Backyard Discovery LIBERTY II User manual

Made in China

INS-44215-A-LIBERTY-ENG 03-18-2022

Please visit www.backyarddiscovery.com

For the most up to date assembly manual, to register your set, or to order replacement parts

Para obtener instrucciones en español, visite www.backyarddiscovery.com

Model # 44215

LIBERTY II

MANUFACTURED BY:

Backyard Discovery

3305 Airport Drive, Pittsburg, KS 66762

800-856-4445

Swing Set

Basepoint Business Centre: Rivermead Drive,Westlea, Swindon SN5 7EX Phone: 0800-118-2476

J.P. Coenstraat 7, The Bridge, The Hague, 2595 WP, Netherlands Phone: 0800-567-8990

WARNING

Adult Assembly Required.

Not suitable for children under 36 months due to small parts.

FOR DOMESTIC USE ONLY. INTENDED FOR OUTDOOR USE.

The assembly manual must be retained

since it contains important information

Important Assembly Notes

1) While assembling unit, take time before and after each phase to make sure fort is level. If fort is

not level, assembly will be difficult and improper assembly may result. Extra care must be taken to

ensure the fort is square.

2) Tighten bolts securely, tighten nuts on bolts flush to the tube or member.

3) Pay close attention to the ITEMS NEEDED FOR EACH PHASE. They can be a valuable aid when

sorting your wood and hardware. Assembly will be made easier if items are sorted by phase.

4) Pay close attention to make sure you are using the correct hardware in the correct phases. Using

incorrect hardware may result in improper assembly.

5) Whenever a T-nut is used, follow these directions. Place T-nut in pre-drilled hole. Tap in with hammer.

Place bolt with washers in the opposite side. Hand tighten to make sure the bolt is in the T-nut.

DO NOT over tighten.

6) Read the steps of each phase thoroughly. The written steps may include important information not

shown in the illustrations.

Basic Setup Dimensions

Place the set on level ground, not less than 6 ft [2 m] from any structure or obstruction such

as a fence, garage, house, overhanging branches, laundry lines, or electrical wires.

Safe Play Zone

Safe play height: 18'-4" [5.6 m]

Maximum fall height: 6'-11 1/4" [2.1 m]

General Information:

Your set has been designed and engineered for

children only and for residential use only.

A maximum of 150 lbs. per child is recommended

for play activities designed for individual use.

A maximum of 120 lbs. per child is recommended

for play activities designed for multiple child use.

A maximum of 9 children is recommended for

this swing set.

13'-11 3/4"

16'-8 1/2" 6'-0"

28'-8 1/2"

25'-11 3/4"

6'-0"

12'-4"

6'-11 1/4"

A50 - SWING BEAM - W4L11733

3 3/8"x5 1/4"x89 1/2" (86x134x2274)

(1)

B1 - PORCH UPRIGHT - W4L03508

3"x3"x89 1/2" (76x76x2274)

(1)

B2 - PORCH UPRIGHT - W4L05692

3"x3"x89 1/2" (76x76x2274)

(1)

B4 - FORT UPRIGHT - W4L05684

3"x3"x59" (76.0x76.0x1500.0)

(2)

B5 - LOWER UPRIGHT - W100998

3"x3"x59" (76.0x76.0x1500.0)

(1)

B6 - FORT UPRIGHT - W4L05686

3"x3"x59" (76.0x76.0x1500.0)

(1)

B7 - LOWER UPRIGHT - W101033

3"x3"x59" (76.0x76.0x1500.0)

(1)

B8 - FORT UPRIGHT - W4L05685

3"x3"x59" (76.0x76.0x1500.0)

(1)

E51 - ANGLE BRACE - W100948

1 3/8"x3 3/8"x88 3/4" (36x86x2254)

(2)

E72 - LEFT RAIL - W100036

1 3/8"x3 3/8"x61 3/4" (36x86x1570)

(1)

E73 - RIGHT RAIL - W100037

1 3/8"x3 3/8"x61 3/4" (36x86x1570)

(1)

E50 - END SUPPORT - W100949

1 3/8"x3 3/8"x44 1/8" (36x86x1120)

(1)

F1 - ANGLE BRACE - W4L05660

1 3/8"x2 3/8"x20 1/4" (36x60x514)

(8)

E1 - CENTER UPRIGHT - W4L05650

3 3/8"x1 3/8"x59" (86.0x36.0x1500.0)

(2)

Parts Identification

Wood Components

(NOT TO SCALE)

Parts Identification

Wood Components

(NOT TO SCALE)

H2 - WALL RAIL - W4L05666

1"x3 3/8"x56 1/2" (24.0x86.0x1434.0)

(2)

G50 - GROUND BOARD - W100947

1"x5 1/4"x86 3/4" (24x134x2202)

(1)

G13 - GROUND BOARD - W4L05655