Bar Maid Glass Washer User manual

ELECTRIC
GLASS WASHERS
Bar Maid Corporation
2950 N.W. 22nd Terrace • Pompano Beach, FL 33069-1045
Tel: [phone] • Fax: [phone]
www.bestinthebar.com
Congratulations on your purchase of the finest Glass Washer made.
Bar Maid®machines are manufactured and tested to meet the toughest safety and
sanitation standards. We are pleased to offer a 2-year limited warranty on our glass
washers. Registration is required to receive the 2nd year of warranty.
Please follow these instructions carefully. Failing to do so in some cases may damage
the machine, cause injury to the operator and/or void warranty.

SAFETY INFORMATION
THESE CAUTION MARKS ARE LOCATED THROUGHOUT THIS GUIDE.
= Lightning ash within a triangle, is to alert the user of the presence of dangerous
voltage that may create a risk of electric shock. Do not open cover. No user serviceable
parts within.
= The exclamation point within a triangle is to alert the user to:
• “CAUTION” important information regarding the care and use of this equipment
• “WARNING” possibility of personal injury
= Power off
= Power on
IMPORTANT SAFEGUARDS! PLEASE READ THIS FIRST
Follow these basic safety precautions when this using electrical appliance to reduce the risk
of fire, electric shock and/or personal injury.
WARNING: Keep all loose items including hair, clothing and towels clear of machine
brushes at all times – entanglement could cause bodily harm to the machine operator.
WARNING: “A” Model Upright machine motors are water resistant but NOT SUBMERSIBLE.
Do not use “A” Model Upright machines in sinks or tanks where there is a risk of falling
over or submersing the motor.
WARNING: Observe the water level labels on machines. Do not overfill tanks. Never fully
submerse any Glass Washer motor.
WARNING: Special SS Model cord requires original replacement part available only from
Bar Maid Corporation. Contact Bar Maid Corporation for replacement.
WARNING: Motors may get hot with extended use. Turn off when not in use.
WARNING: Plug unit only into a GROUNDED outlet that matches the voltage/cycle as
listed on the motor. Outlet must be equipped with a UL/CSA approved ground-fault circuit
interrupter (G.F.C.I.).
WARNING: Keep electrical cord clear of brushes and water.
WARNING: Switches and switch boxes (for SS Model) must NOT contact water. ATTACH
BOX TO A DRY LOCATION with screws provided.
CAUTION: DO NOT operate machine out of water.
WARNING: DO NOT use any machine if the power cord or motor housing is cracked or
damaged.
CAUTION: Ensure brushes are securely in place before turning machine on.
CAUTION: Use machine only for the purpose it was intended.
WARNING: Disconnect from the power source before servicing.
WARNING: Do not use if any parts are cracked, broken or leaking oil.

CAUTION: Do not attempt to open or service the Submersible (SS) motor. No user
serviceable parts. Call Bar Maid Customer Service at 1-866-531-6243 for service
assistance.
CAUTION: Use only genuine Bar Maid®replacement parts.
CAUTION: Keep machines upright!! Lying on side may cause damage.
OPERATING INSTRUCTIONS – ALL MODELS
WARNING: Place unit in sink and fill with warm water to the top of the lowest brushes
or the water line label. Water must be comfortable to touch. Add a quality liquid “low
suds” detergent such as Bar Maid® LoSUDS®. Granular (powder) detergents are not
recommended as they can be abrasive and cause premature wear to gears and bearings.
WARNING: Plug machine into a grounded, G.F.C.I. (ground-fault circuit interrupter)
equipped outlet. Test and reset. Turn machine on.
IMPORTANT NOTE: SS Model Submersible machines will heat water but are equipped
with a thermal cut-off to protect from over-heating. Excessively hot water may cause
the machine to shut off. If this occurs, drain sink and refill with only room temperature
water. Wait 20 minutes for machine to cool down, test and reset the G.F.C.I. at the end
of the power cord and then restart. If machine fails to start, test circuit breakers and/or
receptacle.
For best results, wash one glass at a time. Always start the Glass Washer before placing
glass over the brush. The center brush scrubs the inside of the glass while the four outside
brushes wash the outside. If taller glasses are washed, a longer center brush can be used,
(see Brushes). Rinse in fresh water in second sink, then in third sink sanitize the glass.
Let drain.
CARE AND MAINTENANCE
A FEW SIMPLE PROCEDURES WILL HELP ENSURE A LONG, TROUBLE-FREE LIFE:
1. When closing for the day, drain sink and wipe off machine
2. LET WASHER DRY overnight.
3. Once per month, carefully lift off rubber band that protects gear housing. Immerse machine
in enough water to cover brushes and add a half cup of vinegar or bleach. Run machine for
ten minutes, rinse thoroughly and replace band. Check overall condition. If any parts appear
cracked or damaged, please call 1-800-526-5278 or 954-960-1468. Troubleshooting advice
can also be found online at www.bestinthebar.com.
2-YEAR LIMITED WARRANTY
Bar Maid Corporation provides a one year Limited Warranty with a second year of coverage
providing the owner sends in the warranty registration envelope within 21 days of purchase.
You MUST REGISTER to get year 2 of the warranty. For warranty service information please call
1-866-531-6243.

BRUSHES, LOSUDS, SANITIZER AND TEST STRIPS
BAR MAID OFFERS HUNDREDS OF PRODUCTS!
VISIT WWW.BESTINTHEBAR.COM TO SEE OUR COMPLETE LINE OF PRODUCTS.
BRS-732SG
Perfect brush for
Shot Glasses
BRS-930
Wide coffee pots
and pitchers
BRS-935
Narrow top
coffee pots
BRS-950
Margarita &
Martini glasses
BRS-980
4 inch Muffin
Pan Brush
BRS-917SL
BRS-920SL
BRS-922SL
BRS-975SL
Universal
Slotted Brush
BRS-930
Wide coffee pots
and pitchers
BRS-917
BRS-920
BRS-922
BRS-975
Pinned Brush
BRS-1722, BRS-1720SL
Electric Glass Washer
Replacement Brush Set
DIS-202
Quaternary Sanitizer
Test Strips
DIS-302
Chlorinated Sanitizer
Test Strips
DIS-201
Quaternary Tablet Sanitizer
for Kitchen and Bar,
3rd Sink & Surface
DET-200
Detergent for electric
glass washers
GP-100
Glass
Polisher
TAP-BRUSH
Beer Tap Cap Brush
TAP-CAP
Beer Tap Cap
CR-100P
Glass Rimmer
TAP-STRIP
Drip Tray
Odor Inhibitor
GP-1M
Glass Polishing Wand WEG-816
Citrus Wedger
FB-TS20, FB-TS30
FB-TS35, FB-TS40
Floor Drain Trap Seal
FLY-BYE
Fruit Fly Traps
CR-835W-N
82oz Scoop
CR-1600
Shooter
Tube Rack
CR-220P
Speed Pourer
BMP-5100B
1oz Premium
Pourer
CR-1252W
Pocket
Corkscrew