Action S002004 User manual

7 Station Swing Set
S002004
Instruction Manual
WARNING: To ensure your safety, please do not attempt to assemble this swing set without reading this
instruction manual carefully. Failure to comply with this warning may result in injury and/or property damage.
• Prior to assembly, this swing set includes small parts/accessories that are not suitable for children under 3 years
of age as they may cause a choking hazard.
• This swing set should be assembled by 2 adults.
• Onlyusethisswingsetonasoft,atlevelsurface.
• This swing set has a maximum user weight of 34kg per unit/seat. Only one child per seat at any time.
• The total weight on the swing set at any time must not exceed 204kg.
• This swing set is suitable for users aged 3-9 years.
• This swing set is designed for outdoor domestic use only, it is not intended for commercial use in play centres,
nurseries etc.
Forpartsandserviceenquiries,pleasecontactActionSpareson1800465070ore-mail[e-mail]

2
S002004 7 Station Swing Set
Contents
3Important Safety Information
5Swing Parts List
6Slide Parts List
7Assembly Instructions
17 Warranty

3
S002004 7 Station Swing Set
ImportantSafetyInformation
To reduce the risk of serious injury, read the entire manual before you assemble or use
this swing set. In particular, please note the following safety precautions. Please keep
this manual in a safe place for future reference. Failure to assemble and maintain this
product correctly may cause injury to the user.
1. Regularly check the swing set for wear and damage, replace any worn or damaged
partsimmediately.Removetheswingsetfromuseuntilreplacementpartsaretted.
Checkallhardwareregularlyandtightenwhenrequired.
2. Checkswingseats,ropesandanyothermeansofattachmentforevidenceof
deterioration prior to each use.
3. Prior to assembly, this swing set includes small parts/accessories that are not
suitable for children under 3 years of age as they may cause a choking hazard.
4. Donotovertightenthenutsandbolts.Usehandtoolsonly,donotusepowertools
as this can weaken the connection points.
5. This swing set should be assembled by 2 adults.
6. This swing set is designed for use by children 3-9 years of age.
7. This swing set is designed for domestic use only, it is not intended for commercial
use in play centres, nurseries, etc.
8. This swing set has a maximum user weightof 34kg per unit, totalling 204kg across
the entirety of the swing set.
9. Donotinstallthisproductoverconcrete,asphaltoranyotherhardsurface.
10.Do not orientate the swing set directly towards the sun.
11.There should be at least 2m of space surrounding the swing set from any structure
ofobstructionsuchasafence,garage,house,wall,overhangingbranches,laundry
lines, electrical wires, etc.
12.Swingsmustnotexceedandangleof60degreesfromtheground.

4
S002004 7 Station Swing Set
Warnings (cont)
13.The knots in the swings are integral to the safety of the swing set. Please ensure
they are tight and that the swing is in the correct position, there should be no slack
in the rope allowing a loop to form below the swing.
14.Theminimumdistancebetweenanyswingandthegroundis350mm.
15.Thisswingsetmustbeanchoredrmlyintothegroundusingtheincludedanchor
pegs.
16.Do not allow additional foreign objects to be attached or used with the swing set.
17.Childrenmustbesupervisedbyanadultatalltimeswhentheswingsetisinuse.
18.Only1childshoulduseeachswing(unlessspecicallydesignedfor2children)or
slide at any time.
19.Do not use the swing set when it is wet as it will become slippery and serious injury
may result.
20. Do not stand on the seats when using the swing set.
21.Do not climb on or jump from the swing set when it is in motion.
22. Do not climb or hang on the frame of the swing set.
23. Donotwalkcloseto,infrontoforbehindtheswingsetwheninuseasmoving
units can cause serious injury.
24. Donotwearapparelsuchashatswithstraps,helmets,scarves,garmentswithpull
strings or any other item of loose clothing while using the swing set as children can
gettrappedandmaybeunabletofreethemselvescausingseriousinjury.
25.Donottwistswingropesorwrapthemoverthetopbar.
26.Donotslideheadrstdowntheslide,walkuptheslideorjump/climbofftheslide.

5
S002004 7 Station Swing Set
SwingPartsList
Top Leg (x2)
Glider Leg (x2) Glider Handle Tubes (x2)
Clamps (x2)
Plain Bottom Leg B (x1)
37
Top Leg (x2)
Soccer Goal Net (x1)
Netball Ring (x1)
Nest Swing Fabric (x1)
Fabric (x1)
Nest Swing Rope (x2)
Nest Swing Metal Frame
With Foam Padding (x4)
(x1)
40
41
43
Thin Plastic Spacer (x4)
(x14)
Thick Plastic Spacer (x4)
Soccer Goal Bottom Tube B (x1)
Soccer Goal Bottom Tube A (x1)
45
G7
52
53
Long Bracket (x2)
Short Bracket (x4)
Connection Tube (x2)
(x1)
(x2)
42
Plain Bottom Leg C (x2)

6
S002004 7 Station Swing Set
Top Ladder Rung (x1)
2nd Ladder Rung (x1) 3rd Ladder Rung (x1)
Bottom Ladder Rung (x1)
Ladder Handle (x1)
Chute Side Stay Bar (x1)
Ladder Leg (x1)
Ladder Handle (x2)
M6 Bolt 40mm (x2)
Upper Support Tube (x2)
Ladder Handle (x1)
Lower Support Tube (x2)
Upper Slide (x1)
Lower Slide (x1)
48
SlidePartsList

7
S002004 7 Station Swing Set
AssemblyInstructions
Step 1
Frame, Swing, Trapeze & Netball Ring Assembly
39
39
G7 G7
Note: Attach the swing rope to the U-bolt (S1) before connecting the U-bolt (S1)
to the top bar. Ensure that at least 3 threas from M8 U-bolt (S1) protude from the
top.

8
S002004 7 Station Swing Set
AssemblyInstructions(cont)
53
43
42
42
42
6
Position1 Position 2
Warning: The knots on the swings are integral to the safety of the swing Please
ensure thet are tight and that the swing is in POSITION 1 as shown in the diagram
above. There should be no slack in the rope allowing a loop to form below the
swing.
Correct Assembly Incorrect Assembly

9
S002004 7 Station Swing Set
AssemblyInstructions(cont)
Nest Swing Assembly
InserttheMetalTube(11)intothefabricoftheNestSwing(41).Jointhemetaltubestogetherand
thenfastenthembyusingtheboltattheendoftheRope(43).(Seeabove).
Repeatthisfortheotherside,andthentheNestSwingbecomestwosemicircles(Seebelow).
Laythetwosemicirclesontheground,
join the two part tubes together, and
then press it down so that two parts are
joined together as a circle.
Press Press
PressPress
Semicircle
Semicircle
Finished
43
41
41
41
43
43

10
S002004 7 Station Swing Set
AssemblyInstructions(cont)
Step 2
Soccer Goal Net Assembly
Threadthesoccergoalnet(17)throughthemetaltubes(42,6,37and38)andconnectmetaltube(42)
and(6)byusingthebolt(F2)andthebolt(G3)forthemetaltube(42)and(37)with(42)and(38).
Connectthemetaltube(37)&(38)asabove.

11
S002004 7 Station Swing Set
AssemblyInstructions(cont)
Step 3
Glider Assembly
Assembleseats(12)andattachtoseattubes(10)beforetighteningbolts(G4).

12
S002004 7 Station Swing Set
AssemblyInstructions(cont)
Step 4
Slide Assembly
Bracket Assembly
One connector (34)
for both sides
One connector (34)
for both sides
Top of slide
TheM6Bolt35mm(F3)forsupportstrap(29and31)onlyneedtobengertight.

13
S002004 7 Station Swing Set
AssemblyInstructions(cont)
Assembly of the Bracket onto the Slide

14
S002004 7 Station Swing Set
AssemblyInstructions(cont)
Step 5
Slide Assembly continued
Note: Top Ladder Rung (19) is to be tted behind Ladder Handle (26 and 28) and
Plain Bototm Leg B (18).

15
S002004 7 Station Swing Set
AssemblyInstructions(cont)
Pleasedonotovertightennutsandbolts.Usehandtoolsonly.Donotusepowertools.Thiscan
weaken the connection points.
PleaseensurethatTopLadderRung(19)isttedbehindbothLadderHandles(26and28)andonthe
rearoftheBottomLeg(18).
Please see the below image for correct assembly.
PleasenotethattheTopLadderRung(19)isbehindthe
LadderHandles(26and28)supportingtheslide.
PleasenotethattheTopLadderRung(19)isinfrontof
theLadderHandles(26and28)andnotsupportingthe
slide.
PleaseassembleChuteSideStayBar(20)last.Leavetheboltslooseuntiltheslideisassembledtothe
ladderframe,tomakeconstructioneasier.Thentightenrmly.
Correct Assembly
Incorrect Assembly

16
S002004 7 Station Swing Set
AssemblyInstructions(cont)
Step 6
Anchoring the Swing Set to the ground
Important: For safety reasons this swing set MUST be anchored into the ground.
To carry out this procedure, you must hammer the included pegs into the ground
on the angle shown below. The peg must pull into hard earth and hold rmly.
Attach the swing to the pegs at the connection points shown below. We highly
recommend these anchor pegs be concreted, but this is optional. However if
the ground is soft and the peg can easily be pulled out by hand once installed,
concreting is essential. Contact our service centre for more information.
Onceassemblyiscompleted,carefullycheckequipment.Intheunlikelyeventthatyoudondany
problems,pleasecontactus.DONOTallowchildrentousethisproductuntiltheproblemhasbeen
corrected.
48
48

17
S002004 7 Station Swing Set
Warranty Information
Congratulations on your purchase!
This Action 7 Station Swing Set is warranted to be free from defects in material and workmanship
undernormaluseandserviceconditionsforaperiodof12 months from the date of purchase of this
article.Evidenceofunfairusageorincorrectadjustmentbytheownerwillvoidthispromise.
OurgoodscomewithguaranteesthatcannotbeexcludedundertheAustralianConsumerLaw.Youare
entitled to a replacement or refund for a major failure and for compensation for any other reasonably
foreseeablelossordamage.Youarealsoentitledtohavethegoodsrepairedorreplacedifthegoods
failtobeofacceptablequalityandthefailuredoesnotamounttoamajorfailure.
Thebenetsconferredbythiswarrantyareinadditiontotheconsumerguaranteesandotherrights
andremediesinrespectoftheproductwhichtheconsumerhasundertheAustralianConsumerlaw.
Conditions of Warranty
Allwarrantycoverageextendsonlytotheoriginalretailpurchaserfromthedateofpurchase.Please
keepyourreceipt,taxinvoiceorotherproofofpurchase.
This warranty does not extend to any damage to a product caused by abuse, improper or abnormal
usage,orrepairsnotprovidedbyusorourServiceCentre.Nordoesthiswarrantyextendtoproducts
usedforcommercialorrentalpurposes.Thiswarrantydoesnotcoverordinarywear,tearand
weathering,failuretofollowdirections,improperinstallation,impropermaintenanceoractsofGod
(suchasdamagecausedbystorms,lightning,heavywindsandbysnoworice).
Making A Warranty Claim
InordertomakeaclaimunderthiswarrantypleasedirectyourenquiriestoourServiceCentre.Youcan
contact them on our Freecall 1800 465 070numberorsendmailtothematNationalServiceCentre:
2/24AndersonRoad,SmeatonGrange,NSW2567–ifmailingpleaseincludeyourcontactdetails.
Aservicerepresentativewillthenassistyouintheappropriateactiontobetaken.Forefcient
processingofyourenquirypleasehaveproofofpurchase,thedateofpurchaseandtheretailername
you purchased the item from, and the brand on the product. Photos of the product, and scans of
receipts,mayberequestedtoassistwithyourclaim.

18
S002004 7 Station Swing Set
Warranty Information (cont)
Theservicecentrerepresentativewillassesstheclaim.If:
1)there is a minor fault, they can offer either a replacement spare part, replacement unit, repair or
other suitable remedy.
2) there is a major fault, they can offer a replacement, repair or suggest you return to the store you
purchased it from for a full refund.
Please note: arequestforcompensationwillneeddocumentaryevidenceofthelossordamage
suffered.Itwillalsoneedtobeevidencedthatsuchalosswasareasonablyforeseeableresultof
afailuretocomplywithaconsumerguaranteeundertheAustralianConsumerLaw.
3) The product was damaged through abnormal use, no refund or repair can be offered.
The sending of replacements, spare parts or the cost of repair carried out will be organized and
coveredbytheServiceCentre.IfcollectionoftheitemisrequiredthiswillbeorganizedbytheService
Centre and at our expense. Do not return any products without authorization as this will be at your
expense.
Oursalesandservicecentrehasbeensetuptoprovideassemblyassistance,replacementpartsand
accessories,andtoefcientlyhandleallwarrantyrelatedmatters.Pleasenoteuponreceivingyour
warrantyclaimourServiceCentrewillsend,viapostoremail,arepairandrefurbishedgoodsorparts
notice.
SERVICE CENTRE
Contact details and hours of operation.
Freecall 1800 465 070
9:00am–4:30pmMondaytoFriday(excludingPublicHolidays)
9:00am–3:00pmSaturday
This product is warranted and distributed by:
Action Sports of 48B Egerton St, Silverwater NSW, 2128
Phone: [phone]
©2017ActionSportsEquipmentPtyLtd.