Belgard DESIGNFORMS SQUARE COFFEE TABLE User manual

SQUARE COFFEE TABLE

1
SQUARE COFFEE TABLE
COMPONENTS
27.50”
27.50”
19.30”
Small Panel (x4)
6" x 24"
Large Panel (x4)
12" x 24"
Hardware Kit (x2)
19¼"
27½" 27½"

2
SQUARE COFFEE TABLE
2" x6" x8'
PRESSURE TREATED
WOOD
OUTDOOR
SILICONE
#8 2½"
DECK SCREW
WOOD CUTS 1 = 27½"
2 =20½"
111
1 1 2 2
1
2
x1x2 x20
1 1
211

3
SQUARE COFFEE TABLE
REQUIRED TOOLS
SAFETY EQUIPMENT
MIN 1¾"
DEEP HEX SOCKET
7/16" WITH 1/4" DRIVE
SOCKET ADAPTOR
1/4" HEX SHANK TO 1/4" DRIVE
DRILL SKILL SAW
MEASURING TAPE
GLOVES
CARPENTER SQUARE
SAFETY GLASSES
LEVEL
SAFETY BOOTS
RUBBER MALLET

4
TIPS & TRICKS
READ ALL INSTRUCTIONS BEFORE ASSEMBLY
PREBUILD:
• Prebuild all hardware prior to starting build.
• When assembling hardware SNAP the bolt into place
with the plastic sliders. Pressing down on something
at and hard will help. (Fig. A)
• Do not over hand tighten the slider/bolt piece and the
nut on the completed brackets. They should be loosely
attached so they slide into the channels on the panels.
Leave a space of ¼ in. (Fig. B)
INSTALL:
• Always start in the corner when starting a build. (Fig. C)
• Set the drill clutch (torque) at a low level to deliver a
torque range of 50-65lbs per inch. Refer to your drill
manual for torque adjustment instructions.
• Use a rubber mallet to assist with moving/aligning/
adjusting panel placement during assembly.
WHEN BUILDING WOODEN COMPONENTS:
• Do not exceed prescribed length. Exact measurements
are required for proper assembly.
• Ensure your cuts are straight.
• Do not over tighten the screws into the wood
- this can cause buckling.
• Pre-drill holes for 45º corner assemblies.
• Use cedar or pressure treated wood for outdoor use.
• Seal wooden components for prolonged use.
WHEN BUILDING PLANTERS:
• Line the inside of the planters or garden beds with a
geotextile fabric to help with water management.
90°
Fig. A
Fig. B
Fig. C

5
BASE PREPARATION
SLAB OR PAVER
SLAB OR PAVER
BEDDING SAND 1"
COMPACTED AGGREGATES 6"- 8"
COMPACTED AGGREGATES 6"- 8"
COMPACTED AGGREGATES 6"- 8"
SOIL
SOIL
SOIL
REINFORCED POURED CONCRETE FOUNDATION 2"
ALWAYS LEVEL GROUND BEFORE INSTALLATION
ON COMPACTED FOUNDATION
ON POURED CONCRETE
ON NEW OR EXISTING PATIO
SQUARE COFFEE TABLE

6
BRACKET A x2 x3 x1 x3 x2
2
1
x4
BRACKET B
1
x2 x1 x1 x1
2
x4
BRACKET H ASSEMBLY I
Use with
BRACKETS B and H
during build
x16 J x16
1
x1 x1
x4
SQUARE COFFEE TABLE

7
2
1
90°
A
90º
6”
6"
A
SQUARE COFFEE TABLE

8
4
3
A
A
d1 = d2
d1
d2
SQUARE COFFEE TABLE

9
6
5
x 4
SQUARE COFFEE TABLE
I
I
x4
x3
Insert Assembly I
now for use later
with Bracket B
and Bracket H

10
7
8
SQUARE COFFEE TABLE
H
I
J
J
J
x3

11
9
SQUARE COFFEE TABLE
J J
J
J
B
H

12
10
SQUARE COFFEE TABLE
I
x3

13
SQUARE COFFEE TABLE
11
B
H
J
J J
J

14
14
SQUARE COFFEE TABLE
12
I
x3

15
14
SQUARE COFFEE TABLE
13
J
J
B
J
J
J
J
H
B

16
SQUARE COFFEE TABLE
14
3¹/”
3¹/”
21”
21"
3½"
3¼"
15 x20

17
SQUARE COFFEE TABLE
16
17
© Copyright 2022 Oldcastle, APG Inc. All Rights Reserved. BEL22-D-8950