Bakers Pride XOB-424 User manual

BAKERS PRIDE OVEN CO., INC.
30 Pine Street
New Rochelle, NY 10801
[phone] Phone [phone] US & Canada
[phone] Fax www.bakerspride.com WebAddress
INSTALLATION AND OPERATING INSTRUCTIONS
Open Burner Range
INTENDED FOR OTHER THAN HOUSEHOLD USE
RETAIN THIS MANUAL FOR FUTURE REFERENCE
This equipment has been engineered to provide you with year round dependable service
when used according to the instructions in this manual and standard commercial kitchen
practices.
FOR YOUR SAFETY
Do not store or use gasoline or other flammable vapors
or liquids in the vicinity of this or any other appliance.
WARNING
Improper installation, adjustment, alteration, service or Maintenance can cause property
damage, injury or death. Read the installation, operating and maintenance instructions
thoroughly before installing or servicing this equipment.
P/N U4192A 6/04
1
Models: XOB-212, -424, -636, -848
Instructions must be posted in a prominent location. All safety precautions must be
taken in the event the user smells gas. Safety information can be obtained from your
local gas supplier.
D
E
S
I
G
N
C
E
R
T
I
F
I
E
D
R
CERTIFIED
R
R
All manuals and user guides at all-guides.com
all-guides.com

2
IMPORTANT FOR FUTURE REFERENCE
Please complete this information and retain this manual for the life of the equipment. For
Warranty Service and/or Parts, this information is required.
Model Number Serial Number Date Purchased
All manuals and user guides at all-guides.com

3
INDEX
1. INSTALLATION INSTRUCTIONS
2. LIGHTING INSTRUCTIONS
3. MAINTENANCE INSTRUCTIONS
4. WARRANTY
SECTION ITEM PAGE
SECTION ITEM PAGE
SECTION ITEM PAGE
Safety Precautions 3
Unpacking Instructions 4
Gas Connection 4
Leveling Adjustment 4
Lighting Instructions 4
Shutdown Instructions 5
Cleaning Instructions 5
Maintenance Instructions 5
Parts List & Exploded View 6
A
B
C
D
A
B
A
B
C
11
GAS SPECIFICATIONS
Propane Gas Natural Gas
BTU/HR @ 10 W.C. BTU/HR @ 3.5 W.C.
Model Number
XOB-212
XOB-424
XOB-636
XOB-848
60,000 60,000
120,000 120,000
180,000 180,000
240,000 240,000
All manuals and user guides at all-guides.com

4
C.GASCONNECTIONS
1. INSTALLATION INSTRUCTIONS
A. SAFETYPRECAUTIONS
RETAIN THIS MANUAL FOR FUTURE REFERENCE.
B.UNPACKINGINSTRUCTIONS:
FORYOURSAFETY,THE FOLLOWINGSAFETYPRECAUTIONSSHOULDBEFOLLOWEDANDENFORCED.
IFYOU SMELLGAS:
· SHUTOFFGASSUPPLYTOAPPLIANCE
EXTINGUISHOPENFLAMES
· IMMEDIATELYCALLYOUR GASSUPPLIER
Instructions must be posted in a prominent location.All safety precautions must be taken in the event the user smells
gas.Safetyinformationcan be obtainedfromyourlocalgas supplier.
1. Aseparate gas shut-off valve must be installed in the gasline ahead ofthe unit, as requiredby
2. LIGHTING:Followtheinstructionsonpage4.
3. Atleast24inchesmustbeprovidedat the frontof forservicing.
4. When installing, never enclose the bottom area of the unit with a raised curb or other construction that
wouldobstructtheflowofairintotheunit.
5. This unit may be operated with 0 (sides and back) minimum clearance to non-combustible construction
inareasthatare non-combustiblelocationsonly.
6. This installation must conform to local codes, or in absence of local codes to the
, latest edition.In Canada it mustconform to current
(natural gas) or
7. The appliance and its individual shut-off valve must be disconnected from the gas supply piping system
duringany pressuretestingof that systemattestpressuresinexcessof ½ psi(3.45kPa).
8. The appliance must be isolated from the gas supply piping system by closing its individual manual shut-
off valve during any pressure testing of the gas supply piping system at test pressures equal to or less
then½psi (3.45kPa).
9. Thisappliancemustbeinstalled underaventilationhood.
10. Donotobstructthe flowofcombustionandventilationair.
11. Theareaaroundthisandanyothergas appliancemust alwaysbekeptfree and clearfromcombustibles.
Carefully unpack the open burner range and inspect immediately for shipping damages. Your open burner
range was shipped in a carton designed to give maximum protection in normal handling. It was thoroughly inspected
before leaving the factory and the carrier accepted and signed for it. File any claims for shipping damage or
irregularitieswiththecarrier.
codes.
National Fuel Gas Code
ANSI Z223.1/NFPA 54 Natural Gas Installation Code
CAN/CGA B 149.1 CAN/CGA B 149.2 Propane Installation Code for Gas Burning
Appliances& Equipment.
MAIN SHUT-OFF VALVE
PRESSURE REGULATOR
Figure “A”
STANDING PILOT
All manuals and user guides at all-guides.com

5
2. LIGHTING INSTRUCTIONS
A
If you have any questions concerning the installation, operation, maintenance or service of
this product please contact
Technical Service Department at [phone] US & Canada
1. Turn off all gas valves and main Shut-off valve and wait 5 minutes.
2. Turn the main gas valve to ON position and light standing pilots adjacent to each main burner. (FIG. A & B)
3. Repeat the above step for all standing pilots. There should be slight yellow tip on the pilot flame. Make sure all
the pilots are lit.
4. Turn themainburnervalveto theONposition.
5. Torelightfollowsteps1-4.
Forcompleteshutdownturnall the main burnervalvesand maingasvalveto OFFposition.
Clean the unit regularly after use. Burner ports and burner rest should be thoroughly cleaned. Top grates are
easilyremovable.Aftercleaningrinsewith cleanwateranddry with a dry cloth.
Heavysputteringorspillsmay requirecleaningwitha mildovencleaner.
Usemildsoap or detergenttocleanchassisandstainless steelparts.
ToserviceburnersorpilotsTURNOFF GAS SUPPLYandremovetopgrates.
B.SHUTDOWNINSTRUCTIONS
3.MAINTENANCEINSTRUCTIONS
A.CLEANINGINSTRUCTIONS
·
·
·
·
To provide proper operation and insure the safety of the user, this equipment must be maintained and serviced by a trained
maintenance person or an authorized service agency at regular intervals.
1. Burner ports must be thoroughly cleaned. Venturi must be free from grease and lint.
2. All places where oil, grease or food can accumulate must be kept clean all the time.
3. Pilot light must be kept clean and adjusted at the proper flame height to assure constant ignition and to prevent fire flash-
outs caused by delayed ignition.
4. Carelessness, abusive handling, or altering equipment can shorten the life of the equipment and jeopardize the limited
warranty offered by Baker's Pride.
Pilotshouldbe approximately½- ¾ in height. Adjust as requiredbyturningthe pilot adjusting
screwlocatedonthemanifoldpipe.
B.MAINTENANCEINSTRUCTIONS
Figure “B”
GAS VALVE
All manuals and user guides at all-guides.com

6
Page 1 of 1 6/04 Note: When ordering, ALWAYS specify Part #, Model #, Serial #, Voltage/Phase & type of Gas.
Cookline
SERIES
BAKERS
PRIDE
30 Pine Street • New Rochelle • New York • 10801
914 / 576 - 0200
914 / 576 - 0605
1 - 800 - 431 - 2745
www.bakerspride.com
fax
US & Canada
web address
Open Burner Range
XOB
-212, -424, -636, -848
11
12
13
14
1516
17
18
19 21
22
23 24 25 26
27
28
1
2
3
4
5
6
7
8
9
10
20
Model Number - Width Serial Number Type of Gas
XOB-212 XOB-636
XOB-424 XOB-848
24” 48”
12” 36” Natural
L.P. Other
1
2
3
4
5
6
7
8
9
10
11
12
13
14
R3203A
R3204A
R3032X
S1094A
N5803A
M1460A
U1358A
R3205A
R3222P
L5105A
T1247A
S1395A
R1151A
R1150A
Front Venturi
Rear Venturi
Gas Valve
Knob
Aluminum Tubing 3/16"
Pilot Burner
Rating Plate
Orifice, Nat #38
Orifice, LP #52
Burner, Cast Iron
Grate 12" x 13", Cast Iron
Leg 6"
Manifold 48"
Manifold 36"
15
16
17
18
19
20
21
22
23
24
25
26
27
28
R1149A
R1148A
M1008A
M1009A
R3020A
N3023A
U1044X
U4192A
G7018K
G7019K
G7020K
G7010K
U1381A
R3206A
Manifold 24"
Manifold 12"
Pressure Reg, Nat 3.5" WC
Pressure Reg, LP 10" WC
Pilot Valve, Dual
1/8 Plug, Brass
BP Nameplate, 8"
Inst/Op Manual
Front Panel, 12"
Front Panel, 24"
Front Panel, 36"
Front Panel, 48"
Plate, Lighting Instructions
Valve, Gas Shut-Off
Item Part Number Description Item Part Number Description
Models: XOB-212, -424, -636, -848
PARTS LIST & EXPLODED VIEW
BAKERS PRIDE
Inst/Op
Manual
All manuals and user guides at all-guides.com
all-guides.com

7
Notes:
All manuals and user guides at all-guides.com

8
BAKERS PRIDE LIMITED WARRANTY
30 Pine Street New Rochelle, New York 10801
914 / 576 - 0200  US & Canada: 1 - 800 - 431 - 2745  fax 914 / 576 - 0605
BCO Models: One (1) Year limited parts and labor; (1) Year limited door warranty.
GDCO Models: Two (2) Year limited parts and labor; (2) Year limited door warranty.
CO11 Models:
This warranty covers on-site labor, parts and reasonable travel time and travel expenses of the authorized service
representative up to (100) miles, round trip, and (2) hours travel time. The purchaser, however, shall be responsible
Failures caused by erratic voltages or gas supplies,
Unauthorized repair by anyone other than a BAKERS PRIDE
Factory Authorized Service Center,
Damage in shipment,
Alteration, misuse or improper installation,
Thermostats and safety valves with broken capillary tubes,
Accessories  spatulas, forks, steak turners, grate lifters,
oven brushes, scrapers, peels, etc.,
Freight  other than normal UPS charges,
Ordinary wear and tear.
installation by a
This Warranty is in lieu of all other warranties, expressed or implied, and all other obligations or liabilities on the manufacturers part. BAKERS PRIDE
shall in no event be liable for any special, indirect or consequential damages, or in any event for damages in excess of the purchase price of the unit. The
repair or replacement of proven defective parts shall constitute a fulfillment of all obligations under the terms of this warranty.
Form #U4177A 3/04
WHAT IS COVERED This warranty covers defects in material and workmanship under normal use, and applies only to the original purchaser
providing that:
The equipment has not been accidentally or intentionally damaged, altered or misused;
The equipment is properly installed, adjusted, operated and maintained in accordance with National and local
codes, and in accordance with the installation instruction provided with the product;
The serial number rating plate affixed to the equipment has not been defaced or removed.
WHO IS COVERED This warranty is extended to the original purchaser and applies only to equipment purchased for use in the U.S.A.
COVERAGE PERIOD Cyclone Convection Ovens:
Two (2) Year limited parts and labor; (5) Year limited door warranty.
All Other Products: One (1) Year limited parts and labor. Warranty period begins the date of dealer invoice to customer or
ninety (90) days after shipment date from BAKERS PRIDE - whichever comes first.
WARRANTY
COVERAGE for all
expenses related to travel, including time, mileage and shipping expenses on smaller counter models that may be carried into
a Factory Authorized Service Center, including the following models: PX-14, PX-16, P18, P22S, P24S, PD-4, PDC, WS
Series and BK-18.
EXCEPTIONS All removable parts in BAKERS PRIDE Char-broilers, including but not limited to: Burners, Grates, Radiants, Stones and
Valves, are covered for a period of SIX MONTHS.
All Ceramic Baking Decks are covered for a period of THREE MONTHS. The installation of these replacement decks is the
responsibility of the purchaser.
The extended Cyclone door warranty years 3 through 5 is a parts only warranty and does not include labor, travel, milage or
any other charges.
EXCLUSIONS
Negligence or acts of God,
Thermostat calibrations after (30) days from equipment
installation date,
Air and Gas adjustments,
Light bulbs,
Glass doors and door adjustments,
Fuses,
Char-broiler work decks and cutting boards,
Tightening of conveyor chains,
Adjustments to burner flames and cleaning of pilot burners,
Tightening of screws or fasteners,
INSTALLATION Leveling and installation of decks, as well as proper installation and check out of all new equipment  per appropriate
installation and use materials  is the responsibility of the dealer or installer, not the manufacturer.
REPLACEMENT BAKERS PRIDE genuine Factory OEM parts receive a (90) day materials warranty effective from the date of
PARTS BAKERS PRIDE Factory Authorized Service Center.
!
!
!
4.
All manuals and user guides at all-guides.com