Whirlpool AVM 350 WH User manual

SERVICE Whirlpool Europe
Customer Services
Model AVM 350 WH
Version 8538 350 53291 Page
Introduction safety 2
Technical data 3
Spare part list 4
Exploded view 5
Wiring diagram 6
Program diagram 7 - 8
Service Manual
Microwave oven
AVM 350 WH
AVM 350 WH
This documentation is only intended for qualified technicians who are aware of the respec-
tive safety regulations.
Date: 27.01.1997 Subject to modification
Document-No.: 4812 714 11361

SERVICE
27.01.1997 / Page 2 Whirlpool Europe
Doc. No: 4812 714 11361 Customer Service
Introduction safety
NTRODUCTION
Before leaving the factory each oven is carefully checked.
It must, however, be installed and used correctly.
Despite all the steps taken to make the oven safe, the safety is dependent on the correct installation and the fact
the user understands how to use and maintain the oven.
The information in this section should be used as a reminder that the oven is safe and that anyone who uses it must
first read the instructions for use in order to be able to use the oven correctly and obtain best results.
SAFETY
To avoid injury to yourself and damage to the appliance always work to the following rules when servicing an oven.
Always disconnect the plug from the mains before starting work.
If there is no plug switch off the electric supply at the control box.
When you have finished servicing an oven before you reconnect it to the mains, make sure that:
- all the internal connections are correct
- the wires are insulated and not touching the door or the cabinet or anything sharp
- all the earth connections are electrically and mechanically sound
- do not modify or anyway interfere with the safety devices built-in to the oven
- make sure that each replacement part you use conforms to the manufacturer´s specifications
Do not start a repair if you have any doubt as to your ability to complete it.
CAUTION - MICROWAVE RADIATION
PERSONNEL SHOULD NOT BE EXPOSED TO THE MICROWAVE ENERGY WHICH MAY RADIATE FROM THE MAGNETRON,
WAVEGUIDE OR ANTENNA IF THEY ARE IMPROPERLY USED OR CONNECTED. ALL INPUT
AND OUTPUT MICROWAVE CONNECTIONS, WAVEGUIDES, FLANGES AND GASKETS MUST BE SECURE.
NEVER OPERATE THE DEVICE WITHOUT A MICROWAVE ENERGY ABSORBING LOAD ATTACHED.
NEVER LOOK INTO AN OPEN WAVEGUIDE OR ANTENNA WHILE THE DEVICE IS ENERGIZED.
NEVER OPERATE AN OVEN WITH CABINET OFF WITHOUT MEASURING THE MICROWAVE LEAKAGE
AROUND MAGNETRON AND VISIBLE MICROWAVE CONNECTIONS (WELDING JOINTS).
Do not operate the oven if the following conditions exist:
- the door does not close firmly against the door support because of the door being warped or the hinges damaged.
- The door trims or seals are damaged.
- If there is any visible damage to the oven.
- if the door does not close properly.
Avoid operating the oven if known components in the interlock system, oven door or microwave
generating assembly are known defective. They must be replaced.
WARNING - HIGH VOLTAGE
IT IS POSSIBLE TO COME IN CONTACT WITH LETHAL HIGH VOLTAGE WHEN WORKING WITH
HV TRANSFORMER, HV CAPACITOR AND MAGNETRON. THEREFORE NEVER TRY TO MEASURE
THE HIGH VOLTAGE. ALWAYS TAKE UTMOST CARE WHEN PERFORMING ELECTRIC
MEASUREMENTS INSIDE THE OVEN.

SERVICE Whirlpool Europe 27.01.1997 / Page 3
Customer Service Doc. No: 4812 714 11361
Technical data
Dimensions of cabinet
Height 332 mm
Width 548 mm
Depth 398 mm
Dimensions of cavity
Height 225 mm
Width 346 mm
Depth 341 mm
Volume 26,55 l
Turntable diameter 320 mm
Weight
Net 22 Kg
Packed 24 Kg
Electrical
Voltage 230-240 V
Frequency 50 Hz
Microwave
frequency 2450 MHz
Power
Current
consumption 11,5 A
Output power
Microwave 1000 W
Power
consumption 2550 W
Quarzgrill 1000 W
Timer
90 min

SERVICE
27.01.1997 / Page 4 Whirlpool Europe
Doc. No: 4812 714 11361 Customer Service
Spare part list
Model AVM 350 WH
Service No. 853835053291
Version 853835053291
Pos. No. 12NC Code Description from to
000 1 4819 464 18111 Air guide not shown
002 0 4819 440 59112 Cabinet WH
002 2 4819 442 38056 Cover plate upper
002 2 4819 442 38057 Cover plate lower
003 0 4819 404 78252 Support
013 0 4819 462 79423 Foot
100 0 4819 442 38059 Door cpl. WH
120 0 4819 459 48676 Door frame inner
120 1 4819 466 89181 Door,inner
120 2 4819 404 78429 Lock plate
130 0 4819 276 38331 Unit,pushbutton
130 1 4819 466 88919 Bracket
141 0 4819 450 69828 Oven glass WH
143 0 4819 459 48674 Door frame outer WH
143 1 4819 535 98394 Pin
244 0 4819 466 98789 Stand plastic
245 0 4819 458 19802 Stand metal high
246 0 4819 466 88922 Crisp plate
255 0 4819 466 78186 Turntable sheet-rotary plate
264 0 4819 535 78142 Crosspiece
301 0 4819 276 38327 Unit,pushbutton WH
301 2 4819 462 38751 Frame for switch,
301 3 4819 466 98914 Spacer
305 0 4819 404 78851 Holder
320 0 4819 453 49836 Panel,control WH
334 0 4819 412 58404 Knob WH
334 1 4819 413 38126 Clip Knob inner
352 0 4819 130 38072 Display
352 1 4819 450 69808 Pane for Display
355 0 4819 280 18019 Buzzer
404 0 4819 131 58019 Magnetron
404 1 4819 404 78765 Bracket
404 2 4819 462 38754 Air guide
404 3 4819 462 38616 Air guide
406 0 4819 361 18292 Motor for rotary plate
406 1 4819 466 88918 Cover for motor
406 2 4819 532 68686 Gasket ring
411 0 4819 148 68076 Transformer
412 0 4819 145 78169 Transformer,HT
412 1 4819 462 38755 Air guide
420 0 4819 121 48021 Capacitor,HT
420 1 4819 401 18678 Bracket for capacitor
421 0 4819 121 18162 Filter,mains
426 0 4819 218 38039 Diode HV
442 0 4819 361 18291 Motor blower
442 1 4819 404 78251 Bracket
443 0 4819 310 39002 Fan Set
443 1 4819 462 38614 Air guide
452 0 4819 259 98386 Tube,heating IR
452 1 4819 404 78858 Holder
452 2 4819 380 28015 Reflector quarts tube
452 3 4819 404 78857 Holder reflector
485 0 4819 320 28024 Cable,HT
485 1 4819 462 38756 Air guide
490 0 4819 321 18242 Cable,mains
502 0 4819 214 78461 Control unit
502 1 4819 209 88041 Microprocessor
502 3 4819 101 48142 Potentiometer
502 5 4819 325 18048 Insulation
521 1 4819 113 88001 Resistor 100 Ohm
561 0 4819 282 48281 Thermostat for magnetron 125 C
564 0 4819 282 48249 Thermostat 165 C
566 0 4819 282 48217 Thermostat grill 120 C
617 0 4819 280 68323 Relay 24V
622 0 4819 276 18273 Switch
633 0 4819 271 38156 Microswitch 10 A
651 0 4819 134 28029 Lamp cavity 240V - 25W
901 0 4819 401 18512 Strain relief
902 0 4819 466 88921 Bracket
971 0 4819 253 38019 Fuse T8 A
972 0 4819 253 38006 Fuse T100mA

~~ = :1 ~,~ ~~ ~ Whirlpool Europe 2101.1997/ Page 5
Customer Service Doc. No: 4812 714 11361
Exploded view
2450 002.
2440
2460
2
2
1 4210
4900
1 4431
4430
'r-=- 4420
1 .a~4421
0
1
0
5 0
0
3
3 0
3
0
1
0
4121
3
301
3520
5021
3550
6220 5023 14812 714 680041

SERVICE
27.01.1997 / Page 6 Whirlpool Europe
Doc. No: 4812 714 11361 Customer Service
Wiring diagram

SERVICE Whirlpool Europe 27.01.1997 / Page 7
Customer Service Doc. No: 4812 714 11361
Program diagram

SERVICE
27.01.1997 / Page 8 Whirlpool Europe
Doc. No: 4812 714 11361 Customer Service
Program diagram