Volkswagen Eurovan Camper User manual

Thank you for choosing the EuroVan Camper.
Your new EuroVan was constructed by Volkswagen in their Hannover, Germany assembly plant. Volk-
swagen has been supplying the world with vans for over 45 years, and the EuroVan reflects this experi-
ence.
The mid-sized EuroVan is a heavy-duty vehicle built to endure a wide variety of applications, well
beyond that of a typical minivan. This makes it ideal for a camper vehicle, where comfort and drive-
ability must be combined with strength and durability.
The Winnebago camper package was designed, engineered and quality built in Forest City, Iowa. In
developing the package, we focused on three primary objectives:
I. CAPTURE THE ESSENCE OF THE TRADITIONAL VOLKSWAGEN CAMPER.
To accomplish this we had to provide the most efficient use of space possible, and deliver a high
level of material and workmanship quality.
Thanks to Volkswagen’s long wheelbase, the EuroVan Camper has more interior volume than the
previous model, the Vanagon Camper. We believe that we have found the optimum blend of storage
and living area within this larger space. Even the refrigerator is a special design to fit two cubic feet
into the smallest possible galley space.
Regarding quality and durability, we hope that many of our efforts are easily recognizable, even to
the casual observer. However, what would not be obvious, for example, is the fact that the entire gal-
ley is anchored by an aluminum frame, tig-welded together and then electro-statically “powder
painted”. Or that the cabinet panels are solid-core wood covered with high-pressure laminates.
Even the “pop-up” top is Winnebago’s own design and construction. Here we use an aluminum
frame and high-density foam, sandwiched between two polymer sheets. The result is an insulated
top that is much stronger than Fiberglass, and somewhat lighter in weight.
II. MAXIMIZE VERSATILITY.
Typical camper-vans are good campers, but not very capable at hauling people or things. With the
EuroVan Camper, we set out to ensure that on any given day, it can be a complete camper, a roomy
passenger van, or an effective cargo van.
This versatility comes from the galley-left layout, combined with an optional center seat, and the
fact that the center and rear seats are easily folded or removed. The result is room for up to six full-
sized people or a remarkable variety of cargo (or many things in between!)
AUGUST 2001 132000-01-U02

III. MAXIMIZE VALUE
Winnebago’s past success is not based upon selling the lowest price motor home, but instead on
being the best value. In fact, Winnebago won seven of eleven 1993 “Best Buy” awards given to
motor homes that Consumer’s Digest felt had the best value for the American consumer.
In the development of the EuroVan Camper package, we called upon several proven suppliers for
high quality components and appliances that can be readily serviced in the United States or Canada.
We also produce many of the components ourselves to ensure a high level of quality at a reasonable
cost.
In market research clinics, we spoke with many past and present Volkswagen camper owners about what
drew them to their campers. From them, the message was quite clear:
A. Volkswagen Camper buyers are not looking for a cheap product, but they demand value.
B. Volkswagen Camper buyers do not want “fluff”, they want practical features that make sense.
C. Volkswagen Camper buyers expect versatility, durability and quality.
As a total package, Winnebago believes that the EuroVan Camper lives up to these requirements. We
hope that your own experience with the EuroVan Camper exceeds your expectations. Thank you again for
your purchase.
WILLIAM J. O’LEARY
Vice President, Product Development

OWNER’S NAME
STREET ADDRESS
CITY AND STATE (OR PROVINCE IN CANADA)
MOTOR HOME SERIAL NUMBER
VEHICLE CHASSIS IDENTIFICATION NO. (VIN)
DATE OF DELIVERY TO FIRST RETAIL PURCHASER
VEHICLE MILEAGE AT TIME OF DELIVERY
SELLING DEALER NAME AND ADDRESS

2002 NEW VEHICLE LIMITED WARRANTY
WINNEBAGO INDUSTRIES, INC.
EUROVAN CAMPER
WARRANTY COVERAGE TO OWNER
Winnebago Industries, Inc. of Forest City, Iowa warrants the
portion of each new Eurovan manufactured or installed by it
(excluding those items listed under Items Not Covered) to the
owner for use in U.S. and Canada as follows:
WARRANTY PERIOD
For the period of 24 months or 24,000 miles on the odometer,
whichever occurs first, from the date the vehicle is delivered to the
first retail purchaser or first placed in service as a dealer
demonstrator, whichever occurs first. Winnebago does not
authorize any person to create for it any other obligations or
liability in connection with this vehicle. ANY IMPLIED
WARRANTY OF MERCHANTABILITY OR FITNESS FOR A
PARTICULAR PURPOSE APPLICABLE TO THIS VEHICLE IS
LIMITED IN DURATION TO THE DURATION OF THIS
WRITTEN WARRANTY AS HEREINBEFORE OR
HEREINAFTER PROVIDED. THE PERFORMANCE OF
REPAIRS AND NEEDED ADJUSTMENTS IS THE
EXCLUSIVE REMEDY UNDER THIS WRITTEN WARRANTY
OR ANY IMPLIED WARRANTY. WINNEBAGO SHALL NOT
BE LIABLE FOR INCIDENTAL OR CONSEQUENTIAL
DAMAGES FOR LOSS OF TIME, INCONVENIENCE, OR
OTHER CONSEQUENTIAL DAMAGE INCLUDING EXPENSE
FOR GASOLINE, TELEPHONE, TRAVEL, LODGING, LOSS
OR DAMAGE TO PERSONAL PROPERTY, OR LOSS OF
REVENUE RESULTING FROM BREACH OF THIS WRITTEN
WARRANTY OR ANY IMPLIED WARRANTY. Some states do
not allow limitations on how long an implied warranty will last or
the exclusion or limitation of incidental or consequential damages,
so the above limitations or exclusions may not apply to you.
This warranty gives you specific legal rights and you may also
have other rights which vary from state to state.
ITEMS NOT COVERED UNDER WARRANTY BY
WINNEBAGO INDUSTRIES, INC.
The following items are covered by separate warranties issued by
their respective manufacturers and are not warranted by
Winnebago. Consult separate warranty documents for the terms
and conditions established by the manufacturers of these
components:
Chassis (Volkswagen)
Batteries
Radio
Tires
Wheels
Also, this warranty shall not apply to failures, damages or
malfunctions resulting from normal wear, misuse, abuse,
negligence, alteration, accident, fire, improper repair of the vehicle
or failure to follow recommended maintenance requirements.
Also, Winnebago cannot and does not accept any responsibility in
connection with any of its Eurovans for additional equipment or
accessories installed at any dealership or other place of business, or
by any other party other than Winnebago. Such installation of
equipment or accessories by any other party will not be covered by
the terms of this warranty.
WINNEBAGO’S RESPONSIBILITY
Any part of the Winnebago Eurovan subject to this warranty which
is found to be defective in material or workmanship, will be
repaired or replaced at Winnebago Industries’ option without
charge to the customer for parts or labor. The owner may obtain
warranty repairs or replacement of such items at any authorized
Winnebago Dealership.
________________
________________
________________
PLACE
STAMP
HERE
Winnebago Industries, Inc.
P.O. Box 152
Forest City, Iowa 50436
ATTENTION: WARRANTY DEPT.

CARE AND MAINTENANCE
Defects or damage to appearance items such as fiberglass, metal,
paint, fabrics and trim, may occur during manufacturing or
transporting. Normally, any factory defect or damage is corrected
at the factory. In addition, dealers are obligated to inspect each
vehicle upon delivery to them and prior to delivery to you. You
should also immediately inspect for appearance defects and advise
your selling dealer without delay, as damage and normal
deterioration due to use and exposure is not covered by this
warranty.
IF REPAIRS ARE NEEDED
If a part of the system covered by this warranty fails to function or
requires service during the warranty period:
1. Take the Eurovan to the selling dealer or authorized
Winnebago dealer as specified under the WINNEBAGO
RESPONSIBILITY section of this warranty, for repair.
2. If the dealer is unable to make the repair, he can contact
Winnebago Industries, Inc. for technical or parts assistance.
3. If, after the above steps are completed and the repair is not
made, the customer should contact Winnebago Industries,
Inc., P.O. Box 152, Forest City, Iowa 50436, Attention:
Owner Relations Department (641-585-6939) and furnish the
following information:
− The complete serial number of the Eurovan
− Date of retail purchase
− Selling dealer’s name
− Nature of the service problem and a brief explanation of
the steps or services the dealer has performed, and the
results obtained.
The customer may be directed to another dealer or service center
for repairs to be completed, if such dealer or service center is better
able to complete the repair.
4. If after the above steps are completed and the repairs are not
completed, the customer can:
− Contact the Service Administration Manager of
Winnebago Industries and request a customer relations
board meeting to resolve the problem. This action,
however, is not mandatory.
DEALER’S REPRESENTATIONS EXCLUDED
Winnebago Industries, Inc. does not undertake the responsibility to
any purchaser of its products for any undertaking, representation or
warranty made by dealers selling its product beyond those herein
expressed.
CHANGES IN DESIGN
Winnebago Industries, Inc. reserves the right to make changes in
design and changes or improvements upon its products without
imposing any obligation upon itself to install the same upon its
products theretofore manufactured.
PART NO. 701677-J7-000
------------------------------------------------CUT HERE------------------------------------------------
NOTICE OF SECOND OWNER
ORIGINAL
OWNER
NAME
ADDRESS
NEW
OWNER
NAME
ADDRESS ZIP CODE
WINNEBAGO IDENTIFICATION NUMBER VEHICLE MILEAGE DATE
CHASSIS IDENTIFICATION NEW OWNER SIGNATURE
IMPORTANT: THIS NOTICE IS TO BE USED ONLY FOR RECORD KEEPING BY WINNEBAGO INDUSTRIES
The completed form does not constitute an actual change of ownership.

TABLE OF CONTENTS
INTRODUCTION
Operators Manual ................................. 0-1
Owner Information Binder.................... 0-1
Options and Equipment ........................0-1
Warranty................................................ 0-1
Service Assistance ................................ 0-1
Drinking and Driving............................ 0-2
Reporting Safety Defects...................... 0-2
Exterior Features................................... 0-3
Tank Capacities.....................................0-3
Interior Features.................................... 0-4
SECTION 1: SAFETY PRECAUTIONS
Seat Belts .............................................. 1-1
General Warnings.................................. 1-2
Fuel & LP Gas ...................................... 1-3
LP Gas Leaks........................................1-4
LP Gas Alarm .......................................1-4
Electrical ...............................................1-5
Loading ................................................. 1-5
Formaldehyde Warning......................... 1-5
Carbon Monoxide Alarm ...................... 1-6
Smoke Alarm ........................................ 1-6
Fire Extinguisher...................................1-7
Rear Liftgate Exit.................................. 1-7
SECTION 2: LP GAS SYSTEM
LP Gas Supply ......................................2-1
Safe Use of LP Gas System .................. 2-1
How LP Gas Works ..............................2-1
Selecting Fuel Types.............................2-1
LP Tank System .................................... 2-2
Refilling LP Tank..................................2-2
Air in the LP Gas Tank .........................2-3
Travel with LP Gas ............................... 2-3
Regulator...............................................2-4
LP Gas Leaks........................................2-4
Winter Use of LP Gas ...........................2-5
How Long Will a Tank Last?................ 2-5
SECTION 3: ELECTRICAL SYSTEM
110-Volt AC System .............................3-1
External Power Cord (Shoreline).......... 3-1
110-Volt Outlets .................................... 3-2
110-Volt Circuit Breaker.......................3-2
Ground Fault Circuit Interrupter
(GFCI) ............................................... 3-2
Power Control Center ...........................3-2
Thermal Breaker ...................................3-3
Power Converter Charging Section ......3-3
12-Volt DC System ...............................3-3
Automotive Battery...............................3-3
Auxiliary (Coach) Battery ....................3-3
12-Volt Outlets......................................3-4
12-Volt Circuit Breakers ....................... 3-4
Coach Battery Circuit Breaker.............. 3-4
Battery Storage and Maintenance ......... 3-5
Battery Condition Meter ....................... 3-5
SECTION 4: PLUMBING SYSTEMS
Galley Sink Faucet................................ 4-1
Rear Sprayer Head................................ 4-1
Filling Fresh Water Tank ...................... 4-1
Disinfection of Fresh Water Tank.........4-2
Water Drain Valve................................. 4-2
Waste Water Holding Tank ................... 4-3
Dumping Holding Tank ........................ 4-3
Holding Tank Level Indicators ............. 4-3
SECTION 5: RV FEATURES AND
APPLIANCES
RV Interior Features (Illustration) ........ 5-1
Refrigerator........................................... 5-2
Range Top............................................. 5-3
Monitor Panel ....................................... 5-4
Water and Holding Tank Levels ........... 5-5
LP Gas Level ........................................5-5
Battery Condition Meter ....................... 5-5
LP Gas Furnace..................................... 5-5
Humidity and Condensation ................. 5-5
Pop-Up Roof ......................................... 5-6
Sleeping Facilities.................................5-7
Upper Bed............................................. 5-7
Rear Bench Seat/Bed ............................ 5-8
Center Bench Seat............................... 5-10
Child Restraint Tether Anchors .......... 5-11
Center Companion Seat...................... 5-12
Tables .................................................. 5-12
Interior Lights ..................................... 5-12
Side Tip-Out Window......................... 5-13
Side Slider Window............................ 5-13
Front & Rear Curtains.........................5-13
Pleated Side Window Shades.............. 5-13
Luggage Tray (Roof) .......................... 5-13
Radio/Cassette Player ......................... 5-14
Rear Storage Compartment................. 5-14
SECTION 6: CARE AND STORAGE
Care of Pop-Up Roof Canvas ............... 6-1
Upholstery............................................. 6-1
Vinyl Fabrics......................................... 6-1
Cabinets ................................................ 6-1

TABLE OF CONTENTS
Tables and Galley Cover....................... 6-1
Stainless Steel Sink and Countertop ..... 6-2
Range and Refrigerator.........................6-2
Cold Weather Storage (Winterizing)..... 6-2
Removal from Storage .......................... 6-3
SECTION 7: TRAVELING WITH YOUR
CAMPER
Vehicle Weight......................................7-1
Trailer Towing.......................................7-1
Pre-Travel Checklist ............................. 7-1
Severe Weather Information .................7-1
Campsite Set-Up (Leveling) .................7-2

INTRODUCTION
0-1
Congratulations on the purchase of your new
EuroVan Camper. This conversion package has
been carefully designed, engineered and quality
built by Winnebago Industries, Inc.
OPERATOR’S MANUAL
Please read this operator’s manual and the
Volkswagen EuroVan Owners Manual thorough-
ly. They provide you with information necessary
toproperly and safely operate the vehicle and the
equipment in your camper.
This manual describes those instruments,
controls and instructions which are unique to this
motor home. For information on the automotive
equipment, controls, special seat belt usages and
instructions notdescribed in this manual, we urge
you to read the Volkswagen EuroVan Owner’s
Manual and the equipment manufacturer’s infor-
mation provided in your Owner Information
binder.
This manual should be kept in the vehicle at
all times for personal reference. The operator’s
manual, owner information binder and Volk-
swagen EuroVan operating guide are to be con-
sidered permanent components of this vehicle.
They should remain in the vehicle when sold to
provide the next owner with important safety, op-
erating and maintenance information.
NOTE: The descriptions, illustrations, and spec-
ifications in this manual were correct at
the time of printing. We reserve the right
to change specifications or design with-
out notice, and without incurring obliga-
tion to install the same on products
previously manufactured.
Throughoutthis manual, reference is made to
the following terms: Note, Caution and Warn-
ings. These terms indicate important information
which must be understood and followed. The def-
initions of these terms are:
NOTE: Indicates a special point of information.
OWNER INFORMATION BINDER
Your Owner Information binder contains in-
formation supplied by manufacturers of individ-
ual appliances and equipment installed in your
Winnebago camper.
Consult this information regarding the opera-
tion and care of appliances, accessories and spe-
cial equipment.
OPTIONS AND EQUIPMENT
Some equipment and accessories described in
thismanualmaybeoptional andmay notapplyto
your vehicle.
WARRANTY
The camper conversion components (e.g.
pop-up roof, cabinets, appliances, automotive
radio, etc.) in your new EuroVan Camper are
covered against defects in material and work-
manship by a Winnebago factory warranty. This
warranty should be validated immediately and
returned to the factory by your dealer. For
detailed information on what the Winnebago
warranty includes, see the New Vehicle Limited
Warranty included in our Owner Information
binder.
SERVICE AND ASSISTANCE
Your EuroVan Camper dealer will be glad to
provide any additional information you need, as
well as answer any questions you might have
about operating the equipment in your camper.
When it comes to service, remember that your
dealer knows your vehicle best and is interested
CAUTION
Indicates that a failure to observe can
cause damage to vehicle or equip-
ment
WARNING
This symbol is used to alert you to
precautions that involve your per-
sonal safety as well as vehicle dam-
age. Read and follow them carefully.

INTRODUCTION
0-2
in your satisfaction. Your dealer will provide
quality maintenance and any other assistance that
you may require during your ownership of this
vehicle.
If you need warranty repairs to the camper
equipment while traveling, however, you may
take your vehicle to any Winnebago or Itasca
dealership because they are authorized to assist
you.
DRINKING AND DRIVING
Winnebago Industries supports the recom-
mendations of the Presidential Commission on
Drunk Driving.
· Exercise your good judgment and encourage
others to do the same.
· Know the legal limits and do not exceed
them.
· Also know your personal limits, which may
be lower than the legal limits.
· Should you ever exceed your limits, find al-
ternative transportation; call a cab, ask a
friend to drive you home or call a family
member to come and get you.
The presence of alcohol in significant levels
in the blood increases the probability that the
driver will be involved in an accident.
REPORTING SAFETY DEFECTS
If you believe that your vehicle has a defect
which could cause a crash or could cause injury
or death, you should immediately inform the Na-
tional Highway Traffic Safety Administration
(NHTSA) in addition to notifyingWinnebagoIn-
dustries, Inc.
If NHTSA receives similar complaints, it
may open an investigation, and if it finds that a
safety defect exists in a group of vehicles, it may
order a recall and remedy campaign. However,
NHTSA cannot become involved in individual
problems between you, your dealer, or Winneba-
go Industries.
To contact NHTSA, you may either call the
Auto Safety Hotline toll-free at 1-800-424-9393
(or 366-0123 in Washington, D.C. area) or write
to: NHTSA, U.S. Department of Transportation,
Washington, D.C. 20590. You can also obtain
other information about motor vehicle safety
from the Hotline.

0-3
INTRODUCTION
EXTERIOR FEATURES
1. Tip-Out Window
2. Refrigerator Heat Exhaust Vent**
3. LP Gas Tank Controls/Fill Valve
4. Waste Water Tank Dump Valve
5. 110-Volt Shoreline Input Plug
6. Holding Tank Vent
7. Furnace Exhaust Vent**
8. Coach Battery Compartment Vent
9. Slider Window
10. Pop-Up Roof
11. Roof Vent
12. Luggage Tray
TANK CAPACITIES
Vehicle Fuel Tank ....................................21.1 gal.
LP Gas Tank (tank size).................20 lbs./4.6 gal.
(usable full cap.) .....16 lbs./3.7 gal.
Fresh Water Tank ........................................12 gal.
Waste Water Holding Tank .......................... 8 gal.
**CAUTION: Be careful. These features may become hot while refrigerator or furnace are in use.

INTRODUCTION
0-4
Your EuroVan Camper has many convenient, self-contained RV features.
1. Camper Electrical Power Center
2. Water Center
3. 110-Volt AC Outlet
4. 12-Volt DC Outlet
5. Storage Pockets
6. Cold Air Return Grille
7. Storage Shelves
8. Wardrobe/Storage Closet
9. Storage Cabinet 2/Mirror
10. Furnace Thermostat
11. Fluorescent Light
12. Galley Sink & Faucet
13. LP Gas Range Top
14. Range Burner Spatter Shields
15. Table Storage
16. 110-Volt AC Outlet
17. LP Gas Alarm
18. 12-Volt DC Outlet
19. Refrigerator - AC/DC/Gas
20. System Monitor Panel
21. Utensil Drawer
22. Storage Cabinet
23. Water Line Drain
24. Furnace Heat Vents
25. Storage Cabinet
26. Furnace Cold Air Return Grille

SECTION 1
TO THE OWNER
1-1
Read and understand all instructions and pre-
cautions in both manuals before operating your
new camper. The symbol WARNING is used
throughout this manual to alert you to precau-
tions that involve your personal safety. Read and
follow them carefully. Listed are some safety
precautions that must be adhered to. These pre-
cautions as well as others that involve damage to
equipment are also listed in the appropriate areas
in this manual.
SEAT BELTS
Seats intended for occupancy while the vehi-
cle is in motion are equipped with seat belts for
the protection of the driver and passengers. The
lap belts must be worn as low as possible and fit
snugly across the hip area. Always sit erect and
well back into the seat. To gain full protection of
thesafety belt,neverletmore than oneperson use
the same safety belt at any one time, and do not
let the safety belts become damaged by pinching
them in the doors or in the seat mechanism. After
any serious accident,any safety belts which were
in use at the time should be replaced.
CENTER COMPANION SEAT BELTS
See your Volkswagen Vehicle Owner’s Man-
ual for information regarding care and use of
safety belts for the optional center companion
seat.
CENTER BENCH SEAT LAP BELTS
The seat belts in the rear of your camper are
equipped with automatic locking retractors that
let you easily adjust your seat belt to the proper
length for passenger safety.
• Grasp the end of the belt and pull smoothly
outward from the seat to the required length,
then insert into buckle. Be sure belt is not
twisted before fastening.
• Feed any excess belt length back toward the
seat so the belt retractor will lock the belt at
the proper length for your body when
released.
• Do not jerk the belt or pull out too quickly
because it will lock prematurely and require
you to reset the belt retractor.
• Reset the belt retractor by letting the belt go
all the way back to the starting point, then
pull slowly and smoothly outward.
• Only seats equipped with seat belts are to be
occupied while the vehicle is moving
• To unfasten the lap belt, press the release
button on the buckle. Hold onto the end of
the belt when you release it from the buckle
to keep it from retracting too rapidly.
NOTE: When using the lap belt to restrain a
child seat, pull the seat belt out all the
way and hold it with one hand while you
use your other hand to thread the tongue
of the belt through the slots in the child
car seat. After threading the belt through
the child seat, latch the belt securely.
Feed any excess belt length back into the
retractor so that it locks snugly. The belt
should be tight enough to hold the child
car seat securely against the seat.
WARNING
This manual does not include infor-
mation on very important safety con-
siderations and warning related to
“Safety Belts” and“Child Safety”,Be
sure tocheck the Volkswagen Vehicle
Owner’s Manual for this information
on occupant restraint systems and
child safety and also for additional in-
structions relating to the vehicle.
Although federal law provides for ad-
ditional, separate lap belt on swivel
seats, Winnebago recommends for
your safety and the safety of all occu-
pants, that you always use the combi-
nation lap-shoulder belt and not the
separate lap belt while this vehicle is
moving. Never drive the vehicle un-
less the swivel seat is locked in the
forward facing position.

SECTION 1
TO THE OWNER
1-2
REAR BENCH SEAT 3-POINT LAP
SHOULDER BELTS
Fastening: Hold the belt just behind the
tongue using the hand nearest to the sidewall.
Next, bring the belt across the body and slide the
tongue into the buckle until the latch engages.
Do not pull the belt away from the wall too
quickly or it will “lock” and prevent you from
pulling it any farther. If this happens, relax your
pull on the belt slightly, then continue pulling it
less quickly.
NOTE: When using the lap/shoulder belt to
restrain a child seat, pull the seat belt out
all the way and hold it with one hand
while you use your other hand to thread
the tongue of the belt through the slots in
the child car seat. After threading the
belt though the child seat, latch the belt
securely. Adjust the tongue portion of the
latch so that it is tight enough to hold the
child car seat securely against the seat.
Unfastening: Press the release button in the
buckle. Hold onto the tongue when you release it
from the buckle to keep it from retracting too rap-
idly.
When the lap-shoulder belt is in use, the lap
portion must ride across the strong hip area and
the shoulder portion must ride diagonally over
the shoulder blade toward the buckle.
The shoulder belt is designed tolock only dur-
ing a sudden stop, sudden body movement or a
collision. At all other times it will move freely
with the occupant.
GENERAL WARNINGS
• Only seats equipped with seat belts are to be
occupied while the vehicle is moving.
• Make sure all passengers have seat belts fas-
tened in a low and snug position so the force
exerted by the belt in a collision will be
spread across the strong hip area. Pregnant
women should wear a lap-shoulder belt
whenever possible, with the lap belt portion
worn low and snug throughout the preg-
nancy.
• All moveable or swiveling seats should be
placed and locked in forward facing posi-
tions while the vehicle is moving.
• Never let passengers stand or kneel on seats
while the vehicle is moving.
• Sleepingfacilitiesare not to be utilized while
vehicle is moving.
• Examine the escape window and be familiar
with its operation, but do not use except in an
emergency.
• Inspect the fire extinguisher monthly for
proper charge and operating condition. This
should also be done before beginning a vaca-
tion or any extended trip.
DRIVING
• Do not attempt to adjust the driver’s seat
while the vehicle is moving.
• Do not adjust tilt steering in a moving vehi-
cle.
• Do not operate the cruise control on icy or
extremely wet roads, winding roads, in
heavy traffic, or in any other traffic situation
where a constant speed cannot be main-
tained.
• Use care when accelerating or decelerating
on a slippery surface. Abrupt speed changes
can cause skidding and loss of control.
WARNING
To reduce the risk of an injury in an
accident, position the lap belt tightly
and as low as possible across the pel-
vis. Pregnant women should be espe-
cially certain to wear the lap belt as
low as possible across the pelvis so
there is no pressure on the abdomen.
Only seats equipped with seat belts
are tobe occupied while the vehicle is
in motion.
WARNING
Never wear the shoulder belt in any
position other than as stated above.
Failure to do so could increase the
chance or extent of injury in a colli-
sion.

SECTION 1
TO THE OWNER
1-3
• Driving through water deep enough to wet
the brakes may affect stopping distance or
cause the vehicle to pull to one side. Check
brake operation in a safe area to be sure they
have not been affected. Never operate any
vehicle if a difference in braking efficiency
is noticeable.
• Adverse weather conditions and extremes in
terrain may affect handling and/or perfor-
mance of your vehicle. Refer to your chassis
manual for related information.
• The fire extinguisher should be inspected
monthly for proper charge and operating
condition. This should also be done before
beginning a vacation or any extended trip.
FUEL & LP GAS
• The rangetop, refrigerator and furnace must
be turned off while refilling the fuel tank or
LP tank.
• Never smoke while refilling vehicle fuel
tank or LP gas tank.
• Avoid inhaling exhaust gases produced by
burned gasoline, or LP gas in items such as
the chassis engine, range, refrigerator, and
furnace. They contain carbon monoxide,
which is an odorless, colorless and poison-
ous gas. (See Carbon Monoxide Alarm, page
1-5.)
• Do not bring or store LP gas containers, gas-
oline or other flammable liquids inside the
vehicle because a fire or explosion may
result. LP gas containers are equipped with
safety valves which relieve excessive pres-
sure by discharging gas to the atmosphere.
• Do not alter the LP gas system at any time or
in any way.
• Do not fill LP gas tank above 80 percent of
capacity. Overfilling the LP gas container
can result in uncontrolled gas flow which
can cause fire or explosion. A properly filled
container will contain approximately 80 per-
cent of its volume as liquid LP gas.
• Never use an open flame to test for LP gas
leaks. Close tank valve and replace all pro-
tective covers and caps on LP system after
filling.
• Never connect natural gas to the LP gas sys-
tem.
• When lighting range burners do not turn
burner controls to “On” and allow gas to
escape before lighting match.
• Do not use portable fuel-burning equipment,
including wood and charcoal grills and
stoves, inside the recreational vehicle. Use of
this equipment inside the recreational vehi-
cle may cause fires or asphyxiation.
• LP gas regulators must always be installed
with the diaphragm vent facing downward.
Regulators that are not in compartments
have been equipped with a protective cover.
Make sure that the regulator vent faces
downward and that the cover is kept in place
to minimize vent blockage which could
result in excessive gas pressure causing fire
or explosion.
• The following warning label is located in the
cooking area to remind you to provide an
adequate supply of fresh air for combustion.
Unlike large homes, the oxygen supply
inside a recreational vehicle is limited due to
its size. To avoid danger of axphyxiation,
provide proper ventilation when using the
gas rangetop or gas oven. It is especially
important that the gas oven or range top not
be used for comfort heating. Danger of
asphyxiation is greater when these appli-
ances are used for long periods of time.
• When using the range top, raise the pop-up
roof and open a vent or canvas side flap to
provide sufficient ventilation.
WARNING
IT IS NOT SAFE TO USE COOKING
IT
IS
NOT
SAFE
TO
USE
COOKING
APPLIANCES FOR COMFORT HEATING
APPLIANCES
FOR
COMFORT
HEATING
COOKING APPLIANCES NEED FRESH AIR FOR SAFE OPERATION.
COOKING
APPLIANCES
NEED
FRESH
AIR
FOR
SAFE
OPERATION.
BEFORE OPERATION:
BEFORE
OPERATION:
1. OPEN OVERHEAD VENT OR TURN ON EXHAUST FAN AND;
1.
OPEN
OVERHEAD
VENT
OR
TURN
ON
EXHAUST
FAN
AND;
2. OPEN WINDOW.
2.
OPEN
WINDOW.

SECTION 1
TO THE OWNER
1-4
LP GAS LEAKS
The following label is located in the vehicle
near the range area. If you smell gas within the
vehicle, quickly and carefully perform the proce-
dures listed.
LP GAS ALARM
Your camper is equipped with an LP gas de-
tectorwhich sounds an alarm if an unsafe amount
of LP gas is presentinside the coach.Because LP
gas is heavier than air and will settle to the floor,
the detector is located on a cabinet face near the
floor of the vehicle behind the driver’s seat.
A green light on the face of the alarm shows
when the unit is active. The red button is used to
reset the alarm.
If The Alarm Sounds
If the alarm sounds, do not touch any electri-
cal switches. Immediately turn off the main LP
tank valve and all LP appliances, open all win-
dows and roof vents, and leave the vehicle until
the alarm stops sounding.
If the alarm keeps sounding at regular inter-
vals, a leak may be present. Contact your dealer
or an LP gas service center to have the problem
corrected before using the LP system again.
Power Connection
The LP gas alarm is powered by the coach bat-
teries. If the battery cable is disconnected from
the battery or the fuse is blown, the alarm will not
work. The LP gas alarm fuse is located on the cir-
cuit breaker panel in the rear of the vehicle.
Because the LP gas alarm is connected direct-
ly to the auxiliary battery, it is always drawing a
small amountof current.Even though this current
draw is slight, it could drain the coach battery
during storage periods of 30 days or longer. We
recommend disconnecting the battery cables
from the auxiliary battery during extended stor-
age periods to avoid discharge.
IF YOU SMELL GAS
1. Extinguish any open flames, pilot
lights and all smoking materials.
2. Do not touch electrical switches.
3. Shut off the gas supply at the tank
valve(s) or gas supply connection.
4. Open doors and other ventilating
openings.
5. Leave the area until odor clears.
6. Have the gas system checked and
leakage source corrected before
using again.
Press to stop alarm sound
Green
(Active) Red (Alarm) Amber (Low Batt.)
WARNING
Never use an open flame to test for
gas leaks.
If testing for gas line leaks with a
soapy water solution, DO NOT use a
detergent containing ammonia or
chlorine. These substances may gen-
erate a chemical reaction causing cor-
rosion to gas lines, resulting in
dangerous leak conditions.
LP Alarm Fuse

SECTION 1
TO THE OWNER
1-5
Further Information
See the manufacturer’s information entitled
“Your LP Gas Detector” in the Owner Informa-
tion binder for further instructions on nuisance
alarms and care and testing of the LP gas detec-
tor.
ELECTRICAL
· Careless handling of electrical components
can be fatal. Never touch or use electrical
components or appliances while feet are bare,
while hands are wet, or while standing in wa-
ter or on wet ground.
· Improper grounding of the vehicle can cause
personal injury. Do not plug the utility power
cord intoan outlet which is not grounded and
do not adapt the plug to connect to a recepta-
cle for which it is not designed.
· Do not attach an extension cord to the utility
power cord.
· Be sure that all electrical appliances to be
used contain 3-prong plugs for proper
grounding.
· Avoid overloading electrical circuits. Re-
place fuses or circuit breakers with those of
the same size and amperage rating only. Nev-
er use a higher rated fuse or breaker.
· Use caution when handling or working near
electrical storage batteries. Always remove
jewelry and wear protective clothing and eye
covering. Avoid creating sparks.
LOADING
· Store or secure all loose items inside the mo-
tor home before traveling.
· Never load the vehicle in excess of the gross
vehicle weight rating or the gross axle weight
rating for either axle.
FORMALDEHYDE INFORMATION
NOTE: To aid in dissipation, ventilate the vehi-
cle by opening all windows and circulat-
ing the air with a fan.
CARBON MONOXIDE WARNING
If your suspectthat exhaustfumes are entering
the passenger compartment,have the cause deter-
mined and corrected as soon as possible. If you
must drive under these conditions, drive only
with ALL WINDOWS FULLY OPENED.
The best protection against carbon monoxide
entry into the vehicle body is a properly main-
tained engine exhaust and ventilation system. It
is recommended that the exhaust system and
body be inspected by a qualified Volkswagen
service center.
· Each time the vehicle is raised for an oil
change.
· Whenever a change in the sound of the ex-
haust system is noticed.
WARNING
Some components in this vehicle con-
tain formaldehyde based adhesives
which may release formaldehyde
fumes into the air for an unknown
period of time until total dissipation
occurs. Individuals who are allergic
to formaldehyde gas fumes may
experience irritation to eyes, ears,
nose and throat. Reaction in infants
may be more severe. Although long
range effects are not well understood,
testing to date has not revealed any
serious health effects in humans atthe
level of emission from these prod-
ucts.
WARNING
Avoid inhaling exhaust gases, as they
contain carbon monoxide, which is a
colorless, odorless and poisonous gas.

SECTION 1
TO THE OWNER
1-6
· Whenever the exhaust system, underbody or
rear of the vehicle is damaged.
To allow proper operation of the vehicle’s
ventilation system, keep front ventilation inlet
grill clear of snow, leaves or other obstructions at
all times. DO NOT OCCUPY A PARKED VE-
HICLE WITH ENGINE RUNNING FOR AN
EXTENDED PERIOD.
Do not run engine in confined areas, such as a
garage, except to move vehicle in or out of area.
When vehicle is stopped in an UNCONFINED
area with the engine running for any more than a
short period, adjust heating or cooling system to
force outside air into the vehicle as follows:
1. Set fan to medium or high speed and vent
control to air.
2. On vehicles equipped with air conditioning,
set fan to medium or high speed and set con-
trol to obtain maximum vent air.
Rear liftgate should be closed while driving to
avoid drawing dangerous exhaust gases into the
vehicle.
CARBON MONOXIDE ALARM
If your coach is equipped with a carbon mon-
oxide (CO) alarm, it will belocatedon the ceiling
of the pop-up roof. The CO alarm is powered by
a battery/sensor pack and is designed to detect
toxic carbon monoxide gas fumes resulting from
incomplete combustion of fuel. It will detect CO
gas from any combustion source such as the chas-
sis engine, furnace, gas range and refrigerator.
NOTE: LP gas combustion fumes released dur-
ing normal cooking can cause a false
alarm if there is insufficient ventilation.
Open a window, vent, or side flap while
using the range top.
Further Information
Please read the information provided by the
manufacturer, which is included in your Motor
Home Operations Manual binder. It includes in-
formation on precautions, operational testing,
and battery/sensor replacement.
SMOKE ALARM
Your motor home is equipped with a smoke
alarm located on the ceiling of the pop-up roof.
This alarm meets U.L. Standard 217 and NFPA
Standard 74 for operation of smoke detection
devices.
1. The smoke alarm should be tested for correct
operation each time the vehicle is brought
out of storage, before each trip, and at least
once a week during motor home use. To test
the electronics, firmly depress the button. To
test that smoke reaches the sensor, blow
smoke in a careful, fire-safe manner into
your smoke alarm.
2. Your smoke alarm will not work without
power. Never remove the battery to quiet the
Smoke
Alarm CO Alarm
Pop-Up Roof Ceiling

SECTION 1
TO THE OWNER
1-7
alarm. When your smoke alarm “beeps”
about once a minute the battery is weak.
Install a new battery immediately. Be sure to
use only batteries specified in manual or on
unit. Test unit after installing a new battery.
3. Clean and vacuum the openings on your
smoke alarm once a month.
4. Do not open the smoke alarm or try to repair
it. For replacement information see warranty
in Owner’s Manual.
5. Smoke alarms have technical limitations and
may not respond in all situations. FIRE PRE-
VENTION is your best safeguard.
Further Information
Please read the information provided by the
manufacturer, which is included in your Motor
Home Operations Manual binder. It includes
information on precautions, operational testing,
and battery/sensor replacement.
FIRE EXTINGUISHER
A dry chemical fire extinguisher is located
near the floor by the side entrance door.
We recommend that you become thoroughly
familiar with the operating instructions displayed
on the side of the fire extinguisher or in the infor-
mation supplied in your Motor Home Operations
Manual binder.
We also recommend that you inspect the fire
extinguisher for proper charge at least once a
month in accordance with National Fire Protec-
tion Association (NFPA) recommendations as
stated on the label.
If the charge is insufficient, the fire extin-
guisher must be replaced.
Rear Liftgate Exit
The rear liftgate may also be used as an exit.
Remove the red plastic plug on the inner panel of
the liftgate and lift the small latch mechanism to
open the liftgate.
WARNING
Do not test the fire extinguisher by
discharging it. Partial discharge can
cause leakage of pressure or contents
which would render the unit inopera-
tive when needed. When using the
fire extinguisher, aim the spray at the
base of the fire.