Best Barns Belmont II Safety guide

the Belmont II
Revised September 6, 2022
Assembly Book
Best Barns USA
!"#$%#&'()#*+
,-.(/(-0.
12#3(45&"5$(#3(6789:#'2;+%<(=&%+:(;2+(6789:#'2;($5>3?(;2#3(45&"5$
459(&7;(@+(678#+%?(#&(>27$+(7:(#&(85:;?(>#;27";(67&3+&;(A:74
((((((B!)(C7$%#&'3?(DDE (((((F((E789:#'2;(-G--
Manufactured by RBS Holdings, LLC
205 Arlington Drive Greenville, PA 16125

Tongue Edge
LAP Edge
800-245-1577(H(I7&(H(J:#(KLI(H(MNI(O)1
724-866-4357(H(LA;+:(27":3(5&%(>++P+&%3
Email(H(Q"+3;#7&3R@5:&P#;3<674
IMPORTANT INFORMATION ABOUT YOUR KIT
125&P 97" A7: 8":6253#&' 7": P#;< N$+53+ :+5% ;2+ A7$$7>#&' #&A7:45;#7& @+A7:+ @+'#&&#&' 67&3;:"6;#7&<
L$>593(62+6P(>#;2(97":($765$(CSL(7:(@"#$%#&'(67%+(7AA#6+(A7:(5&9(:+Q"#:+4+&;3(7:(:+3;:#6;#7&3<
177$3(B+Q"#:+%T C5&%(7:(E#:6"$5:()5>
E7:%$+33(U:#$$
C544+:
N+&6#$
D+V+$
I+53":#&'(158+
W.HK.(D5%%+:X3Y
)5A+;9(Z$533+3
U"3;(I53P
N2#$$#83()6:+>%:#V+:
J:54#&'()Q"5:+
Always wear safety glasses when cutting or nailing!
L%%#;#7&5$ I5;+:#5$3 H Not included in kit:
B+Q"#:+%T )2#&'$+3(7:(4+;5$(:77A#&'?(U:#8(O%'+?(B77A#&'([5#$3(7:()6:+>3?(N5#&;
S8;#7&5$T E5"$P?(B#%'+(\+&;
J$77:T ]77%(A$77:#&'(#3(37$%(78;#7&5$$9<(^7"(459(62773+(;7(@"#$%(97":(7>&(7:(87":(5(6+4+&;(85%<
1+:4#&7$7'9T
)Q"5:+(H(E7&A#:4(67:&+:3(5:+(5;(_G(%+':++3
N$"4@(H(E7&A#:4(>5$$3(5&%(;:"33+3(5:+(3;:5#'2;(V+:;#65$$9
]5$$(N$5;+(H(178(5&%(@7;;74(-/03("3+%(;7(A:54+(>5$$3
1#+(N$5;+(H(-/03(67&&+6;#&'(>5$$(3+6;#7&3(;7'+;2+:
C+5%+:(H()85&3(;78(7A(%77:(78+&#&'
S)!(H(S:#+&;+%();:5&%(!75:%
DLN(H(O%'+(7A(3#%#&'(;25;(7V+:$583(17&'"+
17&'"+(H(O%'+(7A(3#%#&'(;25;(#3(7V+:$588+%
S:'5&#*+T
=&856P(5$$(#;+43(`(7:'5&#*+(5667:%#&'(;7(3#*+(5&%(;98+<(12#3(>#$$(45P+(#;+43(+53#+:(;7(A#&%
>2+&(#&3;:"6;+%<
B+V#+>(;2+(85:;3($#3;(7&(;2+(@56P(85'+<()27"$%(;2+:+(@+(4#33#&'(#;+43(7:(3"@H85:(45;+:#5$
67&;56;(!+3;(!5:&3(E"3;74+:()+:V#6+<
US([S1(%#365:%(5&9(45;+:#5$(#&6$"%#&'(;2+(85$$+;("&;#$(97":(8:7a+6;(#3(6748$+;+<
L33+4@$9T
B+V#+>(5$$(#&3;:"6;#7&3(@+A7:+(97"(@+'#&<(N$+53+(A7$$7>(3;+83(65:+A"$$9(5&%(#&(3+Q"+&6+(A7:
3"66+33A"$(:+3"$;3<
bA(97"(25V+(5&9(Q"+3;#7&3(>+(5:+(25889(;7(533#3;(97"<(N$+53+(67&;56;("3(5;T
Primed Siding Detail

-< E"; X,GY ;+& -/0H,-. A$77: a7#3; ;7 ,,.H_c< Treated lumber may be thicker than 1-1/2". Take this
into account when cutting the length of floor joists. Shorten the joist measurements if necessary
to obtain 12'-0" building width.
d< N$56+(0/0H,-.(;:+5;+%(;#4@+:3(7&(;2+(':7"&%<(E";(X-Y(;>7(-/0HK.(@75:%3(#&;7(-.($7&'(@$76P3(;7
3+6":+(;2+(0/03(>2+:+(;2+9(@";;(;7'+;2+:<
Assembly Instructions for Rear Floor Section
XXXX
XXXX
X
X
0< b&3;5$$ ;2+ A$77: a7#3;3 6"; 5@7V+ @+;>++& ;2+ ,-. a7#3; 2+5%+:3< )+6":+ >#;2 ,W% '5$V< %+6P &5#$3<
M< N$56+ A$77: 3+6;#7&3 7V+: ;2+ 0/03< )Q"5:+ A$77:< I+53":+ ;2+ A$77: %#5'7&5$$9 X67:&+: ;7 67:&+:Y<
12+3+(4+53":+4+&;3(>#$$(@+(;2+(354+(#A(;2+(A$77:(#3(3Q"5:+(X-GdHMeKcY<(17(P++8(;2+(-/0(A:54+
A:74(47V#&'?(;7+&5#$(A:54+(;7(;2+(0/0(:"&&+:3<
4x4-12' Treated
Runner
4x8 Flooring
2x4-12' Joist Header
4x4-12' Treated
Runner
Foundation size is 12'-0" x 24'-0". E2+6P $765$ @"#$%#&' 67%+3 #& 97": 5:+5? ;2+ 67&3;:"6;#7& 459
25V+ ;7 625&'+< J7: 5 67&6:+;+ 3$5@? #&3;5$$ 3#$$ 3+5$+: 53 5 47#3;":+ @5::#+: @+;>++& ;2+ 67&6:+;+ 5&%
;2+(>5$$(8$5;+3<(J754(3#$$(3+5$+:(65&(@+(8":6253+%(5;(274+(6+&;+:3(#&(:7$$3(dH,e-c(7:(>#%+:<
,< E"; X-Y ;>7 -/0H,-. ;7 5 $+&';2 7A ,-. HGc< 12+9
>#$$ @+ "3+% A7: ;2+ a7#3; 2+5%+:3< D597";? A:74
;2+ $+A;? A7: ,Wc 7& 6+&;+: a7#3; 3856#&'< 12+ .f.
45:P3(>2+:+(A$77:(a7#3;(>#$$(@+(8$56+%<
W< B+8+5;(3;+8(&"4@+:(,(5&%(-(5@7V+(5&%(533+4@$+
5&7;2+:(A$77:(3+6;#7&<
g< b&3;5$$(;2#3(3+6;#7&(5'5#&3;(;2+(A:7&;(A$77:(3+6;#7&<
[5#$(;7'+;2+:(>#;2(,W%('5$V<(%+6P(&5#$3<
K< b&3;5$$(0/K(A$77:#&'(7V+:(;2+(-/03<(=3+(K%('5$V<
38#:5$(&5#$3<
Details for Optional Deluxe Floor System
Material Description 12' x 24'
-/0 !$76P3 -(863< K.
-/0 h7#3;(C+5%+:3 0(863< ,-.
-/0 J$77:(h7#3; -G(863< ,-.
0/0 1:+5;+%(B"&&+:3 K(863< ,-.
J$77:#&'((((MeKc(7:(de0c _(863< 0/K
)6:+>(J$77:([5#$3 0($@< K%
Z5$V<(!7/([5#$3 M($@< ,W%
2x4-2' Treated
Blocks
Front Floor Section
15-1/4" 16" 16" 16"

X
X
X
X
X
X
X
X
Depending on your location pre-cut wall studs vary in
length from 92-1/4" to 93". This doesn't affect construction.
Step 1 Assemble 12' Back Wall
LAP
Edge
d< )Q"5:+(>5$$(A:54+<(I+53":+(;2+(>5$$(%#5'7&5$$9(X67:&+:(;7(67:&+:Y<(12+&(4+53":+
;2+(78873#;+(67:&+:3<(12+3+(4+53":+4+&;3(>#$$(@+(;2+(354+(#A(;2+(>5$$(#3(3Q"5:+<
,< E"; X-Y ;>7 -/0H,-. ;7 5 $+&';2 7A
,00c< N73#;#7& ;2+ @75:%3 ;7'+;2+: 5&%
#&%#65;+ >#;2 .f. 45:P3 >2+:+ ;2+
>5$$(3;"%3(>#$$(@+($765;+%< 24"
23-1/4"
,00c Wall Plate
24"
144" Wall Plate
Pre-Cut Wall Studs
-< b&3;5$$ XgY 3+V+& 8:+H6"; >5$$ 3;"%3 @+;>++& ;2+ ;78 ` @7;;74 8$5;+3<
[5#$ 3;"%3 ;7 >5$$ 8$5;+3 >#;2 ,G% 3#&P+:3? X-Y ;>7 &5#$3 7& +562 +&%<
M< b&3;5$$ X-Y ;>7 47:+ 3#%#&' 85&+$3< bA &+6+335:9
6"; ;2+ $53; 85&+$ A$"32 >#;2 ;2+ +&% 7A ;2+ A:54+<
0< b&3;5$$(;2+(A#:3;(3#%#&'(85&+$(>#;2(;2+(.DLN.(+%'+(A$"32(>#;2
;2+ +&% 7A ;2+ >5$$< )#%#&' >#$$ +/;+&% de0c @+$7> ;2+ @7;;74
8$5;+<([5#$(3#%#&'(>#;2(W%('5$V<(&5#$3?(3856+%(Kc(585:;<
Tip: use a 1x4 trim board as a gauge.
Siding Extends 3/4" Below Plate
Siding Flush

XX
XX
X
X
C
X
X
Stud Spacing
T
T
T
T
T
T
Step 2 Assemble 140-1/2" Side Walls
Step 3 Assemble Door Header
0< B+8+5;(;7(533+4@$+(XdY(;2:++(47:+(,0GH,e-c($7&'(>5$$(A:54+3<(12+(3#%#&'(>#$$(@+(588$#+%(5A;+:
;2+(>5$$3(5:+(3+;(7&(;2+(A$77:<
d< b&3;5$$ XgY 3+V+& 8:+H6"; >5$$ 3;"%3
@+;>++&(;2+(;78(`(@7;;74(8$5;+3
>#;2(,G%(3#&P+:3<
(,0GH,e-c Wall Plates
24"
19-3/4" 24"
Top Wall Plate
Bottom Plate
75" Long 2x8
48" OSB Filler
Cut OSB to fit
,< D765;+(X-Y(;>7(-/KHK.(@75:%3<(E";(;2+3+(@75:%3(;7(5($+&';2(7A(gMc<
-< L33+4@$+ ;2+ %77: 2+5%+: "3#&' -/K @75:%3 5&% X-Y ;>7 gH,e0c / 0Kc S)! A#$$+: #&6$"%+% #& 7":
P#;<(L88$9(>77%('$"+(>#;2(5(@:"32(;7(@7;2(3#%+3(7A(S)!(5&%(#&3;5$$(X,Y(7&+(A#$$+:(;7(7&+(+&%<(E";
;7(A#;(3+67&%(S)!(A#$$+:<([5#$(;7'+;2+:(>#;2(X,-Y(;>+$V+(,G%(3#&P+:3(3856+%(+V+&$9(7&(+562(3#%+<
C
140-1/2" Wall Plate
Pre-Cut
Wall Studs
,< E";(X-Y(;>7(-/0H,-.(;7(5($+&';2(7A(,0GH,e-c<(N73#;#7&(;2+(@75:%3(;7'+;2+:(5&%(#&%#65;+(>#;2(.f.
45:P3(>2+:+(;2+(>5$$(3;"%3(>#$$(@+($765;+%<
-< I5:P(5(.E.(5&9>2+:+(@+;>++&(A#:3;(;>7(3;"%(45:P3<(12#3(#3(:+A+:+&6+%(#&(5($5;+:(3;+8<

X
X
X
X
X
X
X
X
X
X
X
X
Step 4 Assemble Front Wall Frame
,< E"; X-Y ;>7 -/0H,-. @75:%3 ;7 5 $+&';2 7A ,00c A7: >5$$ 8$5;+3< N73#;#7& ;2+ @75:%3 ;7'+;2+: 5&%
#&%#65;+(>#;2(.f.(I5:P3(>2+:+(;2+(>5$$(3;"%3(>#$$(@+($765;+%<
d< E";(X-Y(8:+H6";(3;"%3(;7(5
$+&';2(7A(gKH,e-c(5&%(#&3;5$$
53(2+5%+:(3"887:;3(>2+:+
327>&< [5#$ ;7 3;"%3 >#;2 ,G%
3#&P+:3<
0< b&3;5$$(;2+(%77:(2+5%+:(7&(;2+
-/0(2+5%+:(3"887:;3<([5#$(;7
;2+(3;"%(>#;2(,G%(3#&P+:3<
M< I+53":+ 3856+ @+;>++& 2+5%+:
5&% ;78 8$5;+< E"; A:74 5 8:+H
6"; 3;"% X0Y A7": 8#+6+3 ;7 ;2#3
$+&';2<(OV+&$9(3856+(8#+6+3
5&% &5#$ ;2:7"'2 ;78 8$5;+ 5&%
;7+&5#$(;7(2+5%+:<(=3+(,G%
3#&P+:3<
Install these Studs Centered
-< b&3;5$$(XWY(3#/(8:+H6";(>5$$(3;"%3(@+;>++&(;2+(>5$$(8$5;+3(>2+:+(327>&<
33" 33"
K< b&3;5$$(5(A"$$(>#%;2(3#%#&'(85&+$(7&(;2+(:#'2;(3#%+(7A
;2+(>5$$(85&+$<(E";(3#%#&'(53(8:+V#7"3$9(#&3;:"6;+%<
'LAP' Edge Flush
Flush
Cut Siding Flush
2x8 Door Header
78-1/2" Header Support
nail nail
2x4 Blocks
72" Between Header Supports
Siding Extends 3/4" Below Plate
W< N$56+(5(A"$$(>#%;2(3#%#&'(85&+$(>#;2(;2+(.DLN.(+%'+(A$"32(>#;2($+A;(3#%+(7A(>5$$(A:54+<()#%#&'
327"$% +/;+&% de0c @+$7> @7;;74 8$5;+< !+A7:+ &5#$#&' 3#%#&'? 6"; ;2+ 3#%#&' A$"32 >#;2 ;2+ 3#%+
7A(;2+(%77:(78+&#&'(5&%(@7;;74(7A(;2+(%77:(2+5%+:<
g< b&3;5$$(5(-Gc/0Kc(3#%#&'(85&+$(5@7V+(;2+(%77:(78+&#&'<(E";(;2+(3#%#&'(A$"32(>#;2(;2+(3#%+(7A
;2+(%77:(78+&#&'(5&%(@7;;74(7A(;2+(%77:(2+5%+:<

Temporary Nails
EndMarked 'C'
EndMarked 'C'
End Marked 'C'
Tip:((If you are erectingbuilding on a wood floor insert
nails between the 3/4" floor sheathing and the 2x4 floor
frame. Rest the siding on the nails while nailing to frame.
,< O:+6; @56P >5$$ 5&% ,0GH,e-c 3#%+ >5$$3< IMPORTANTT b&3;5$$ ;2+ 3#%+ >5$$ A:54+3 >#;2 ;2+
.E. 45:P3 7:#+&;+% 5'5#&3; ;2+ @56P 5&% A:7&; >5$$ 67:&+:3< )+6":+ >5$$3 ;7'+;2+: 5; ;2+ 67:&+:3<
=3+ X0Y A7": ,G% 3#&P+:3 8+: 67:&+:< !:56+ 3#%+ >5$$3 >#;2 8:+H6"; >5$$ 3;"%3 ;7 27$% >5$$3 3+6":+
5&%(8$"4@<
-< E";(5(3#%#&'(85&+$(#&(25$A($+&';2>593<()+$+6;(;2+(85&+$(>#;2(;2+(.;7&'"+.(+%'+<(b&3;5$$(;2#3(85&+$
>#;2 ;2+ 6"; +%'+ A$"32 >#;2 ;2+ 3#%#&' 7& ;2+ @56P >5$$< )#%#&' 327"$% +/;+&% de0c @+$7> @7;;74
8$5;+<([5#$(3#%#&'(;7(@56P(>5$$(5&%(5$$(-/03("3#&'(W%('5$V<(&5#$3(3856+%(Kc(585:;<
Step 5 Set Walls
d< b&3;5$$(XMY(A#V+(A"$$(>#%;2(3#%#&'(85&+$3<(b&3;5$$
-0c(>#%+(3#%#&'(;7(A#&#32<()#%#&'(327"$%(+/;+&%
&7(47:+(;25&(dH,e-c(853;(>5$$(;7(:+6+#V+(A:7&;
>5$$(85&+$<
0< B+8+5;(;7(3#%+(78873#;+(3#%+(>5$$<
M< O:+6;(A:7&;(>5$$(85&+$(5&%(3+6":+(67:&+:3(>#;2
,G%(3#&P+:3(5&%(&5#$(3#%+(>5$$(3#%#&'(;7(-/03<
!:56+(>#;2(8:+H6";(>5$$(3;"%3<
W< E";(5&%(:+47V+(@7;;74(-/0(A:74(%77:(78+&#&'<
g< [5#$(>5$$3(;7(A$77:(;2:7"'2(@7;;74(8$5;+<()856+(,G%(3#&P+:3(-0c(585:;<
Back Wall
Siding Extends
3/4" Below Plate Cut 2x4 Plate
from Opening
Cut Edge

Step 6 Install 2x4 Tie Plates
,< E"; 5 -/0H,-. @75:% #& 25$A< b&3;5$$ 5 -/0HW. 7& 5 3#%+ >5$$? A$"32 >#;2 ;2+ -/0 7& ;2+ @56P >5$$<
b&3;5$$ 5 -/0H,-. &+/;< b&3;5$$ ;2+ -&% W. $7&' -/0 A$"32 >#;2 ;2+ -/0 7& ;2+ A:7&; >5$$< E"; $+&';2
;7(A#;<(=3+(,G%(3#&P+:3(;7(3+6":+(;2+(;#+(8$5;+3(;7(A:7&;(5&%(@56P(>5$$3(5&%(5$7&'($+&';2<
-< B+8+5;(;7(#&3;5$$(-/03(7&(;2+(78873#;+(3#%+(>5$$<
d< E"; X-Y ;>7 ,-. $7&' -/03 ;7 A#; @+;>++& 3#%+ >5$$ ;#+ 8$5;+3 5&% #&3;5$$ 7& A:7&; 5&% @56P >5$$3<
Cut 2x4-12' to Fit
2x4-6' Tie Plate
2x4-12' Tie Plate
Step 7 Install Metal 2x4 Joist Hangers
b&3;5$$(X--Y(;>+&;9(;>7(-/0(a7#3;(25&'+:3(5$#'&+%
>#;2(;2+(>5$$(3;"%3(7&(@7;2(3#%+(>5$$3<(=3+(5(327:;
-/0(@$76P(53(5('5"'+(;7(+&3":+(;2+(-/03?(#&3;5$$+%
#& &+/; 3;+8? >#$$ @+ A$"32 >#;2 ;2+ ;78 7A ;2+ -/0 ;#+
8$5;+ >2+& #&3;5$$+%< )+6":+ ;2+ 25&'+: >#;2 ,H,e-c
25&'+:(&5#$3<
2x4 Gauge Block
2x4-6' Tie Plate

Step 8 Install Loft Floor
Step 9A Install Loft Floor Sheathing
Before installing floor sheathing consider where to locate the 2' x 4' access
opening. The detail below shows one possibility. Regardless of desired
layout it is important to install sheathing staggered when possible.
4' x 8'
Suggested 2'x4 Opening Location
4' x 8'
4' x 8'
2' x 4'
Important: Before securing the 2x4 floor joists make sure the side walls are plumb. The
building width should be 12'-0" measuring from the outside of the 2x4 tie plates.
4' x 8'
E";(X,,Y(+$+V+&(-/0H,-.(@75:%3(;7(5($+&';2(7A(,dgc(5&%(#&3;5$$
#&(;2+(4+;5$(25&'+:3<(=3+(,H,e-c(25&'+:(&5#$3<
4' x 4'
Cut a 4' x 8'
in half
4' x 4'
4' x 4'
Cut a 4' x 8'
in half

3-1/2" x 24" OSB Filler
IMPORTANT: Do not
placeheavyweighton loft
at this point.
96" Between OSB Fillers
Back
Wall Side
Wall
1x3 Corner Trim
Step 10 Install Corner Trim
IMPORTANT: Lower Trim Must Be Installed Before Installing Roof Gables!
1x4 Trim Boards
d< b&3;5$$(X-Y(;>7(g-c($7&'(,/0(;:#4
@75:%3(@+;>++&(67:&+:(@75:%3<(1:#4
327"$% @+ A$"32 >#;2 S)! 32+5;2#&'<
E";(-&%(@75:%(;7(A#;<
0< B+8+5;(;7(#&3;5$$(;:#4(@75:%3(;7(;2+
A:7&;(>5$$(85&+$<
Step 9B Install Loft Floor Sheathing continued
Siding Filler
OSB Filler
,< D765;+(XdY(;2:++(-c(/(0KHde0c(A#$$+:(3;:#83<([5#$(;2+3+(7&(;78(7A(;2+(3#%#&'(7&(;2+(@56P(>5$$<
=3+(W%('5$V<(&5#$3<
-< b&3;5$$ X-Y ;>7 __c $7&' ,/d ;:#4 @75:%3 53 67:&+: ;:#4 ;7 ;2+ @56P >5$$< E"; $+&';2 37 ;:#4
#3(A$"32(>#;2(;78(7A(S)!(A#$$+:(5&%(@7;;74(7A(3#%#&'<(b&3;5$$(;:#4(A$"32(>#;2(;2+(3#%#&'(7&
;2+(3#%+(>5$$3<(=3+(W%('5$V<(&5#$3(3856+%(,-c(585:;(;7(#&3;5$$(5$$(;:#4<
,< D765;+(X0Y(A7":(dH,e-c(/(-0c(S)!(A#$$+:3<(b&3;5$$(5;(A:7&;(5&%(@56P(67:&+:3(7&(;78(7A(-/0(;#+
8$5;+3<(=3+(X0Y(A7":(W%(67447&(&5#$3(+562<(b&3":+(;2+(3856+(@+;>++&(A#$$+:3(#3(_Wc<
-< b&3;5$$ $7A; A$77:#&' @+;>++& S)! A#$$+:3< O%'+ 7A 32+5;2#&' 327"$% @+ A$"32 >#;2 A:7&; 5&% @56P
>5$$ ;#+ 8$5;+3< B+A+: ;7 ;2+ 3"''+3;+% $597"; 7& 8:+V#7"3 85'+< b&3;5$$ A$77:#&' "3#&' W% 67447&
&5#$3(3856+%(,-c(585:;<
Back
Wall Side
Wall

Step 11A Assemble Gables
32-1/2" Long 2x4s
49-1/2"
Long 2x4
Right Pre-built
Gable Frame
1x4 Block MUST
be Positioned Here
and Another on
Opposite Side
Gable Stud
Detail 'A'
Temporary
1x4 blocks
5-3/4"x14"
Gusset
,< Z5;2+:(8:+H@"#$;('5@$+(+&%(A:54+3?(X,Y(7&+($+A;(5&%(X,Y(:#'2;?(X,Y(7&+(0_H,e-c($7&'(-/0(5&%(X-Y
;>7(d-H,e-c($7&'(-/03(>#;2(5&'$+%(+&%3<
-< N73#;#7&(;2+3+(67487&+&;3(;7'+;2+:(53(327>&(@+$7><(]2+&(5$#'&+%(67::+6;$9(;2+(@7;;74(-/03
>#$$(@+(3;:5#'2;(5&%(4+53":+(,-.HGc(A:74(+&%(;7(+&%<(Pre-built gable ends highlighted in gray.
d< 1+487:5:#$9(;56P(,/0(@$76P3(;7($7A;(A$77:#&'(5:7"&%(;2+(A:54+(4+4@+:3<(12+3+(@$76P3(>#$$(@+
KcH,-c $7&' 5&% 459 25V+ 5&'$+% +&%3< I5P+ 3":+ X-Y ;>7 7A ;2+3+ @$76P3 5:+ 873#;#7&+% #&3#%+
+562(8:+H@"#$;('5@$+(+&%(A:54+(53(327>&<(N73#;#7&(;2+(:+3;(7A(;2+(@$76P3(588:78:#5;+$9(3856+%
;7(27$%(-/03(#&(8$56+<(12+3+(>#$$(#&3":+(;25;(5$$(;:"33+3(5&%('5@$+3(5:+(@"#$;(+/56;$9(;2+(354+<
US([S1(&5#$(@$76P3(;7('5@$+<
0< )+6":+(;2+(@7;;74(-/0(;7(;2+('5@$+(3;"%("3#&'(X-Y(;>7(-H,e-c(36:+>3<
M< D765;+ X-Y ;>7 MHde0c/,0c S)! '"33+;3< L;;562 ;2+3+ ;7 ;78 7A +562 '5@$+ 3;"% ;7 3+6":+ A:54+
;7(d-H,e-c(-/03<(=3+(W%(67447&(&5#$3<()++(U+;5#$(.L.<

Siding Extends 3/4" Below Plate
2x4s Under
Gable Frame
Tongue Edge on Right Side
Flush
Step 12A Install Front Gable Siding
Step 11B Assemble Gables Continued
,< E5:+A"$$9 ;":& ;2+ '5@$+ A:54+ 7V+:< 1+487:5:#$9 8$56+ -/03 "&%+: ;2+ '5@$+ A:54+ ;7 P++8 ;2+
A:54+($+V+$(>2#$+(#&3;5$$#&'(;2+('5@$+(3#%#&'<
-< D765;+(8:+H6";('5@$+(3#%#&'<(]7:P#&'($+A;(;7(:#'2;(#&3;5$$(5(3#%#&'(85&+$(>#;2(5(.;7&'"+.(+%'+
5$7&' :#'2; 3#%+< b&3;5$$ A$"32 >#;2 +&% 7A A:54+ 5&% +/;+&%#&' de0c @+$7> ;2+ @7;;74 -/0 8$5;+<
=3+(W%('5$V<(&5#$3(3856+%(Kc(585:;<
M< D765;+ X-Y ;>7 MGHde0c $7&' -/03<b&3;5$$ ;2+3+ +Q"5$$9
3856+% A:74 6+&;+: 7A ;2+ '5@$+< )+6":+ ;2+ @7;;74 -/0
;7(;2+('5@$+(3;"%3("3#&'(X-Y(;>7(-H,e-c(36:+>3(+562<
W< b&3;5$$ 5 >77% '"33+; 5; 8+5P< [5#$
"3#&'(X,0Y(A7":;++&(W%(67447&
&5#$3<
g< D765;+(X-Y(;>7(MH,e-c/-gHde0c
'"33+;3< L;;562 ;2+3+ ;7 ;78 7A +562
'5@$+ 3;"% ;7 3+6":+ ;7 ;2+ d-H,e-c
-/03<(=3+(W%(67447&(&5#$3<
50-3/4" Gable Studs
5-1/2"x27-3/4"
Gusset

Step 12B Install Gable Siding continued
Step 13 Install Gable Overhang
0< b&3;5$$($53;(3#%#&'(85&+$<
d< b&3;5$$(6+&;+:(3#%#&'<(bA(97"(8":6253+%(5(3"&@":3;(>#&%7>(97"(459(6";(;2+(78+&#&'(#&(;2+
3#%#&'(5;(;2#3(;#4+<(b&3;:"6;#7&3(5:+(856P+%(#&(;2+(>#&%7>(@7/<(b;(#3(5%V#35@$+(;7(#&3;5$$(;2+
>#&%7>(5A;+:(;2+('5@$+(#3(3+;
30-3/4" Long 2x4 77-3/8" Long 2x4
Do not remove the temporary 1x4 blocks until
the roof trusses and back gable are assembled.
,< D765;+(X-Y(;>7(ggHdeKc($7&'(-/0(:5A;+:3(7&('5@$+<(b&3;5$$(-/03(A$"32(>#;2(;2+(;78(7A('5@$+
A:54+<(=3+(,G%(3#&P+:3<
-< D765;+(X-Y(;>7(dGH,e0c($7&'(-/0(:5A;+:3(5&%(#&3;5$$(;7(A#&#32<(-/03(>#$$(+/;+&%(@+97&%(+&%(7A
'5@$+<

Repositioned
1x4 Blocks
12'-0" Span
Step 14 Set Front Gable
,< b&3;5$$('5@$+(7&(;2+(A:7&;(>5$$<()+6":+(@7;;74(7A
'5@$+ ;7 $7A; A$77: 5&% S)! A#$$+:3 "3#&' ,G% 3#&P+:3<
-< [5#$ ;2+ @7;;74 +%'+ 7A ;2+ 3#%#&' #&;7 ;2+ ,/0 ;:#4<
=3+(W%('5$V<(&5#$3< Bottom edge of gable siding
extends over 1x4 trim
Step 16 Assemble Roof Trusses
Important: Temporarily brace the gables with 2x4s
to secure gables until the roof sheathing is installed!
,< b&3+:; $+A; 5&% :#'2; 8:+H@"#$; ;:"33 +&%3 #&;7 ;2+ @$76P3 ;25; 2+$% ;2+ '5@$+ A:54+3 #& 8$56+< b&3":+
385&(#3(,-.HGc(@+;>++&(;:"33(+&%3(53(#&%#65;+%(#&(%:5>#&'(@+$7><
-< !";; X-Y ;>7 ggHdeKc $7&' -/03 5'5#&3; ;2+ ;:"33 +&%3< B+47V+ ;2+ ,/0 @$76P3 ;25; 3+6":+% ;2+
@7;;74 '5@$+ 8$5;+ 5&% :+873#;#7& ;7 P++8 :5A;+:3 5$#'&+%< D765;+ 5 ,KH,e-c $7&' -/0 :#%'+ @$76P
>#;2 5&'$+% +&%3 5&% #&3;5$$ 5; 8+5P< )+6":+ :5A;+:3 5&% :#%'+ @$76P 5; 8+5P >#;2 5 >77% '"33+;<
b&3;5$$ >#;2 X,0Y A7":;++& W% 67447& &5#$3<
d< b&3;5$$('"33+;3(7&(;:"33(+&%3<()++(U+;5#$(L<(b&3;5$$(>#;2(X-GY(;>+&;9(W%(67447&(&5#$3<
0< E5:+A"$$9(A$#8(;:"33(7V+:(5&%(#&3;5$$(5&7;2+:('"33+;(5;(;2+(8+5P<
M< )+; ;:"33 53#%+< B+8+5; 3;+83 ;7 @"#$% X,GY ;+& 47:+ ;:"33+3<
W< B+47V+ ;+487:5:9 ,/0 @$76P3<
Front
Wall
Step 15 Assemble Rear Gable
B+8+5; );+83 ,, ;2:7"'2 ,d ;7 533+4@$+ 5&% 3+; :+5: '5@$+<
Detail 'A'
Tip: Place a gusset under
rafters to help level.
Repositioned
1x4 Blocks
Pre-built Truss
Assembly
77-3/8" long 2x4
Truss Rafter
Wood Gusset
18-1/2" Ridge Block
12'-0" Span Measure Span
from Here

Step 17 Set Trusses
-< E7&;#&"+ 3;5&%#&' ;:"33+3 ;7 A:7&; 7A @"#$%#&'<
I5P+(3":+(;:"33+3(5&%('5@$+3(5:+(8$"4@<(bA
&+6+335:9(385&(5(-/0(56:733(;783(5&%(;56P(;7
P++8(8$"4@("&;#$(:77A(32+5;2#&'(#3(#&3;5$$+%<
Step 18 Install Side wall Trim
-< B+8+5; ;7 #&3;5$$ 67:&+: ;:#4 5; ;2+ 7;2+:
;2:++(67:&+:3<
d< b&3;5$$ 5 0. $7&' ,/d ;:#4 5$7&' ;2+ ;78
7A(;2+(3#%+(>5$$<(=3+(;2+('5"'+(@$76P
;7(3+;(>2+:+(;2+(;:#4(>#$$(@+(#&3;5$$+%<
0< b&3;5$$(XdY(;2:++(g-.($7&'(,/d(;:#4(5$7&'
;2+ ;78 7A ;2+ 3#%+ >5$$< E"; 5 0. $7&' ,/d
;:#4(@75:%(;7(A#&#32<
M< B+8+5;(7&(78873#;+(3#%+(>5$$<
It's easier to install the soffit if the corner and side wall trim are installed first. This
enables the soffit to rest on the trim where it meets the building. See lower detail.
,< );5:;#&' 5; @56P '5@$+ 3+; 5 ;:"33 @9 3$#%#&' +&%3 7V+: -/0 A$77: a7#3;< 1:"33 +&%3 327"$% 3+; A$5;
5;78(A$77:(a7#3;<()+6":+(>#;2(X,GY(;+&(W%(67447&(&5#$3(7&(@7;2(3#%+3<
,< D765;+ 5 deKc / dc / Kc 3#%#&' '5"'+ @$76P 856P+%
#& ;2+ 25:%>5:+ @5'< N$56+ ;2#3 '5"'+ @$76P "&%+:
;2+(-/0(7V+:25&'(5&%(@";;(5(__c($7&'(,/0(;:#4
@75:%(5'5#&3;(#;<(E";(;:#4(@75:%(;7($+&';2(5&%
#&3;5$$ ;2+ ;:#4 A$"32 >#;2 ;2+ 67:&+: ;:#4 7& ;2+
@56P(7A(;2+(@"#$%#&'<(=3+(W%('5$V<(&5#$3<
99" Corner Trim
3/8" Gauge Block
1x3 Trim
3/8" Gauge Block

,< D765;+(X0Y(A7":((_Hde0c(/(0Kc(37AA#;(85&+$3<(S&(;2+(A:7&;('5@$+(&5#$(A#:3;(37AA#;(>#;2(;2+(.DLN.
+%'+ 873#;#7&+% _Hde0c A:74 ;2+ @7;;74 +&% 7A ;2+ -/0 ;7 5$$7> A7: ;2+ >#%;2 7A ;2+ 37AA#; 85&+$3
7&(;2+(3#%+(>5$$3<(=3+(W%('5$V<(&5#$3<
Step 19 Install Soffit
-< E"; ;7 A#; &+/; 37AA#; ;7 67V+: -/0 5;
;2+ 8+5P< b&3;5$$ X-Y ;>7 37AA#; 85&+$3
7&(7;2+:(3#%+<
d< D765;+ XgY 3+V+& _Hde0c / 0Kc 37AA#;
85&+$3< I+53":+ A:74 6+&;+: 7A A#:3;
;:"33 ;7 +%'+ 7A 37AA#; 7& '5@$+< E";
5(37AA#;(85&+$(;7(;2#3($+&';2<(I5P+
3":+(.DLN.(+%'+(#3(;2+(3#%+(6";(7AA<
0< [5#$(;2+(37AA#;(85&+$(;7(;2+(+&%(7A
;2+(-/03<()++(Detail 'C'(@+$7><
M< b&3;5$$ 47:+ 37AA#; 85&+$3 5$7&' ;2+
3#%+(7A(;2+(@"#$%#&'(6";;#&'(;2+($53;
37AA#;(85&+$(A$"32(>#;2(;2+(-/0(7&
;2+(:+5:('5@$+<
W< B+8+5;(3;+83(dHM(;7(#&3;5$$(37AA#;
85&+$3(7&(;2+(A:7&;('5@$+(5&%(;2+
78873#;+(3#%+(>5$$<
1x3 Trim Board
Detail 'C'
Nail Soffit to End of 2x4
9-3/4"Soffit
Soffit
9-3/4" Wide Soffit
Tongue Edge at
Center of Truss Cut Edge

Soffit
Straight Edge
2x4 Rafter
1x6
48" x 51"
48" x 96"
48" x 75"
51"
48" x 96"
48"
48" x 59-1/4"
48" x
35-1/4"
59-1/4"
Step 20 Install 1x6 Fascia on Side Walls
1x6 Fascia Board
-< b&3;5$$(X,Y(7&+(0Kc$7&'(,/W(;:#4(@75:%(&+/;<
E7&;#&"+(>#;2(XdY(;2:++(,/WHW.(;:#4(@75:%3<
E";(5(0Kc($7&'(,/W(;:#4(@75:%(A$"32(>#;2(;2+
A:7&;(37AA#;(7V+:25&'(;7(A#&#32<
d< B+8+5;(7&(78873#;+(3#%+(>5$$<
,< );5:;#&'(5;(;2+(@56P('5@$+?(#&3;5$$(5(gMc($7&'(,/W(;:#4(@75:%(A$"32(>#;2(;2+(A56+(7A(;2+(-/0<
b&3;5$$(;2+(,/W(@75:%(37(;2+(;78(7A(;2+(@75:%(#3(5$#'&+%(>#;2(;2+(;78(7A(;2+(;:"33+3<(12+(:77A
32+5;2#&'?(installed later?(327"$%(:+3;(7&(;2+(A536#5<(=3+(5(3;:5#'2;(+%'+(53(327>&(@+$7><(=3+
W%('5$V<(&5#$3<
Step 21A Install Roof Sheathing
Plyclip
Cut From
48"x96"
)"88$#+%(#&(7":(67487&+&;(P#;<
,< D765;+ X-Y 0Kc/_Wc 32++;3 7A S)!< E"; A:74 ;2+3+
X-Y ;>7 0Kc/M_H,e0c 32++;3< J:74 %:783 6"; X-Y ;>7
0Kc/dMH,e0c(32++;3<
-< J7$$7>#&'($597";(@+$7>(#&3;5$$(:77A(32+5;2#&'
5667:%#&'(;7(#&3;:"6;#7&3(7&(&+/;(85'+<
Front Gable
Back
Gable
48" x 96"
48" x 96"
48" 48" 48"

,< I5P+ 3":+ ;2+ ;:"33+3 5&% '5@$+3 5:+ 8$"4@<
-< B+A+:(;7(;2+(:77A(32+5;2#&'($597";<(b&3;5$$
5(0Kc/M_H,e0c(32++;(5;($7>+:(A:7&;(67:&+:<
)2+5;2#&'(327"$%(@+(A$"32(>#;2(37AA#;(5&%
:+3;(7&(,/W(A536#5<()+6":+(32+5;2#&'(>#;2
W%(67447&(&5#$3<()856+(&5#$3(,-c(585:;<
E7&;#&"+(#&3;5$$#&'(;7(@56P('5@$+<
d< 12+(;78(:7>(7A(32+5;2#&'(>#$$(5$$7>(5('58
5;(;2+(;78(A7:(V+&;#$5;#7&(#A(:#%'+(V+&;(#3
588$#+%<(b&3+:;(X-Y(;>7(8$9H6$#83(#&;7(;2+
:77A(32+5;2#&'(@+;>++&(+562(;:"33(5;(;2+
;78(:7>?(3++(%:5>#&'(7&(8:+V#7"3(85'+<
A$"32
-< b&3;5$$(5(dGH,e-c($7&'(-/0(@+;>++&
;2+ :77A 32+5;2#&' 5&% ;2+ 37AA#; 85&+$
d< B+8+5;(7&(78873#;+(3#%+<
Step 21B Install Roof Sheathing continued
Step 22 Install 2x4s in Front overhang
L#:
)856+
48"x59-1/4"
OSB
48"x35-1/4"
OSB
,< );5:;#&'(5;(;2+(8+5P(#&3;5$$(5(ggHdeKc($7&'(-/0(@+;>++&(;2+(:77A(32+5;2#&'(5&%(;2+(37AA#;
85&+$3< )+; ;2#3 @75:% A$"32 >#;2 +%'+ 7A 37AA#; 85&+$3 5&% :77A 32+5;2#&'< =3+ W% '5$V< &5#$3
7&(37AA#;(5&%(W%(67447&(;2:7"'2(;2+(:77A(32+5;2#&'<
Nail with 6d Common
Nail with 6d Galv.

Step 24 Install Front Gable Trim and Door Trim
,< S&(A:7&;('5@$+(#&3;5$$(X-Y(;>7(,/W(;:#4(@75:%3(7V+:(;2+(-/0(@75:%3?(A$"32(>#;2(;2+(;78(7A
;2+(S)!(:77A(32+5;2#&'<(=3+(W%('5$V<(&5#$3<
-< b&3;5$$('5@$+(;:#4(7&(;2+(:+5:('5@$+<
1x6 Gable
Trim
W< b&3;5$$(5&(K,Hde0c($7&'(,/0(;:#4(@75:%?(this board has angle cuts on both ends?(6+&;+:+%
56:733(;2+(;78(7A(;2+(%77:(78+&#&'<
d< b&3;5$$(5(dHgeKc(/(g-c
8:#4+%(a54@(45;+:#5$(7&
;2+ ;78 7A ;2+ %77: 78+&#&'?
A$"32(>#;2(;2+(A:7&;(>5$$
3#%#&'<(=3+(W%('5$V<(&5#$3<
Step 23 Install Door Flashing 3-1/2"x5"
Flashing
,< D765;+ X-Y ;>7 dH,e-c / Mc 4+;5$ A$532#&'
5&% @+&% 5$7&' >#%;2 ;7 _G %+':++3< b&3;5$$
5; +562 67:&+: 7A ;2+ %77: 78+&#&'< 12+3+
>#$$(@+(67V+:+%(#&(;2+(&+/;(3;+83<
-< b&3;5$$ ;2+ '5$V< %77: 3#$$ 7V+: A$532#&' #&
;2+ 6+&;+: 7A ;2+ %77: 78+&#&'< =3+ ,H,e0c
85&(2+5%(36:+>3(5$7&'(;2+(A:7&;(+%'+<
Galv. Sill
0< D765;+(X-Y(;>7(dHgeKc(/(g_HMeKc(8:#4+%
a54@(45;+:#5$(5&%(#&3;5$$(7&(;2+(3#%+3(7A
;2+ %77: 78+&#&'? A$"32 >#;2 ;2+ A:7&; >5$$
3#%#&'<
M< D765;+ X-Y ;>7 KGHde0c $7&' ,/03 5&% #&3;5$$
A$"32(>#;2(%77:(a54@(5&%(;78(7A(%77:
78+&#&'<

Step 25 Install Pocket Doors Track
Galv. Sill
M< b&3;5$$ ;2+ ;:+5;+% %77: 3#$$ @+2#&% ;2+ %77:
78+&#&'< 12+:+ &++%3 ;7 @+ 5 3856+ @+;>++& ;2+
;:+5;+% 3#$$ 5&% ;2+ #&3#%+ >5$$< 17 873#;#7& ;2+
3#$$? #&3+:; 5 -H,e-c 36:+> @+;>++& ;2+ ;:+5;+%
3#$$ 5&% ;2+ #&3#%+ >5$$ 53 5 3856+:< )6:+> ;2+
3#$$ ;7 ;2+ A$77: >#;2 XWY 3#/ -H,e-c $7&' 36:+>3<
B+47V+(;2+(36:+>("3+%(53(5(3856+:<
2x3 Track Support Assembly
-< b&3;5$$(;2+(7;2+:(;:56P(3"887:;(533+4@$9<
2x8 Door Header
View From Inside
View From Inside
Screw Used
as Spacer
Treated Sill
Board
Notch in Sill
Building Tip; run a bead of caulking where
flashing, treated sill and aluminum sill
meet to prevent moisture from penetrating.
!
82-3/4"
to Floor
,< b&3;5$$(5(g-c($7&'(1:56P()"887:;(L33+4@$9(K-Hde0c(A:74(;2+(A$77:<(ImportantT(4+53":+(A:74
;2+(@7;;74(7A(;2+(-/d(7&(;2+(3"887:;(533+4@$9(;7(;2+(A$77:<(b&3":+(;2+(&7;62+%(+&%(7A(;:56P(#3
6+&;+:(7A(%77:(78+&#&'<(=3+(-H,e-c(36:+>3<