ALLPOWER EPW1600 User manual

Electric Pressure Washer
MODEL NO. EPW1600
OWNER’S MANUAL

2 | ALL POWER™ EPW1600 POWER WASHER www.allpoweramerica.com
Copyright and Compliance Statements
© 2014, Jiang Dong North America and All -Power America are copy written by Chong Qing
Dajiang Power Equipment Co. Ltd.
UNITED STATES ENVIRONMENTAL PROTECTION AGENCY, WASHINGTON, DC 20460
2014 Model Year Certicate of Conformity:
Manufacturer: Chong Qing Dajiang Power Equipment Co. Ltd.
Certicate Number: CDP-NRSI-06-02
Effective Date: 12/30/2014
Date Issued: 12/30/2014
Merrylin Zaw-Mon, Director, Compliance and Innovation Strategies Division, Ofce of
Transportation and Air Quality.
Pursuant to Section 213 of Clean Air Act (42 U.S.C. Section 7547) and 40 CFR 90, and subject
to the terms and conditions prescribed in those provisions, this certicate of conformity is
hereby issued for the following small non-road engine family, more fully described in the
documentation required by 40 CFR 90 and produced in the stated model year.
This certicate of conformity covers only those new small non-road engines which conform
in all material respects to the design specications described in the documentation required
by 40 CFR 90 and which are produced during the model year stated on this certicate.
This certicate of conformity does not cover small non-road engines imported prior to the
effective date of the certicate. SMALL NON-ROAD ENGINE FAMILY: 6CDPS
This certicate of conformity is conditional upon compliance of said manufacturer with
the averaging, banking, and trading provisions of 40 CFR Part 90, Subpart C both during
and after model year production. Failure to comply with these provisions may render this
certicate void ab initio. The HC + NOX family emission limit (FEL) is: g/k W-hr.
It is a term of this certicate that the manufacturer shall consent to all inspections described
in 40 CFR 90.126 and 90.506 and authorized in a warrant or court order. Failure to comply
with the requirements of such a warrant or court order may lead to revocation or suspension
of this certicate for reasons specied in 40 CFR 90. It is also a term of this certicate that
this certicate may be revoked or suspended or rendered void ab initio for other reasons
specied in 40 CFR 90.
This certicate does not cover small non-road engines sold, offered for sale, or introduced,
or delivered for introduction, into commerce in the U.S. prior to the effective date of the
certicate.
WARNING! PLEASE READ AND UNDERSTAND ALL SAFETY PRECAUTIONS IN THIS
MANUAL BEFORE OPERATING. FAILURE TO COMPLY WITH INSTRUCTIONS IN THIS
MANUAL COULD RESULT IN PERSONAL INJURY, PROPERTY DAMAGE, AND/ OR
VOIDING OF YOUR WARRANTY. ALL POWER AMERICA WILL NOT BE LIABLE FOR
ANY DAMAGE BECAUSE OF FAILURE TO FOLLOW THESE INSTRUCTIONS.
IMPORTANT INFORMATION
This manual contains important notations that
you need to know and understand to protect
YOUR SAFETY and to PREVENT EQUIPMENT
PROBLEMS.
READ AND UNDERSTAND ALL SAFETY PRECAUTIONS
IN THIS MANUAL BEFORE OPERATING. FAILURE
TO COMPLY WITH INSTRUCTIONS IN THIS MANUAL
COULD RESULT IN PERSONAL INJURY, PROPERTY
DAMAGE, AND/OR VOIDING YOUR WARRANTY.
ALLPOWER™ AMERICA WILL NOT BE LIABLE FOR ANY
DAMAGE DUE TO FAILURE OF COMPLYING THESE
INSTRUCTIONS.
This is a safety alert symbol. This is used to
alert you to potential personal injury hazard.
Obey all safety messages that follow this
symbol to avoid possible injury or death.
A WARNING indicates a hazardous
situation which, if not avoided, could result
in death or serious injury.
A NOTE indicates special precautions that
must be taken to avoid damage to the
machine or other property.
Congratulations on your purchase of an
All Power™EPW1600 Pressure Washer!
All Power™designs and builds pressure washers with the consumer in mind. With
proper use and maintenance, this pressure washer will bring years of service. This
‘Owner’s Manual’ will provide you with a good basic understanding of the operation
and maintenance of this machine. Every effort has been made to ensure the
accuracy and completeness of the information in this package. We reserve the
right to change, alter and/or improve the product and this document at any time
without prior notice. WARNING
2ALL POWER EPW1600 PRESSURE WASHER

ALL POWER™ EPW1600 POWER WASHER | 3
SAFETY INFORMATION .............................................4
Hazard Warnings ....................................................... 5
Dust ........................................................................... 5
Bursting ..................................................................... 5
Risk of Eye or Head Injury ......................................... 5
Risk of Fire or Explosion............................................ 6
Risk to Hearing Loss .................................................. 6
Risk to Breathing/Inhalation Hazard.......................... 6
Risk of Fire or Injury.............................................. 7 - 8
Risk of Electric Shock ................................................ 8
Risk of Entanglement ................................................ 8
Risk of Cut or Burns..............................................8 - 9
Precautions................................................................ 9
Basic Air Compressor Components ...................9 - 10
Assembling the Air Compressor ............................. 10
Compressor Controls .......................................10 - 11
ELECTRICAL POWER REQUIREMENTS....................11
Electrical Wiring ...................................................... 11
Extension Cord.................................................11 - 12
Grounding Instructions............................................ 12
BREAKING IN THE PUMP ........................................12
OPERATING INSTRUCTIONS....................................13
MAINTENANCE........................................................13
Lubrication............................................................... 13
Draining the Tank .................................................... 14
Checking the Relief Valve........................................ 14
Testing for Leaks...................................................... 14
Storage.................................................................... 14
Servicing.................................................................. 14
TROUBLESHOOTING.........................................15 - 19
PARTS LIST ........................................................20 - 23
CONSUMER INFORMATION ....................................24
 IdenticationNumberRecords ............................... 24
LIMITED WARRANTY ...............................................25
OWNER’S MANUAL | CONTENTS

4 | ALL POWER™ EPW1600 POWER WASHER www.allpoweramerica.com
4SAFETY INFORMATION | OWNER’S MANUAL
Read and understand all Safety Precautions
in this manual before operating. Failure to
comply with instructions in this manual could
result in personal injury, property damage
and/or voiding of your warranty. All Power
will not be liable for and damage because of
failure to follow these instructions.
Ground Fault Circuit Interrupter (GFCI)
This pressure washer is provided with a
ground fault circuit interrupter (GFCI) built
into the plug of the power supply cord. This
device provides additional protection from
the risk of electric shock. Should replacement
of the plug or cord become necessary, use
only identical replacement parts that include
GFCI protection.
This unit is equipped with a Ground Fault
Circuit Interrupter (GFCI). When connecting
the GFCI to the receptacle, the indicator
should appear red. If the indicator is not red,
depress the RESET button on the GFCI until
the indicator appears red. If the indicator
does not appear red, please see Section titled
“Troubleshooting” for more information.
SAFETY GUIDELINES - DEFINITIONS
This manual contains important information
that you need to know and understand in
order to protect YOUR SAFETY and to
PREVENT EQUIPMENT PROBLEMS. The
following symbols help you recognize this
information. Please read the manual and pay
attention to these sections.
SAVE THESE IMPORTANT SAFETY
INSTRUCTIONS!
A WARNING indicates a
certainty or strong possibility
of personal injury or death if
instructions are not followed.
WARNING
A CAUTION indicates a
possibility of equipment
damage if instructions are not
followed.
CAUTION
A NOTE indicates helpful
information.
WARNING
IMPROPER OPERATION OR MAINTENANCE OF
THIS PRODUCT COULD RESULT IN SERIOUS
INJURY AND PROPERTY DAMAGE. READ AND
UNDERSTAND ALL WARNINGS AND OPERATING
INSTRUCTIONS BEFORE USING THIS
EQUIPMENT. WHEN USING AIR TOOLS, BASIC
SAFETY PRECAUTIONS SHOULD ALWAYS
BE FOLLOWED TO REDUCE THE RISK OF
PERSONAL INJURY.
IMPORTANT SAFETY TIPS
• Never point the high-pressure nozzle at
people or animals.
• Never drink alcohol or use drugs while
operating the pressure washer.
• Never operate the pressure washer while
standing in water.
• Never touch the electrical plug with wet
hands.
• Never let electrical connections rest in water.
• Never operate pressure washer without the
water turned on.
• Never use hot water with this pressure
washer.

ALL POWER™ EPW1600 POWER WASHER | 5
OWNER’S MANUAL | SAFETY INFORMATION 5
IMPORTANT SAFETY PRECAUTIONS
WARNING
DUST FROM POWER SANDING, SAWING,
GRINDING, DRILLING, AND OTHER
CONSTRUCTION ACTIVITIES CONTAIN
CHEMICALS KNOWN TO THE STATE OF
CALIFORNIA TO CAUSE CANCER, BIRTH
DEFECTS OR OTHER REPRODUCTIVE HARM.
1. Read all instructions before using the
product. Save all safety instructions.
2. Do not operate the pressure washer when
 fatiguedorundertheinuenceofalcohol
or drugs.
3. Risk of injection or injury – do not direct
the high pressure water stream at any
people or animals.
4. Do not allow children to operate the
pressure washer at any time.
5. To reduce the risk of injury, close
supervision is necessary when the pressure
washer is used near children.
6. Know how to stop the unit and reduce
pressure immediately. Be completely
familiar with the controls.
7. Stay alert – always be aware of where you
are directing the high pressure spray.
8. Keep cleaning area clear of all people.
9. Keep good footing and balance at all times
– do not overreach or stand on an unstable
support.
10. The work area should have adequate
drainage to reduce the possibility of a fall
due to slippery surfaces.
11. Follow the maintenance instructions
 speciedinthemanual.
12. To reduce the risk of electrocution, keep all
connections dry and off the ground. Do not
touch plug with wet hands.
General Safety Precautions
1. Intended for outdoor household use only.
2. High-pressure hose can develop leaks
from wear, abuse, kinking etc. Do not use
a damaged hose.
3. Do not use the pressure washer in areas
near combustible materials, combustible
fumes, or dust.
4. Some chemicals or detergents may be
harmful if inhaled or ingested causing
severe injury. Use a respirator or mask
whenever there is a chance that vapors may
be inhaled. Read all instructions included
with the mask so you are certain the mask
will provide the necessary protection
against inhaling harmful vapors.
5. Before starting the pressure washer in
cold weather, check all of the parts of the
equipment and be sure that ice has not
formed. Do not store the unit anywhere
that the temperature will fall below
0° C (32° F).

6 | ALL POWER™ EPW1600 POWER WASHER www.allpoweramerica.com
6. DONOTMAKEANYMODIFICATIONSTO
 ANYOFTHECOMPONENTS!Unitswith
broken or missing parts, or without the
 protectivehousingorcoversshouldNEVER
be operated
7. Keep the high-pressure hose connected to
the pressure washer and the spray gun
while the system is pressurized.
Disconnecting the hose while the unit is
pressurized is dangerous, and may cause
injury.
8. Do not leave the pressure washer
 unattendedwhilethepowerswitchisON.
9. Keep water spray away from electrical
wiring or fatal electric shock may result.
Servicing Of A Double-Insulated Appliance
In a double-insulated product, two systems of
insulation are provided instead of grounding.
Nomeansofgroundingisprovidedona
double-insulated product, nor should a means
for grounding be added to the product.
Servicing a double-insulated product requires
extreme care and knowledge of the system,
andshouldbedoneonlybyqualiedservice
personnel. Replacement parts for a
double-insulated product must be identical
to the parts they replace. A double-insulated
product is marked with the words “DOUBLE
INSULATION”or“DOUBLEINSULATED”.
This symbol may also be marked on the
product.
Use Of Extension Cords
Use of an extension cord with this product is
NOTRECOMMENDED.Ifyoumustusean
extension cord, use only extension cords that
are intended for outdoor use. These cords
areidentiedbyamarking“ACCEPTABLE
FORUSEWITHOUTDOORAPPLIANCES,
STOREINDOORSWHILENOTINUSE.”Use
only extension cords having an electrical
rating not less than the rating of the product.
Examine extension cord before use. Do not
usedamagedextensioncords!Donotpullon
cord to disconnect from receptacle, always
disconnect by pulling on plug. Keep cord away
from heat and sharp edges. Always disconnect
the extension cord from the receptacle before
disconnecting the product from the extension
cord.
WARNING
To reduce the risk of electrocution, keep all
connections dry and off the ground. Do not touch
the plug with wet hands.
Proper Use of The Pressure Washer
Use of an extension cord with this product is
NOTRECOMMENDED.Ifyoumustusean
extension cord, use only extension cords that
are intended for outdoor use. These cords are
identiedbyamarking“ACCEPTABLE
NOTE: THIS UNIT IS INTENDED FOR
USE WITH COLD WATER ONLY!
DO NOT USE HOT WATER IN THIS
PRESSURE WASHER.
1. Operate the pressure washer at no more
 thantheuidpressureratedforthe
 pressurewasher.Neverrunthepressure
washer without a water supply. Running
the unit without a water supply will cause
irreparable damage to the unit.
6SAFETY INFORMATION | OWNER’S MANUAL

ALL POWER™ EPW1600 POWER WASHER | 7
Proper Use of The Pressure Washer
(cont’d)
2. Makesurethatthewatersupplyyouuse
for the pressure washer is not dirty, sandy,
and does not hold any corrosive chemical
products. Using a dirty water supply will
compromise the long life of the pressure
washer.
The pressure washer can be used for a variety
of applications including washing cars, boats,
patios, decks, garages etc. where high pressure is
necessary to remove dirt and debris. High-pressure
water ow can damage the work surface if not
used properly! See the section titled “Operating
Instructions” for more details. Always test the
spray in an open area rst.
CAUTION
3. NEVERmovetheunitbypullingonthe
high pressure hose. Use the handle
provided on the top of the unit.
4. Always hold the high pressure gun and
wand with two hands. Keep one hand on
the gun/trigger, while supporting the wand
with the other hand (see diagram).
5. When dispensing detergent, the pressure
washer applies detergent to the cleaning
area at low pressure only. Once the
detergent has been applied, spray the
detergent off of the work area by using
the adjustable nozzle.
ASSEMBLY INSTRUCTIONS (Fig 1)
Unpacking The Carton
After opening the carton, please remove all
parts and check them against the following
list of components that are included:
A. High Pressure Washer
B. Gun
C. High Pressure Hose
 D.AdjustableNozzle
E. Water Intake Filter (Pre-Installed)
F. Two-way Hose Connector
G. Gun-shelve
(Fig 1)
To assemble the enclosed parts, please refer
to the steps that follow:
Step 1 (Fig 2)
Attach the high pressure hose to the gun. Use
awrenchtotightenthetting.
(Fig 2)
OWNER’S MANUAL | ASSEMBLY 7

8 | ALL POWER™ EPW1600 POWER WASHER www.allpoweramerica.com
Step 2 (Fig 3)
Insert the adjustable spray nozzle into the gun.
Push and turn the adjustable nozzle clockwise
onto the gun until hand tight to lock it in
place. When the pieces are joined properly,
you cannot separate the two components by
pulling straight out on the adjustable nozzle.
All attachments must be inserted into the gun
for proper use.
(Fig 3)
Step 3 (Fig 4)
Attach the high-pressure hose to the male
ttingonthefrontofthepressurewasher.
Before attaching the high-pressure hose to the
maletting,removetheplasticcap,whichis
insertedontothettingbeforeshipping.This
plastic cap can be discarded once removed.
Twist on tight to avoid leakage.
(Fig 4)
Step 4 (Fig 5)
Attach the hose connector to pressure washer.
Before attaching the connector to the male
tting,removetheplasticcap,whichis
insertedontothemalettingonthepressure
washer before shipping. This plastic cap
can be discarded once removed. After both
components have been installed, attach the
garden hose with connector screw on the
pressure washer. Connect the garden hose to
the waterspout.
(Fig 5)
OPERATING INSTRUCTIONS
NOTE: THIS UNIT IS INTENDED FOR
USE WITH COLD WATER ONLY!
DO NOT USE HOT WATER IN THIS
PRESSURE WASHER.
Bleeding The Gun
It is very important to bleed all the air out of
the pressure washer before using it. To do this:
1. Release trigger lock.
2. Squeeze the trigger before turning the
electrical supply on. This removes any air
trapped inside the pressure washer and
lance before using the units.
3. Continue holding trigger for approximately
one minute to allow any excess air out of the
 unit.Waterwillowthroughthegunatlow
pressure during this procedure.
4. Lock the trigger.
5. Plug the main power cable into the
electricity supply.
6. Release the trigger lock.
7.TurntheON/OFFswitchclockwisetothe
 I/ONposition.Thepressurewasherisready
to using now.
8ASSEMBLY/OPERATION | OWNER’S MANUAL

ALL POWER™ EPW1600 POWER WASHER | 9
Starting Up
After connecting the pressure washer to your
cold water supply, proceed as follows:
 - MakesurethattheON/OFFswitchis
in the OFF position.
- Connect the garden hose with quick
  connecttotheinlettting.
- Attach the hose to the gun as per
assembly instruction step #1.
- Insert the adjustable spray nozzle
into the gun as per assembly
step #2.
- Connect the high pressure hose to
  thehighpressureoutletttingas
per assembly step #3.
- Open the water supply valve completely.
- Before turning the unit on, press the gun
trigger to bleed all the remaining air out
of the pump and hose.
- Start the pressure washer by turning the
on/off switch to the on position and
squeeze the trigger.
REMINDER:Motordoesnotruncontinuously,
only when the trigger is squeezed.
WARNING
RISK OF INJECTION! Unit will start spraying
when trigger is squeezed. When turning the unit
off after use, high pressure still exists inside the
hose and unit. Point the gun in a safe direction
and discharge the excess pressure. NEVER direct
the high pressure water stream at people or
animals.
Automatic ON/OFF
The pressure washer is equipped with an
automatic on/off switch. The pressure washer
will only run when the power switch is in the
ONpositionandthetriggeronthegunis
squeezed. When you release the trigger to
stop spraying water through the gun, the
motor on the pressure washer will
automatically shut off. Simply squeeze the
trigger again to resume using the washer. To
stop using the pressure washer, release the
trigger and switch the unit to the OFF position.
The unit should be turned completely
OFF while not in use or while unattended.
Gun Safety Lock
This pressure washer is equipped with a
gun trigger safety lock. When not using the
pressure washer, use the safety lock to keep
from accidentally engaging the high pressure
spray.
Adjustable Spray Nozzle (Fig 6)
(Fig 6)
The adjustable nozzle will allow you to use any
variety of spray patterns from a full fan spray
(Diagram 1) to a direct stream spray (Diagram
2). When using the pressure washer to clean
wood decks, siding, vehicles etc., always start
using the fan spray and begin spraying from
aminimum36”awaytoavoiddamaging
the surface of the material you are cleaning.
Always begin by spraying in a testing area free
and clear of people and objects.
OWNER’S MANUAL | OPERATION 9

10 | ALL POWER™ EPW1600 POWER WASHER www.allpoweramerica.com
Adjusting The Pressure (Fig 8)
To adjust the pressure,proceed as follows:
1. Hold the shaft of the lance in one hand.
2. Turn the gray part of the nozzle clockwise
 (to“+”end)toobtainthehighpressure.
3. Turn the gray part of the nozzle
 counterclockwise(to“-”end)toobtain
the low pressure.
(Fig 8)
Adjusting The Pressure
Thepressurewasheristtedwithatotalstop
system to protect the motor when in use.
When the trigger is released the motor will
stop. When the trigger is squeezed the motor
will start up again.
Detergent Nozzle (Fig 7)
The detergent nozzle will allow you to apply
many forms of liquid detergent onto the
work surface. Detergent application happens
at low pressure only. Fill the container
with detergent only. Do not put any water into
the container. The pressure washer will
mix water and detergent automatically. When
nishedapplyingthedetergenttothe
work surface, insert the adjustable spray
nozzle, and remove the detergent by using
the high pressure spray.
(Fig 7)
Using Detergents
Biodegradabledetergentsarespecically
formulated to protect the environment and
your pressure washer. These Detergents will
notclogthelterandwillprotecttheinternal
parts of the pressure washer for a longer life.
(Fig 9)
Step 1 (Fig 9)
Open the cover of the detergent bottle by
twisting it off.
Step 2 (Fig 9)
Fill the detergent bottle with any approved
liquid detergent. Close the cover.
10 DETERGENTS | OWNER’S MANUAL

ALL POWER™ EPW1600 POWER WASHER | 11
Step 3 (Fig 10)
OfoadingtheFront-gun,andinstallthe
detergent nozzle with the bottle.
(Fig 10)
Step 4
To apply the detergent cleanser to your working
area,turnthepressurewasherswitchtotheON
position. Pull the trigger to operate the unit.
The pressure washer will mix the detergent with
water. Do not allow the detergent to dry on the
object that you are cleaning.
WARNING
NEVER USE PRODUCTS WITH BLEACH OR
CHLORINE OR ANY OTHER CORROSIVE
MATERIALS, INCLUDING LIQUIDS CONTAINING
SOLVENTS (I.E. GAS, OILS ETC), TRI-SODIUM
PHOSPHATE PRODUCTS, AMMONIA, OR ACID-
BASED CLEANERS. THESE CHEMICALS WILL
HARM THE UNIT AND CAUSE DAMAGE TO THE
SURFACE BEING CLEANED. ALWAYS READ THE
LABEL.
Clean-Up And Storage
Shutting Down the Pressure Washer
WHEN FINISHED USING THE PRESSURE
WASHER, FOLLOW THESE STEPS TO SHUT
DOWN THE UNIT: (Fig 11)
• Turn the pressure washer to the OFF
position.
• Turn off the water supply.
• Before disconnecting high-pressure
hose connection, point the gun in a safe
direction and discharge the high-pressure
water.
• Disconnect high-pressure hose from the
pressure washer and gun.
• Disconnect garden hose from the
pressure washer.
• Remove excess water from the pump by
tipping the unit on both sides to
drain any remaining water from inlet and
  outletttings.
 •RemoveWaterIntakeFilterandushwith
water to remove dirt or debris. Return
  lteroncecleaned.
(Fig 11)
 •Draindetergentreservoirandushwith
running water.
• Wipe away any remaining water on all
  partsandttings.
• Engage the gun safety lock.
• Store the pressure washer, parts, and
accessories in an area with a temperature
above 0°C (32°F).
OWNER’S MANUAL | DETERGENTS/CLEAN-UP AND STORAGE 11

12 | ALL POWER™ EPW1600 POWER WASHER www.allpoweramerica.com
12 CLEANING TIPS | OWNER’S MANUAL
Winterizing and Long-Term Storage
FOLLOW ALL OF THE ABOVE SHUT-DOWN
PROCEDURES, ADDING
THE FOLLOWING STEPS….
• After disconnecting the water supply, and
before disconnecting the high-pressure
hose, turn the pressure washer on for 2-3
seconds, until any remaining water in the
pump exits. Turn unit off immediately.
CONTINUED USE OF THE PRESSURE
WASHER WITHOUT WATER SUPPLY
ATTACHED WILL CAUSE SEVERE
DAMAGE TO THE UNIT!
• Always store the pressure washer, parts,
and accessories in an area with a
temperature above 0° C (32° F).
WARNING
Failure to comply with these storage instructions
will result in damage to the pump assembly.
MAINTENANCE
• This pressure washer is supplied with a
closed lubrication system, so no addition
of oil is needed.
• Check all hoses and accessories for
damage prior to use.
 • Checkthewaterintakelterperiodically 
  fordeposits.Cleanthislterregularly 
for maximum performance.
(Fig 12)
WARNING
Always test the spray in an area free and clear
of people and objects before you spray at the
intended cleaning surface.
Wood and Vinyl Decks
Rinse deck and surrounding area with fresh
water.Ifusingdetergent,llthedetergent
reservoir and apply to the area being cleaned
at low pressure. For optimal results, reduce
your work area to smaller sections and
clean each section one at a time. Allow the
detergent to rest on the surface for a few
minutes and then rinse at high pressure.
Do not let the cleanser dry. Always clean
from left to right and top to bottom for best
results. Rinse at high pressure using the fan
spray keeping the tip of the spray nozzle at
least 6-9 inches from the cleaning surface.
Maintainafurtherdistancefromthecleaning
area when using a direct spray.
For softer woods, increase the distance from the
cleaning area.
CAUTION

ALL POWER™ EPW1600 POWER WASHER | 13
OWNER’S MANUAL | CLEANING TIPS/TECHNICAL DATA 13
Cement Patios, Stone, and Brick
Rinse cleaning and surrounding area with
freshwater.Ifusingdetergent,llthe
detergent reservoir and apply to the area
being cleaned at low pressure. Rinse at high
pressure using the fan spray in a sweeping
motion keeping the tip of the spray nozzle
at least 3-6 inches from the cleaning surface.
Maintainafurtherdistancefromthecleaning
area when using a direct spray.
Cars, Boats, and Motorcycles
Rinse cleaning and surrounding area with
freshwater.Ifusingdetergent,llthe
detergent reservoir and apply to the area
being cleaned at low pressure. To achieve the
best results, clean one side at a time. Allow
the detergent to rest on the surface for a few
minutes, but do not let the detergent dry.
Rinse at high pressure using the fan spray in a
sweeping motion keeping the tip of the spray
nozzle at least 8 inches from the cleaning
surface.
Maintainafurtherdistancefromthecleaning
area when using a direct spray. Wipe
surfacedryforapolishednish.
Barbecue Grills, Power Equipment,
and Garden Tools
Rinse cleaning and surrounding area with
freshwater.Ifusingdetergent,llthe
detergent reservoir and apply to the area
being cleaned at low pressure. Allow the
detergent to rest on the surface for a few
minutes, but do not let the detergent dry.
Rinse at high pressure using the fan spray
keeping the tip of the spray nozzle at least
1-3inchesfromthecleaningsurface.Maintain
a further distance from the cleaning area
when using a direct spray.
TECHNICAL DATA
Mainsvoltage: 120V
Mainsfrequency: 60Hz
Max.operatingpressure: 1600PSI
Waterconsumption: 1.6GPM
Max.pressurewatersupply:40-80PSI
Max.watertemperature 40-140F(5-60°C)
Weight: 18LBS
Guarantee
Refer to the enclosed guarantee conditions
for the terms and conditions of guarantee.
Environment
Should your machine need replacement
after extended use, do not put it in the
domestic waste but dispose of it in an
environmentally safe way.

14 | ALL POWER™ EPW1600 POWER WASHER www.allpoweramerica.com
14 TROUBLESHOOTING | OWNER’S MANUAL
Problem Probable Cause Solution
When the switch is in the “I”
position the machine will not
start.
Electrical socket is faulty. Check plug, socket and fuses.
Voltage is inadequate. Check that the voltage is adequate.
GFCI trips. Reset/Try another outlet.
Power cord is not plugged in. Plug in power cord.
The pump does not reach
adequate pressure or
uctuates.
Water Intake Filter is clogged Remove and clean lter
Pump is drawing air Tighten connections/bleed system
Suction valves are clogged/worn Clean or replace valves
Diameter of garden hose too small Replace with ¾ inch garden hose
Water supply is restricted Check hose for kinks or leaks
Insufcient water supply Fully open water source
The pressure washer has or
will not maintain pressure. Excessive air in waterline and pump Turn unit and water supply off / Bleed system / Hold trigger down
TROUBLESHOOTING GUIDE
The following troubleshooting guide is recommended for basic or
common problems; if there’s an issue with the generator that is not
listed, please call 1-888-896-6881.
NOTE: Troubleshooting problems may have similar causes
and solutions.

ALL POWER™ EPW1600 POWER WASHER | 15
OWNER’S MANUAL | TROUBLESHOOTING 15
Problem Probable Cause Solution
The pressure washer makes
excessive noise.
Intake is blocked. Check the intake valves.
Valves are worn, dirty, or clogged. Check, clean or replace valves.
Water Intake Filter is dirty. Check, clean, or replace lter.
The motor stops running
while in use Net voltage lower than suggested. Check that the voltage is adequate.
NOTE: Troubleshooting problems may have similar causes
and solutions.
The following troubleshooting guide is recommended for basic or
common problems; if there’s an issue with the generator that is not
listed, please call 1-888-896-6881.
TROUBLESHOOTING GUIDE

16 | ALL POWER™ EPW1600 POWER WASHER www.allpoweramerica.com
16 PARTS LIST | OWNER’S MANUAL

ALL POWER™ EPW1600 POWER WASHER | 17
APA PART # DESCRIPTION QTY
EPW1600-01-MT SWITCH KNOB 1
EPW1600-02-MT ORNAMENT RING 1
EPW1600-03-MT OUTLET CAP 1
EPW1600-04-MT CASE(FRONT) 1
EPW1600-05-MT SCREW (ST2.9×20) 4
EPW1600-06-MT SWITCH CASE (FRONT) 1
EPW1600-07-MT SWITCH 1
EPW1600-08-MT SWITCH CASE (REAR) 1
EPW1600-09-MT O-RING 1
EPW1600-10-MT SWITCH STALK 1
EPW1600-11-MT RUBBER BAND 4
EPW1600-12-MT PUMP 1
EPW1600-13-MT INLET FILTER 1
EPW1600-14-MT INLET CAP 1
EPW1600-15-MT SCREW (ST3.9×14) 2
EPW1600-16-MT CLIP COVER 1
EPW1600-17-MT JACKET 1
EPW1600-18-MT WHEEL CAP 2
EPW1600-19-MT WHEEL 2
APA PART # DESCRIPTION QTY
EPW1600-20-MT WATERPROOF CAP (BOTTOM) 1
EPW1600-21-MT SCREW (ST3.9×25) 6
EPW1600-22-MT HOOK 1
EPW1600-23-MT WATERPROOF CAP (UPPER) 1
EPW1600-24-MT SCREW 2
EPW1600-25-MT SCREW (ST3.9×16) 4
EPW1600-26-MT HANDLE FIXER 1
EPW1600-27-MT SCREW (ST3.9×16) 4
EPW1600-28-MT CASE (REAR) 1
EPW1600-29-MT SHELVES 1
EPW1600-30-MT HOOK 1
EPW1600-31-MT HANDLE 1
OWNER’S MANUAL | PARTS LIST 17

18 | ALL POWER™ EPW1600 POWER WASHER www.allpoweramerica.com
Record your generator’s model number, serial number, date
of purchase and place of purchase in the spaces provided.
Have this information available when ordering parts and
when making technical or warranty inquiries.
Note:Itisrecommendedthatyouplacethecompleted
sticker on the unit itself where it can be seen (e.g., gas tank.)
CONSUMER INFORMATION
MODEL NO.
SERIAL NO.
DATE OF PURCHASE
PLACE OF PURCHASE
18 CONSUMER INFORMATION | OWNER’S MANUAL

ALL POWER™ EPW1600 POWER WASHER | 19
All Power warrants to the original purchaser who uses the
product in a consumer application (personal, residential
or household usage) that all products covered under
this warranty are free from defects in material and
workmanship for one year from the date of purchase.
All products covered by this limited warranty which are
used in commercial applications (i.e. income producing)
are warranted to be free of defects in material and
workmanship for 90 days from the date of original
purchase. Products covered under this warranty include
air compressors, air tools, service parts, pressure washers
and generators.
All Power will repair or replace, at All Power sole option,
products or components which have failed within the
warranty period. Service will be scheduled according to
the normal work ow and business hours at the service
center location, and the availability of replacement parts.
All decisions of All Power with regard to this limited
warranty shall be nal.
This warranty gives you specic legal rights, and you may
also have other rights which vary from state to state.
RESPONSIBILITY OF ORIGINAL PURCHASER (initial User):
To process a warranty claim on this product, DO
NOT return item to the retailer. The product must be
evaluated by an Authorized Warranty Service Center. For
the location of the nearest Authorized Warranty Service
Center call 888.896.6881.
Retain original cash register sales receipt as proof of
purchase for warranty to work.
Use reasonable care in the operation and maintenance of
the product as described in the Owner’s Manual(s).
Deliver or ship the product to the Authorized Warranty
Service Center. Freight costs, if any must be paid by the
purchaser.
If the purchaser does not receive satisfactory results form
the Authorized Warranty Service Center, the purchaser
should contact All Power.
THIS WARRANTY DOES NOT COVER:
• Merchandise sold as reconditioned, used as rental
equipment, or oor or display models.
• Merchandise that has become damaged or inoperative
because of ordinary wear, misuse, cold, heat, rain,
excessive humidity, freeze damage, use improper
chemicals, negligence, accident, failure to operate
the product in accordance with the instructions
provided in the Owner’s Manual(s) supplied with the
product, improper maintenance, the use of accessories
or attachments not recommended by All Power, or
unauthorized repair or alterations.
• Repair and transportation costs of merchandise
determine not to be defective.
• Costs associated with assembly, required oil,
adjustments or other installation and start-up costs.
• Expendable parts or accessories supplied with the
product which are expected to become inoperative or
unusable after a reasonable period of use.
• Merchandise sold by All Power which has been
manufactured by and identied as the product of
another company, such as gasoline engines. The
product manufacturer’s warranty, if any, will apply.
• ANY INCIDENTAL, INDIRECT OR CONSEQUENTIAL
LOSS, DAMAGE, OR EXPENSE THAT MAY RESULT
FROM ANY DEFECTS, FAILURE OR MALFUNCTION
OF THE PRODUCT IS NOT COVERED BY THIS
WARRANTY. Some states do not allow the exclusion,
so it may not apply to you.
• IMPLIED WARRANTIES, INCLUDING THOSE OF
MERCHANTABILITY OR FITNESS FOR A PARTICULAR
PURPOSE, ARE LIMITED TO ONE YEAR FROM THE
DATE OF ORIGINAL PURCHASE. Some states do not
allow limitations on how long an implied warranty
lasts, so the above limitations may not apply to you.
LIMITED WARRANTY
OWNER’S MANUAL | WARRANTY 19

www.allpoweramerica.com
©2014 All Power America