Atollspeed 300H User manual

www.atollspeed.eu
Operation Manual
Atollspeed Highspeed Oven
Touchscreen Series
Atollspeed 300H K02–3003T1S
Atollspeed 400H K02–4003T1S

2Operation Manual Atollspeed Oven
Follow the operation manual
> Read the operation manual prior to use.
> Always follow the operation manual,
especially the safety instructions and the
chapter on safety.
> Observe the warnings on the Atollspeed
oven.
> Make sure that all users and personnel have
access to the operation manual.
Danger to life due
toelectricalshock
yThere is high voltage that is hazardous
tolife inside the oven.
> Never open the housing.
> Never loosen the screws, and do not
remove any housing parts.
Conditions for use
andinstallation
yThese appliances are intended to be used
for commercial applications, for example
in kitchens of restaurants, canteens,
hospitals and in commercial enterprises
such as bakeries,butcheries, etc., but not
for continuous mass production of food.
yIn the event of failure to comply with
maintenance information and the
specications in the Technical Data
chapter, no liability is accepted for any
resultant damage.
> Follow the operation manual.
> Maintenance and repair work may be
performed only by licensed service
personnel, using original spare parts.
CAUTION
Follow the Signs and
symbols in the operation
manual
wpage 3
Follow the Safety chapter
wstarting on page 6
WARNING
Follow the Safety chapter
wstarting on page 6
INSTRUCTIONS
Technical data
wstarting on page 67
Maintenance
wstarting on page 60
Introduction and general information

3
Operation Manual Atollspeed Oven
Operation Manual Signs and Symbols
Personal injury safety
instructions
If the safety instructions are not followed,
thiscould lead to mild to severe injury in case
of improper use.
Personal injury safety
instructions
If the safety instructions are not followed,
thiscould lead to mild injury in case of
improper use.
Electrocution Hot liquid
Crushing hazard Hot surfaces
Slipping hazard
Potential property damage
yto the Atollspeed oven
yfor the installation location
> Always follow the operation manual.
Instructions/tip
yInstructions for safe use and tips for easier
operation.
WARNING
Follow the Safety chapter
wstarting on page 6
CAUTION
Operation
safetyinstructions
wpage 25
Follow the Safety chapter
wstarting on page 6
INSTRUCTIONS
Follow the Warranty
chapter
wstarting on page 75
Technical data
wstarting on page 67
INSTRUCTIONS
TIP
Introduction and general information

4Operation Manual Atollspeed Oven
Table of contents
Tableof contents 4
1 Safety 6
1.1 General safety instructions 6
1.2 Intended use 16
1.3 Conditions for use and installation 17
1.4 Oven safety 18
Microwave function 18
Conditions for installation 18
2 Introduction and general information 19
2.1 Parts of the device 19
2.2 Start screen with keypad 19
3 Installation and setup 20
3.1 Start-up safety instructions 20
3.2 Setting up the oven 21
Installation location 21
Unpacking 22
General notes 22
Scald hazard warning sign 22
3.3 Electrical connection 23
3.4 Starting up the oven 24
Resetting the thermal limiter 24
4 Operation 25
4.1 Operation safety instructions 25
4.2 General tips 26
Place the products in the oven 26
Temperature and air circulation 26
4.3 Switch on the oven 27
4.4 Home screen 28
Keypad 28
Oven temperature 29
Preheating temperatures T1/T2 29
Start button 30
Program button 30
Favorites button 30
Microwave intensity 30
Air circulation speed 31
Baking temperature 31
Baking time 32
Preheating timer 32
Reheating timer 33
4.5 Start baking manually 34
Bake using the parameter settings 34
Pause the baking cycle 34
Continue the baking cycle 35
4.6 Start abaking program 36
4.7 Start Favorites 37
4.8 Switching o the oven 38
5 Open abaking program 40
Setting up anew baking program 40
Changing abaking program 40
Open abaking program 40

5
Operation Manual Atollspeed Oven
Table of contents
Deleting aprogram 42
Adding aprogram 42
Saving aprogram as afavorite 42
Adding an image 42
5.1 Editing the group name 43
5.2 Favorites 44
PIN-protected favorites 45
5.3 +1function (continue baking) 46
6 User settings 49
6.1 Temperature settings 50
Preheating temperature T1 50
Secondary temperature T2 50
Preheating timer 50
Reheating timer 50
Force timer 50
Temperature unit 50
6.2 Continue baking function 50
6.3 Alarm settings 51
Acoustic signal 51
Sound repeat time 51
Volume 51
Visual alarm 51
Button sound 51
6.4 Language 52
6.5 Cleaning 52
6.6 PIN 52
6.7 Deleting all programs 52
6.8 Factory setting 52
7 USB transfer 53
8 Cleaning the oven 56
8.1 Cleaning the outside of the oven 56
8.2 Clean the baking chamber daily 57
8.3 Cleaning the air lter 58
8.4 Clean the baking chamber regularly 59
9 Maintenance 60
10 Faults and errors 61
10.1 Error messages 61
10.2 Error correction 64
11 Contact 65
12 Technical data 67
13 Electrical drawings 70
14 Directives and certicates 71
15 Certicates 72
16 Guarantee 75

6Operation Manual Atollspeed Oven
Safety
1 Safety
Misuse
yFailure to follow safety
instructions can result in death
orserious injury.
> Follow all the safety instructions.
1.1 General safety instructions
Hazard to the operator
The greatest possible safety is one of
the most important product features
at Atollspeed. The eectiveness of the
safety devices can only be ensured if the
following points are observed:
> Read the operation manual
carefully prior to use.
> Do not touch hot parts of the
device.
> Do not use the Atollspeed oven if
it is not in perfect working order
or is damaged.
> Use the Atollspeed oven only
when fully assembled.
WARNING
CAUTION

7
Operation Manual Atollspeed Oven
Safety
> Built-in safety devices must never
be altered.
> The operator is required to make
sure that anyone who works
with the device is familiar with
the fundamental regulations
on worker safety and accident
prevention, and has been
instructed in the use of the
device. The operator agrees to
not allow anyone to work with
the device who has limited
physical, mental, or sensory
abilities. Children under 14years
of age must be supervised to
make sure they do not play with
the device.
> Cleaning and user maintenance
must not be performed by
children.
CAUTION

8Operation Manual Atollspeed Oven
Safety
Despite the safety devices, every coee
machine poses hazard potential if
incorrectly used. Follow these instructions
when using the device in order to prevent
injuries and hazards to health:
Danger to life due
toelectricalshock
yThere is high voltage that is
hazardous to life inside the oven.
> Never open the housing.
> Never loosen the screws, and do
not remove any housing parts.
> Never use adamaged power
cord.
> Avoid damage to the power cord.
Do not kink or crush it.
> Never immerse the mains plug
in water or other liquids, or pour
water or other liquids over the
mains plug. Always keeps the
mains plug dry.
WARNING

9
Operation Manual Atollspeed Oven
Safety
Danger to life due
toelectricalshock
yDamaged power cords may
be replaced only by atrained
electrician.
yNever spray water to clean the
device as this can damage it.
There is ahazard of being injured
by electrical shock.
yDo not use the device around
water.
WARNING

10 Operation Manual Atollspeed Oven
Safety
Risk of re
yAlways keep the ventilation fan
openings clear and do not block
them.
yNever use plastics or paper,
including those suitable for
microwave use, in the Atollspeed
oven. The baking chamber has
very high convection heat.
These materials can melt or
burn. Microwave-safe ceramic
containers are preferred.
yIf you smell smoke, immediately
turn o the oven and pull the
mains plug.
yThe microwave function must not
be used to heat large quantities
of cooking oil for deep frying.
CAUTION

11
Operation Manual Atollspeed Oven
Safety
Burn hazard
yAlways wear gloves when
removing heated products, or use
the including product paddle or
tongs. Burn hazard.
yNever touch the interior surface
ofthe oven.
CAUTION
yWhen heated by the microwave function, the products
themselves become much hotter than the surface of
the container.
yAlways check the temperature of the heated food
products before giving them to children.
yAlways remove caps or nipples when heating baby
food in jars or bottles. Always stir heated baby food
thoroughly before serving so that the heat is even
distributed. Check the temperature.
yDo not cook eggs in the shell with the microwave
function, as the pressure generated in the shell will
cause the egg to explode. Before cooking fried eggs,
pierce the egg yolk several times.

12 Operation Manual Atollspeed Oven
Safety
Burn hazard
yOnly use utensils that are suitable
for use in microwave ovens.
yNever cook closed containers
of food or liquids using the
microwave function, as the
containers may explode.
yNever heat liquids in tightly
closed containers. Risk of
explosion!
yLiquids heated using the
microwave function can boil over
after some delay. Handle the
container carefully.
yContents of containers must
always be visible. The installation
surface for the oven should not
be higher than 1.20m above the
oor.
CAUTION

13
Operation Manual Atollspeed Oven
Safety
Risk of injury
yIf aglass container or abowl is
damaged in the oven, this may
produce splinters. The food
products in the container may
nolonger be eaten.
yDo not place objects on the
device.
yDo not heat explosive materials
or liquids in the microwave.
CAUTION

14 Operation Manual Atollspeed Oven
Safety
Health hazard
yOnly process products that are
suitable for consumption and
foruse in the Atollspeed oven.
yRemove prepared foods from
packaging prior to cooking,
as the packaging is typically
not heat-resistant. Follow the
manufacturer's preparation
instructions for food products.
yAlways keep the oven clean in
order to protect the quality of
its surfaces. Adirty oven has
anegative eect on service life
and hygiene.
yEnsure that food reaches
aminimum temperature of 70°C
when cooking and heating.
CAUTION

15
Operation Manual Atollspeed Oven
Safety
Danger from microwave
radiation
yNever remove the safety covers
that protect against microwave
radiation. If the covers need to be
removed for maintenance work,
then this work may be done only
by acertied service.
yDo not use the oven if the door
orthe door seal is damaged.
Havethe certied service repair
the damage.
Bruising or crushing hazard/
risk of injury
yWhen closing the door, hands
and ngers may be pinched.
> Always close the door carefully.
CAUTION
CAUTION

16 Operation Manual Atollspeed Oven
Safety
1.2 Intended use
This device is intended for commercial use for snack concepts
in gastronomy, hotels, and similar locations.
Reasonably foreseeable misuse
yIf the device is used other than as
intended, this could lead to arisk
of injury.
> The Atollspeed oven may be used
only as intended.
The Atollspeed is acombination convection and microwave
oven for preparing food products.
With the Atollspeed oven, backing and cooking are much faster
than with aconventional convection oven.
Very high-speed air circulation combined with the microwave
function produces very fast heating results. Baked goods
get crispy on the outside, while the inside heats up quickly.
Thistechnology serves customers quickly and protects the
avor of freshly prepared foods.
Use of the device is subject to this operation manual. Any other
use or use that goes beyond the aforementioned is considered
incorrect use. The manufacturer shall not be liable for any
damage resulting from this.
WARNING

17
Operation Manual Atollspeed Oven
Safety
1.3 Conditions for use and installation
Risk of re and accidents
> The conditions for installation
and use must be met.
> The conditions for installation
and use listed in the Technical
Data chapter must be met.
The operator must have on-site prep work for the electrical
connection completed by others. This work must be performed
by licensed installers in compliance with general, national, and
local regulations. AtollspeedService is only allowed to connect
the oven to the prepared connection points. WMF Service is
neither authorized nor responsible for carrying out any on-site
installation work prior to connection.
WARNING
Technical data
wstarting on
page67

18 Operation Manual Atollspeed Oven
Safety
1.4 Oven safety
Microwave function
yNever start the microwave function when the baking chamber is empty.
A liquid or suitable product must always be in the baking chamber before the
microwave function is started.
yDo not dry towels, wet clothing, or wet paper with the microwave function.
yDo not use the microwave function to heat up plates.
yBeverages must not be overheated.
yDo not heat beverages with an alcohol content above 5%.
Set ashort time and observe the process.
yThe oven may be used only for heating food products.
yMagnetic dishes and objects will destroy the microwave. Any metal
containers used must not contain any magnetic materials.
yThe microwave function must not be used when loose metal objects
(knives,covers, skewers, etc.) are inside the oven. Only open stainless-steel
oraluminum containers are permissible. Open metal pans can be used on
thestone.
Conditions for installation
yThis device must not be stored or operated outdoors or exposed to direct
sunlight or rain.

19
Operation Manual Atollspeed Oven
Introduction and general information
2 Introduction and general information
2.1 Parts of the device
5
4
1
2
3
1Condenser tank (exhaust)
Becomes hot when in use.
2Thermal limiter
3Baking shelf
4USB connection
5Screen
2.2 Start screen with keypad
Oven temp. 260°C T1
TIME
TEMP
AIR
MIC
0 : 30
270
90%
90%
1
0
2
ABC
5
JKL
8
TUV
4
GHI
7
PQRS
3
DEF
6
MNO
9
WXYZ
Start screen
2

20 Operation Manual Atollspeed Oven
Installation and setup
3 Installation and setup
3.1 Start-up safety instructions
(For initial start-up after delivery from the factory)
Follow the operation manual
> Read the operation manual prior to use.
> Always follow the operation manual,
especially the safety instructions and the
chapter on safety.
> Observe the warnings on the oven.
> Make sure that all users and personnel have
access to the operation manual.
Danger to life due
toelectricalshock
yThere is high voltage that is hazardous
tolife inside the oven.
> Never open the housing.
> Never loosen the screws, and do not
remove any housing parts.
Conditions for use
andinstallation
Follow the operation manual.
CAUTION
Follow the Signs and
symbols in the operation
manual
wpage 3
Follow the Safety chapter
wstarting on page 6
WARNING
Follow the Safety chapter
wstarting on page 6
INSTRUCTIONS
Technical data
wstarting on page 67