARRANTY CONDITIONS .............................................................................................. - 7 -
REQUIREMENTS FOR THE OPERATOR ............................................................................ - 9 -
SAFETY WARNINGS AND RECOMMENDATIONS ........................................................... - 10 -
DANGER AND WARNING SIGNS ................................................................................... - 11 -
INSTRUCTIONS AND PRECAUTIONS AT WORK ............................................................. - 21 -
MAINTENANCE INSTRUCTIONS ................................................................................... - 22 -
AT THE END OF THE WORK. ......................................................................................................... - 23 -
SOLVING PROBLEMS .................................................................................................................... - 24 -
SAFETY STANDARDS AND GUIDELINES......................................................................................... - 12 -
USE AND CONSERVATION OF THIS MANUAL ............................................................... - 25 -
MIXER DESCRIPTION............................................................................................ - 26 -
INTRODUCTION........................................................................................................... - 26 -
USE OF THE MIXER ...................................................................................................... - 27 -
MAIN PARTS OF THE MIXERS ...................................................................................... - 28 -
INSTRUMENTS AND MIXER COMMANDS ............................................................. - 33 -
HITCH .......................................................................................................................... - 33 -
POWER TAKE OFF AND 2-SPEED GEARBOX .................................................................. - 34 -
FRONT JACK ................................................................................................................ - 36 -
MIXER CONTROLS ....................................................................................................... - 38 -
LIGHTING AND SIGNALING .......................................................................................... - 41 -
PARKING BRAKE .......................................................................................................... - 42 -
BATTERY ..................................................................................................................... - 44 -
WEIGHING SCALE ........................................................................................................ - 45 -
CONNECTIONS BETWEEN MIXER AND TRACTOR.......................................................... - 46 -
USING THE MIXER ............................................................................................... - 48 -
START UP .................................................................................................................... - 49 -
LOADING THE MIXER................................................................................................... - 53 -
OPERATION AND USE OF RETAINERS........................................................................... - 54 -
PREPARATION OF THE MIXTURE ................................................................................. - 55 -
DISTRIBUTION OF THE MIXTURE ................................................................................. - 56 -
STOPPING THE MIXER ................................................................................................. - 60 -
LOADING TESTS ........................................................................................................... - 61 -
Tatoma Ag Equipments Corp. Located in Colcord, OK. Phone [phone]
-1-

VERTICAL TOWED MIXER - TWO AUGERS
MV-30D SERIES
ACCESS INTO THE TUB ................................................................................................. - 62 -
LONG TERM STOP OF THE MIXER ................................................................................ - 63 -
MAINTENANCE OF THE MIXER ............................................................................. - 64 -
GENERAL INDICATIONS FOR MAINTENANCE ............................................................... - 64 -
MAINTENANCE OPERATIONS ...................................................................................... - 65 -
CHECKING LEVELS ....................................................................................................... - 67 -
GREASING ................................................................................................................... - 69 -
WHEELS AND TIRES ..................................................................................................... - 72 -
BATTERY(Optional) ..................................................................................................... - 73 -
LOADING AND MIXING SYSTEM .................................................................................. - 74 -
UNLOADING CONVEYOR ............................................................................................. - 76 -
HYDRAULIC INSTALLATION .......................................................................................... - 78 -
ELECTRICAL INSTALLATION .......................................................................................... - 80 -
LONG TERM STOP OF THE MIXER ................................................................................ - 82 -
OPTIONAL EQUIPMENT ............................................................................................... - 85 -
OPERATING FAULTS ............................................................................................. - 86 -
Tatoma Ag Equipments Corp. Located in Colcord, OK. Phone [phone]
-2-

VERTICAL TOWED MIXER - TWO AUGERS
MV-30D SERIES
ATTENTION! PLEASE READ CAREFULLY
THIS OWNER’S MANUAL BEFORE
YOU START USING THE MIXER
The mixers manufactured by TATOMA are designed to facilitate your daily work, save
you time and improve the performance, benefits and profitability of your operation.
With a TATOMA mixer, you can rationalize the feeding of your livestock, improving the
efficiency of your work.
The breadth of our product range allows us to solve any of the needs of our customers.
Tatoma Ag Equipments Corp. Located in Colcord, OK. Phone [phone]
-3-

VERTICAL TOWED MIXER - TWO AUGERS
MV-30D SERIES
PREVIOUS INSTRUCTIONS
Congratulations on the purchase of your new TATOMA Vertical Towed Mixer. With the
correct use and preventive maintenance, your mixer will last for years.
When you see this symbol, be alert to the possibility of personal
injury and, carefully read the message next to it.
NEVER OPERATE WITHOUT all covers, shields and protections in place.
KEEP hands, feet and clothing away from moving parts.
In this manual, some covers, and protections have been removed in the pictures for
illustrative purposes only. The equipment must not be operated under these
conditions, so all protections must be kept in place. If the removal of the protection
becomes necessary for repairs, restore it immediately after work is finished and before
use.
The warranty is shown on the cover of this book along with the Certificate of
Registration and Inspection.
For information on how to order spare parts, see the “part repair section” in the
second part of this book.
The serial number plate is located on the front-right side of the mixer. This number
must be registered in the Certificate of Registration and Inspection to correctly
reference your TATOMA mixer.
It is recommended that you read this manual and follow the instructions carefully.
Your efforts will be rewarded with better performance and service, as well as savings
in time and repair costs.
If you do not read the manual and take for granted your full knowledge of the
operation of the machine, improper handling of the machine can lead to serious injury.
If you do not understand the instructions in this manual, contact your nearest dealer.
This manual replaces all previous published
Tatoma Ag Equipments Corp. Located in Colcord, OK. Phone [phone]
-4-

VERTICAL TOWED MIXER - TWO AUGERS
MV-30D SERIES
SERIAL NUMBER PLATE
Below is an image of the serial number plate.
The plate is located on the front right side of the mixer, on the frame.
Tatoma Ag Equipments Corp. Located in Colcord, OK. Phone [phone]
-5-

VERTICAL TOWED MIXER - TWO AUGERS
MV-30D SERIES
RECEPTION AND IDENTIFICATION OF THE MIXER
Upon receipt of the mixer, the owner/operator must proceed as follows:




Check that the mixer is supplied with the corresponding instruction
manual.
Read the owner’s manual carefully, paying special attention to the safety
recommendations.
Check that the mixer has no damage or failure.
Check that the mixer is delivered with all the accessories and optional
elements you requested.
Once the mixer has been delivered and before it is used, qualified TATOMA personnel
will instruct the owner/operator about the handling, maintenance, and safety
regulations to be taken into account for its correct use.
The reading and correct understanding of this manual remains under the entire
responsibility of the person in charge of the mixer’s operation.
¡Attention! If the owner sells/rents the mixer, he must
also deliver the owner’s manual and instruct the new
owner about the above procedures.
Tatoma Ag Equipments Corp. Located in Colcord, OK. Phone [phone]
-6-

VERTICAL TOWED MIXER - TWO AUGERS
MV-30D SERIES
WARRANTY CONDITIONS
TATOMA offers a 12-month warranty for the entire range of products, against any
manufacturing defect. The validity of the guarantee will be subject to the following
conditions:
1. Any damage caused to the machinery during its transportation shall be covered
by the freight company. Claims must be carried out by those who have
contracted the transport service.
2. The 1-year warranty period will start from the date of receipt of the machinery
by the end user.
3. The warranty covers, only and exclusively, the free replacement of components
that were defective when they left the factory.
4. Free replacement of those components that have failed under circumstances
other than those indicated in the previous point, will be excluded from the
warranty.
5. In case of replacement of defective components and/or the performance of
repairs by TATOMA personnel, once the warranty has been accepted, the costs
corresponding to travel and labor will be borne by the TATOMA.
6. VERY IMPORTANT: The defective components must be returned to TATOMA
within a period of fifteen days, after the replacement of the same. Otherwise,
the warranty will not be managed, and the costs of the replaced components
and labor will be borne by the buyer of the machinery.
7. The components that are subject to wear are not covered by the warranty.
8. Warranty claims must be made by written (email), through the dealer or
directly to TATOMA.
9. TATOMA reserves the right to verify possible claims and assess whether they
are covered by the warranty or not.
10. Any faults and/or damage produced in the machinery in the following cases will
result in the immediate cancellation of the warranty:
a. Improper maintenance or performed by unqualified personnel
b. Improper use of the machine, or for functions other than those specified
in this instruction manual.
c. Use of the machinery by personnel not instructed in its handling.
d. Repairs made by unauthorized personnel.
Tatoma Ag Equipments Corp. Located in Colcord, OK. Phone [phone]
-7-

VERTICAL TOWED MIXER - TWO AUGERS
MV-30D SERIES
e. Handling or disassembly of parts of the machinery by unauthorized
personnel.
f. Use of spare parts not original or not specified by TATOMA.
g. The modification, or addition of any element that varies the original
design of the machinery.
h. Failure to comply with safety regulations and recommendations
included in this instruction manual.
i. Tow the machinery with vehicles not suitable for this purpose, or
without using a trailer. The machinery is not prepared to be towed by
roads or highways.
j. Exceptional events such as accidents or weather.
11. TATOMA declines all responsibility for the possible damages caused to people
or things due to any of the actions mentioned in the previous section.
12. TATOMA reserves the right to modify the design and/or specifications of its
products without prior notice.
13. In case of doubt or litigation, contact the authorized dealer.
Tatoma Ag Equipments Corp. Located in Colcord, OK. Phone [phone]
-8-

VERTICAL TOWED MIXER - TWO AUGERS
MV-30D SERIES
REQUIREMENTS FOR THE OPERATOR
The handling of this mixer will be limited to competent and experienced operators.
Likewise, anyone who is going to act or work around the mixer should use common
sense.
In order to be considered a qualified person, he or she must also meet other
requirements, such as;
1. Some regulations specify that no person under sixteen (16) years old can handle
machinery. It is your sole responsibility to know that it is within the scope of these
standards.
2. Current OSHA regulations state: At the time of initial assignment and, at least
annually, the employer shall instruct each employee in the safe handling and
maintenance of all equipment with which said employee is going to be in touch.
3. Unqualified personnel must REMAIN OUTSIDE THE WORK AREA.
4. A person who has not read and understood all operational and safety instructions
will not be qualified to operate machinery.
NOT READING THIS MANUAL WILL CARRY A BAD USE OF THE EQUIPMENT
Tatoma Ag Equipments Corp. Located in Colcord, OK. Phone [phone]
-9-

VERTICAL TOWED MIXER - TWO AUGERS
MV-30D SERIES
SAFETY WARNINGS AND RECOMMENDATIONS
TAKE NOTE! This safety alert symbol is used to call your attention
about the instructions that affect your personal safety and, the
safety of others. Failure to follow these instructions may result in
injury or death.
Identifying, correctly interpreting and respecting the indications of the warning signs
located at the different points of the mixer, as well as properly identifying the
importance of the indications and recommendations, included in this manual,
contributes unequivocally to prevent accidents that can cause serious damage and
injury.
It is recommended to read this section with special attention in order to quickly and
correctly identify and interpret the warning signs described below.
Symbols used in the user’s manual
ATTENTION!
BE CAREFUL!
YOUR SECURITY IS AT STAKE!
It indicates, in general, that the instruction it accompanies
is of particular importance.
Look closely the safety messages that accompany the DANGER, WARNING and
CAUTION signal. These messages have been selected using the following criteria:
DANGER: Indicates an imminently hazardous situation that, if not avoided, will result
in serious injury or death. This word in the signal is limited to the most extreme
situations, for machine components that, for functional reasons, cannot be monitored.
WARNING: Indicates a potentially hazardous situation that, if not avoided, will result in
serious injury or death, and includes the risks to which it is exposed when guards are
removed. It can also be used to alert against unsafe practices.
CAUTION: Indicates a potentially dangerous situation that, if not avoided, may result in
moderate or serious injury. It can also be used to alert against unsafe practices.
Tatoma Ag Equipments Corp. Located in Colcord, OK. Phone [phone]
- 10 -

VERTICAL TOWED MIXER - TWO AUGERS
MV-30D SERIES
DANGER AND WARNING SIGNS
Safety symbols located on the machine
Attention! Warning, never lower the
unloading conveyor without first
checking the presence of people or
obstacles in your movement area
Location
Side
discharge
Attention! Danger, auger rotation
can cause serious injuries and
death.
Outside
the tube
Attention! Danger, rotation of the
drive shafts can cause serious injury
and death.
Front of
the mixer
Attention! Warning for projections
of pressurized fluids. Check the
instructionmanualbefore
proceeding with any maintenance
operation
Front of
the mixer
Attention! Danger, do not climb
into the mixer while it’s running
Front of
the mixer
Attention! Danger, stay out of the
articulation zone while the machine
is running
Hitch
Tatoma Ag Equipments Corp. Located in Colcord, OK. Phone [phone]
- 11 -

VERTICAL TOWED MIXER - TWO AUGERS
MV-30D SERIES
SAFETY STANDARDS AND GUIDELINES
Most accidents are caused by human errors. The operator must be careful and
methodical and take the necessary precautions in order to avoid the possibility of
injury or death.
Next, a series of mandatory regulations are established to avoid unnecessary risks that
could lead to possible accidents.
STEP 1: BEFORE YOU START USING THE MIXER
- Carefully study and understand this manual.
- Before start working with the mixer, the operator must
familiarize with the controls, with their functions and should read
carefully this instruction manual.
- It is strictly forbidden to perform any operation with the mixer
before reading the owner’s manual and receiving the training
from TATOMA.
- Respect the instructions contained in this manual, and the
legislation related to safety and accident prevention
requirements.
- Do not wear loose clothing that can be caught by moving parts. Always wear
protective clothing and appropriate footwear.
- Keep the wheel nuts or bolts tightened to the specified torque (220 ft-lb), and make
sure the tires are inflated evenly.
- Dedicate a previous visual inspection to check for loose bolts, defective parts or
broken welds, and make the necessary repairs. Follow the safety and maintenance
instructions included in this manual.
- Make sure there are no tools on the floor, on the mixer or inside the mixing bowl.
- Do not use the mixer till you are sure the area is completely clear of personnel.
- It is the responsibility of the mixer operator, to know the lighting requirements
established by the local and road authorities, so will have to install and maintain the
components of its equipment in correct condition and comply with the regulations in
force.
Tatoma Ag Equipments Corp. Located in Colcord, OK. Phone [phone]
- 12 -

VERTICAL TOWED MIXER - TWO AUGERS
MV-30D SERIES
- All operators involved in the operation of the mixer must practice the mixing
operation in empty, as well as the loading and unloading operations, until they
become fully familiar with them, before using the loaded mixer.
- Do not rush the learning process and do not take anything for granted, it is essential
to familiarize yourself with your new mixer before operating.
- Do not attempt to operate the mixer under the influence of drugs or alcohol.
STEP 2: MIXER SET UP
- Before using the mixer, check that all protection devices are in place and in good
condition. If a protection is removed for maintenance or repair, reinstall it immediately
after maintenance or repair is completed. Damaged protections must be replaced
immediately.
- The mixer has been designed to be towed by a tractor. It is strictly forbidden to use
any other type of vehicle for towing, as the stability and visibility conditions on the
different mixer mechanisms during the use may vary considerably.
In order to hitch the tractor with the mixer, consider the following:
- Make sure nobody is around the mixer when approaching the tractor.
- Adjust the height of the hitch and center the shot with the tractor, never center it
manually. Perform this operation with the mixer completely horizontal.
- When lowering the jack, make sure that there is no crushing risk.
- Couple the mixer hoses and electric connections to the tractor using work gloves.
Once the mixer is hitched, in order to connect the PTO shaft, take into account the
following precautions:
- Check that the hitch has been correctly made.
- To avoid transmission damage, adjust the tractor drawbar to the recommended
setting. The mixer should be leveled with the tractor when hitching.
- Be sure the tractor power take-off is not working.
- Handle the transmission elements with work gloves.
- Do not wear loose clothes at the time of this operation.
- Do not pass or jump over the PTO shaft.
Tatoma Ag Equipments Corp. Located in Colcord, OK. Phone [phone]
- 13 -

VERTICAL TOWED MIXER - TWO AUGERS
MV-30D SERIES
- Respect the position of the PTO shaft protections (tractor and mixer sides) and fix
them in their correct location using the appropriate devices.
- Finally unlock the parking brake.
STEP 3: START USING THE MIXER
- Before accessing the tractor cabin check the status of the different mechanisms and
protections of the mixer.
- Adjust the driver's seat so that access to the mixer controls is carried out
comfortably.
- Adjust the rearview mirrors of the tractor so that there is good visibility on the mixer
mechanisms, without their adjustment affecting the visibility for driving. It is
recommended to request the help of another person to perform this operation.
- Check the presence of people before moving the mixer. Be careful with the
spectators, especially with the children. Always look around to make sure it is safe to
start the engine and move the unit. If necessary, indicate with the horn or other means
that the mixer will be set in motion. This is very important, since with the noise levels
of the tractor / mixer and the isolation of the cabins, you cannot hear people
screaming.
- It is strictly forbidden to operate the mixer by several people simultaneously, so it will
only be used by the driver.
- It is strictly forbidden to transport people, animals or any type of objects on the
mixer.
- Under no circumstances will the mixer be used to tow other vehicles, move or push
objects or lift loads. It is strictly forbidden to access the mixer through the loading
device or use it by people, as a system to reach high points.
- In order to maneuver, make sure there are no people or obstacles behind or near the
mixer, in case you don’t have enough visibility, request the help of other people.
Tatoma Ag Equipments Corp. Located in Colcord, OK. Phone [phone]
- 14 -

VERTICAL TOWED MIXER - TWO AUGERS
MV-30D SERIES
STEP 4: DRIVING THE MIXER
- The driving of the mixer must be adapted to the conditions of the terrain or the route
through which it circulates.
- Maintain a prudential distance to ditches, canals, gutters, slopes, ditches, etc., since it
can yield the ground and cause the mixer to tip over, together with the tractor.
- Access to the mixer, or the proximity to its work area, should be prohibited to any
person outside the operation in which it operates.
- When working with the mixer, the operator must always check that there is nobody
in the work area. Likewise, you must report the risks that exist to the personnel close
to their work area.
- During the loading of the machine the driver must ensure that there is nobody on the
silo. In case of direct loading to the tank from the automatic silo, the driver will remain
inside the cabin at all times. If the load is made with auxiliary machinery, the access of
people in the work area must be prohibited. Never exceed the load capacity of the
mixer.
- Observe the work area and the terrain, watch out for holes, rocks or other obstacles.
Always inspect the area before operation.
- Avoid sudden starts and stops. Choose a uniform level as a route during transport
through the fields.
- Do not use the mixer near the edge of slopes or terraces. Do not operate on steep
slopes. Operate from top to bottom and not through the slopes.
Tatoma Ag Equipments Corp. Located in Colcord, OK. Phone [phone]
- 15 -

VERTICAL TOWED MIXER - TWO AUGERS
MV-30D SERIES
- Maneuver the vehicle at safe speeds. Reduce speed before turning to avoid the risk
of tipping over. Avoid sharp turns uphill on steep slopes.
- Always keep the vehicle running to provide engine braking when going downhill.
- Avoid aerial, electrical and telephone cables or other
obstacles
- Contact with electric overhead lines could cause
serious injury or death.
STEP 5: ROAD TRANSPORTATION
- Comply with state and local laws governing road safety and the circulation of
agricultural machinery on public roads.
- When driving on public roads with the mixer, the rules of the current traffic code
must be observed and respected.
- In order to maneuver or move with the road mixer, the loading/unloading system
(depending on the model) must be in its transport position.
- Use approved lighting fixtures, banners and warning devices necessary to protect
other vehicles drivers on the road during the day and night transportation.
- The use of flashing amber lights is acceptable in most locations, however, some
prohibit their use. It must be checked for all road lighting and comply with the
requirements established by local laws.
- When driving the mixer by road or highway below 20 MPH (40 KPH) at night or during
the day, use amber or / and a slow moving vehicle (SMV) with the emblem of
identification.
- Plan your route to avoid heavy traffic. Be a courteous and safe driver. Always give
way to traffic in risky situations, such as narrow bridges, intersections, etc.
Tatoma Ag Equipments Corp. Located in Colcord, OK. Phone [phone]
- 16 -

VERTICAL TOWED MIXER - TWO AUGERS
MV-30D SERIES
- Respect the load and height ratings of bridges and tunnels. Do not cross bridges or
tunnels with a rating lower than the total weight or height of the tractor-mixer
assembly.
STEP 6: DURING OPERATION, MOVING ELEMENTS
- When the mixer is in operation, do not look inside the tub, or handle the product
inside it.
- If it is necessary to access the tub, keep in mind there is a danger of falling. Access to
the tub must be carried out exclusively by experienced personnel, with the mixer
completely stopped and with the tractor key held by the person accessing it.
- Before accessing the inside of the tub, it is recommended, as an additional safety
measure, to disconnect the cardan from the tractor power take-off.
- It is strictly forbidden to incorporate devices into the mixer, which allow access to the
tank with a height higher than the marked by the last step of the access ladder.
- Operate with the utmost caution when handling the mobile elements of the mixer
and make sure that there is nobody close before operating them, otherwise, the mixer
driver must proceed to warn and evacuate the work area.
- Do not open the protections of the mixer mechanisms when they are running, or
manipulate moving elements such as the unloading conveyor, etc.
- Do not clean, lubricate or adjust the mixer while it is moving.
- Caution, do not wear loose clothing when approaching the moving parts of the mixer
or the power take-off and gimbal. Check at all times that all safety guards and
protections are in their correct position and in good condition.
- As a precaution, recheck the mixer every 100 hours of operation. Correct all problems
and follow maintenance safety procedures.
- Never leave the mixer running
Tatoma Ag Equipments Corp. Located in Colcord, OK. Phone [phone]
- 17 -

VERTICAL TOWED MIXER - TWO AUGERS
MV-30D SERIES
STEP 7: MAINTENANCE WORKS. HIGH PRESSURE FLUIDS, WELDS…
It is the responsibility of the owner/operator
of the mixer to perform good maintenance.
Poor maintenance is an invitation to problems
and breakdowns.
- The area where machine maintenance work is carried out
should be sufficiently ventilated. Never do these works with
the tractor engine running in a closed building. Exhaust gases
can cause suffocation.
- Before working inside the mixer, stop the vehicle completely,
apply the parking brake, disengage the power take-off and
power cables, turn off the engine and remove the ignition key.
- Make sure all moving parts of the accessories have stopped
completely before performing any maintenance work.
- Always use a safety system to block the wheels, such as parking blocks. Never use a
jack to support or support the machine while doing such work.
- Always use the most appropriate tools and equipment for the type of work you do by
hand. Always wear protective gloves and be very careful when making adjustments.
- Replace all covers and protections after repair and before moving the mixer.
- After work, make sure that all the tools, parts and
equipment that have intervened in the service are collected
separately.
- Pressurized fluid can penetrate the skin through openings
and small wounds and cause serious injury or death.
- Avoid this danger, relieving hydraulic pressure before
disconnecting any hydraulic line. Tighten all connections
before applying pressure.
- Never use your hands to locate hydraulic leaks in pressure
pipes. Look for possible leaks with a small piece of cardboard
where oil is reflected and protects hands and body from high
pressure fluids.
Tatoma Ag Equipments Corp. Located in Colcord, OK. Phone [phone]
- 18 -

VERTICAL TOWED MIXER - TWO AUGERS
MV-30D SERIES
- If such an accident occurs, go to the nearest
medical center immediately. The fluid injected into
the skin should be surgically removed within the first
few hours or it could cause gangrene.
- Do not allow grease to accumulate and remove
spilled oil immediately from the ladder and the
operator platform and other access areas. Keep all
access areas clean and clear of obstacles.
- Never replace the original screws with others of less than grade eight (8.8), unless
otherwise specified.
- A first aid kit must be accessible in the performance of the maintenance work of this
mixer.
- When welding work is carried out on the mixer, prevent current from flowing through
the balls of the bearings or the chain rollers by directly grounding the element being
welded.
- Clean the area before welding and have an extinguisher accessible at all times.
- Always disconnect when welding, weighing scale, load cells and power supply,
preventing electricity from passing through them. Also disconnect the alternator from
the tractor if the mixer is still attached to it when welding.
- Tire explosion may cause serious injury. Do not
exceed the recommended tire pressure. See the
Specifications section of the Owner’s Manual, to
apply the correct pressure to the tires.
- Replace worn or damaged tires with the one
corresponding to the equipped tire. See the
Specifications section of the Instruction Manual for
the correct tire size.
- Do not weld on the tire when the tire is installed. Welding can cause an explosion of
the air / gas mixture carried by the wheel when it is started at high temperatures.
Tatoma Ag Equipments Corp. Located in Colcord, OK. Phone [phone]
- 19 -