UUNI 3A User manual

Uuni-3A-Gas Burner
Manual

1
Please read the present legal disclaimer fully before assembling, installing and using/
servicing your Uuni-3A-Gas Burner attachment part in connection with your Uuni 3
oven. Failure to comply with all the provisions of the present legal disclaimer could
result in property damage, serious bodily injury or even death, or in a fire causing
damage to property.
1. When using Uuni 3 oven together with your Uuni-3A-Gas Burner attachment
part, bear in mind that (i) the Uuni-3A-Gas Burner attachment part shall only be
used with your Uuni which excludes any other appliance, and (ii) the entirety of
the provisions of the Uuni 3 oven’s Safety Legal Disclaimer also apply to the use
of the your Uuni-3A-Gas Burner attachment part in addition to the provisions of
the present safety legal disclaimer. You are strongly advised to not use your Uuni
3 oven with the Uuni-3A-Gas Burner attachment part until your Uuni 3 oven has
been thoroughly and properly gas leak-tested.
2. Combustion by-products, produced when using the Uuni 3 oven with your Uuni-
3A-Gas Burner attachment part, contain carbon and carbon monoxide in the flue
gas of Uuni-3A-Gas Burner; these substances, if inhaled indoors or in any other
unventilated area, are known as a possible cause of death through asphyxiation
and/or carbon monoxide poisoning.
3. If Uuni-3A-Gas Burner does not light, turn knobs OFF, wait 5 minutes, and try
again. Always close the gas valve during the 5 minute waiting period. If Uuni-3A-
Gas Burner does not ignite with the valve open, gas will continue to flow out of
Uuni-3A-Gas Burner and could accidentally ignite with risk of injury.
4. If a gas leak is detected at any time, STOP and call the fire department. Leaking
propane may result in explosion, fire, severe personal injury, or death. If you
smell gas (1) shut off gas to the appliance, (2) extinguish any open flame, (3)
open door, and (4) If odour continues, keep away from your Uuni 3 oven and
immediately call your gas supplier or your fire department. If you cannot stop a
gas leak, immediately close LPG (propane) valve and call LP gas supplier or your
fire department. If “growing” bubbles appear in the cylinder do not use or move
the LPG (propane). Contact an LP gas supplier or your fire department.
5. Do not store or use gasoline or other flammable liquids or vapours in the vicinity
of your Uuni 3 oven or any other appliance. Do not insert any tool or foreign object
into the valve outlet or safety relief valve. You may damage the valve and cause a
leak. Never attempt to attach your Uuni-3A-Gas Burner to the self-contained LP
gas system of a camper trailer or motor home. Never operate your Uuni 3 oven
with LPG (propane) in any other position other than that specified in assembly
instructions. Always close LPG (propane) valve before moving LPG (propane)
from specified operation position. Turn controls and gas source or tank OFF when
not in use.
Safety Legal Disclaimer: Must be read in full prior to use
For use with LPG
(Propane) Gas only.
Use only with
supplied Gas regulator.
Register your
Uuni-3A-Gas Burner
at uuni.net/register
For the full user guide,
cooking instructions,
tips and tricks
please visit
uuni.net

2 3
6. Use the Uuni-3A-Gas Burner, as purchased, only with LPG (propane) and the
regulator/valve assembly supplied. Do not attempt to repair or alter the hose/
valve/regulator for any “assumed” defect. Any modification to this assembly
will create the risk of a gas leak and fire. Use only authorized replacement parts
supplied by UUNI LIMITED. NEVER store a spare LPG (propane) under or near
your Uuni 3 oven or in an enclosed area. An LPG (propane) not connected for
use shall not be stored in the vicinity of your Uuni 3 oven or any other appliance.
7. You shall use your Uuni-3A-Gas Burner attachment part, in connection with your
Uuni 3 oven, only with pre-bottled LPG (propane).
8. An improperly stored LPG (propane) is a hazard due to possible gas release
from the safety relief valve. This could cause an intense fire with risk of property
damage, serious injury or death. If you see, smell or hear gas escaping, immediately
move away from the LPG (propane)/appliance and call your fire department.
UUNI LIMITED DOES NOT ACCEPT ANY RESPONSIBILITY, LEGAL OR OTHERWISE,
FOR THE INCIDENTAL OR CONSEQUENTIAL DAMAGE TO PROPERTY OR PERSONS
RESULTING FROM THE USE OF YOUR Uuni-3A-Gas Burner ATTACHMENT PART
WHICH DOES/DID NOT COMPLY WITH ANY OF THE PROVISIONS OF THE PRESENT
LEGAL DISCLAIMER.
UUNI LIMITED SHALL IN NO EVENT BE LIABLE FOR ANY SPECIAL, INDIRECT,
CONSEQUENTIAL OR OTHER DAMAGES OF ANY NATURE WHATSOEVER IN EXCESS
OF THE ORIGINAL PURCHASE PRICE OF YOUR Uuni-3A-Gas Burner ATTACHMENT
PART.
Some states or countries do not allow the exclusion or limitation of incidental or
consequential damages, therefore such limitations or exclusions may not apply to you.
• Read instructions in their entirety before using appliance.
• Only to be used outdoors.
• WARNING: accessible parts may be very hot.
• Keep away from young children.
• Do not move appliance during use.
• Ensure the gas supply is turned off at the cylinder after use.
• Do not modify the appliance.
• Parts sealed by the manufacturer or agent must not be manipulated by the user.
• Always use protective gloves when handling hot components.
• Storage of an appliance indoors is only permissible if the cylinder is disconnected
and removed from the appliance. When the appliance is not used for a period of
time, it should be removed from the oven and stored in its original packaging in a
dry dust free environment.
• CAUTION: All cleaning and maintenance should be carried out when the oven is
cool and with the fuel supply turned OFF at the gas cylinder and disconnected.
• BEFORE USE CHECK APPLIANCE AND CONNECTIONS FOR LEAKS: Never check
for leaks with a naked flame, always use a soapy water solution.
Leak testing: Leak test each time a new gas tank is connected or after a long
period without having used the appliance. Make sure that the valve is in correct
alignment with the venturi. Make sure that the hose has no cracking or splitting.
IMPORTANT: if you cannot stop a gas leak, turn off the gas tank valve and call
your local gas tank dealer or fire department.
• The appliance must be kept away from any flammable materials during use.
• When changing the gas canister, ensure that the Uuni-3A-Gas Burner knob is
turned to the off position, disconnect the regulator from the gas canister and
remove the canister. Throughout this process, ensure that the canister is kept a
minimum of 1m away from the oven to avoid ignition risks.
Safety Information

4 5
Parts required:
Assembled Uuni
Uuni-3A-Gas Burner
M5 10mm bolts x2
Step 1
Install Uuni-3A-Gas Burner
Uuni-3A-Gas
Burner
Parts required:
Tools required:
Uuni-3A-Gas Burner
Hose pipe
Hose clip
Flat head screwdriver
Install hose pipe

6 7
Step 2
Secure Uuni-3A-Gas Burner
Parts required:
Assembled Uuni
with Uuni-3A-Gas
Burner
Allen key
Gas bottle
Patio gas regulator
This is a push-on gas fitting.
Ensure that the black switch is in
the horizontal position. Depress
the button located below the black
switch and press the regulator on
to the tank valve until it locks into
place.
Secure but
do not over
tighten
bolts
!
• The appliance must be installed at least 1 meter from any flammable materials.
• The oven should be placed on a non-flammable, stable and flat surface.
• Make sure your oven is placed in an area that will not be affected by adverse
weather.
• When the diameter of the injector is 0.76mm use the provided 37mbar regulator
with Propane LPG cylinder.
• Appliance only to be used with Propane LPG. Minimum cylinder capacity 4kg
maximum cylinder capacity 13kg.
• Use a suitable provided regulator certified to EN 16129 and a flexible hose certified
to EN 16436.
• The length of the hose must be no more than 1.5 meters. Worn or damaged hose
must be replaced. Ensure that the hose is not obstructed, kinked, or in contact
with any part of the oven other than at its connection.
• The gas supply hose should be checked periodically and should replaced if
damaged and at least every two years.
• Your countries national requirements will advise you how often to replace the
hose. Regularly review these requirements for your country.
• In the case of blocked venturi immediately turn off burner unit, turn off gas supply,
disconnect gas supply and wait until cooled to removed from oven.
• Ensure the appliance is clear of debris before every use. If any debris does build
up use a brush to remove this when appliance has cooled.
Gas Safety Information

8 9
Step 3 Parts required:
Assembled Uuni
with Uuni-3A-Gas
Burner
Remove the door
Step 4 Parts required:
Assembled Uuni
with Uuni-3A-Gas
Burner
Turn the button anticlockwise
until it clicks
Off Max. power Min. power
Click!
Warning The door should removed at
all times during use with the Uuni-3A-Gas
Burner

10 11
Step 5 Parts required:
Assembled Uuni
with Uuni-3A-Gas
Burner
Verify that Uuni-3A-Gas Burner
is on
Step 6 Parts required:
Assembled Uuni
with Uuni-3A-Gas
Burner
Match holder
If Uuni-3A-Gas Burner still does
not ignite
If not, turn off the gas and go back to step 4
If Uuni-3A-Gas Burner still does not ignite go
to step 6
Turn the gas on and light using a match and
the supplied match holder through the front
of the oven
If the flames go out turn off the gas and wait 5
minutes before reigniting
You can now set the required power level

12
Product label
Product Technical Information
Injectors
Model number: UUNI-3A-GAS_BURNER
INJECTOR MARKING 0.76 mm
MARKING (MARKED 0.76)
Use outdoors only.
Read the instructions before using the appliance.
WARNING: accessible parts may be very hot.
Keep young children away.
This appliance must be kept away from
flammable materials during use.
Do not move the appliance during use.
Turn o the gas supply at the gas cylinder
after use.
Do not modify the appliance.
WARNING: The door of Uuni 3 must be removed
while the gas burner is lit.
WARNING: If flames go out, turn o the gas
supply and wait 5 minutes before reigniting.
Exercise caution when cooking with gas. uuni.net
SN:
UUNI
Gas Burner Oven
Uuni-3A-Gas Burner
4.5 KW (327 g/h)
I3+ (28 - 30/37)
Butane, Propane
Butane: 23-30 mbar, Propane: 37 mbar
GB, IE, MT
2531-18 2531CS0019
Uuni Limited, Unit 5, Bishopsgate Business Centre,
189 West Main Street, Broxburn, UK. EH52 5LH

uuni.net
©Uuni 2018
Uuni is a registered trademark of Uuni Ltd. All rights reserved. GB v1.1