Backyard Pro 554BP50SSKIT User manual

1
OUTDOOR SEAFOOD BOILER
OPERATION INSTRUCTIONS
KEEP THIS MANUAL FOR FUTURE REFERENCE.
01/2021
554BP50SSKIT, 554BP60ALKIT, 554BP80ALKIT, 554BP100ALKIT

2
Index
Warnings ................................ . 3
Maintenance & Care ....................... .6
............ .8
554BP50SSKIT ......................... .10
554BP60ALKIT ......................... . 11
554BP80ALKIT ......................... . 11
554BP100ALKIT ........................ . 11
Warranty ............................... . 12

3
READ AND UNDERSTAND BEFORE USING THIS PRODUCT
Throughout this manual the words appliance, cooker, fryer/boiler, burner and stove
will be used interchangeably to refer to the Backyard Pro Outdoor Ranges and Cookers.
IF YOU SMELL GAS:
1.
2.
3.
and immediately call your Fire Department.
1.
use (oil, grease or water above 100°F (38°C)). Heated liquid and equipment can remain at
2.
3.
assemble or safely operate this appliance. DO NOT assemble or operate this appliance if
4. This appliance is for OUTDOOR use only. DO NOT use in a building, garage, tent or any other
as a heater.
5.
balcony or deck.
6.
burn, blister or melt.
7.
used with this appliance.
8.
9. If the temperature of cooking oil exceeds 350°F (177°C) or if oil begins to smoke,
immediately turn the burner or gas supply OFF and wait for the temperature to decrease to
10.
12.
for establishing proper oil, grease or water levels.
! WARNING !
Warnings

4
Warnings
13.
14.Never drop food or accessories into hot cooking liquid. Lower food and accessories slowly
the appliance, care shall be taken to avoid burns from hot cooking liquids.
15.
16.
17.
18.DO NOT move the appliance when in use. Allow the cooking vessel to cool to 100°F (38°C)
before moving or storing.
19. Avoid bumping into the hot appliance to prevent any spillage or splashing of hot cooking liquid.
20.
CAN/
DO
beyond 80% full. For proper vapor withdrawal, the 20 lb. (9 kg) cylinder should be used in
damage, personal injury or death.
21.Use Backyard Pro appliances only in accordance with state and local ordinances, or in the
FAILURE TO FOLLOW THESE INSTRUCTIONS MAY RESULT IN FIRE, EXPLOSION, BURN
HAZARD OR CARBON MONOXIDE POISONING WHICH COULD CAUSE
PROPERTY DAMAGE, PERSONAL INJURY OR DEATH.
! WARNING !
NOTE
be ready for use. Do not use in an enclosed area under any circumstances.

5
Warnings
1. Combustible by-products, such as carbon
monoxide, produced when using this product
contain chemicals known to the State of
California to cause cancer, birth defects,
or other reproductive harm.
2. This product contains chemicals, including lead
and lead compounds, known to the State of
California to cause cancer, birth defects, or other
reproductive harm.
Wash your hands after handling this product.
CALIFORNIA PROPOSITION65
!!
WARNING

6
Maintenance & Care
CLEANING THE APPLIANCE
1. Cooker & LP Hose/Regulator:
If necessary, remove any oil or liquid which has spilled onto the unit during cooking with
mild soapy water on a rag and towel dry. Do not immerse the burner unit or hose and
regulator into water as this will cause rust.
2. Aluminum or Stainless Steel Pots:
3. Cast Iron Cookware:
4. Thermometer:
or put in dishwasher.
1.
2.
3. Before each use of the appliance, check the burner/venturi tube for insects, insect nests,
4.
venturi tube using the phillips screwdriver. Assemble and light the cooker again as per the
5. Always use the LP Hose/Regulator assembly supplied with the appliance. Before each use
of the appliance check the LP Hose for evidence of abrasion, wear, cuts or leaks. If there
is any damage to the hose, the hose/regulator assembly must be replaced prior to using
with the appliance.
6. For purchase of any replacement parts which may have become damaged or lost, please
visit WebstaurantStore.com.

7
TIPS FOR CARING FOR ALUMINUM FRY PANS AND BOILING POT
It is not necessary to season aluminum pots before cooking with them. Wash with a liquid dish
washing detergent and towel dry.
has cooked to the outside of the pot while cooking with your outdoor cooker, scrub the outside
of the pot with a steel wool scouring pad.
DO NOT SPRAY OVEN CLEANER ON ALUMINUM POTS TO REMOVE GREASE OR SOOT.
OVEN CLEANER WILL CAUSE THE FINISH TO BECOME DULL.
with soap and steel wool to loosen the food.
NEVER PLACE AN EMPTY ALUMINUM OR STAINLESS STEEL POT ON A LIT COOKER.
Do not store used oil inside your aluminum pot. The salt used in cooking can corrode the pot
INFORMATION REGARDING COOKING OIL
SUGGESTIONS FOR KEEPING USED COOKING OIL:
Maintenance & Care

8
FOR MODELS WITH ADJUSTABLE REGULATORS
1. .
2. OFF reaches
the stop.
3. Open cylinder control valve by turning it counterclockwise as per the diagram .
4. , or use a paper book
. Turn the regulator control toward the ON
procedure.
5. If
6. process
OFF. Wait
NEVER PUT HANDS OR FACE DIRECTLY OVER BURNER WHILE LIGHTING
OR WHILE THE APPLIANCE IS LIT
! WARNING !

9
TURNING OFF AND STORING THE COOKER AFTER USE
1.
2.
regulator is separated from the tank.
3. Storage of this cooker indoors is permissible only if the cylinder is disconnected and removed from
the cooker. Do not use or store cylinder in a building, garage or enclosed area. Read and follow all
FAILURE TO FOLLOW THESE INSTRUCTIONS AND WARNINGS COULD RESULT IN FIRE,
EXPLOSION, BURN HAZARD, OR CARBON MONOXIDE POISONING WHICH COULD
CAUSE PROPERTY DAMAGE, PERSONAL INJURY, OR DEATH.
! WARNING !
! WARNING !

10
FOR ITEM
554BP50SSKIT
HARDWARE FOR ASSEMBLY TOOLS NEEDED FOR ASSEMBLY
INSTRUCTIONS
1.
2
3
4

11
FOR ITEMS
554BP60ALKIT, 554BP80ALKIT, 554BP100ALKIT
HARDWARE FOR ASSEMBLY TOOLS NEEDED FOR ASSEMBLY
INSTRUCTIONS
1.
2
3
4

12
EQUIPMENT LIMITED WARRANTY
To Make a Warranty Claim:
• WebstaurantStore.com: Contact
• The Restaurant Store:
• TheRestaurantStore.com:
HEREBY DISCLAIMS ALL
IMPLIED WARRANTIES, INCLUDING THE IMPLIED WARRANTIES OF MERCHANTABILITY AND OF FITNESS FOR A
PARTICULAR PURPOSE.
This Limited Warranty does not cover:
•
•
•
•
•
•
•
30 days date of purchase