Volvo S60 - ANNEXE 931 Quick start guide

2005SUPPLEMENT
VOLVO
TP 3985202
S60/S60R/S80
V70/V70R/XC70/XC90

© Volvo Car Corporation
Vehicles with SRS (Airbag)/SIPS bag/IC
(Inflatable curtain)
Warning!
Extra caution must be exercised when working on vehicles equipped with SRS/SIPS bag/IC
in order to avoid:
1. Personal injuries when performing repair work.
2. Damage or malfunction of the SRS/SIPS bag/IC system.
Work involving the SRS/SIPS bag/IC systems or other components in the vehicle that may
affect the SRS/SIPS bag/IC systems must always be performed by an authorized Volvo
workshop.
In case of doubt, consult the SRS and SIPS bag/IC service manual.
Is the vehicle equipped with SRS/SIPS bag/IC?
Vehicles with SRS are most easily recognized by the letters SRS in the center of the steering
wheel. If the vehicle also has a passenger side airbag, the letters SRS are stamped on the
dashboard above the glove compartment. SRS vehicles from 1993 and onward also have
explosive seat belt tensioners. SIPS bags are only installed on SRS vehicles from 1995 and
onward. SIPS bag decals are located on the windshield and seat compartment. Vehicles with
IC can be recognized by the letters IC on the C/D panel (4 door) or the B panel (5 door).
General recommendations
• Be especially careful when working on or around SRS, SIPS, and IC components.
• Make sure that no wires are pinched, frayed, or pierced.
• Never fit accessories by the sensors.
• Where applicable, work on the steering wheel, steering shaft, or steering gear must be done
in accordance with the methods in the SRS section of VADIS.
• Certain components of the aforementioned systems must be grounded while working. Read
the appropriate sections in VADIS.
• Do not install any accessories in the areas between the A and B-pillars, the B and C-pillars,
and the C and D-pillars.
Test terminal
Fuse in cargo compartment auxiliary fuse box.
Modifications introduced up to August 2004
Any changes made to the vehicle after this date are not included in the
manual. If necessary, refer to service bulletins.
Volvo models are sold in versions adapted for different markets. These
adaptations depend on factors such as legal requirements, taxation, and
market demands.
This manual may therefore include illustrations and text that do not apply to
the vehicles in your country.
Order number TP 3985202
This publication contains updated information for model year 2005 late edition. For other
electrical systems, see publication TP 3977202, which is found in
Electronic Wiring Diagram (EWD) TP 3983003 or later.
We retain the right to make modifications.

TP3985202 Supplement 2005
Vehicles with SRS (Airbag)/SIPS bag/IC
(Inflatable curtain).......................................................... 2
Abbreviations................................................................. 5
How to use the wiring diagrams 1:2............................... 6
Electrical distribution 1:2 XC90...................................... 8
Fuses
Engine compartment 11A/1-5.......................................10
Engine compartment 11B/1-12.....................................11
Engine compartment 11B/13-15...................................12
Engine compartment 11B/16-20...................................13
Central Electronic Module (CEM) F1-F14.....................14
Central Electronic Module (CEM) F15-F34...................15
Rear Electronic Module (REM) F1-F6 ..........................16
Rear Electronic Module (REM) F7-F27 ........................17
Rear Electronic Module (REM) F28-F38 ......................18
Relays
Engine compartment FMA1 - FST3............................. 19
Ground connections
Overview...................................................................... 20
31/2 - 31/100 ............................................................... 21
Control modules
Data communication, high speed CAN XC90.............. 22
Data communication, low speed CAN XC90............... 23
LIN data communication 1:2........................................ 24
Group 23 Fuel system
Engine management system, 5-cyl. XC90 1:2............. 26
Engine management system, 6-cyl. XC90 1:2............. 28
Engine management system, 8-cyl. XC90 1:2............. 30
Engine management system, Diesel XC90 1:2........... 32
Emission control 5 & 6-cyl. XC90 ................................ 34
Emission control 8-cyl. XC90....................................... 35
Group 26 Cooling system
Electric cooling fan XC90............................................. 36
Group 27 Engine control
Cruise control XC90......................................................37
Group 32 Generator and voltage regulator
Power supply XC90..................................................... 38
Group 33 Starting system
Starter system XC90.................................................... 39
Group 35 Lighting
High and low beams/Bi-Xenon & Daytime running
lights XC90 ................................................................ 40
Position/parking lights, tail lights & license
plate lighting XC90 ..................................................... 41
Auxiliary lights XC90.................................................... 42
Group 36 Additional electrical equipment
Windshield wipers/washer XC90 ................................. 43
High pressure headlight washer XC90 ........................ 44
Group 38 Instruments
Driver information module, 8-cyl. XC90....................... 45
Group 39 Other
Infotainment XC90....................................................... 46
Road Traffic Information (RTI) & CD changer
S60/S80/V70 .............................................................. 47
Subwoofer V70 ............................................................ 48
Satellite radio S60/S80/V70......................................... 49
MP3 player S60/S80/V70 ............................................ 50
Group 43 Transmission
Automatic transmission 4T65AWD XC90.................... 51
Automatic transmission TF-80SC AWD XC90............. 52
Group 59 Brake system
Brake control system XC90......................................... 53
Group 84 Exterior decorative elements etc.
Power door mirrors with camera function .................... 54
Group 87 Climate controls
Parking heater, auxiliary heater XC90 ....................... 55
Climate control system XC90 1:2................................. 56
Connectors................................................. 58
Junction points ..........................................59
Component illustrations............................62
Index........................................................... 69
List of components 1:4..............................70
Table of Contents 1:2

TP3985202 Supplement 2005

TP3985202 Supplement 2005 5
Explanations
Abbreviations
Groups
Group 23 = Fuel system
Group 26 = Cooling system
Group 27 = Engine controls
Group 32 = Generator and voltage regulator
Group 33 = Starting system
Group 35 = Lighting
Group 36 = Additional electrical equipment
Group 37 = Wiring and fuses
Group 38 = Instruments
Group 39 = Other
Group 43 = Transmission
Group 59 = Brake system
Group 64 = Steering
Group 76 = Shock absorbers
Group 83 = Doors and openings
Group 84 = Exterior decorative elements etc.
Group 85 = Interior equipment
Group 87 = Climate controls
Group 88 = Internal equipment
Ignition switch symbols
X = Accessories (audio position)
S = Powered upon insertion of key
15 = The switch remains connected during
start
15l = Contact is broken while starting
30 = Constant power from the battery
50 = Start
Countries/Markets
A=Austria
AUS = Australia
B = Belgium
CDN = Canada
CH = Switzerland
D=Germany
DK = Denmark
E=Spain
EU/OS = Markets outside USA and Canada
FIN = Finland
GB = Great Britain
ISR = Israel
J=Japan
KOR = Korea
N=Norway
NL = Netherlands
S=Sweden
USA = United States of America
WEU = Western Europe
Other
ACC = Accessory
AMP = Amplifier
AUDIO = Audio system
AUTO = Automatic transmission
Bi-X = Bi-Xenon
BLIS = Blind spot information system
CEM = Central Electronic Module
DRL = Daytime Running Lights
DSTC = Dynamic Stability Traction Control
ECC = Electronic climate control system
ECPS = Electronic power steering
EXC = Exclusive
EXT. D = Extended electrical distribution
HISPEED = High speed data bus
LH = Left-hand side
LHD = Left-hand drive
LOSPEED = Low speed data bus
MAN = Manual transmission
OPN = Option (factory-installed)
PCL = Power Child Lock
PETROL = Gasoline
REM = Rear Electronic Module
RH = Right-hand side
RHD = Right-hand drive
RTI = Road Traffic Information
SRS = Airbag
SUBWOOF = Bass speaker
SULEV = Super Ultra Low Emission Vehicle
SUM = Suspension Module (SUM)
T=Turboengine
ULEV = Ultra Low Emission Vehicle
W/O = Without
5CYL = 5-cylinder engine
6CYL = 6-cylinder engine
8CYL = 8-cylinder engine
Colors
BL = Blue
BN = Brown
GN = Green
GR = Gray
LBL = Light Blue
LGN = Light Green
OR = Orange
P=Pink
R=Red
SB = Black
VO = Violet
W=White
Y = Yellow

TP3985202 Supplement 2005 6
The descriptions below apply in general
to all wiring diagram manuals, although
not all sections are necessarily con-
tained in this manual.
How to use the wiring diagrams 1:2
A. Component designation
Every component has a component designation that
consists of two parts.
The first part is a type number that describes the
type of component in question, for example 3/xx.
The second part of the designation is a serial num-
ber, e.g. x/2.
Combined these give a component designation, for
example 3/2.
At the end of the manual is a list of components,
where, with the help of the component designation,
you can read off the name of the component, for
example, 3/2 = light switch.
List of type numbers
The list shows which type of component that respec-
tive type numbers refer to, for example, 3/x = switch,
6/x = electric motor, etc.
1 Battery
2Relay
3Switch
4 Control module
5 Driver Information Module
6 Electric motor
7 Sensor
8Actuator
9 Heating element
10 Light
11 Fuse
15 Electrical distribution rail/box
16 Audio
17 Service/diagnostics
18 Contact reel
19 Meter
20 Ignition component/shunt
26 Converter
27 Optics
31 Ground connection
53 Junction point
54 Connector
B. Junction points
The wiring diagrams contain numbered junction
points, e.g. 53/352.
This manual contains a section with a list of junction
points. This list shows all the components which are
connected to each junction point.
The location of the junction points is shown in the
"Cable harness routing in vehicle" section.
C. Connectors
Connectors provide a bridge between two cable har-
nesses and are described in the "Connectors" sec-
tion.
D. Electrical distribution
Operation of the fuses and relays is shown in the
"Electrical distribution" section.
E. Data communication
Today’s cars are equipped with CAN, LIN & MOST
networks that transmit information. Connections to
these networks are shown in their entirety on the
respective wiring diagram. Complete information on
Data communication can be found in the section
entitled "Control modules".
F. Abbreviations
A number of different abbreviations are used in the
manual. These are explained in the section "Abbre-
viations".
G. Component location
There is a section at the end of the manual in which
the appearance and location of components is
described in numerical order.

TP3985202 Supplement 2005 7
How to use the wiring diagrams 2:2
AF EDCB
G
10/1-2
BN
20
53/503
7/149
BN
GN
3
2
1
5
3
UEM
D:49
13
8
GN
BN
54/16
1
2
3VO-W
1
2
11C/7
30+
1
2
11C/6
D:34
D:35
D:50
CEM
4/56
1
54/13
53/534
SWM
3/254
LIN
RR
31/98
4/70
1
11 R
R
BN
44
VO-W
WW
53/505
VO-W
D:11
54/13
14
W
BL-W
321
4
H
SB
31/93
BN
53/331
L
6/1
RSM
20 BN
BN
31/83
53/400
BN
CAN
LIN
C:31
BN
53/397
CAN
LIN
LIN
7
GN-W
D:58
List of symbols
= System voltage
= Ground connection via wiring
= Ground connection in compo-
nent/chassis
= Screened wire
= Junction point
= Twisted cable
= Electrical connection
= Variant
= CAN communication
= CAN high data signal (CAN H)
= CAN low data signal (CAN L)
= LIN communication
= LIN communication
= DIN cable, coaxial cable, etc.
= Data communication
= CAN communication
= MOST communication
= MOST communication
= Connection with distribution
box
= Further connection to...
= Connector between cable
harnesses
= Connector connected in
component
LIN
CAN
1
1

TP3985202 Supplement 2005 8
Electrical distribution 1:2 XC90
Overview
R-W
R-W
R-W
R-SB
GN-W
GN-Y
R-W
R-W
R
R-W
GN-OR
BL-R
BL-R
BL-R
BL
GN-OR
GN-OR
BL-R
R
SB
R
R
RY
Y
BL
R
123
DIESEL DIESELDIESEL
DIESEL
W/O 8 CYL
8CYL
11A/1
2
1
11A/2
2
1
11A/3
2
1
BA
11A/4
2
1
11A/5
2
1
11B/1
2
1
11B/2
2
1
11B/3
2
1
11B/4
2
1
11B/5
2
1
11B/6
2
1
11B/7
2
1
11B/8
2
1
11B/9
2
1
11B/10
2
1
11B/11
2
1
11B/12
2
1
11B/13
2
1
11B/14
2
1
11B/15
2
1
11B/16
2
1
11B/17
2
1
11B/18
2
1
11B/19
2
1
11B/20
2
1
11B/21
2
1
5(87)2(85)
4
1
2
3
3(30)
1(86)
FMA2
2/14
15/31
A1 A1 A1
5(87)2(85)
4
1
2
35
3(30)
1(86)
FST1
2/90
6/1
4(87a) 5(87)2(85)
4
1
2
35
3(30)
1(86)
FST2
2/91
4(87a) 5(87)2(85)
4
1
2
35
3(30)
1(86)
FST3
2/182
4(87a)
5(87)2(85)
4
1
2
3
3(30)
1(86)
FMA3
2/32
5(87)2(85)
4
1
2
3
3(30)
1(86)
FMA1
2/35
5(87)2(85)
4
1
2
3
3(30)
1(86)
FMI2
2/22
17/17
4/56C:7
4/46B:11
GR 54/1B:6
GN-R
BL-OR
W/O 8 CYL
8CYL
54/1B:8
4/56C:6
BL-OR 4/46B:51
GN-W
R-W
BL-GN
W/O 8 CYL
8CYL
W/O 8 CYL
8CYL
4/46B:44
4/46B:53
GR-SB
GR
4/56C:25
53/331
4/56C:4
GN-SB
6/104:1
Y
Y
6/1
Y
4/56C:3
Y/W
Y/W
4/46B:16
4/46B:38
R
54/1:1
BN
4/46B:50
DC FE
53/305
GN-Y
GN-Y

TP3985202 Supplement 2005 9
Electrical distribution 2:2 XC90
Overview
2
R
R
R
R
R-W
BL-R
4/9B:27/55
11C/1111C/1
1 1
11C/2
2 2
11C/4
11
11C/3
1
11C/5
222
53/408
11C/8
1
11C/6
11
11C/7
2 22
1
11C/9
11
11C/10
2 22
4
3/1
R-SB
X
30
5
S
37
50
6
15
8
1
15 15I
16/65:1
BL-R
53/443
BL-R
11C/1311C/12
1 1
2 2
53/415
4/9B:28/56
3/157:2
1
11E
67
2
45
22
23
22
1
F1-38
D:16
B:2
B:24
B:3
B:16
D:15
D:60
4/56
CEM
D:8
CAN
1/1
12V
+
SB
SB
-
31/53
VO
VO
BL-R
2
C:13
C:14
REM
4/58
54/40D
2
VO VO
C:13
D:50
D:35
LIN
BL-R
Y
Y-W
C:14
3/157:1
R
R
53/403
1
E:A
E:B
R
R
R
R
Y-R
CNG/LPG
R
R
K:1
A:13
A:4
ABCDEF
BL
BL
R-W BL-R
R
R
A:29
54/40C 12
F16
F3,5-10,
17-23,
31-32 ,34
F1-2,11,
13-16,
26-30,33
CAN
LIN
ACM
A:1
6/26
B+
31
G
LIN
1
6/25
50
31
M
30

TP3985202Supplement2005 10
11A Fuses in engine compartment XC90
No. Fuse function via A
1 20/22-26 Glow plug 2/14 60
2 6/29 Motor, cooling fan 4/71 60
3- --
4- --
5- --
5
4
3
2
1
Fuses
Engine compartment 11A/1-5

TP3985202Supplement2005 11
11B Fuses in engine compartment XC90
No. Fuse function via A
1 4/16 Brake Control Module (BCM) - 30
2 4/16 Brake Control Module (BCM) - 30
3 6/104 High pressure headlight washer 2/182 35
4 6/35 Fuel pump, auxiliary heater
6/73 Coolant pump, auxiliary heater
9/30 Auxiliary heater
4/7
4/7
4/7
25
5 54/8 Connector cable harness extra lights, 30-feed - 20
6 6/25 Starter motor 2/35 35
7 2/90 Relay, windshield wiper, low/high speed
2/91 Relay, intermittent wiping
6/1 Windshield wiper motor
-
-
2/90, 2/91
25
8 4/28 Transmission Control Module (TCM), TF-80SC AWD - 15
9 6/33 Fuel pump 4/56 15
10 20/3-8 Spark plug and ignition coil
20/12-13 Spark plug and ignition coil
20/14 Condenser, ignition coils, 8-cyl.
8/111 Solenoid valve, high-pressure, Diesel
4/46 Engine Control Module (ECM), Diesel
-
-
-
-
-
20
11 6/44 Cooling fan, electrics box, engine compartment
7/51 Accelerator pedal sensor
8/3 Electromagnetic clutch, climate control system
-
-
2/22
10
12 7/17 Mass airflow sensor (MAF), Diesel - 5
4/46 Engine Control Module (ECM), Gasoline
7/17 Mass airflow sensor (MAF), Gasoline
8/6-11 Injectors, Gasoline
8/115-116 Injectors, Gasoline
-
-
-
-
15
continues
1
2
3
4
5
6
7
8
9
21
20
19
18
17
16
15
14
13
12
11
10
Fuses
Engine compartment 11B/1-12

TP3985202Supplement2005 12
11B Fuses in engine compartment XC90
No. Fuse function via A
13 4/46 Engine Control Module (ECM), 8-cyl. - 10
14 7//15 Heated oxygen sensor
7/15 Front heated oxygen sensor, bank A, 8-cyl.
7/82 Heated oxygen sensor, diagnosis 1
7/82 Front heated oxygen sensor, bank B, 8-cyl.
7/103 Heated oxygen sensor 3
7/103 Rear heated oxygen sensor, bank A, 8-cyl.
7/104 Rear heated oxygen sensor, bank B, 8-cyl.
-
-
-
-
20
15 2/14 Relay, glow plug unit
6/67 Pump, fuel leakage control
8/17 EGR valve, Diesel
8/18 EVAP valve
8/19 Solenoid, variable valve timing intake
8/28 Turbo control valve
8/64 Solenoid valve, engine mounting, Diesel
8/81 Solenoid, variable valve timing outlet
8/82 Solenoid, variable turbo geometry, Diesel
9/32 PTC resistor - air preheating
-
-
-
-
-
-
-
-
-
-
10
4/46 Engine Control Module (ECM), 8-cyl.
6/67 Pump, fuel leakage control, 8-cyl.
7/17 Mass air flow sensor (MAF), 8-cyl.
8/3 Electromagnetic clutch, climate control system, 8-cyl.
8/18 EVAP valve, 8-cyl.
8/19 Solenoid, variable valve timing intake, bank A, 8-cyl.
8/81 Solenoid, variable valve timing outlet, bank A, 8-cyl.
8/107 Valve, variable intake, 8-cyl.
8/117 Solenoid, variable valve timing intake, bank B, 8-cyl.
8/118 Solenoid, variable valve timing outlet, bank B, 8-cyl.
-
-
-
2/22
-
-
-
-
-
-
15
continues
1
2
3
4
5
6
7
8
9
21
20
19
18
17
16
15
14
13
12
11
10
Fuses
Engine compartment 11B/13-15

TP3985202Supplement2005 13
Fuses
Engine compartment 11B/16-20
11B Fuses in engine compartment XC90
No. Fuse function via A
16 10/1 Left front lamp housing, daytime running lights
10/70 Left-hand low beam 4/56 4/56 20
17 10/2 Right front lamp housing, daytime running lights
10/66 Right-hand low beam 4/56 4/56 20
19 2/32 Main relay, engine management system
4/46 Engine Control Module (ECM) - -5
20 10/11 Front left parking light
10/12 Front right parking light
10/71 Side running light, front left
10/73 Side running light, front right
4/56
4/56
4/56
4/56
15
1
2
3
4
5
6
7
8
9
21
20
19
18
17
16
15
14
13
12
11
10

TP3985202Supplement2005 14
4/56 Central Electronic Module (CEM)
No. Fuse function via A
F1 9/13 Seat Heater Module (SHM), right-hand - 15
F2 9/12 Seat Heater Module (SHM), left-hand - 15
F3 16/10 Horn 1
16/11 Horn 2 - -15
F5 16/46 Multimedia display, XC90
16/94 Infotainment Control Module (ICM), XC90
16/106 Control module, CD player (MP2), XC90
16/107 Control module, MD player (MP1), XC90
16/108 Multimedia module (MMM), XC90
54/112 Connector cable harness Infotainment, increased D-feed, XC90
-
-
-
-
-
-
10
F8 16/35 Siren Control Module (SCM) - 5
F9 3/9 Brake light contact - 5
F10 3/112 Climate Control Module (CCM)
4/7 Combustion Preheater Module (CPM)
4/52 Power Seat Module (PSM)
5/1 Driver Information Module (DIM)
6/48 Damper Motor Module (DMM), recirculation
6/69 Damper Motor Module (DMM), ventilation/floor/defroster
6/95 Damper Motor Module (DMM), temperature, left-hand side
6/96 Damper Motor Module (DMM), temperature, right-hand side
6/102 Damper Motor Module (DMM), defroster
6/103 Damper Motor Module (DMM), floor/ventilation
7/93 Occupant Weight Sensor (OWS)
7/159 Air Quality Sensor (AQS)
-
-
-
-
-
-
-
-
-
-
-
-
10
F11 9/1 Outlet 12V front
9/25 Outlet 12V rear
11 F/2 Fuse in cargo compartment auxiliary fuse box
-
-
-
15
F14 6/3 Right-hand headlight wiper motor
6/4 Left-hand headlight wiper motor - -15
12
31 32 33
363534
4
35678910 11 12 13 14 15 16
17 18 19 20 21 22 23 24 25 26 27 28 29 30
Fuses
Central Electronic Module (CEM) F1-F14

TP3985202Supplement2005 15
4/56 Central Electronic Module (CEM)
No. Fuse function via A
F15 4/16 Brake Control Module (BCM) - 5
F16 4/99 Electronic power steering control module
6/38 Left-hand headlight level adjustment motor
6/39 Right-hand headlight adjustment motor
8/76 Gas tank valve, Bi-Fuel
8/88 Solenoid, fuel tank CNG rear, Bi-Fuel
8/89 Solenoid, fuel tank CNG front left, Bi-Fuel
8/90 Solenoid, fuel tank CNG front right, Bi-Fuel
10/1 Left front lamp housing, Bi-Xenon
10/2 Right front lamp housing, Bi-Xenon
-
-
-
4/58
4/58
4/58
4/58
-
-
10
F17 10/5 Front left fog light - 7.5
F18 10/6 Front right fog light - 7.5
F20 6/113 Coolant pump, 8-cyl. - 5
F21 3/156 Gear Selector Module (GSM)
4/28 Transmission Control Module (TCM)
8/36 Shift lock solenoid
8/134 Solenoid, reverse interlock, manual
-
-
3/156
-
10
F22 10/68 Left-hand high beam - 10
F23 10/64 Right-hand high beam - 10
F28 3/27 Power passenger seat module - 5
16/1 Audio Module (AUM)
16/46 RTI display, accessory
16/93 Control module, cellular telephone handsfree
-
-
-
F30 27/3 Left-hand Camera Module (LCM)
27/4 Right-hand Camera Module (RCM) - -5
F33 6/114 Vacuum pump 8/84 20
F34 6/3 Right-hand headlight wiper motor
6/4 Left-hand headlight wiper motor
6/127 Washer motor
-
-
-
15
12
31 32 33
363534
4
35678910 11 12 13 14 15 16
17 18 19 20 21 22 23 24 25 26 27 28 29 30
Fuses
Central Electronic Module (CEM) F15-F34

TP3985202Supplement2005 16
4/58 Rear Electronic Module (REM)
No. Fuse function via A
F1 10/48 Right-hand reversing light
10/55 Left-hand reversing light - -10
F2 10/3 License plate lighting
10/19 Auxiliary brake light
10/42 Rear right parking light
10/44 Right-hand tail light lamp 1
10/45 Right-hand tail light lamp 2
10/46 Fog light, right rear
10/49 Rear left parking light
10/51 Left-hand tail light lamp 1
10/52 Left-hand tail light lamp 2
10/53 Fog light, left rear
10/127 Lighting, cargo compartment, left-hand side
10/128 Lighting, cargo compartment, right-hand side
-
-
-
-
-
-
-
-
-
-
-
-
20
10/173 Cargo compartment lighting, tailgate, XC90 -
F3 4/78 Accessory Electronic Module (AEM)
4/106 Control module, remote parking heater start - -15
F5 4/58 Rear Electronic Module (REM) - 10
F6 16/15 CD changer
16/36 TV receiver
16/45 Road Traffic Information (RTI)
16/46 RTI display, accessory
16/149 MP3 player
-
16/45
-
-
-
7.5
16/110 Antenna control module (ATM), XC90
54/98 Connector cable harness Rear Seat Entertainment, 30-feed,
XC90
-
-


 




 
 

 
 


 


  
Fuses
Rear Electronic Module (REM) F1-F6

TP3985202Supplement2005 17
4/58 Rear Electronic Module (REM)
No. Fuse function via A
F7 17/39 13-pin outlet, tow hitch cable harness - 15
F8 17/19 12V outlet, cargo compartment - 15
F9 2/139 Deadlock relay, right-hand rear door
3/86 Rear right door power window switch
6/93 Motor, rear right power window
-
-
3/86
20
F10 2/138 Deadlock relay, left-hand rear door
3/85 Rear left door power window switch
6/92 Motor, rear left power window
-
-
3/85
20
F13 8/85 Thermostatic switch and fuel filter heating - 15
F14 16/79 Bass speaker - 15
6/76 Climate control system, rear XC90
16/79 Subwoofer Module (SUB), XC90 - -
F17 16/145 Satellite radio receiver - 5
F19 6/32 Rear window wiper motor
8/59 Rear left head restraint solenoid
8/60 Rear right head restraint solenoid
-
-
-
15
F20 17/38 7-pin outlet, tow hitch cable harness
17/39 13-pin outlet, tow hitch cable harness - -20
F23 4/82 Differential Electronic Module (DEM) - 7.5
F24 4/84 Suspension Module (SUM) - 15
F26 4/86 Parking Assistance Module (PAM) - 5
F27 Main fuse for F20, F23, F24, F26 - 30


 




 
 

 
 


 


  
Fuses
Rear Electronic Module (REM) F7-F27

TP3985202Supplement2005 18
Fuses
Rear Electronic Module (REM) F28-F38
4/58 Rear Electronic Module (REM)
No. Fuse function via A
F28 3/76 Left-hand rear door lock unit
3/77 Right-hand rear door lock unit
3/78 Trunk lid lock unit
6/37 Lock motor, fuel filler cover
-
-
-
-
15
F29 4/110 Trailer Module
- position lights
- left-hand direction indicator
26/4 Converter cable harness tow hitch
- position lights
- left-hand direction indicator
-
-
-
-
-
-
25
F30 4/110 Trailer Module
- brake lights
- fog lights
- right-hand direction indicator
-
-
-
-
25
F31 Main fuse for F37-F38 - 40
F37 9/2 Heated rear window - 20
F38 9/2 Heated rear window - 20


 




 
 

 
 


 


  

TP3985202 Supplement 2005 19
Relays in engine compartment XC90
Pos Relay function
FMA1 2/35 Starter motor relay
FMA2 2/14 Relay, glow plug unit
FMA3 2/32 Main relay, engine management system
FMI2 2/22 Relay, climate control system
FST1 2/90 Relay, windshield wiper, low/high speed
FST2 2/91 Relay, intermittent wiping
FST3 2/182 Relay, high pressure headlight washer motor
FMA3
FMI1 FMI2
FMA2 FST2
FST3
FST1FMA1
Relays
Engine compartment FMA1 - FST3

TP3985202 Supplement 2005 20
31/72
31/99
31/120 31/72 31/120
XC90
XC90
31/48
31/118
31/73
31/66
31/83
31/6
31/98
31/46
31/47
31/53
31/93
31/2
31/95
31/70
31/44
31/4
31/102
31/91
31/84
31/10
31/94
31/67
31/89
31/88
31/1
31/96
31/90
31/100
Ground connections
Overview