Volvo 2012 XC60 Quick start guide

WIRING DIAGRAM 2012
VOLVO XC60
TP 39215202

© Volvo Car Corporation
Vehicles with SRS (Airbag)/SIPS bag/IC (Inflatable Curtain)
Warning!
Extra caution must be exercised when working on vehicles equipped with SRS/SIPS bag/IC
in order to avoid:
1. Personal injuries when performing repair work.
2. Damage or malfunction of the SRS/SIPS bag/IC system.
Work involving the SRS/SIPS bag/IC systems or other components in the vehicle that may
affect the SRS/SIPS bag/IC systems must always be performed by an authorized Volvo
workshop.
In case of doubt, consult the SRS and SIPS bag/IC service manual.
Is the vehicle equipped with SRS/SIPS bag/IC?
Vehicles with SRS are most easily recognized by the letters SRS in the center of the steering
wheel. If the vehicle also has a passenger side airbag, the letters SRS are stamped on the
dashboard above the glove compartment. SRS vehicles from 1993 and onward also have
explosive seat belt tensioners. SIPS bags are only installed on SRS vehicles from 1995 and
onward. SIPS bag decals are located on the windshield and seat compartment. Vehicles with
IC can be recognized by the letters IC on the C/D panel (4 door) or the B panel (5 door).
General recommendations
• Be especially careful when working on or around SRS, SIPS, and IC components.
• Make sure that no wires are pinched, frayed, or pierced.
• Never install accessories by the sensors.
• Where applicable, work on the steering wheel, steering shaft, or steering gear must be done
in accordance with the methods in the SRS section of VIDA.
• Certain components of the aforementioned systems must be grounded while working. Read
the appropriate sections in VIDA.
• Install no accessories in the areas between the A and B-posts, the B and C-posts, and the C
and D-posts.
Test terminal
Data link connector in the passenger compartment.
Changes introduced up to and including structure week 11w20
Any changes made to the vehicles after this date are not included in the manual. If necessary
refer to service bulletins.
Volvo models are sold in versions adapted for different markets. These adaptations depend
on factors such as legal requirements, taxation, and market demands.
This manual may therefore include illustrations and text that do not apply to the vehicles in
your country.
Ordering:
Electronic Wiring Diagrams (EWDs) can be ordered from the Technical Information Shop
(TIS) at www.volvocarstechinfo.ford.com/vss
We reserve the right to make modifications.

TP39215202 XC60 2012 3
Vehicles with SRS (Airbag)/SIPS bag/IC (Inflatable
Curtain).......................................................................... 2
Explanations .................................................................. 6
Abbreviations................................................................. 6
How to use the wiring diagrams 1:2............................... 7
Electrical distribution
Overview without Start/stop function ............................. 9
Overview with Start/stop function ................................ 10
Overview, Distribution box in engine compartment ..... 11
Overview, Distribution box in passenger compartment 12
Overview, Distribution box in cargo compartment ....... 13
Fuses
Distribution box in engine compartment F1-F7............. 14
Distribution box in engine compartment F8 - F23......... 15
Distribution box in engine compartment F27 - F37....... 16
Distribution box in engine compartment F38 - F39....... 17
Distribution box in engine compartment F40 - F44....... 18
Central electronic module (CEM) F1 - F13................... 19
Central electronic module (CEM) F14 - F24................. 20
Distribution box in passenger compartment F1 - F19... 21
Distribution box in passenger compartment
F21 - F30 ...................................................................... 22
Distribution box in cold zone F1 - MF2 ......................... 23
Distribution box in cargo compartment FA1 - FA11...... 24
Battery PF1 - PF2......................................................... 25
Relays
Relays in the engine compartment R1 - R9................. 26
Relays in the engine compartment R10 - R13............. 27
Relays in passenger and cargo compartments ........... 28
Ground connections
Overview...................................................................... 29
31/1 - 31/7 ................................................................... 30
31/10 - 31/15 ............................................................... 31
31/47 - 31/68 ............................................................... 32
31/83 - 31/88 ............................................................... 33
31/89 - 31/96 ............................................................... 34
31/131 - 31/TRM.......................................................... 35
Control modules
Overview locations....................................................... 36
Overview designations................................................. 37
Central electronic module (CEM) 1:3........................... 38
Data communication high speed CAN......................... 41
Data communication intermediate speed CAN, LHD... 42
Data communication intermediate speed CAN, RHD .. 43
Data communication Local CAN.................................. 44
Data communication MOST......................................... 45
Data communication, LIN 1:2....................................... 46
Steering Wheel Module (SWM) ................................... 48
Group 26 Cooling system
Cooling fan 4-Cyl. Turbo.............................................. 49
Cooling fan, 5-Cyl. Diesel ............................................ 50
Cooling fan 6-Cyl. ........................................................ 51
Group 27 Engine controls
Cruise control 4-Cyl. Turbo...........................................52
Cruise control 5-Cyl. Diesel ..........................................53
Cruise control 6-Cyl. .....................................................54
Start-/Stop function 4-Cyl. 1.6L. Turbo .........................55
Start-/Stop function 4-Cyl. 1.6L. Diesel.........................56
Start-/Stop function 5-Cyl. Diesel..................................57
Group 28 Ignition and control system
Engine management system, 5-Cyl. Diesel 1:3 ........... 58
Engine management system, 4-Cyl. Turbo 2.0l 1:2..... 61
Engine management system 6-Cyl. 1:2 ....................... 63
Engine management system 6-Cyl. B6324S4 1:2 ....... 65
Engine management system, 6-Cyl. Turbo 1:2............ 67
Emission control 4-Cyl. Turbo...................................... 69
Emission control 6-Cyl. ................................................ 70
Group 32 Alternator and voltage regulator
Power supply 4-Cyl. Turbo........................................... 71
Power supply 5-Cyl. & 6-Cyl. ....................................... 72
Group 33 Starting system
Starting system 4-Cyl. Turbo ....................................... 73
Starting system 5- & 6-Cyl. .......................................... 74
Table of Contents 1:3

TP39215202 XC60 2012 4
Group 35 Lighting
High and low beam...................................................... 75
High and low beam (Dual Xenon)................................ 76
Beam length adjustment, manual ................................ 77
Running/Parking light, Tail lights ................................. 78
Running/Parking light, Tail lights (Dual Xenon) ........... 79
Fog lights ..................................................................... 80
Brake lights.................................................................. 81
Reversing lights ........................................................... 82
Follow-me-home lighting LHD ..................................... 83
Follow-me-home lighting RHD..................................... 84
Interior lighting, LHD 1:2 .............................................. 85
Interior lighting, RHD 1:2 ............................................. 87
Active headlight ........................................................... 89
Lighting in door sill trims .............................................. 90
Auxiliary lights.............................................................. 91
Group 36 Additional electrical equipment
Rain sensor.................................................................. 92
Direction indicator and hazard warning flashers
LHD ........................................................................ 93
Direction indicator and hazard warning flashers
RHD ........................................................................ 94
Wiper/Washer windshield ............................................ 95
Washer headlights....................................................... 96
Wiper/Washer rear window.......................................... 97
Horn ........................................................................ 98
Keyless vehicle 1:2...................................................... 99
Anti-theft alarm .......................................................... 101
Parking assistance..................................................... 102
Collision warning with power brake booster .............. 103
Tire pressure monitoring system (TPMS) .................. 104
Alcohol lock................................................................ 105
Group 37 Wiring and fuses
Diagnostics system.................................................... 106
Outlet 12 V................................................................. 107
Cable harness towbar/tow hitch 4-pin ....................... 108
Cable harness towbar/tow hitch 7-pin........................ 109
Cable harness towbar/tow hitch 13-pin...................... 110
USB unit (AUU).......................................................... 111
Group 38 Instruments
Seat belt reminder ..................................................... 112
Driver information module.......................................... 113
Group 39 Other
Audio High/Premium 1:3............................................ 114
Audio 1:2 ................................................................... 117
Cellular phone 1:2...................................................... 119
DAB Radio................................................................. 121
Rear seat entertainment, RSE................................... 122
Multimedia monitor with DVD, Dual Screen RSE ...... 123
TV receiver / TV control module ............................... 124
Bluetooth Handsfree .................................................. 125
Navigation system & Traffic information, portable ..... 126
Satellite radio ............................................................. 127
Parking camera.......................................................... 128
Parking camera rear .................................................. 129
Wide angle camera front............................................ 130
Group 43 Transmission
Automatic transmission TF-80SC .............................. 131
Transmission M66 & MMT 6...................................... 132
Automatic transmission MPS6................................... 133
Differential electronic module (DEM) ......................... 134
Group 55 Parking brake
Electric parking brake ................................................ 135
Group 59 Brake system
Brake control system & DSTC ................................... 136
Group 64 Steering
Speed dependent power steering .............................. 137
Group 76 Shock absorbers
Four-C ...................................................................... 138
Group 83 Doors and openings
Central locking front doors LHD................................. 139
Central locking front doors RHD ................................ 140
Central locking rear doors.......................................... 141
Central locking tailgate with POT............................... 142
Central locking tailgate without POT.......................... 143
Signal receiver central locking ................................... 144
Central locking fuel filler flap ...................................... 145
Power windows front doors LHD................................ 146
Power windows front doors RHD ............................... 147
Power windows rear doors......................................... 148
Power sunroof............................................................ 149
Group 84 Exterior decorative elements, etc.
Power door mirrors LHD ............................................ 150
Power door mirrors RHD............................................ 151
Heated door mirrors LHD........................................... 152
Heated door mirrors RHD .......................................... 153
Blind spot information system LHD............................ 154
Blind spot information system RHD ........................... 155
Heated rear window................................................... 156
Table of Contents 2:3

TP39215202 XC60 2012 5
Group 85 Interior equipment
Power driver’s seat with memory function, LHD ........ 157
Power driver’s seat with memory function, RHD ....... 158
Power passenger seat, LHD...................................... 159
Power passenger seat, RHD ..................................... 160
Heated front seats with fans ...................................... 161
Heated front seats without fans ................................. 162
Heated rear seat........................................................ 163
Group 87 Climate control system
Climate control system, 4-Cyl. 1:2............................. 164
Climate control system 5-Cyl. & 6-Cyl. 1:2 ................ 166
Climate control system PTC-elements ...................... 168
Parking heater, auxiliary heater................................. 169
Parking heater, remote start ...................................... 170
Group 88 Internal equipment
Rear-view mirror with automatic dimming.................. 171
Supplemental restraint system 1:2 ............................ 172
Remote control opener garage door.......................... 174
Power folding headrest.............................................. 175
Group 89 Body other
Radiator masking blind .............................................. 176
Connectors .............................................. 177
Branching points .....................................211
Cable harness routing in vehicle
Harness engine 4-Cyl. Turbo ......................................228
Engine harness, 6-Cyl.................................................228
Harness engine, 6-Cyl. Turbo .....................................229
Harness engine, Diesel 2.0l........................................229
Harness engine, Diesel 2.4l........................................230
Engine compartment harness.....................................231
Dashboard harness, LHD ...........................................232
Harness Dashboard, RHD ..........................................233
Floor Harness, LHD ....................................................234
Floor Harness, RHD....................................................235
Harness infotainment, LHD.........................................236
Harness infotainment, RHD ........................................237
Roof harness ..............................................................238
Center console harness..............................................238
Tunnel harness ...........................................................239
Harness front door, left ...............................................240
Harness front door, right .............................................240
Harness rear door, left ................................................241
Harness rear door, right..............................................241
Tailgate harness .........................................................242
Harnesses rear axle....................................................242
Component illustrations ..........................243
Index 1:2 ....................................................295
List of components 1:6 ........................... 297
Table of Contents 3:3

TP39215202 XC60 2012 6
Explanations
Abbreviations
Groups
Group 26 = Cooling system
Group 27 = Engine controls
Group 28 = Ignition and control system
Group 32 = Alternator and voltage regulator
Group 33 = Starting system
Group 35 = Lighting
Group 36 = Additional electrical equipment
Group 37 = Wiring and fuses
Group 38 = Instruments
Group 39 = Other
Group 43 = Transmission
Group 55 = Parking brake
Group 59 = Brake system
Group 64 = Steering
Group 76 = Shock absorbers
Group 83 = Doors and openings
Group 84 = Exterior decorative elements, etc.
Group 85 = Interior equipment
Group 87 = Climate control system
Group 88 = Internal equipment
Group 89 = Body other
Ignition switch symbols
X = Accessories (audio position)
S= Powered upon insertion of key
15 = Contact remains connected during
start
15l = Contact is broken while starting
30 = Constant power from the battery
50 = Start
Countries/Markets
A = Austria
AUS = Australia
B = Belgium
CDN = Canada
CH = Switzerland
D= Germany
DK = Denmark
E= Spain
EU/OS = Markets outside USA and Canada
FIN = Finland
GB = Great Britain
ISR = Israel
J= Japan
KOR = Korea
N= Norway
NL = Netherlands
S= Sweden
USA = United States of America
WEU = Western Europe
Other
ACC = Adaptive Cruise Control
Ag = Silver plated
Au = Gold plated
AUTO = Automatic transmission
BLIS = Blind spot information system
CAN = CAN communication
DPY = Display
ECC = Electronic climate control system
ETA = Throttle unit
EXC = Exclusive
GDL = Gas discharge lamp
HS = High speed data bus
KEYLESS = Keyless vehicle
IR = Infrared sensor
LIN = LIN communication
LH = Left-hand side
LHD = Left-hand drive
MAN = Manual transmission
MEMORY = Memory driver’s seat
MIRCAM = Parking camera in rear-view mirror
MS = Midspeed data bus
MMS = Mass Movement Sensor
PANROOF = Panoramic roof
PETROL = Gasoline
RH = Right-hand side
RHD = Right-hand drive
RTI = Road Traffic Information
SCR = Screened
SRS = Airbag
T= Turbocharged engine
W/O = Without
2WD = Two-wheel drive
4CYL, I4 = 4-cylinder engine
5CYL, I5 = 5-cylinder engine
6CYL, I6 = 6-cylinder engine
Colors
BK, SB = Black
BN = Brown
BU, BL = Blue
GN = Green
GY, GR = Gray
LGN = Light Green
NL = Natural
OG, OR = Orange
PK, P = Pink
RD, R = Red
VT, VO = Violet
WH, W = White
YE, Y = Yellow

TP39215202 XC60 2012 7
The descriptions below apply in general
to all wiring diagram manuals, although
not all sections are necessarily con-
tained in this manual.
The systems are shown in non-active
status. i.e. with "key removed" and when
the doors, hatches and hood are closed.
How to use the wiring diagrams 1:2
A. Component designation
Every component has a component designation that
consists of two parts.
The first part is a type number that describes the
type of component in question, for example 3/xx.
The second part of the designation is a serial num-
ber, e.g. x/2.
Together, this constitutes a component designation,
e.g. 3/2.
At the end of the manual is a list of components,
where, with the help of the component designation,
you can read off the name of the component, for
example, 3/2 = light switch.
List of type numbers
The list shows which type of component that respec-
tive type numbers refer to, for example, 3/x = switch,
6/x = electric motor, etc.
1 Battery
2Relay
3 Switch
4Control module
5 Driver information module
6 Electric motor
7Sensor
8 Actuator
9Heating element
10 Light
11 Fuse
15 Electrical distribution rail/box
16 Audio
17 Service/diagnostics
18 Contact reel
19 Meter
20 Ignition component/shunt
27 Optics
31 Ground connection
73 Branching point
74 Connector
B. Branching points
The wiring diagrams contain numbered branching
points, for example 73/5035.
This manual contains a section with a list of branch-
ing points. This list shows all the components that
are connected to each branching point.
The location of the branching points is shown in the
"Cable harness routing in vehicle" section.
C. Connectors
Connectors provide a bridge between two cable har-
nesses and are described in the "Connectors" sec-
tion.
D. Electrical distribution
Operation of the fuses and relays is shown in the
"Electrical distribution" section.
E. Data communication
Today’s cars contain CAN, LIN and MOST networks
that transfer information. Connections to these net-
works are not shown in their entirety in the respec-
tive wiring diagram. Complete information on CAN,
LIN and MOST communication is found in the sec-
tion "Control modules".
F. Abbr e v i a tions
A number of different abbreviations are used in the
manual. These are explained in the section "Abbre-
viations".
G. Co m pone n t l o cati o n
There is a section at the end of the manual in which
the appearance and location of components is
described in numerical order.

TP39215202 XC60 2012 8
How to use the wiring diagrams 2:2
List of symbols
= System voltage
= Ground connection via wiring
= Ground connection in
component/chassis
= Screened wire
= Junction point
= Twisted cable
= Electrical connection
= Variant
= CAN communication
= CAN high data signal (CAN H)
= CAN low data signal (CAN L)
= LIN communication
= LIN communication
= DIN cable, coaxial cable, etc.
= Data communication
= CAN communication
= MOST communication
= MOST communication
= Connection with distribution box
= Further connection to...
= Connector between cable
harnesses
= Connector connected in
component

TP39215202 XC60 2012 9
15/36
R1
2/88
21
3
5
R4
2/193
2
1
3
5
11D/A7
21
11D/A6
21
11D/A5
21
11D/A8
21
11D/A3
21
11D/A2
21
11D/A1
21
11D/A4
21
11D/A10
21
11D/A9
21
11D/A11
21
11D/A12
21
21
3
5
2/82
15/32
RA2
21
3
5
A
RA1
RD-GN RD-GN
RD-GN
RD-VT
RD-VT
73/5075
2/16
74/504B
2
R7
2/31
2
1
35
11A/3
12
11A/2
12
11A/1
12
11A/4
12
11A/5
12
11B/17
RD
12
12
15/31
11B/27
C1:63
C1:13
C5:1
C5:2
30+
C2:5
C2:17
C1:9
I013545
12 12 12 12 12
GY-BK
RD-BU RD-BK
GN-VT
RD-GN
RD-BN
RD-GY
RD-GN
74/504
14
VT-GN
VT-GN
BU
CAN
CEM
4/56
LIN
12 12 12 12 12
12 12 12 12
F17 F20
12
F1
F6
Electrical distribution Overview without Start/stop function

TP39215202 XC60 2012 10
15/36
R1
2/88
21
3
5
R4
2/193
2
1
3
5
11D/A7
21
11D/A6
21
11D/A5
21
11D/A8
21
11D/A3
21
11D/A2
21
11D/A1
21
11D/A4
21
11D/A10
21
11D/A9
21
11D/A11
21
11D/A12
21
21
3
5
2/82
15/32
RA2
21
3
5
A
RA1
RD-GN RD-GN
RD-GN
RD-VT
RD-VT
73/5075
2/16
74/504B
2
R7
2/31
11A/3
12
11A/2
12
11A/1
12
11A/4
1211A/5 12
11B/17
RD
12
12
15/31
11B/27
CAN
CEM
4/56
C1:63
C1:13
C5:1
C5:2
LIN
C2:5
C2:17
C1:9
I013546
12 12 12 12 12
GY-BK
RD-BU RD-BK GN-VT
RD-GN
RD-BN
RD-GY
RD-GN
74/504 14
VT-GN
VT-GN
BU
21 21 21 21 21 21
11A/8
21
2
1
35
15/37
R2
2/246
2
1
2
121
3
5
21
3
5
11A/7
2
1
2
1
11B/12
2
1
21
2
1
R1
2/166
11A/6
MF1
F10
11A/2
MF2
M11
11A/1
11A/4 11A/5 11A/3
11A/9
12V BK
31/131
1/2
RD
74/301
27
74/504
3
74/316 4
RD
RD
RD
RD
12V BK
31/3
1/1
RD 21
PF1
21
PF4
Electrical distribution Overview with Start/stop function

TP39215202 XC60 2012 11
Electrical distribution 1:3
Overview, Distribution box in engine compartment
15/31
11B/36
21
11B/37
21
11B/38
21
11B/41 11B/18 12
11B/16 12
11B/17
73/3068
73/3085 12
11B/19 12
11B/20 12
11B/21 12
11B/22 12
11B/23 12
11B/28 12
11B/29 12
YE-GN
RD
RD
RD
RD
GY-BK
RD
RD
GN-VT
RD-BK
RD-GN
RD-GY
RD-BN 15/36
15/36
15/32
4/56C5:2
4/56C5:1
RD
RD
RD
4/46B:16
5&6 CYL.T
RD
RD
RD
RD
RD
RD
RD
RD
GY-VT
GY-VT
GY-VT
GY-VT
RD
RD-BK
RD
11B/27 12
11A/1
11A/2
11A/3
11A/4
11A/5
11A/6
12
11A/7
12
12
12
12
12
12
21
11B/40
21
11B/39
21
11A/43
21
11A/42
21
11A/44
21
11B/33
21
11B/32
21
11B/31
21
11B/30
21
11B/35
21
11B/34
21
21
3
52/22
R13
R10
2
1
35
2/31
R7
21
3
52/32
21
3
52/35
R12
11B/13
11B/11
11B/9
11B/12
11B/10
12
11B/14 12
12
12
12
12
11B/8 12
9/42
4/56C1:13
4/56C1:63
RD
RD-VT
RD
2/142 R11
Diesel
2/133 R11
4 Cyl. T
4 Cyl. T &
4 Cyl. T
4 Cyl. T
5 Cyl. D
5 Cyl. D
BU-OG
GN-OG
GN-OG
BU-OG
YE-GN
74/301
16
I012216
2
1
35
2/17
R8
2
1
35
2/182
R9
RD-VT
RD
RD RD
A
RD-BU
RD-BU
30+

TP39215202 XC60 2012 12
Electrical distribution 2:3
Overview, Distribution box in passenger compartment
2
1
35
4
R2
R1
2/88
2
1
35
4
R3
2
1
3
5
R4
2/193
21
3
5
11C/3 12
11C/2 12
11C/1 12
11C/4 12
11C/7 12
11C/6 12
11C/5 12
11C/8 12
11C/10 12
11C/9 12
11C/11 12
11C/14 12
11C/13 12
11C/12 12
11C/15 12
11C/18 12
11C/17 12
11C/19 12
11C/25 12
11C/24 12
11C/23 12
11C/22 12
11C/21 12
11C/16 12
11C/20 12
11C/27
12
11C/26
12
12
11C/28
12
11C/29
12
11C/30
RD
RD
RD
RD
RD
73/5117
15/36
RD-BN
RD-GY
I012227
15/31
11A/5
12
11A/4
12
30+
15/37
11A/3
12
11A/4
12RD-GY
RD-BN
STOSTA STOSTA

TP39215202 XC60 2012 13
11D/A7
21
11D/A6
21
11D/A5
21
11D/A8
21
11D/A3
21
11D/A2
21
11D/A1
21
11D/A4
21
11D/A10
21
11D/A9
21
11D/A11
21
11D/A12
21
21
3
5
2/82
15/32
RA2
21
3
5
A
RA1
RD-GN
RD-GN
RD-GN
RD-GN
RD-VT
RD-VT
73/5075
2/16
74/504B
2
I012220
15/31
11A/3
12
3
15/31
2
30+
11A/5
12 RD-GN 2
2
RD-GN
15/37
STOSTA
Electrical distribution 3:3
Overview, Distribution box in cargo compartment

TP39215202 XC60 2012 14
Fuses
Distribution box in engine compartment F1 - F7
15/31 Distribution box in engine compartment
No. No. Fuse function via A
F1 11A/1 4/56 Central electronic module (CEM) -50
F7 Fuse in the Central electronic module (CEM) -
F9-F10 Fuses in the Central electronic module (CEM) relay in
CEM
F21 Fuse in the Central electronic module (CEM) -
F23 Fuse in the Central electronic module (CEM) -
F2 11A/2 4/56 Central electronic module (CEM) -50
F1-F6 Fuses in the Central electronic module (CEM) relay in
CEM
F8 Fuse in the Central electronic module (CEM) relay in
CEM
F11-F12 Fuse in the Central electronic module (CEM) relay in
CEM
F13-F16 Fuses in the Central electronic module (CEM) -
F22 Fuse in the Central electronic module (CEM) -
F24 Fuses in the Central electronic module (CEM) -
F3 11A/3 11D/A1-
11D/A11 Fuses in distribution box cargo compartment -
60
F4 11A/4 2/193 Relay, comfort functions -60
11C/1-
11C/15 Fuses in distribution box passenger compartment -
11C/21-
11C/22 Fuses in distribution box passenger compartment 2/193
11D/A5 Fuses in distribution box cargo compartment -
F5 11A/5 2/88 Relay, 15-feed -60
11C/23-
11C/25 Fuses in distribution box passenger compartment 2/88
11C/26-
11C/30 Fuses in distribution box passenger compartment -
F7 11A/7 9/42 PTC-element -100
continues

TP39215202 XC60 2012 15
Fuses
Distribution box in engine compartment F8 - F23
15/31 Distribution box in engine compartment
No. No. Fuse function via A
F8 11B/8 2/182 Relay, headlight washer motor -20
6/104 Washer motor headlights 2/182
F9 11B/9 6/1 Wiper motor module (WMM) -30
F10 11B/10 4/7 Combustion preheater module (CPM) -25
4/106 Control module, remote parking heater start -
F11 11B/11 4/31 Fan control module -40
6/28 Motor, passenger compartment fan -
F13 11B/13 4/16 Brake control module (BCM), pump -40
F14 11B/14 4/16 Brake control module (BCM), valves -20
F16 11B/16 10/1 Lamp housing, front left -10
10/2 Lamp housing, front right -
F17 11B/17 4/56 Central electronic module (CEM) -20
F18-F20 Fuses in the Central electronic module (CEM) -
F18 11B/18 4/16 Brake control module (BCM) -5
F19 11B/19 4/99 Electronic power steering control module -5
6/164 Electrical power steering module (EPS) -
F20 11B/20 4/9 Supplemental restraint system module (SRS) -10
4/28 Transmission control module (TCM) -
4/46 Engine control module (ECM) -
F21 11B/21 9/43 Heated windshield washer nozzle, left -10
9/44 Heated windshield washer nozzle, right -
F22 11B/22 2/133 Relay vacuum pump -5
F23 11B/23 3/111 Light switch module (LSM) -5
continues

TP39215202 XC60 2012 16
Fuses
Distribution box in engine compartment F27 - F37
15/31 Distribution box in engine compartment
No. No. Fuse function via A
F27 11B/27 2/17 Relay, horn
2/31 Relay, 15-feed
2/182 Relay, headlight washer motor
-5
F28 11B/28 2/64 Relay auxiliary lights -20
10/65 Auxiliary lights, front right 2/64
10/69 Auxiliary lights, front left 2/64
F29 11B/29 16/10 Horn 1 2/17 15
16/11 Horn 2 -
F30 11B/30 2/32 Main relay, engine management system -10
4/46 Engine control module (ECM) -
F31 11B/31 4/28 Transmission control module (TCM) -15
F32 11B/32 6/73 Coolant pump
8/3 Electromagnetic clutch, climate control system
2/22 15
F33 11B/33 2/22 Relay, climate control system -5
F34 11B/34 6/25 Starter motor 2/35 30
F35 11B/35 4/109 Glow plug control module, 5-Cyl. Diesel -10
20/3-6 Spark plug with ignition coil, 4-Cyl. Turbo
20/3-8 Spark plug with ignition coil, 6-Cyl. -20
20/16 Capacitor, 6-Cyl. -
F36 11B/36 4/46 Engine control module (ECM), 5-Cyl. Diesel -15
4/46 Engine control module (ECM), 4-Cyl. Turbo & 6-Cyl. -10
F37 11B/37 7/17 Mass air flow sensor MAF, 5-Cyl. Diesel -15
8/98 Control valve fuel pressure, 5-Cyl. Diesel -
8/111 Control valve fuel flow, 5-Cyl. Diesel -
4/46 Engine control module (ECM), 6-Cyl. -
7/17 Mass air flow sensor MAF, 6-Cyl. -
8/6-11 Injection valves, 6-Cyl. -
continues

TP39215202 XC60 2012 17
Fuses
Distribution box in engine compartment F38 - F39
15/31 Distribution box in engine compartment
No. No. Fuse function via A
F38 11B/38 7/17 Mass air flow sensor MAF, 4-Cyl. Turbo -10
8/18 EVAP valve, 4-Cyl. Turbo -
8/19 Solenoid, variable valve timing, intake, 4-Cyl. Turbo -
8/28 Turbocharger control valve, 4-Cyl. Turbo -
8/81 Solenoid, variable valve timing, exhaust, 4-Cyl. Turbo -
7/35 Oil level sensor, 5-Cyl. Diesel -
8/3 Electromagnetic clutch, climate control system, 5-Cyl. Diesel -
8/28 Turbocharger control valve, 5-Cyl. Diesel -
8/113 Bypass valve, EGR cooling, 5-Cyl. Diesel -
8/157 Turbocharger control valve, 5-Cyl. Diesel -
8/164 Electric piston cooling valve, 5-Cyl. Diesel -
4/46 Engine control module (ECM), 6-Cyl. -
6/139 Upper actuator motor intake manifold, 6-Cyl. W/O Turbo. -
6/140 Lower actuator motor intake manifold, 6-Cyl. W/O Turbo. -
8/3 Electromagnetic clutch, climate control system, 6-Cyl. -
8/28 Turbocharger control valve, 6-Cyl. Turbo -
8/68 Relief valve, 6-Cyl. Turbo -
8/117 Solenoid, variable valve timing, intake, 6-Cyl. -
8/125 Solenoid cam profile front, 6-Cyl. W/O Turbo -
8/126 Solenoid cam profile rear, 6-Cyl. W/O Turbo -
F39 11B/39 7/15 Front heated oxygen sensor, 4-Cyl. Turbo -10
7/82 Rear heated oxygen sensor bank 1, 4-Cyl. Turbo -
7/15 Front heated oxygen sensor, 5-Cyl. Diesel -
7/15 Front heated oxygen sensor, bank 1, 6-Cyl. -15
7/82 Rear heated oxygen sensor, bank 1, 6-Cyl. -
7/103 Front heated oxygen sensor, bank 2 6-Cyl. W/O Turbo -
7/104 Rear heated oxygen sensor, bank 2 6-Cyl. W/O Turbo -
8/18 EVAP valve, 6-Cyl. -
continues

TP39215202 XC60 2012 18
Fuses
Distribution box in engine compartment F40 - F44
15/31 Distribution box in engine compartment
No. No. Fuse function via A
F40 11B/40 2/142 Relay pre-heater fuel filter, 5-Cyl. Diesel -20
6/114 Vacuum pump, 4-Cyl. Turbo 2/142
9/32 PTC resistor crankcase ventilation, 5-Cyl. Diesel -
9/38 Heated fuel filter, 5-Cyl. Diesel 2/142
F41 11B/41 6/67 Pump, fuel leakage control 6-Cyl. -5
6/179 Electric transmission oil pump -
9/32 PTC resistor crankcase ventilation, 5-Cyl. Diesel -
9/38 Heated fuel filter, Diesel -
F42 11A/42 4/109 Glow plug control module -70
20/22-26 Glow plug, 5-Cyl. Diesel 4/109
F43 11A/43 4/71 Control module cooling fan 4-Cyl. Turbo -60
4/71 Cooling fan control module, 5-Cyl. Diesel & 6-Cyl. -80
F44 11A/44 6/164 Electrical power steering module (EPS) -100

TP39215202 XC60 2012 19
Fuses
Central electronic module (CEM) F1 - F13
4/56 Central electronic module (CEM)
No. Fuse function via A
F1 2/16 Relay, rear window wiper - 15
6/32 Rear window wiper motor 2/16
F3 3/26 Switch unit, power driver’s seat - 7.5
3/27 Switch unit, power passenger seat -
3/176 Power window switches, driver’s door -
3/291 Tailgate closing switch -
4/52 Power seat module (PSM) -
10/25 Ceiling light cargo compartment -
10/29 Glove compartment lighting -
10/125 Left-hand front courtesy lighting -
10/126 Right-hand front courtesy lighting -
17/45 Alcolock outlet
26/6 Converter/control module, sill moldings, driver’s side
26/7 Converter/control module, sill moldings, passenger side
26/8 Alcolock charging cradle
-
-
-
F4 5/1 Driver Information module (DIM) - 5
F5 4/80 Forward Sensing Module (FSM) - 10
7/203 Forward-aimed radar (FLR) -
F6 7/149 Rain sensor module (RSM) - 7.5
10/22 Ceiling light -
10/114 Vanity mirror lighting, left -
10/115 Vanity mirror lighting, right -
10/150A Rear reading light -
10/150B Rear reading light -
F7 3/4 Steering wheel switch left (SWSL) 3/130 7.5
3/131 Steering wheel switch right (SWSR) 3/130
F8 6/37 Lock motor, fuel filler flap - 10
F9 6/127 Washer motor - 15
F10 6/127 Washer motor - 15
F13 4/83 Control module fuel pump - 20
6/33 Fuel pump 4/83
continues

TP39215202 XC60 2012 20
Fuses
Central electronic module (CEM) F14 - F24
4/56 Central electronic module (CEM)
No. Fuse function via A
F14 4/6 Climate control module (CCM) - 5
7/122 Mass movement sensor module (MMS), front -
7/199 Ultrasonic sensor (IMS) -
F15 4/102 Steering column lock module (SCL) - 15
F16 16/35 Siren control module (SCM) - 5
17/13 Data link connector -
F18 4/9 Supplemental restraint system module (SRS) - 10
4/125 Closing velocity module (CVM) -
7/93 Occupant weight sensor (OWS) -
F19 4/80 Forward Sensing Module (FSM) - 5
7/203 Forward-aimed radar (FLR) -
F20 3/65 Switch, heated rear seat - 7.5
7/51 Accelerator pedal sensor -
8/48 Auto-dimming rearview mirror -
9/42 PTC-element -
F21 16/1 Integrated Audio Module (IAM) - 15
16/109 RSE control module -
16/159 Control module, cellular phone handsfree -
F22 3/9 Contact brake light - 5
F23 4/33 Sun roof module (SRM) - 20
F24 3/1 Ignition lock - 5
16/65 Immobilizer antenna unit -