Weber Summit 56209 User manual

#56209
470
Guía del Propietario del Asador de Gas Licuado de Propano - Pg. 37
Guide de L’Utilisateur du Grill à Gaz PL - Pg. 73
ESNA
GAS GRILL
Natural Gas Grill Owner’s Guide
YOU MUST READ THIS OWNER’S GUIDE
BEFORE OPERATING YOUR GAS GRILL.
mDANGER
If you smell gas:
1. Shut off gas to the appliance.
2. Extinguish any open flames.
3. Open lid.
4. If odor continues, keep away from the
appliance and immediately call your gas
supplier or your fire department.
Leaking gas may cause a fire or explosion
which can cause serious bodily injury or
death, or damage to property.
mWARNING:
1. Do not store or use gasoline or other
flammable liquids or vapors in the
vicinity of this or any other appliance.
2. An LP cylinder not connected for use
shall not be stored in the vicinity of this
or any other appliance.
mWARNING: Follow all leak-check
procedures carefully in this manual prior
to barbecue operation. Do this even if the
barbecue was dealer-assembled.
NOTICE TO INSTALLER: These instructions
must be left with the owner and the owner
should keep them for future use.
THIS GAS APPLIANCE IS DESIGNED FOR
OUTDOOR USE ONLY.
56209 02/01/10 NG
US - ENGLISH
mWARNING: Do not try to light this
appliance without reading the “MAIN
BURNER IGNITION” section of this
manual.

2
WARNINGS
mDANGER
Failure to follow the Dangers,Warnings and Cautions contained in this Owner’s Manual may result in serious bodily injury or
death, or in a fire or an explosion causing damage to property.
mWARNINGS
mDo not store a spare or disconnected liquid propane cylinder under or near this barbecue.
mImproper assembly may be dangerous. Please follow the assembly instructions carefully.
mAfter a period of storage, and/or nonuse, the Weber®gas barbecue should be checked for gas leaks and burner obstructions
before use. See instructions in this manual for correct procedures.
mDo not operate the Weber®gas barbecue if there is a gas leak present.
mDo not use a flame to check for gas leaks.
mCombustible materials should never be within 24 inches (61 cm) of the back or sides of your Weber®gas barbecue.
mDo not put a barbecue cover or anything flammable on, or in the storage area under the barbecue.
mYour Weber®gas barbecue should never be used by children. Accessible parts of the barbecue may be very hot. Keep young
children away while it is in use.
mYou should exercise reasonable care when operating your Weber®gas barbecue. It will be hot during cooking or cleaning and
should never be left unattended, or moved while in operation.
mShould the burners go out while in operation, turn all gas valves off. Open the lid and wait five minutes before attempting to
relight, using the lighting instructions.
mDo not use charcoal or lava rock in your Weber®gas barbecue.
mNever lean over open grill or place hands or fingers on the front edge of the cooking box.
mShould a grease fire occur, turn off all burners and leave lid closed until fire is out.
mDo not enlarge valve orifices or burner ports when cleaning the valves or burners.
mThe Weber®gas barbecue should be thoroughly cleaned on a regular basis.
mLiquid propane gas is not natural gas.The conversion or attempted use of natural gas in a liquid propane unit or liquid propane
gas in a natural gas unit is dangerous and will void your warranty.
mDo not attempt to disconnect any gas fitting while your barbecue is in operation.
mUse heat-resistant barbecue mitts or gloves when operating barbecue.
mKeep any electrical supply cord and the fuel supply hose away from any heated surfaces.
mCombustion byproducts produced when using this product contain chemicals known to the state of California to cause cancer,
birth defects, or other reproductive harm.
mDo not use this barbecue unless all parts are in place. The unit must be properly assembled according to the assembly
instructions.
mDo not build this model of grill in any built-in or slide in construction. Ignoring this Warning could cause a fire or an explosion
that can damage property and cause serious bodily injury or death.
mProposition 65 Warning: Handling the brass material on this product exposes you to lead, a chemical known to the state of
California to cause cancer, birth defects or other reproductive harm.
(Wash hands after handling this product.)
LIQUID PROPANE GAS UNITS ONLY:
mUse the pressure regulator and hose assembly that is supplied with your Weber®gas barbecue.
mDo not attempt to disconnect the gas regulator and hose assembly or any gas fitting while your barbecue is in operation.
mA dented or rusty liquid propane cylinder may be hazardous and should be checked by your liquid propane supplier. Do not
use a liquid propane cylinder with a damaged valve.
mAlthough your liquid propane cylinder may appear to be empty, gas may still be present, and the cylinder should be transported
and stored accordingly.
mIf you see, smell or hear the hiss of escaping gas from the liquid propane cylinder:
1. Move away from liquid propane cylinder.
2. Do not attempt to correct the problem yourself.
3. Call your fire department.

WWW.WEbER.com®3
TAbLE oF coNTENTS
WARNINGS ..........................................2
TAbLE oF coNTENTS .................................3
EXPLoDED VIEW .....................................4
EXPLoDED VIEW LIST ................................5
WARRANTY .........................................6
GENERAL INSTRUcTIoNS ............................7
CANADIAN INSTALLATION ..........................................7
STORAGE .......................................................7
OPERATING. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
GAS SUPPLY TESTING.............................................7
GAS INSTRUcTIoNS ..................................8
INSTALLGASSUPPLY .............................................8
TYPE OF GAS ....................................................9
WHAT IS NATURAL GAS?...........................................9
PORTABLE INSTALLATION..........................................9
LEAK CHECK PREPARATION....................................... 10
CHECK THE FLEXIBLE HOSE TO MANIFOLD CONNECTION . . . . . . . . . . . . 11
CHECK FOR GAS LEAKS.......................................... 11
LIGHT FEATURES ...................................13
WEBER®GRILLOUT™HANDLELIGHT..............................13
LIGHTEDCONTROLKNOBS.......................................13
bEFoRE USING YoUR GRILL ..........................13
SLIDE OUT GREASE TRAY AND DISPOSABLE DRIP PAN................13
SNAP IGNITIoN oPERATIoN ..........................14
mAIN bURNER IGNITIoN & USAGE .....................15
MAIN BURNER IGNITION .......................................... 15
TO EXTINGUISH .................................................15
MAINBURNERMANUALIGNITION .................................16
TO EXTINGUISH .................................................16
GRILLING TIPS & HELPFUL HINTS .....................17
cooKING mETHoDS .................................18
DIRECT COOKING ...............................................18
INDIRECT COOKING .............................................18
SIDE bURNER IGNITIoN & USAGE .....................19
SIDEBURNERIGNITION..........................................19
SIDEBURNERMANUALIGNITION..................................20
SEAR STATIoN® IGNITIoN & USAGE ....................21
SEAR STATION®BURNER IGNITION .................................21
TO EXTINGUISH .................................................21
SEAR STATION®BURNER MANUAL IGNITION . . . . . . . . . . . . . . . . . . . . . . . . 22
TO EXTINGUISH .................................................22
USING THE SEAR STATION®.......................................22
SmoKER bURNER IGNITIoN & USAGE ..................23
SMOKER BURNER IGNITION.......................................23
TO EXTINGUISH .................................................23
SMOKER BURNER MANUAL IGNITION...............................24
TO EXTINGUISH .................................................24
USING THE SMOKER .............................................25
CLEANINGTHESMOKER .........................................25
RoTISSERIE bURNER IGNITIoN & USAGE . . . . . . . . . . . . . .26
ROTISSERIE BURNER IGNITION....................................26
TO EXTINGUISH .................................................26
ROTISSERIE BURNER MANUAL IGNITION............................27
TO EXTINGUISH .................................................27
BEFORE USING YOUR ROTISSERIE.................................28
OPERATINGTHEROTISSERIE .....................................28
ROTISSERIECOOKING...........................................29
ROTISSERIE MOTOR STORAGE ....................................29
ROTISSERIE SPIT STORAGE. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 29
TRoUbLESHooTING .................................30
SIDE bURNER TRoUbLESHooTING . . . . . . . . . . . . . . . . . . . .30
SEAR STATIoN® TRoUbLESHooTING ...................31
RoTISSERIE TRoUbLESHooTING ......................31
GRILL oUT™ HANDLE LIGHT TRoUbLESHooTING . . . . . . .31
mAINTENANcE .....................................32
CLEANING......................................................32
WEBER®SPIDER/INSECTSCREENS................................32
MAIN BURNER CLEANING.........................................32
REPLACINGMAINBURNERS ......................................33
SIDE BURNER MAINTENANCE .....................................34
ANNUALMAINTENANCE..........................................35

4
8
9
11
12
13
16
25
27
28
29
30
31
32
33
41
42
43
44
46
54
55
56
26
7
14
48
57
47
45
34
35
36
37
38
39
40
17
18
19
20
21
22
24
49
50
52
53
51
59
60
10
2
3
4
5
6
1SUMMIT 470_NG_US_010810
23
15
58
EXPLoDED VIEW

WWW.WEbER.com®5
Shroud Hardware1.
Shroud2.
Thermometer3.
Thermometer Bezel4.
Handle5.
Grill Out™ Handle Light6.
Rotisserie Motor7.
Rotisserie Bracket8.
Warming Rack9.
Cooking Grates10.
Flavorizor11. ®Bars
Burner Tubes12.
Side Table13.
Left Tool Holder14.
Control Panel Wiring Harness15.
Manifold16.
Control Panel1 7.
Small Knob Bezel18.
Small Knob19.
Large Knob20.
Large Knob Bezel21.
Sear Station22. ®Knob
Battery Housing23.
Water Baffle / Heat Shield24.
Disposable Drip Pan25.
Slide Out Grease Tray26.
Catch Pan27.
Catch Pan Holder28.
Left Door29.
Door Handles30.
Right Door31.
Left Frame Panel32.
Bottom Panel33.
IR Burner Cover34.
Infrared Burner35.
IR Burner Box36.
IR Burner Igniter Wire37.
Thermocouple38.
IR Burner Hose39.
Rotisserie Spit Assembly40.
Smoker Box41.
Smoker Bar42.
Smoker Burner43.
Sear Station44. ®Burner
Side Burner45.
Cookbox46.
Bulkhead47.
Manifold Hose48.
Side Burner Lid49.
Side Burner Table50.
Side Burner Hose51.
Right Tool Holder52.
Frame Support53.
Back Panel54.
Right Frame Panel55.
Natural Gas Hose56.
Matchstick Holder57.
Front Frame Support58.
Caster59.
Locking Caster60.
EXPLoDED VIEW LIST

6
Weber-Stephen Products Co. (Weber) hereby warrants to the ORIGINAL PURCHASER of this Weber®
gas grill that it will be free of defects in material and workmanship from the date of purchase as follows:
Aluminum castings, 25-years (2 years on paint; excludes fading)
Stainless steel shroud, 25-years
Porcelain-enameled shroud, 25-years
Stainless steel burners tubes, 10-years
Stainless steel cooking grates, 5-years no rust through or burn through
Stainless steel Flavorizer®bars, 5-years no rust through or burn through
Porcelain-enameled cast-iron cooking grates, 5-year no rust through or burn through
Porcelain-enameled cooking grates, 3-years no rust through or burn through
Porcelain-enameled Flavorizer®bars, 2-years no rust through or burn through
Infrared rotisserie burner, 2-years
All remaining parts, 2-years
when assembled and operated in accordance with the printed instructions accompanying it. Weber
may require reasonable proof of your date of purchase. THEREFORE, YOU SHOULD RETAIN YOUR
SALES SLIP OR INVOICE.
This Limited Warranty shall be limited to the repair or replacement of parts that prove defective under
normal use and service and which on examination shall indicate, to Weber’s satisfaction, they are
defective. Before returning any parts, contact the Customer Service Representative in your area
using the contact information on our website. If Weber confirms the defect and approves the claim,
Weber will elect to replace such parts without charge. If you are required to return defective parts,
transportation charges must be prepaid. Weber will return parts to the purchaser, freight or postage
prepaid.
This Limited Warranty does not cover any failures or operating difficulties due to accident, abuse,
misuse, alteration, misapplication, vandalism, improper installation or improper maintenance or
service, or failure to perform normal and routine maintenance, including but not limited to damage
caused by insects within the burner tubes, as set out in this owner’s manual.
Deterioration or damage due to severe weather conditions such as hail, hurricanes, earthquakes
or tornadoes, discoloration due to exposure to chemicals either directly or in the atmosphere, is not
covered by this Limited Warranty.
There are no other express warrants except as set forth herein and any applicable implied warranties
of merchantability and fitness are limited in duration to the period of coverage of this express written
Limited Warranty. Some regions do not allow limitation on how long an implied warranty lasts, so this
limitation may not apply to you.
Weber is not liable for any special, indirect or consequential damages. Some regions do not allow the
exclusion or limitation of incidental or consequential damages, so this limitation or exclusion may not
apply to you.
Weber does not authorize any person or company to assume for it any other obligation or liability in
connection with the sale, installation, use, removal, return, or replacement of its equipment; and no
such representations are binding on Weber.
This Warranty applies only to products sold at retail.
WEBER-STEPHEN PRODUCTS CO.
Customer Service Center
1890 Roselle Road, Suite 308
Schaumburg, IL 60195
USA
For replacement parts call:
1-800-446-1071
Visit www.weber.com®, select your country of origin, and register your grill today.
WARRANTY

WWW.WEbER.com®7
Your Weber®gas barbecue is a portable outdoor cooking appliance. With the Weber®
gas barbecue you can grill, barbecue, roast and bake with results that are difficult to
duplicate with indoor kitchen appliances.The closed lid and Flavorizer®bars produce
that “outdoor” flavor in the food.
The Weber®gas barbecue is portable so you can easily change its location in your yard
or on your patio. Portability means you can take your Weber®gas barbecue with you if
you move.
The natural gas supply is easy to use and gives you more cooking control than charcoal
fuel.
• Theseinstructionswillgiveyoutheminimumrequirementsforassemblingyour
Weber®gas barbecue. Please read the instructions carefully before using your
Weber®gas barbecue. Improper assembly can be dangerous.
• Notforusebychildren.
• Iftherearelocalcodesthatapplytoportablegasgrills,youwillhavetoconformto
them. Installation must conform with local codes or, in the absence of local codes,
with either the National Fuel Gas Code, ANSI Z223.1/NFPA 54, Natural Gas and
Propane Installation Code, CSA B149.1, or Propane Storage and Handling Code,
B149.2, or the Standard for Recreational Vehicles, ANSI A 119.2/NFPA 1192, and
CSA Z240 RV Series, Recreational Vehicle Code, as applicable.
• ThisWeber®gas barbecue is designed for natural (piped in city) gas only. Do not use
liquid propane (LP) bottled gas. The valves, orifices and hose are for natural gas only.
• Donotusewithcharcoalfuel.
• Checkthattheareaunderthecontrolpanelandthebottomtrayarefreefromdebris
that might obstruct the flow of combustion or ventilation air. ◆
CANADIAN INSTALLATION
These instructions, while generally acceptable, do not necessarily comply with the
Canadian Installation codes, particularly with piping above and below ground. In Canada
the installation of this appliance must comply with local codes and/or Standards CAN/
CGA-B149.1 (Installation Code for Natural Gas Burning Appliances and Equipment). ◆
STORAGE
• ThegasmustbeturnedoffatthenaturalgassupplywhentheWeber®gas barbecue
is not in use.
• WhentheWeber®gas barbecue is stored indoors, the gas supply must be
disconnected.
• TheWeber®gas barbecue should be checked for gas leaks and any obstructions
in the burner tubes before using. (See Section: “MAINTENANCE/ANNUAL
MAINTENANCE”).
• Checkthattheareasunderthecontrolpanelandtheslideoutbottomtrayarefree
from debris that might obstruct the flow of combustion or ventilation air.
• TheSpider/InsectScreensshouldalsobecheckedforanyobstructions.(See
Section: “MAINTENANCE/ANNUAL MAINTENANCE”). ◆
OPERATING
mWARNING: Only use this barbecue outdoors in a well-
ventilated area. Do not use in a garage, building, breezeway
or any other enclosed area.
mWARNING:Your Weber®gas barbecue shall not be used
under overhead combustible construction.
mWARNING:Your Weber®gas barbecue is not intended to be
installed in or on recreational vehicles and/or boats.
mWARNING: Do not use the barbecue within 24 inches of
combustible materials.This includes the top, bottom, back or
sides of the grill.
mWARNING:The entire cooking box gets hot when in use. Do
not leave unattended.
mWARNING: Keep any electrical supply cord and the fuel
supply hose away from any heated surface.
mWARNING: Keep the cooking area clear of flammable vapors
and liquids, such as gasoline, alcohol, etc., and combustible
materials. ◆
GAS SUPPLY TESTING
• DisconnectyourWeber®gas barbecue when the gas supply is being tested at high
pressures. This appliance and its individual shutoff valve must be disconnected
from the gas supply piping system during any pressure testing of that system at test
pressures in excess of 1/2 psig (3.5 kPa).
• TurnoffyourWeber®gas barbecue when the gas supply is being tested at low
pressures. This appliance must be isolated from the gas supply piping system by
closing its individual manual shutoff valve during any pressure testing of the gas
supply piping system at the pressure equal to or less than 1/2 psig (3.5 kPa). ◆
GENERAL INSTRUcTIoNS

8
INSTALL GAS SUPPLY
General Specifications for Piping
Note: Contact your local municipality for building codes regulating outdoor
gas barbecue installations. In absence of Local Codes, you must conform to
the latest edition of the National Fuel Gas Code: ANSI Z 223.1/NFPA 54, or CAN/
CGA-B149.1, Natural Gas and Propane Installation Code. WE RECOMMEND THAT THIS
INSTALLATION BE DONE BY A PROFESSIONAL.
Some of the following are general requirements taken from the latest edition of the
National Fuel Gas Code: ANSI Z 223.1/NFPA 54, or CAN/CGA-B149.1, Natural Gas and
Propane Installation Code for complete specifications.
• Thisbarbecueisdesignedtooperateat4.5inchesofwatercolumnpressure(.163psi).
• Amanualshut-offvalvemustbeinstalledoutdoors,immediatelyaheadofthequick
disconnect.
• Anadditionalmanualshut-offvalveindoorsshouldbeinstalledinthebranchfuelline
in an accessible location near the supply line.
• Thequickdisconnectconnectstoa1/2inchNPTthreadfromthegassource.The
quick disconnect fitting is a hand-operated device that automatically shuts off the flow
of gas from the source when the barbecue is disconnected.
• Thequickdisconnectfittingcanbeinstalledhorizontally,orpointingdownward.
Installing the fitting with the open end pointing upward can result in collecting water
and debris.
• Thedustcovers(suppliedplasticplugs)helpkeeptheopenendsofthequick
disconnect fitting clean while disconnected.
• Pipecompoundshouldbeusedwhichisresistanttotheactionofnaturalgaswhen
connections are made.
• Theoutdoorconnectormustbefirmlyattachedtorigid,permanentconstruction.
mWARNING: Do not route the 10 foot hose under a deck.The
hose must be visible.
Gas Line Piping
• Ifthelengthofthelinerequireddoesnotexceed50feet,usea5/8"O.D.tube.One
size larger should be used for lengths greater than 50 feet.
• Gaspipingmaybecoppertubing,typeKorL;polyethyleneplastictube,witha
minimum wall thickness of .062 inch; or standard weight (schedule 40) steel or
wrought iron pipe.
• Coppertubingmustbetin-linedifthegascontainsmorethan0.3gramsofhydrogen
sulfide per 100 cubic feet of gas.
• Plastictubingissuitableonlyforoutdoor,undergrounduse.
• Gaspipingincontactwithearth,oranyothermaterialwhichmaycorrodethepiping,
must be protected against corrosion in an approved manner.
• Undergroundpipingmusthaveaminimumof18"cover.
Test Connections
All connections and joints must be thoroughly tested for leaks in accordance with local
codes and all listed procedures in the latest edition of the National Fuel Gas Code: ANSI
Z 223.1/NFPA 54, or CAN/CGA-B149.1
mDANGER
Do not use an open flame to check for gas leaks. Be sure
there are no sparks or open flames in the area while you
check for gas leaks.This will result in a fire or explosion
which can cause serious bodily injury or death and damage
to property. ◆
GAS INSTRUcTIoNS
This is a typical installation of a Weber®natural gas barbecue.
Local codes may require different installations.
INSIDE WALL
1Gas Supply 2Shut off
oUTSIDE WALL
3Quick-Disconnect 4½"PipeNipple
5Locking Shut Off 6Do Not Use

WWW.WEbER.com®9
TYPE OF GAS
Your natural gas grill is factory built to operate using natural gas only. Never attempt to
operate your grill on gases other than the type specified on the grill rating plates.
Yourgrilloperatesat4.5"ofwatercolumnpressure.Ifreplacementofthehosebecomes
necessary, factory specified parts are required. See your local dealer.
For safety and design reasons, the conversion of a Weber®grill from operation using
Natural gas to operation using LP gas requires the change out of the entire gas
supply system of the grill. If this becomes necessary, see your dealer for additional
information. ◆
WHAT IS NATURAL GAS?
Natural gas, often called methane, is a safe modern fuel. Natural gas is supplied by your
local utility and should be readily available if your house is already heated with gas. ◆
PORTABLE INSTALLATION
Weber®recommends moving the grill at least two feet from the gas supply and any
combustible surfaces. After the gas supply has been run and checked for leaks in
accordance to the assembly instructions, you are ready to grill. To connect the hose
to the gas supply, pull back the outer fitting, insert the hose fitting all of the way, and
release the outer fitting. This process will produce a gas joint. ◆
1Swivel Connection
2Install covers when hose is disconnected
3Shut Off Valve
4Coat this pipe nipple with gas resistant pipe dope
5Socket
6Male Connection
1Socket
2Sleeve
3Push Sleeve Back
4Plug
Push plug until sleeve snaps forward locking plug in socket.
(This turns on gas automatically.)
When properly assembled the plug cannot
be removed without pushing the sleeve back.
To disconnect, push sleeve back and pull out plug.
(This automatically shuts off gas.)
GAS INSTRUcTIoNS

10
GAS INSTRUcTIoNS
mWARNING:The gas connections of your Summit®gas grill
have been factory tested.We do however recommend that
you leak check all gas connections before operating your
Summit®gas grill.
Remove Control Panel
Parts required: Phillips screwdriver and a towel.
A) Remove the burner control knobs (1).
B) Open both doors and place a towel on top of the doors. This will protect the control
panel and tops of the doors from getting scratched on the next step.
C) Remove the screws from the underside of the control panel with a Phillips
screwdriver (2).
D) Tilt the conrol panel forward and lift up and away from the grill (3) (For Summit®
models with LED features: Be careful not to break or disconnect the wires for the
control panel LED’s).
E) Place the control panel on the towel covering the door assemblies (4). ◆
LEAK CHECK PREPARATION
Check That All Burner Valves Are Off
Valves are shipped in the OFF position, but you should check to be sure that they are
turned off. Check by pushing in and turning clockwise. If they do not turn, they are off. If
they do turn continue turning them clockwise until they stop, then they are off.
23
4
1
The grill illustrated
may have slight
differences than the
model purchased.