BIOS Icarus LLi User manual

bioslighting.com
[phone]
[e-mail] Page 1 of 2
Rev6 [2020 12/15]
Specications and dimensions subject to change without notice.
Contact BIOS for questions and the most current information.
ICES-005 (A)
Installation Guide
Icarus™LLi
EASY-TO-CLEAN
INSTALL IN SECONDS
OPTIMUM UNIFORMITY 1. Loosen RapidRack™thumb screw enough to slide RapidRack™ plate.
2. Slide RapidRack™plate into desired rack mount position.
3. Tighten RapidRack™thumb screw to secure RapidRack™plate into place.
RapidRack™ Mounting Plate
RapidRack™ Thumb Screw
Extend & rest on ledge
Extend & secure
1. Extend RapidRack™ plates on one end and rest on rack ledge.
2. Extend RapidRack™ on opposite side to complete secure mounting solution.
Tip:
FIXTURES 600W 780W
1 TO 2 N/A N/A
3228W x 3 N/A
4150W x 4* 195W x 4
5120W x 5 156W x 5
6100W x 6 130W x 6
786W x 7 111W x 7
875W x 8+97W x 8+
967W x 9 87W x 9
10 60W x 10+78W x 10
For more info, documents and videos reqarding your BIOS Icarus LLi xtures: Please log onto www.bioslighting.com/product/icarus-lli/
BIOS Programmable Power Supply
BIOS Icarus LLi 6 Fixture Conguration Example - (one of many LLi congurations)
*Recommended for cannabis veg. (See cannabis application guide for more details)
+See leafy greens application guide for more details
IMPORTANT:
To avoid risk of damage to the xture and
their LEDs, make all wiring connections
before plugging in power supply.
Easy Rack Mount Solution with RapidRack™
BP-0LLi-000-000001-1 & BP-0LLi-000-000002-1
Read all instructions prior to performing installation. All facility wiring to be performed only by licensed electricians in accordance with National Electric
Code and local code specications. Failure to do so voids warranty and may result in serious injury or death. Supplied Connectors on all power cables have
breaking capacity and can be installed by non-licensed individuals. Disconnect main power prior to installation, maintenance or service.
ELECTRICAL SHOCK HAZARD CAUTION!

bioslighting.com
[phone]
[e-mail] Page 2 of 2
Rev6 [2020 12/15]
Specications and dimensions subject to change without notice.
Contact BIOS for questions and the most current information.
ICES-005 (A)
Fixture Specications
BIOS Icarus™LLi
• DC Extension Cable 2.5 Meter
• AC Extension Cable 1.5 Meter
NEMA Plug Choices:
• 5-15P, 6-15P, L6-15P, L6-20P, L7-15P,
L7-20P
• AC Power Chain System
• Dimmer Chain System
Product Accessories
WARNING: Changes or modications not expressly approved by the party responsible for compliance could void the user’s authority to
operate the equipment. This device complies with Part 15 of the FCC rules. Operation is subject to the following two conditions:
(1) this device may not cause harmful interference, and
(2) this device must accept any interference received, including interference that may cause undesired operation. This equipment, if not installed
and used in accordance with the instructions, may cause harmful interference to radio communications. Any changes or modications not expressly
approved by the manufacturer could void the user’s authority to operate the equipment.
NOTE: This equipment has been tested and found to comply with the limits for a Class A digital device, pursuant to part 15 of the FCC Rules. These
limits are designed to provide reasonable protection against harmful interference when the equipment is operated in a commercial environment.
This equipment generates, uses, and can radiate radio frequency energy and, if not installed and used in accordance with the instruction manual,
may cause harmful interference to radio communications. Operation of this equipment in a residential area is likely to cause harmful interference in
which case the user will be required to correct the interference at his own expense.
Fixtures Shall Comply with the Following Safety Requirements:
• Are not concealed or extended through a wall, oor, ceiling, or
other parts of the building structure;
• Are not located above a suspended ceiling or dropped ceiling;
• Are not permanently axed to the building structure;
• Are routed so that they are not subject to strain and are
protected from physical damage;
• Are visible over their entire length; and
• Are used within their rated ampacity as determined for the
maximum temperature of the installed environment specied in
the instructions.
Bios provides a 5 year limited warranty on the Icarus product against defects in materials and workmanship under normal use conditions. Eective warranty
begins on the date of the invoice or purchase receipt. If the product is deemed by BIOS to be defective and fails to serve this warranty, BIOS will, at its
discretion, repair, replace or refund the purchase price. This warranty is void if BIOS determines improper installation, wiring misuse, alterations or repairs of
this product not under the written consent of BIOS. This xture meets UL8800 - a standard specic to LED lighting xtures and is approved for use in both the
US & Canada. Full warranty information can be found at www.bioslighting.com.
Warranty Information (abridged)
For general cleaning of external parts of the Icarus™LLi xture and spot-free lens cleaning use only facility compressed air or a soft, non-abrasive cloth and
and water. If necessary, a mild general purpose non-solvent glass cleaner that is compatible with indoor crop production regulations may be used.
Product Maintenance:
FCC responsible party name: BIOS Lighting - Address: 2796 Loker Ave W Suite 111 Carlsbad, CA. 92010 - 321-260-2467
Additional Accessories (not included - See
associated Spec Sheets):
APPLICATIONS Indoor Racks, Shelves, Suspension
INPUT VOLTAGE 100-305 VAC & 305-580 VAC
FIXTURE SIZE / WEIGHT US 45"L x 21.22"W x 3"H | 13.8 lbs
FIXTURE SIZE / WEIGHT M 114.3 cm L x 53.9 cm W x 7.6 cm H | 6.3 kg
POWER SUPPLY WEIGHT US 21.3”L x 7.76”W x 2.95”H ǀ 13.2lbs
POWER SUPPLY WEIGHT M 54.1 cm L x 19.7cm W x 7.5 cm H ǀ 6kg
DIMMING SOURCE 300 uA (typical)
DIMMING PROTOCOL 0-10V | Dims to O Linearly
HOUSING AND FINISH Anodized Aluminum & Tempered Glass
MOUNTING TECHNIQUE RapidRack Mounting, T-Slot Suspension
MOUNTING HEIGHT 4"-30" Above Plant Canopy - see application guide
SPECTRUM Photosynthetically Optimized Broad Spectrum
CERTIFICATIONS UL8800, RoHS, FCC, DLC
FIXTURE WATTAGE Up to 150W
POWER FACTOR ≥ 96%
PPF 405 μmol/s @ 150W - 272 μmol/s @ 97W
PAR EFFICACY 2.7 μmol/J @ 150W - 2.8 μmol/J @ 97W
THERMAL MNGMT Passive Thermal Management
WARRANTY 5 Year Standard Limited
LIGHT DISTRIBUTION 115 °
AMBIENT TEMP. RANGE 41°F-104°F (5°C-40°C)
INGRESS PROTECTION IP65
PROJECTED LIFETIME Q90: > 36000 hrs