Black Series HQ Installation and user guide
I. Upkeep and Maintenance of Exterior and
Auxiliary Components
II. Interior Maintenance
III. Upkeep and Maintenance of Tent
IV. Anti-Freeze Upkeep and Maintenance
V. Compulsory Maintenance
9,(ƈHFWVRI/RQJ7HUP6WD\DQG
Upkeep & Maintenance
Service
And Maintence
Regular maintenance of your camper trailer is the best way to protect your investment. Scheduled maintenance is essential
to maintain high level of safety and reliability for the camper trailer.
&WARNING
Do not get under your trailer unless it is on solid and level ground where the jack bracket is secured in place.
(;7(5,25:$//522)
6RPHRIWKHWUDLOHUŇVH[WHULRUFRPSRQHQWVDUHPDGHRIƉEHUJODVVPHWDOUXEEHUDQGSODVWLFPDWHULDOV7KHLUFRDWLQJLVGXUDEOH
EXWQRWLQGHVWUXFWLEOH([SRVHGWRSROOXWDQWVIURPVXQOLJKWPRLVWXUHDQGDLUDQ\PDWHULDORUGHFRUDWLRQZLOOGHWHULRUDWHRYHU
WLPHFKDQJLQJWKHVXUIDFHRIWKHPDWHULDOUHVXOWLQJLQGLPPLQJDQGIDGLQJ,QJHQHUDOFKDQJHVLQƉQLVKLQJGXHWRZHDWKHULQJ
DUHVXSHUƉFLDO7KH\DUHRQWKHVXUIDFHRIWKHFRPSRQHQWDQGZLOOQRWDƈHFWLWVVWUHQJWK'DLO\PDLQWHQDQFHLVWKHEHVW
VROXWLRQLQWKLVUHJDUG,IWKHƉQLVKLVQRWWKRURXJKO\FOHDQHGDQGZD[HGWKHVXUIDFHZLOOGHWHULRUDWHUDSLGO\7KHIROORZLQJ
JXLGHOLQHVFDQKHOSUHGXFHHƈHFWVRIWKHZHDWKHULQJ
1) Wash the surface at least once a month with a mild liquid detergent. Do not clean the outer surface with strong abrasive
WRROV'RQRWXVHVROLGRUJUDQXODUFOHDQHUVDVWKH\FDQGDPDJHWKHƉQLVK'RQRWXVHKLJKO\DFLGLFRUDONDOLQHFOHDQLQJ
VROXWLRQVDQGWKHUHFRPPHQGHGS+LVEHWZHHQDQG7KHFOHDQLQJVROXWLRQVKRXOGQRWFRQWDLQVWURQJVROYHQWRU
alcohol. Avoid contact with window cleaning agents that contain ammonia. Wash the trailer in a cool place without direct
VXQOLJKWGRQRWZDVKXQWLOWKHH[WHULRUVRIWKHWUDLOHUFRROGRZQ&KHPLFDOVROYHQWVDQGVWURQJFOHDQLQJDJHQWVPD\GDPDJH
WKHWUDLOHUŇVVLGLQJURRIPHWDODQGSODVWLFWULPPLQJ5LQVHWKHWUDLOHUWKRURXJKO\ZLWKFROGZDWHUWRUHPRYHORRVHGLUW8VH
DPLOGGHWHUJHQWVXFKDVGLVKZDVKLQJOLTXLGRUDSURGXFWPDGHVSHFLƉFDOO\IRUFDURUFDPSHUWUDLOHUFOHDQLQJ&OHDQWKH
WUDLOHUZLWKFOHDQZDWHUDQGPLOGGHWHUJHQWVROXWLRQDVZHOODVDVRIWEUXVKVSRQJHRUVRIWFORWK6WDUWDWWKHWRSDQGZRUN
your way down.
$IWHUULQVLQJWKHHQWLUHH[WHULRUGU\ZLWKVXHGHRUDVRIWWRZHO3OHDVHQRWHWKDWGU\LQJQDWXUDOO\FDQFDXVHH[WHULRUGDUNHQLQJDQG
ZDWHUVSRWV,WLVDOVRLPSRUWDQWWRFKHFNDQGUHSDLUWKHVXUURXQGLQJVHDOZKHQGU\LQJWKHWUDLOHU
2) :D[WKHVXUIDFHDWOHDVWRQFHD\HDUSUHIHUDEO\WZLFH8VHDXWRPRWLYHZD[SROLVKUDWKHUWKDQDEUDVLYHFOHDQHUVRUDEUDVLYH
compounds. Wash and dry the entire trailer before waxing.
&OHDQWKHURRIHYHU\WZRPRQWKV)RUJHQHUDOFOHDQLQJXVHDPL[WXUHRIPLOGOLTXLGGHWHUJHQWDQGZDWHUUDWKHUWKDQVROLGRU
JUDQXODUFOHDQHUVZKLFKPD\GDPDJHWKHƉQLVK8VHPLQHUDODOFRKROVRDNHGFORWKHVWRFOHDQVWXEERUQVWDLQV'RQRWDSSO\PLQHUDO
RLOLQODUJHDUHDVDQGGRQRWVRDNPLQHUDORLORQWKHURRIPHPEUDQH
&CAUTION
Wet roof is slippery.
'$0$*(,163(&7,21
,WLVLPSRUWDQWWRFKHFNWKHHQFORVXUHUHJXODUO\IRUGDPDJH$WWHQWLRQVKRXOGEHSDLGWRWKHIROORZLQJLWHPV
·Waste cylinders and pipes.
·Gas cylinder and assembly.
z6HDODQWVDSSOLHGDURXQGGRRUVURRIVYHQWVDQGZLQGRZV
·External lighting.
6($/$175(1(:$/
7KHDGKHVLYHVDQGVHDODQWVXVHGLQWKHWUDLOHUDUHPHDQWWRUHPDLQZDWHUSURRIDJDLQVWWKHFRQVWDQWHƈHFWVRIZHDWKHUDQGYLEUDWLRQ
(YHQWKHEHVWPDWHULDOVHYHQWXDOO\GU\RXWDQGIDLOXQGHUWKHFRQVWDQWKHDWRIWKHVXQOLJKWWKHHURVLRQRIRWKHUIDFWRUVDQGWKH
YLEUDWLRQVRIWKHURDG7RSURWHFWWKHFDPSHUWUDLOHUIURPZDWHULQYDVLRQDQGGDPDJHLWVKRXOGEHWKRURXJKO\LQVSHFWHGDQGUHVHDOHG
IRUDQ\GHIHFWVIRXQG5RRIZLULQJDQGVHDODQWVDURXQGGRRUVDQGZLQGRZVVKRXOGEHLQVSHFWHGDWOHDVWHYHU\VL[PRQWKV
7KHDƈHFWHGDUHDPXVWEHUHVHDOHGLIDQ\RIWKHIROORZLQJFLUFXPVWDQFHVDUHIRXQGGXULQJWKHLQVSHFWLRQ
(1) Weathered or dried sealant.
&UDFNHGRUSHHOLQJVHDODQW
+ROORZVHDODQW
(4) Shrunk or separated sealant.
&OHDQDOODUHDVWKDWUHTXLUHUHVHDOLQJ(QVXUHWKDWDOODUHDVWREHUHVHDOHGDUHDEVROXWHO\GU\EHIRUHDSSO\LQJWKHQHZVHDODQW
,83.((3$1'0$,17(1$1&(2)(;7(5,25$1'
$8;,/,$5<&20321(176
6(59,&($1'0$,17(1$1&( 1
&KHFNDQGWLJKWHQDQ\ORRVHIDVWHQHUV'RQRWPDNHWKHPRYHUWLJKWHQHGRUWKH\ZLOOSHHO,IDUHDVRQWKHURRIUHTXLUHUHVHDOLQJ
UHPRYHDQ\ORRVHRUFUDFNHGVHDODQWDQGGRQRWGDPDJHWKHURRI8VHZRRGHQRUSODVWLFVFUDSHUVWRSUHYHQWJRXJLQJSXQFWXULQJ
RURWKHUZLVHGDPDJLQJWKHURRI7KHURRIPD\EHFXWRUSXQFWXUHGE\VKDUSREMHFWV&RQWLQXRXVO\DSSO\QHZVHDODQWWRWKHMRLQWV
DQGƊDQJHVDQGGRQRWOHDYHDQ\WKLQJEHKLQG$SSO\HQRXJKVHDODQWVWRƊRZRYHUWKHKHDGVRIDOOIDVWHQHUV:DLWDWOHDVWKRXUV
for the sealant to set completely before cleaning or waxing the trailer.
4. DOOR AND WINDOW
&OHDQZLQGRZIUDPHVDQGUDLOVWRHQVXUHHDV\RSHUDWLRQ&OHDQJODVVZLQGRZVWKRURXJKO\ZLWKJODVVFOHDQHUV:LSHDOOJODVVZLWKD
VRIWFORWKRUSDSHUWRZHO&OHDQWKHVHDOVHYHU\PRQWKVZLWKDGDPSFORWKRUPLOGGHWHUJHQWUDWKHUWKDQVWURQJVROYHQWVDVWKH\
PD\GDPDJHWKHVHDOV$SSO\DOD\HURIQDWXUDOVLOLFRQHOXEULFDQWRQWKHGU\VHDOWRNHHSLWHODVWLF)UHTXHQWOXEULFDWLRQLVUHTXLUHG
if the trailer is exposed to salty air.
$&5</,&:,1'2:
0DNHDFU\OLFZLQGRZVORRNOLNHQHZE\XVLQJDSSURSULDWHFDUHSURGXFWVDQGWHFKQLTXHV3UHYHQWVFUDWFKLQJDFU\OLFZLQGRZVZLWK
URXJKFORWKVKDUVKVRDSVRUFOHDQLQJSURGXFWV5HPRYHIURVWHGGLUWDVIDUDVSRVVLEOHZLWKRXWWRXFKLQJWKHVXUIDFHZKHQFOHDQLQJ
WKHZLQGRZ,GHDOO\ULQVHWKHVXUIDFHZLWKZDWHUWRVRDNWKHDFFXPXODWHGUHVLGXHDQGDGGPLOGFOHDQVLQJVROXWLRQWRWKHZDWHU8VH
QRQDEUDVLYHVRDSGHWHUJHQWDQGZDWHU8VHDVRIWVSRQJHFORWKRUVXHGH5LQVHIUHTXHQWO\WRNHHSLWIUHHRIJULW:DVKXSDQG
GRZQRUOHIWDQGULJKWQRWLQDFLUFXODUPRWLRQ)LQDOO\ULQVHZLWKPRUHZDWHUDQGGU\ZLWKDFOHDQVRIWFORWK6WDUWDWWKHWRSRIWKH
ZLQGRZDQGXVHWKHFOHDQVLGHRIWKHFORWKDIWHUWKHRWKHUVLGHJHWVGLUW\'RQRWZRUNLQDFLUFXODUPRWLRQ
&WARNING
'RQRWXVHDEUDVLYHFRUURVLYHFOHDQHUVDOFRKRORUVROYHQWVDVWKH\PD\FDXVHSHUPDQHQWGDPDJHWRWKHƉQLVK'RQRWXVHDQ\
SHWUROHXPFOHDQHUVRUFRUURVLYHFKHPLFDOVRQDFU\OLFZLQGRZV'RQRWXVH:'EHFDXVHLWLVSHWUROHXPEDVHG1HYHUXVHD
KLJKSUHVVXUHQR]]OHWRFOHDQZLQGRZV'RQRWZDVKZLQGRZVLQGLUHFWVXQOLJKW
5. AIR CONDITIONER
&KHFNZKHWKHUWKHDLUFRQGLWLRQHULQVWDOODWLRQEROWVDUHWLJKWHQHGDIWHUNPGULYLQJ5HPRYHWKHLQQHUFRYHUDQGLQVSHFWWKHIRXU
EROWVORFDWHGDWWKHFRUQHUVRIWKHURRIRSHQLQJV7KHVHIDVWHQHUVZKLFKVHFXUHWKHDLUFRQGLWLRQHURQWKHURRIDOVRH[HUWSUHVVXUH
on the sealing gasket between the air conditioner and the roof. Loose fasteners may lead to water intrusion around the roof opening.
723+2/'9(17
7KHYHQWFDQEHFOHDQHGIURPWKHWRSRIWKHWUDLOHU7KHƉOWHUPHVKFDQEHYDFXXPHGRUEUXVKHGJHQWO\WRUHPRYHWKHDFFXPXODWHG
leaves or other debris.
Lubricate gears and components annually with waterproof grease.
6.</,*+7
Rinse the skylight with warm water at least four times per year. Wash gently with a soft cloth or sponge and mild soapy water to
soften dirt. Do not scrub with a brush or scraper. Rinse repeatedly and dry with a soft cloth to prevent water accumulation.
II. INTERIOR MAINTENANCE
1. INDOOR ODOR
,QKRWZHDWKHUWKHQHZWUDLOHUVPD\KDYHVWURQJRGRUVZKLFKPD\HYHQLUULWDWHWKHH\HVGXHWRWKHJOXHXVHGLQFDELQHWVDQG
SDQHOLQJ7KLVVLWXDWLRQPD\GLVDSSHDURYHUWLPH+RZHYHULQH[WUHPHFDVHV\RXFDQRSHQWKHDFFHVVGRRUDQGDOOZLQGRZVIRU
air ventilation for several hours.
)851,785($1'&857$,16
&XUWDLQVPDWWUHVVFRYHUVLQGRRUXSKROVWHU\DQGZDOOPDWVDUHDOOPDGHRITXDOLW\PDWHULDOVDQGVKRXOGEHGU\FOHDQHGRQO\9DFXXPLQJ
UHJXODUO\RUFOHDQLQJZLWKDVRIWEUXVKFDQKHOSSUHYHQWEXLOGXSRIGLUWDQGJULPH:DWHURUGHWHUJHQWEDVHGFOHDQHUVPD\FDXVH
VKULQNDJH:DWHUGDPDJHFDQEHSHUPDQHQW6PDOOVSLOOVVKRXOGEHFOHDQHGXSTXLFNO\WRDYRLGFRQWDPLQDWLRQ$ƈHFWHGDUHDVVKRXOG
XQGHUJRVRLOSLFNXSUDWKHUWKDQIULFWLRQWRSUHYHQWWKHVWDLQIURPHQWHULQJGHHSHULQWRWKHIDEULF<RXPD\UHPRYHGLUWDQGGXVW
IURPYLQ\OLQWHULRUVZLWKDYDFXXPFOHDQHU:LSHZLWKDVRIWFORWKDQGVRDNZLWKPLOGVRDSDQGZDWHU8VHWKHVDPHVROXWLRQLQDUHDV
WKDWDUHGLƋFXOWWREUXVK8VHDVSUD\W\SHRUIRDPW\SHYLQ\OFOHDQHU
6(59,&($1'0$,17(1$1&( 2
&WARNING
'RQRWXVHSDLQWWKLQQHUQDLOSROLVKUHPRYHUFDUERQWHWUDFKORULGHJDVROLQHRUQDSKWKDIRUDQ\FOHDQLQJDVWKHVHSURGXFWVPD\
FDXVHGDPDJHWRWKHPDWHULDOEHLQJFOHDQHGDQGDUHKLJKO\ƊDPPDEOHRUWR[LF
:$//6$1'&(,/,1*6
'RQRWXVHFRDUVHVFDOHLQKLELWRURUDEUDVLYHRQZDOOVRUFHLOLQJV0RVWVXUIDFHVFDQEHFOHDQHGZLWKDVRIWFORWKGLSSHGLQDPLOG
OLTXLGFOHDQHULQZDUPZDWHU'RQRWXVHODUJHDPRXQWVRIZDWHUDVLWPD\VDWXUDWHWKHPDWHULDO
)/225
9LQ\OƊRRUVRQO\UHTXLUHFOHDQLQJDQGUHJXODUZD[LQJ9DFXXPFDUSHWVUHJXODUO\WRUHPRYHGLUW
0$,17(1$1&(2):22'352'8&7
Remove dust with a clean and slightly damp rag. Apply quality furniture polishes with a soft and dry cloth. Do not use harsh detergents
or solvents.
0$,17(1$1&(2)/$0,1$7('%2$5'
&OHDQWKHWRSRIODPLQDWHGERDUGZLWKPLOGGLVKZDVKLQJOLTXLGDQGZDUPZDWHU8VHDVRIWFORWKIRUZDVKLQJDQGGU\LQJ$EUDVLYH
FOHDQHUVVWHHOZRRORUJULWFOHDQHUVPD\GDPDJHWKHVXUIDFH
7. REFRIGERATOR
&OHDQWKHLQVLGHZLWKDPLOGFOHDQVHUDQGZDWHUDIWHUHDFKWULS7KDZWKHUHIULJHUDWRUDQGHPSW\WKHLFHWUD\:KHQWKDZLQJ
SODFHGU\WRZHOVLQWKHUHIULJHUDWRUWRDEVRUEPRLVWXUH3ODFHWKHWUD\ZLWKKRWZDWHULQWKHIUHH]LQJFKDPEHU$IWHUGHIURVWLQJ
ZKHQWKHIUHH]LQJFKDPEHUDQGFRQGHQVHUDUHIURVWIUHHGU\WKHUHIULJHUDWRUZLWKDFOHDQUDJ
6(:(5
Do not use lye or any strong chemicals if the sink or shower drain gets clogged. Strong chemicals may damage plastics in the waste
system. A standard drain is recommended.
%$7+52200$,17(1$1&(
1RQDEUDVLYHFOHDQHUVDUHXVHGIRUGDLO\FOHDQLQJ+RXVHKROGƉEHUJODVVFOHDQHUVDUHUHFRPPHQGHG'RQRWXVHKDUVKFOHDQHUVRU
abrasive cleaners. Do not clean surfaces with steel wool.
6,1.0$,17(1$1&(
Do not use abrasive cleaners or washing powders. Abrasive cleaners may dull or damage product surfaces and may leave scratches.
'RQRWXVHZDVKSDGVVWHHOZRRORUDQ\RWKHUDEUDVLYHVFUXEEHU:LSHZLWKDVRIWFORWKRUVSRQJHRQO\$OZD\VXVHDFXWWLQJERDUG
RUVLQNSURWHFWRUZKHQXVLQJNQLYHVRUVKDUSREMHFWV&RROWKHSDQEHIRUHSODFLQJLWLQWKHVLQN
,,,83.((3$1'0$,17(1$1&(2)7(17
$17,0,/'(:
1RWGU\LQJDZHWWHQWDVVRRQDVSRVVLEOHLVRQHRIWKHPRVWOLNHO\UHDVRQVIRUGDPDJHWRWKHWHQW0LOGHZLVOLNHO\WRVWDUWIRUPLQJ
RQWKHIDEULFRIDZHWWHQWZKLFKKDVEHHQVWRUHGIRUKRXUVLQZDUPZHDWKHU0LOGHZFDQFDXVHWKHZDWHUSURRIFRDWLQJWR
VHSDUDWHIURPWKHIDEULFZKLFKFDQFDXVHSHUPDQHQWGDPDJH
0LOGHZLVSHUPDQHQW,WFDQQRWEHUHPRYHGZLWKRXWSRWHQWLDOGDPDJHWRWKHIDEULFFRDWLQJDQGGDPDJHVLQWKLVUHJDUGDUHQRW
FRYHUHGE\ZDUUDQW\(YHQLI\RXUWHQWORRNVGU\DIWHUXVHLWLVEHWWHUWRXQIROGLWLQGRRUVDQGPDNHVXUHLWŇVFRPSOHWHO\GU\EHIRUH
storage. Open the tent regularly to prevent odor accumulation and clothing deterioration.
&/($1,1*
7KHUHLVQRQHHGWRFOHDQ\RXUWHQWXQOHVVLWVPHOOVEDGRUEHFRPHVYHU\GLUW\,ILWLVKHDYLO\FRQWDPLQDWHGZDVKLWE\KDQGZLWK
ZDUPZDWHUVSRQJHDQGPLOGGHWHUJHQWIUHHVRDS'RQRWXVHGLVKZDVKLQJOLTXLGGHWHUJHQWEOHDFKSUHVRDNVROXWLRQRUVWDLQ
UHPRYHU:DVKZLWKFOHDUZDWHU3URSXS\RXUWHQWXQWLOLWGULHV1HYHUGU\FOHDQPDFKLQHZDVKRUGU\\RXUWHQWDVHDFKRIWKHVH
methods may remove the waterproof coating from the fabric.
6(59,&($1'0$,17(1$1&(
681/,*+7$1'8/75$9,2/(75$<
8OWUDYLROHWUD\LVRQHRIWKHPRVWKDUPIXOHOHPHQWVWR\RXUWHQW7HQWVDUHRIWHQXVHGXQGHUVXQOLJKWDQGSURORQJHGH[SRVXUHPD\
FDXVHWKHIDEULFWRIDGHORVHVWUHQJWKDQGHYHQWXDOO\WHDUKLVHƈHFWLVPRUHHYLGHQWDWKLJKHUDOWLWXGHV3ODFH\RXUWHQWRXWRI
direct sunlight if possible. Damages due to ultraviolet ray are not covered by the warranty.
$1,0$/6
1HYHUVWRUHIRRGLQDWHQWWRSUHYHQWDQLPDOVIURPELWLQJKROHVLQWKHIDEULF
-2,176($/
Superior fabrics and construction make your tent extremely waterproof. Seal only certain areas if anything goes wrong. Keep the joint
VHDOLQVLGHDQGFRDWWKHVKLQ\VLGH3UHYHQWGULHGVHDODQWDGKHULQJWRRWKHUSDUWVRIWKHWHQWZLWKEDE\SRZGHURUWDOFXPSRZGHU
&21'(16$7,21
&RQGHQVDWLRQLVPRLVWXUHWKDWIRUPVLQVLGHDWHQWGXHWRWKHGLƈHUHQFHLQWHPSHUDWXUHEHWZHHQLQVLGHDQGRXWVLGH,WFRPHVIURP
WKUHHVRXUFHV
·:HDWKHUFRQGLWLRQKLJKKXPLGLW\&ROGDQGUDLQ\FRQGLWLRQVSURGXFHWKHPRVWFRQGHQVDWLRQ
·3HRSOHHYDSRUDWLRQWKURXJKUHVSLUDWLRQDQGVNLQ
·+XPLGHQYLURQPHQWKXPLGJURXQG
7KHNH\WRUHGXFLQJFRQGHQVDWLRQLVYHQWLODWLRQ)UHVKDLUKDVWRHQWHUZKLOHZDUPDQGPRLVWDLUKDVWRHVFDSHWKHWHQW1RWHQW
FDQFRPSOHWHO\HOLPLQDWHFRQGHQVDWLRQLQDOOFRQGLWLRQVDQGJRRGYHQWLODWLRQLVWKHRQO\HƈHFWLYHZD\RIHOLPLQDWLQJFRQGHQVDWLRQ
on a daily basis.
=,33(5
6DQGLQWKH]LSSHUWHHWKZLOOFDXVHZHDUDQGGDPDJHWRWKH]LSSHUVOLGHU7RXVHWKHWHQWLQWKLVFDVHSOHDVHULQVHWKH]LSSHUWHHWK
ZLWKZDWHU&DUHIRUWKH]LSSHUVOLGHUPD\H[WHQGWKHVHUYLFHOLIHRI]LSSHU$OLJQWKHUDLOVEHIRUH]LSSLQJXS
,9$17,)5((=(83.((3$1'0$,17(1$1&(
0DLQWHQDQFHRILQWHUQDOWHPSHUDWXUHKHOSVSUHYHQWZDWHUIURPIUHH]LQJLQVWRUDJHF\OLQGHUVZDWHUF\OLQGHUVSXPSVDQGSLSHV7XUQ
RQWKHKRWDLUV\VWHPWRFLUFXODWHWKHKRWDLUWKURXJKWKHZDWHUV\VWHPFRPSRQHQW$GGLQJQRQWR[LFDQWLIUHH]HWRWKHSOXPELQJ
V\VWHPLVWKHPRVWHƈHFWLYHPHWKRG,QVWDOOZLQWHUFRYHUSODWHRQWKHDLUFRQGLWLRQHU7KHHTXLSPHQWLVSRZHUHGE\SURSDQH
7KHUHDUHKROHVLQWKHZLQGRZVWRGUDLQZDWHURXWRIWKHZLQGRZUDLOV'XULQJKHDY\UDLQDQGKLJKZLQGVZDWHUFDQEHEORZQLQWR
WKHWUDLOHUWKURXJKWKHVHKROHV3ODFHDVSRQJHRQWKHWUDFNRIWKHKROHWRSUHYHQWWKLVVLWXDWLRQ
$17,)5((=,1*0($685(6'85,1*9(+,&/(6725$*(
6+2577(5075$,/(56725$*(
(1) Wash the external surface.
3DUNWKHWUDLOHUDVKRUL]RQWDOO\DVSRVVLEOH
%HIRUHGLVFRQQHFWLQJWKHEDWWHU\FDEOHFKHFNWKHEDWWHU\OHYHODQGFKDUJHLWLIQHFHVVDU\
3RZHURƈWKHEDWWHU\ZKLOHFOHDQLQJWKHEDWWHU\DQGEDWWHU\FDVH
'UDLQUHVHUYRLUVWRLOHWVDQGIUHVKZDWHUUHVHUYRLUV7XUQRƈWKHZDWHUSXPSDQGZDWHUKHDWHU
&ORVHJDVF\OLQGHUYDOYH
7XUQRƈWKHUHIULJHUDWRUVWRYHDQGRYHQEXUQHUYDOYHV
(7) Remove all food from the refrigerator and kitchen cabinets. Leave the refrigerator door open to reduce the accumulation of odors.
2SHQDURRWYHQW
&ORVHDQGORFNDOOZLQGRZV(QVXUHWKDWWKHH[KDXVWIDQDQGUDQJHKRRGIDQVZLWFKHVDUHWXUQHGRƈ
&RYHUDQGFORVHWKHGUDLQSLSHZDWHULQOHWDQGIUHVKZDWHULQOHWRIWKHVWRUDJHWDQN
7XUQRƈDOOUDGLRVWHOHYLVLRQVLQGRRUDQGRXWGRRUOLJKWV
&ORVHPLQLORXYHUVDQGGD\QLJKWZLQGRZVKDGHV
'LVFRQQHFW9SRZHUFDEOHVDQGVWRUHLQWKHFRPSDUWPHQW
&KHFNWKHWUDLOHUSHUZHHN
,QMHFWQRQWR[LFDQWLIUHH]HLQWRWKHZDWHUZD\V\VWHPSLSHOLQHLQFOXGLQJWKHZDWHUKHDWHUSLSHOLQH
6(59,&($1'0$,17(1$1&( 4
/21*7(50/2:7(03(5$785(6725$*(
3HUIRUPWZRZRUGVVKRUWWHUPVWRUDJHVWHSV
(2) Operate the air conditioner periodically to lubricate the compressor seal.
5HPRYHWKHEDWWHU\DQGVWRUHLWLQDFRRODQGGU\SODFH&KHFNWKHEDWWHU\OHYHOHYHU\GD\V&KDUJHLWZKHQQHFHVVDU\
&KHFNVHDODQWVRIURRIMRLQWVYHKLFOHERG\MRLQWVDQGVHDODQWVDURXQGZLQGRZVUHDSSO\VHDODQWVZKHQQHFHVVDU\
3UHSDUHWKHHOHFWULFJHQHUDWRULIDQ\
5HPRYHEDWWHU\RIWKHVPRNHGHWHFWRU.HHSWKHFRYHURSHQVRDVWRUHSODFHWKHEDWWHU\ZKHQQHFHVVDU\
(7) (QFORVHH[WHUQDOYHQWVZDWHUKHDWHUHOHFWULFVWRYHDLUFRQGLWLRQHUKRRGUDQJHKRRGFRYHUWRNHHSLQVHFWVDQGVPDOODQLPDOVRXWRI
the trailer.
Remove all covering material before using appliances and vents.
6725$*($768%=(527(03(5$785(
7RSUHYHQWGDPDJHWRSLSHVDQGRWKHUFRPSRQHQWVWKHWUDLOHUSLSHOLQHV\VWHPVKRXOGEHGUDLQHGDQGSURWHFWHGDJDLQVWIUHH]LQJ
7KHIROORZLQJDQWLIUHH]LQJVWHSVPXVWEHIROORZHG
3HUIRUPDOOVWHSVLQORQJWHUPDQGVKRUWWHUPVWRUDJHSURFHVV
2SHQWKHGUDLQSLSHRIWKHZDWHUWDQNHPSW\WKHWDQNDQGNHHSWKHGUDLQSLSHRSHQ
7XUQRQDOOKRWDQGFROGZDWHUIDXFHWV2SHQWKHORZSRLQWGUDLQRIWKHKRWDQGFROGSLSHV
(4) Open the drain plug at the bottom of the water heater and open the pressure relief valve to drain the water from the heater.
(5) 3UHVVWKHƊXVKSHGDORUKDQGOHYHU&ORVHDOOIDXFHWVZDWHUSLSHGUDLQYDOYHVIUHVKZDWHUWDQNGUDLQYDOYHVZDWHUKHDWHUGUDLQYDOYHV
and pressure relief valves.
(6) Disconnect the hose from the faucet and drain the shower head and hose from the inside out of the shower.
(7) Discharge waste water in accordance with normal procedures for tank drainage.
(QVXUHDOOSLSHVDUHGUDLQHGFRPSOHWHO\
)LQDOO\LQMHFWQRQWR[LFDQWLIUHH]HLQWRWKHZDWHUZD\SLSHV
7KHGUDLQDJHV\VWHPDORQHIDLOVWRSURYLGHDGHTXDWHSURWHFWLRQVDJDLQVWFROGZHDWKHU$QWLIUHH]HLVDPXVW
'RQRWXVHDXWRPRWLYHDQWLIUHH]HRUZLQGVFUHHQFOHDQHUDQWLIUHH]HLQWKHZDWHUV\VWHPRIWKHWUDLOHUDVWKHVHDUHKD]DUGRXVWRKHDOWK
$17,)5((=,1*0($685(6)2568%6<67(0&20321(176
:$7(5+($7(5$1'7$1.
(QVXUHWKDWWKHSXPSVZLWFKLVRƈ
,QVHUWWKHKRVHIURPWKHDQWLIUHH]HYDOYHLQWRDQRQWR[LFDQWLIUHH]HFRQWDLQHU
7XUQWKHZDWHUKHDWHUE\SDVVYDOYHWRE\SDVVSRVLWLRQDQGGUDLQZDWHUIURPWKHKHDWHUE\UHPRYLQJWKHGUDLQSOXJDQGRSHQLQJWKH
UHOLHIYDOYH7XUQRQWKHIDXFHWWRUHOLHYHSUHVVXUH2SHQWKHORZSRLQWGUDLQRIWKHKRWDQGFROGSLSHV
2SHQWKHGUDLQSLSHRIWKHZDWHUWDQNHPSW\WKHWDQNDQGNHHSWKHGUDLQSLSHRSHQ
$IWHUWKHV\VWHPLVGUDLQHGFORVHDOOIDXFHWVDQGORZSRLQWGUDLQYDOYHV
7XUQWKHDQWLIUHH]LQJYDOYHWRʼnDQWLIUHH]LQJŊSRVLWLRQ
7XUQRQWKHSXPSVZLWFK
7XUQRQWKHKRWZDWHUIDXFHWIXUWKHVWIURPWKHWDQN:KHQWKHZDWHUZD\SLSHLVƉOOHGZLWKDQWLIUHH]HOHWDWOHDVWRQHFXSRIZDWHUƊRZ
LQWRWKHGUDLQWRSUHYHQWWKH3WUDSIURPIUHH]LQJ7KLVDOVRDSSOLHVWRRWKHUKRWDQGFROGGUDLQDJHRXWOHWVLQFOXGLQJVKRZHUVWRLOHWV
and outdoor showers.
7XUQRƈWKHSXPS
7XUQRQWKHIDXFHWWRUHOLHYHSUHVVXUHWKHQWXUQLWRƈ
&RPSOHWHRSHUDWLRQ
6(59,&($1'0$,17(1$1&( 5
:$7(5+($7(56+817,)$1<
7KHZDWHUKHDWHUVKXQWYDOYHORFDWHGEHKLQGWKHZDWHUKHDWHULVXVHGWRSURWHFW
WKHZDWHUKHDWHUIURPIUHH]LQJ5RWDWHWKHKDQGOHWRWKHVKXQWSRVLWLRQDQGWKH
DQWLIUHH]HZLOOQRWHQWHUWKHZDWHUKHDWHU$VPDOODPRXQWRIDQWLIUHH]HPD\
protect the water system pipeline.
CAUTION:
0DNHVXUHWRRSHQWKHGUDLQSOXJDWWKHERWWRPRIWKHZDWHUKHDWHUDQGRSHQWKH
pressure relief valve to drain water from the water heater.
)LOOWKHWDQNZLWKZDWHU
$GMXVWWKHDQWLIUHH]LQJYDOYHWRWKHQRUPDOƊRZSRVLWLRQ
7XUQWKHZDWHUKHDWHUE\SDVVYDOYHWRʼnE\SDVVŊVRDVWRSUHYHQWDQWLIUHH]HIURPHQWHULQJWKHZDWHUKHDWHU
7XUQRQWKHSXPSVZLWFK
(5) 7XUQRQWKHIDXFHWIDUWKHVWIURPWKHWDQNDQGVWRUHWKHDQWLIUHH]HLQWKHFRQWDLQHUXQWLOFOHDUZDWHUDSSHDUV7XUQRƈWKHIDXFHW
7KLVDSSOLHVWRRWKHUIDXFHWVDQGVKRZHUKHDGVLQFOXGLQJRXWGRRUVKRZHUKHDGV
6HWZDWHUKHDWHUE\SDVVYDOYHWRQRUPDOƊRZSRVLWLRQ
7XUQRQWKHKRWZDWHUIDXFHWXQWLOZDWHUUXQVRXW
,QMHFWDQWLIUHH]HV
<RXDUHDVVXPHGWRFDUHIXOO\VWRUHWKHWUDLOHUDQGWDNHHƈHFWLYHDQWLIUHH]LQJPHDVXUHVLQWKHDERYHSURFHGXUHV)DLOXUHWRIROORZ
DERYHVWHSVPD\OHDGWRH[WHQVLYHIUHH]LQJGDPDJHVRURWKHUVHULRXVGDPDJHV
(;7(51$/$5($
(1) 7KRURXJKO\LQVSHFWWKHRXWVLGHRIWKHWUDLOHUDQGRSHQDOOGRRUVDQGZLQGRZV&KHFNIRUDQLPDORULQVHFWLQYDVLRQRURWKHUGDPDJHV
5HPRYHDOODSSOLDQFHYHQWVFHLOLQJYHQWVDQGDLUFRQGLWLRQLQJFRYHUV
0DNHVXUHRSHQLQJVRIWKHVWRYHZDWHUKHDWHUDQGUHIULJHUDWRUDUHFOHDQDQGIUHHRIGHEULVLQVHFWQHVWVFREZHEVHWF
CAUTION:
6SLGHUVDQGRWKHUVPDOOLQVHFWVPD\FUDZOLQWRWKHEXUQHUWXEH6SLGHUVPD\VSLQZHEVEXLOGQHVWVRUOD\HJJVWKHUH7KHVHZHEVDQG
QHVWVPD\EHYHU\VPDOOEXWVWURQJHQRXJKWRVWRSWKHJDVƊRZ
97+()2//2:,1*0$1'$725<83.((3,7(060867%(
,03/(0(17('%<%/$&.6(5,(6&$03(566725(625
352)(66,21$/83.((3250$,17(1$1&(6(59,&(
3529,'(5672*8$5$17((7+(75$9(/6$)(7<
Operation Tips
Chapter VI Upkeep and Maintenance
101
V. The following mandatory upkeep items must be implemented by Black Series
Camper 4S stores or professional upkeep or maintenance service providers to
guarantee the travel safety.
Compulsory maintenance item Maintenance content First
maintenance Maintenance period
Wheel hub assembly
Check whether the wheel retaining bolts and nuts are loose, check
bolt wear, and retighten or replace hub nuts or bolts according to
the inspection result. Replace the bolts and nuts if there is a
potential hazard related to wear. Replace wheel hubs with cracks,
pits or other damages.
First
maintenance at
1,000km mileage
Receive maintenance
once for every
5,000km mileage, or
at the 6th month if the
mileage is less than
5,000km
Tires
Check for wear, bulge, cut or other damages, and replace the tire
in case of any hidden danger. The tire pressure must meet the
requirements of the selected tire specification.
Brake assembly
Disassemble the brake hub to check the fastening and wearing
conditions of the fastener, the loss of lubricating grease and check
if the bearing is working normally. Check whether the brake wiring
is exposed or worn. Check whether the bearing is corroded or
worn, clean or reassemble it, and readjust the brake operating
clearance. Replace the bearing every 10,000km mileage, and
6(59,&($1'0$,17(1$1&( 6
Chapter VI Upkeep and Maintenance
102
Compulsory maintenance item Maintenance content First
maintenance Maintenance period
replace it immediately in case of any abnormality during
maintenance.
Damper Check for leakage, and test damper performance.
Hand brake Check the brake performance, adjust the brake wire.
Towing device Check bolt status and lubricate the spring fixing part of the towing
device.
Brake synchronizer Check its performance against standard requirement.
Electromagnetic brake system
Check whether the brake pad, electromagnetic system and circuits
are worn, whether such wear is normal, and check contact
sensitivity. Clean the system again. Check the electromagnet wear,
electric current attraction, and replace with new brake parts in
case of any hidden danger.
Electric system Check the electric system and equipment, ensure they are
operating normally, repair and upgrade the electric system.
Gas system Check and maintain gas system, equipment and safety
components.
Water system Check whether the water pump and water level gauge are normal
and whether the pipeline leaks.
External signal light of trailer
Check whether the turn light, brake light, clearance lamp, parking
light, fog light, reversing light, license plate light and alarm light are
working properly.
Indoor light Check whether all indoor lamps are working properly
Gas alarm Test the sensitivity in gas leak alarm, and battery level.
First
maintenance at
1,000km mileage
Receive maintenance
once for every
5,000km mileage, or
at the 6th month if the
mileage is less than
5,000km
Air conditioning system
Check whether the air conditioner works properly, whether the air
conditioner is clean, and whether the air conditioner components
are damaged.
Control panel Check whether the control switches on the control panel work
normally.
Electric step Check whether the electric step and component function are
normal.
Stereo system Check whether it is working properly.
First
maintenance at
1,000km mileage
Receive maintenance
once for every
5,000km mileage, or
at the 6th month if the
mileage is less than
5,000km
Water tanks Check for damages or leaks.
Fuel tank Check for damages or leaks.
Battery Check batter charging and discharging functions, and check
whether the electric power storage capability is normal.
Inverter Check whether it is working properly.
Power supply system circuit
Check whether external cables are in good condition, whether
connection terminals are fastened, and whether sockets are
normal.
Charging system
Check whether the solar charging and solar panels,
modules/Andersen charging system/shore power charging system
are working properly, check functions of components.
Electric leakage protection Check whether it is working properly.
Spare wheel carrier Check whether it is fastened firmly.
Chassis bolt Check whether it is fastened firmly.
Balancing of tires Dynamic balance check
Remarks: warranty period of consumables and wearing parts is 6 months.
6(59,&($1'0$,17(1$1&( 7
&WARNING
$FKDQJHWRPHWDOVWUHVVEHWZHHQWKHKXEDQGWKHIDVWHQLQJQXWEROWZLOOFDXVHORRVHQLQJRIWKHIDVWHQLQJ:KHHOVIDOOLQJRƈPD\
UHVXOWLQVHULRXVVDIHW\DFFLGHQWVRUHYHQFDVXDOWLHV&KHFNDQGWLJKWHQQXWVEROWVEHIRUHHDFKWULS
&WARNING
5HLQVWDOOHGKXEDVVHPEO\QXWVDUHHDV\WRORRVHDQGPXVWEHFKHFNHGIRUWKHWLJKWQHVVRIFODPSQXWLQWKHƉUVWNPNPDQG
NPPLOHDJHV
HUB NUT FASTENING (TORQUE)
Ensuring fastened wheel mounting nuts and proper torque for the trailer is an important safety responsibility that users need to
IDPLOLDUL]HWKHPVHOYHVZLWKDQGSUDFWLFH7KHXVHUPXVWSHUIRUPPDLQWHQDQFHRQWKHKXEDVVHPEO\IRUWKHVDNHRIVDIHW\,QVXƋFLHQW
or inappropriate torque (tightness) of the wheel nut is the main reason for the loosening of the bearing nut in use. Loose nuts can
TXLFNO\OHDGWRZKHHOVHSDUDWLRQZLWKVHULRXVVDIHW\FRQVHTXHQFHV+RZHYHUH[FHVVLYHWLJKWHQLQJZLOOOHDGWREROWIUDFWXUHRUSHUPDQHQW
GHIRUPDWLRQRIEROWKROHVLQVWDOOHGRQWKHZKHHOZKLFKZLOODOVRFDXVHVHULRXVVDIHW\DFFLGHQWVDQGHYHQFDVXDOWLHVUHODWHGWRZKHHO
shedding.
·&KHFNKXEQXWWLJKWQHVVEHIRUHHDFKWULS
·7KHRQO\ZD\WRHQVXUHWLJKWQHVVRUWRUTXHRIWKHQXWLVWRXVHDWRUTXHZUHQFK7RROVOLNHDIRXUZD\ZUHQFKFDQEHXVHGIRU
VKRUWWHUPHPHUJHQF\UHSDLUVEXWWKH\DUHQRWVXLWDEOHWRROVIRUFKHFNLQJQXWWRUTXHDFFXUDWHO\7KHWRUTXHZUHQFKLVDPXVWWR
indicate exactly how much torque you are applying to the nut.
·1RWHWKHPLOHDJHZKHQ\RXFKHFNQXWWRUTXH'HWHUPLQHWKHWLPHRIWKHQH[WPDLQWHQDQFH
·3OHDVHLPPHGLDWHO\UHVRUWWRSURIHVVLRQDOPDLQWHQDQFHVHUYLFHSURYLGHUVLQFDVHRIDQ\SHUVLVWHQWQXWORRVHQLQJ
CAUTION:
7LJKWHQWKHQXWVLQWKHVHTXHQFHVKRZQLQʼn1XW7LJKWHQLQJ6HTXHQFHŊ1XWVORRVHQHDVLO\DIWHUWKHƉUVWDVVHPEO\)RUWKHLQVWDOODWLRQ
DQGIDVWHQLQJSURFHGXUHVRIKXEQXWVSOHDVHIROORZ6HFWLRQ&KDSWHU,9RIWKHPDQXDOʼn&RUUHFW7LJKWHQLQJ7RUTXHRI+XE1XW,V
&ULWLFDOWR'ULYLQJ6DIHW\Ŋ
1HYHULQVWDOOQRQRULJLQDOZKHHOKXEVRUQXWVRQ\RXUWUDLOHU7KHQRQRULJLQDOKXEDQGQXWFDQQRWPHHWWKHORDGEHDULQJDQGRƈVHW
RIWKHRULJLQDOHTXLSPHQWDQGRWKHUVDIHW\WHFKQLFDOUHTXLUHPHQWV'RQRWLQVWDOODOXPLQXPZKHHOVRQKXEVVWXGVGHVLJQHGIRUVWHHO
ZKHHOV7KHVWXGOHQJWKUHTXLUHGE\DOXPLQXPZKHHOLVODUJHUWKDQWKDWUHTXLUHGE\VWHHOZKHHO
TIRES
&WARNING
3OHDVHFKHFNWKHWLUHSUHVVXUHEHIRUHGULYLQJDQGPDNHLWUHDFKWKHVWDQGDUGYDOXH&KHFNWLUHSUHVVXUHZKHQLWLVFROG'RQRWFKHFN
WKHWLUHSUHVVXUHLPPHGLDWHO\ZKHQWKHWUDLOHUVWRSVDIWHUWUDYHOLQJDFHUWDLQGLVWDQFHHYHQLIRQO\NPNHHSWKHWLUHFRROIRUDW
OHDVWKRXUV&KHFNWKHVLGHVRIHDFKWLUHIRUEXEEOHVFXWVRUEXOJHV$QLQƊDWHGVLGHZLWKEXEEOHVRUFXWVFRXOGFDXVHWKHWLUHWR
EXUVW:RUQGDPDJHGRUXQGHULQƊDWHGWLUHVFDQFDXVHWKHYHKLFOHWRORVHFRQWURO5HSODFHWKHEURNHQWLUHEHIRUHWRZLQJWKHWUDLOHU
2ƈURDGWUDLOHUWLUHVDUHUHSODFHGHYHU\NPPLOHDJHRU\HDUVHUYLFHOLIHXQGHUQRUPDOFRQGLWLRQVZKLFKHYHUFRPHV
ƉUVW
5HSODFHPHQWWLUHVPXVWFRQIRUPWRWKHVSHFLƉFDWLRQVRIWKHRULJLQDOWLUHV0LVPDWFKHGWLUHVDQGULPVPD\FDXVHWLUHVWRƊ\RXWDQG
EORZRXWGXHWRXQEDODQFHGIRUFHVUHVXOWLQJLQVHULRXVFDVXDOWLHV
)RUSUHFDXWLRQVRQWLUHLQVWDOODWLRQDQGPDLQWHQDQFHSOHDVHIROORZ6HFWLRQRI&KDSWHU,9RIWKHPDQXDOʼn6DIHW\FRPHVƉUVWEDVLF
PDLQWHQDQFHRIWLUHVŊ
RIM
&WARNING
,IWKHULPRIWKHWUDLOHUJHWVKLWRUKLWVDKDUGFXUEFKHFNWKHULPIRUGDPDJHURXQGQHVVUHSODFHGDPDJHGULPV&KHFNWKHULPVIRU
damage during regular professional maintenance even if no apparent collision has occurred.
WHEEL BEARING
&WARNING
/RRVHZRUQRUGDPDJHGZKHHOEHDULQJVDUHWKHPRVWFRPPRQFDXVHVRIEUDNLQJV\VWHPIDLOXUHDVZHOODVRQHRIWKHLPSRUWDQW
FDXVHVRIWLUHVKHGGLQJ&KHFNWKHEHDULQJ5HSODFHWKHEHDULQJLILWFDQVKDNHWKHULPRUVZLQJWKHZKHHO%HDULQJVDUHKLJKSUHFLVLRQ
VDIHW\SDUWVDQGRUGLQDU\XVHUVPD\IDLOLQGHSHQGHQWPDLQWHQDQFHGXHWROLPLWHGNQRZOHGJHRUH[SHULHQFH7KHUHIRUHWKHOXEULFDWLRQ
inspection and maintenance of bearings must be carried out by professional institutions.
6(59,&($1'0$,17(1$1&(
ELECTRIC BRAKE
7KHUHDUHWZRGLƈHUHQWW\SHVRIHOHFWULFEUDNHVRQWKHWUDLOHU2QHLVWKHHPHUJHQF\HOHFWULFVHSDUDWLRQV\VWHPZKLFKRQO\ZRUNVLI
WKHWUDLOHUGHWDFKHVIURPWKHWRZLQJGHYLFHDQGWKHVHSDUDWLRQSLQLVSXOOHGGRZQ7KHRWKHULVWKHHOHFWULFEUDNHV\VWHPZKLFKVWDUWV
WRZRUNZKHQWKHWUDLOHUŇVEUDNHLVDFWLYDWHG7KHEUDNHV\VWHPKDVEHHQWULDOHGDQGWHVWHGZKHQOHDYLQJWKHIDFWRU\7KHPDLQWHQDQFH
RIWKHEUDNHV\VWHPLVRIYLWDOLPSRUWDQFH7KHIULFWLRQGLVFHOHFWURPDJQHWLFV\VWHPDQGIULFWLRQFOHDUDQFHPXVWEHNHSWLQQRUPDO
ZRUNLQJVWDWH,WPXVWEHPDLQWDLQHGE\SURIHVVLRQDOPDLQWHQDQFHVHUYLFHSURYLGHUVHYHU\NPPLOHDJHDQGSURIHVVLRQDORYHUKDXOLQJ
and maintenance are required immediately in case of any abnormal braking in daily driving.
&WARNING
,IWKHHOHFWULFVHSDUDWLRQEUDNHVGRQRWZRUNZKHQWKHWUDLOHULVVHSDUDWHGIURPWKHWRZLQJYHKLFOHFDVXDOWLHVRUVHULRXVVDIHW\DFFLGHQWV
PD\RFFXU&KHFNWKHHPHUJHQF\VHSDUDWLRQEUDNHV\VWHPEHIRUHHDFKWULS7KHHOHFWULFEUDNHVUXQQLQJZLWKWKHWUDFWRUEUDNHVPXVW
EHV\QFKURQL]HGVRWKDWWKHEUDNHVDUHFRUUHFWO\DVVLJQHGWRWKHWUDFWRUDQGWUDLOHUEUDNHV
SIGNAL LIGHT
&KHFNWKHRSHUDWLRQRIOLJKWVVLJQDOOLJKWVRXWVLGHWKHWUDLOHUEHIRUHHDFKWULS0DNHVXUHWKHWUDFWRUDQGWUDLOHUKDYHV\QFKURQL]HG
OLJKWVLJQDOV'DPDJHGVLJQDOOLJKWFDQQRWVHQGFOHDUVLJQDORIGULYLQJLQWHQWLRQWRWKHIROORZLQJYHKLFOHWKXVFDXVLQJPLVMXGJPHQW
RIWKHIROORZLQJYHKLFOHUHVXOWLQJLQWUDƋFVDIHW\DFFLGHQWV'RQRWEUHDNWKHVHDODQWDURXQGWKHODPSZKHQUHSODFLQJWKHFRYHUEXOE
,QVWDOOQHZODPSVZLWKVHDODQWVVDWLVIDFWRU\WRRULJLQDOIDFWRU\VWDQGDUGV
BATTERY SYSTEM CHARGING
7KHWUDLOHULVHTXLSSHGZLWKEDWWHULHVWRSRZHUOLJKWLQJHOHFWULFUHWUDFWLQJJHDUVNLGDQGRWKHU$&HOHFWULFDOHTXLSPHQW%DWWHULHVDUH
FKDUJHGE\WKHWUDFWRUJHQHUDWRURUVKRUHSRZHU'LVFRQQHFWWKHEDWWHU\VZLWFKLIWKHWUDLOHULVQRWXVHGIRUDORQJWLPHVXFKDVLQ
VHDVRQDOVWRUDJH&KHFNWKHEDWWHU\$QGHUVHQFKDUJLQJV\VWHPLQYHUWHUVRODUFKDUJLQJV\VWHPWHUPLQDOSRVWVDQGFRQQHFWLRQ
WHUPLQDOVUHJXODUO\DQGFRUUHFWDQGPDLQWDLQWKHPLPPHGLDWHO\LIWKH\DUHORRVH5HJXODUO\WHVWWKHHOHFWULFSHUIRUPDQFHRI$QGHUVHQ
FKDUJLQJFLUFXLWLQYHUWHUFKDUJLQJGLVFKDUJLQJFLUFXLWDQGVRODUFKDUJLQJFLUFXLWDQGPDLQWDLQDQGUHSDLUWKHSUREOHPVIRXQGLQD
timely manner.
FRESH WATER SYSTEM
,IDQWLIUHH]LQJPHDVXUHVKDYHEHHQWDNHQIRUWKHIUHVKZDWHUV\VWHPGUDLQWKHDQWLIUHH]HIURPWKHIUHVKZDWHUV\VWHP
7XUQRQWKHSXPSDQGWXUQRQDOOIDXFHWVXQWLOWKHDQWLIUHH]HVWRSVƊRZLQJ
2SHQWKHZDWHUKHDWHUE\SDVVYDOYH
)OXVKWKHIUHVKZDWHUV\VWHPDVGHVFULEHGLQWKHʼnIUHVKZDWHUV\VWHPŊVHFWLRQ
2SHUDWHDOOIDXFHWVDQGƉ[WXUHVIRUWKHIUHVKZDWHUV\VWHP&KHFNDOOFRQQHFWLRQVDQGƉWWLQJVIRUOHDNV5HSDLUZKHQQHFHVVDU\
GAS SYSTEM
&KHFNWKHJDVSDWKV\VWHPUHJXODUO\2SHQWKHJDVF\OLQGHUYDOYHFKHFNWKHDLUYDOYHDQG7VKDSHGFRQQHFWRUIRUOHDNVFKHFNWKH
SLSHOLQHIRUFUDFNVRUGDPDJHVDQGFKHFNWKHWLJKWQHVVRIWKHFRQQHFWLRQEHWZHHQWKHSLSHOLQHDQGWKHHTXLSPHQW2SHUDWHHDFK
JDVDSSOLDQFH2EVHUYHWKHFRORURIEXUQHUƊDPHVDQGLJQLWLRQƊDPHV
6(59,&($1'0$,17(1$1&( 9
VI. EFFECTS OF LONG-TERM STAY AND UPKEEP & MAINTENANCE
7KHWUDLOHULVGHVLJQHGIRUUHFUHDWLRQDOSXUSRVHVDQGVKRUWWHUPXVH7RXVHLWIRUDQH[WHQGHGSHULRGRIWLPH\RXQHHG
WREHSUHSDUHGWRGHDOZLWKSUREOHPVLQFOXGLQJFRQGHQVDWLRQH[FHVVLYHKXPLGLW\DQGSRVVLEOHGDPDJHGXHWRPRLVWXUHVXFK
DVPLOGHZ7KHPDWHULDOVDQGSURFHVVFKRVHQWRFRQVWUXFWWKHWUDLOHUDUHGHVLJQHGWRPLQLPL]HDLUOHDNDJHDQGFUHDWHD
ZHDWKHUSURRIHQFORVXUH+RZHYHUWRSURWHFW\RXULQYHVWPHQWDQGUHGXFHWKHULVNRIPRLVWXUHUHODWHGGDPDJHDQGUHSDLU
H[SHQVHVFDUHPXVWEHWDNHQWRPDQDJHPRLVWXUHLQVLGHWKHWUDLOHU
7KHUHODWLYHO\VPDOOVSDFHDQGDLUWLJKWVWUXFWXUHRIPRGHUQUHFUHDWLRQDOYHKLFOHVPHDQVWKDWHYHQWKHQRUPDODFWLYLWLHVRI
DIHZSHRSOHFDQFDXVHWKHPRLVWXUHFRQWDLQHGLQWKHDLULQVLGHWKHWUDLOHUWRTXLFNO\VDWXUDWHDQGEHFRPHYLVLEOHHVSHFLDOO\
in cold weather.
-XVWDVPRLVWXUHFROOHFWVRQWKHRXWVLGHRIDJODVVRIFROGZDWHURQDZHWGD\PRLVWXUHFRQGHQVHVRQWKHLQQHUVXUIDFH
RIWKHWUDLOHULQWKHHYHQWRIKLJKUHODWLYHDLUKXPLGLW\LQFROGZHDWKHU7KLVVLWXDWLRQPD\DSSHDUPRUHIUHTXHQWO\DVWKH
WUDLOHUŇVWKHUPDOO\LQVXODWHGZDOOLVPXFKWKLQQHUWKDQKRXVHZDOO$FFRUGLQJWRFDOFXODWLRQVDIDPLO\RIIRXUFDQHYDSRUDWH
XSWROLWUHVRIZDWHUDGD\E\EUHDWKLQJFRRNLQJEDWKLQJDQGZDVKLQJ8QOHVVEURXJKWRXWVLGHE\YHQWLODWLRQRUFRQGHQVHG
E\DGHKXPLGLƉHUWKHZDWHUYDSRUFRQGHQVHVDVPRLVWXUHRQWKHLQVLGHRIZLQGRZVDQGZDOOVRUDVIURVWRULFHLQFROG
ZHDWKHU,WPD\DOVRFRQGHQVHXQVHHQLQVLGHZDOOVRUFHLOLQJVZKHUHLWZLOOVKRZXSDVZDUSLQJRUVWDLQHGSDQHOV
7KHVHFRQGLWLRQVLQGLFDWHDVHULRXVFRQGHQVDWLRQSUREOHP,QFDVHRIVLJQVRIH[FHVVLYHPRLVWXUHDQGFRQGHQVDWLRQLQ
\RXUWUDLOHU\RXVKRXOGWDNHVWHSVWRPLQLPL]HWKHHƈHFWV
&DXWLRQ7KHWUDLOHUFDQQRWVHUYHDVDSHUPDQHQWKRXVH/RQJWHUPRUSHUPDQHQWXVHRIWKLVSURGXFWPD\FDXVHSUHPDWXUH
DJLQJRIVWUXFWXUHVLQWHULRUƉQLVKHVIDEULFVFDUSHWVDQGFXUWDLQV'DPDJHRUGHWHULRUDWLRQGXHWRSURORQJHGXVHLVQRW
FRQVLGHUHGQRUPDODQGFRQVWLWXWHVPLVXVHDEXVHRUQHJOLJHQFHXQGHUWKHZDUUDQW\WHUPVDQGWKHUHIRUHPD\UHGXFH\RXU
warranty protection.
6LJQVRIH[FHVVPRLVWXUHPD\EHREYLRXVVXFKDVGURSOHWVIRUPLQJRQWKHVXUIDFH,WLVLPSRUWDQWWRLGHQWLI\WKHFDXVHV
RIH[FHVVPRLVWXUHLQDWLPHO\PDQQHUDQGWDNHDSSURSULDWHFRUUHFWLYHDFWLRQVWRSUHYHQWPRLVWXUHUHODWHGGDPDJH
0RQLWRULQJDQGFRQWUROOLQJWKHUHODWLYHKXPLGLW\LQVLGHWKHWUDLOHULVRQHRIWKHPRVWLPSRUWDQWVWHSVWRPLQLPL]HWKHULVN
RIPRLVWXUHUHODWHGGDPDJH,GHDOO\WKHUHODWLYHKXPLGLW\VKRXOGEHRUOHVV5HODWLYHKXPLGLW\FDQEHPRQLWRUHGZLWK
a portable hygrometer.
([KDXVWIDQVDLUFRQGLWLRQHURUDSRUWDEOHGHKXPLGLƉHUPD\EHXVHGWRFRQWUROPRLVWXUHLQWKHWUDLOHUDQGNHHSWKHUHODWLYH
KXPLGLW\DWRUOHVV,QFROGFOLPDWHVUHODWLYHKXPLGLW\PD\QHHGWREHRUORZHUWRSUHYHQWZLQGRZFRQGHQVDWLRQ
SUREOHPV,IWKHWUDLOHULVXVHGLQDKRWDQGKXPLGHQYLURQPHQWPRVWRIWKHWLPHLWPD\EHGLƋFXOWWRNHHSWKHUHODWLYH
KXPLGLW\EHORZ'HKXPLGLƉHUVFDQKHOS
Lower surface temperatures increase the likelihood of condensation and surface mold growth.
0RLVWXUHLQWKHDLUFRQGHQVHVRQFRROVXUIDFHVVXFKDVZLQGRZV,I\RXOHDYHWKHWUDLOHUIRUDQH[WHQGHGSHULRGRIWLPHZH
UHFRPPHQGWKDW\RXGRQRWVHWWKHWHPSHUDWXUHEDFNZLWKRXWWDNLQJRWKHUVWHSVWRFRQWUROWKHUHODWLYHKXPLGLW\LQFOXGLQJ
XVLQJDGHKXPLGLƉHU:LQGRZFRQGHQVDWLRQSUREOHPVFDQEHLGHQWLƉHGE\ZDWHURULFLQJXVXDOO\DWWKHERWWRPRIWKH
ZLQGRZ0RVWRIWKHVHSUREOHPVFDQEHVROYHGE\FRQWUROOLQJWKHPRLVWXUHJHQHUDWHGLQVLGHWKHWUDLOHU0LQRUFRQGHQVDWLRQ
SUREOHPVDUHQRWXQFRPPRQHVSHFLDOO\IRUWUDLOHUVXVHGLQFROGFOLPDWHV7KHNH\LVWRPDLQWDLQUHDVRQDEOHUHODWLYH
humidity in the device.
7RPLQLPL]HZLQGRZFRQGHQVDWLRQXVHH[KDXVWIDQVWKDWRSHQWRWKHRXWVLGHSUHYHQWGUDVWLFFKDQJHVWRWKHUPRVWDW
VHWWLQJVGRQRWXVHʼnYHQWIUHHŊKHDWHUVXVHFXUWDLQVZLVHO\2URSHQFXUWDLQVRUORXYHUVLQWKHGD\WLPHWRDOORZDLUWR
circulate and protect window surfaces.
6WRUDJHDUHDVDUHPRUHGLƋFXOWWRDGMXVWEHFDXVHWKH\DUHLVRODWHGIURPWKHPDLQERG\RIWKHWUDLOHU7KHVXUIDFHVRI
WKHVHDUHDVDUHPRUHSURQHWRFRQGHQVDWLRQDQGVXUIDFHPROGJURZWK7RPLQLPL]HWKLVULVNSOHDVHFOHDQVWRUDJHDUHDV
UHJXODUO\DQGDOORZDLUVSDFHEHWZHHQVWRUHGLWHPVDQGH[WHULRUZDOOVWRIDFLOLWDWHDLUFLUFXODWLRQ)RUSURORQJHGXVHLQ
YHU\FROGZHDWKHUNHHSFDELQHWDQGFORVHWGRRUVSDUWLDOO\RSHQWRZDUPDQGYHQWLODWHWKHLQWHULRURIWKHVWRUDJHURRP
EXLOWDJDLQVWWKHH[WHULRUZDOO7KHDLUƊRZZLOOKHDWWKHH[WHULRUZDOOVXUIDFHVUHGXFLQJRUHOLPLQDWLQJFRQGHQVDWLRQDQG
PLQLPL]LQJSRVVLEOHLFLQJ
6(59,&($1'0$,17(1$1&(
1RQYHQWLODWHGFRPEXVWLRQHTXLSPHQWVXFKDVWKHVWRYHLVWKHVRXUFHRIPRLVWXUHLQWKHWUDLOHU)RUHYHU\OLWHURIIXH
FRQVXPHGDERXWDOLWHURIZDWHUYDSRUHYDSRUDWHVLQWRWKHDLU:KHUHSRVVLEOHXVHH[KDXVWIDQVLQFRQMXQFWLRQZLWKDQ\
QRQYHQWLODWHGFRPEXVWLRQHTXLSPHQWLQWKHWUDLOHU:DWHUYDSRUDQGRWKHUFRPEXVWLRQE\SURGXFWVVKRXOGEHYHQWHGWR
WKHRXWVLGHRIWKHWUDLOHU<RXQHHGWRVWULFWO\IROORZWKHLQVWUXFWLRQVIRUXVHDQGPDLQWHQDQFHVRDVWRVDIHO\RSHUDWHDQ\
FRPEXVWLRQHTXLSPHQWHVSHFLDOO\QRQYHQWLODWHGHTXLSPHQW
7KHWUDLOHUŇVHQFORVXUHLVWKHPDLQEDUULHUDJDLQVWZHDWKHUDQGPRLVWXUH7KHHQFORVXUHUHTXLUHVUHJXODUPDLQWHQDQFH
WKURXJKRXWWKHOLIHF\FOHRIWKHWUDLOHU7KHHQFORVXUHLQFOXGHVWKHWUDLOHUŇVURRIVLGHZDOOVZLQGRZVGRRUVDQGƊRRUV6SHFLDO
FDUHVKRXOGEHWDNHQWRHQVXUHWKDWWKHVHFRPSRQHQWVDUHPDLQWDLQHGDQGWRHQVXUHWLJKWEDUULHUVDJDLQVWZDWHULQWUXVLRQ
7KHH[WHULRUVVKRXOGEHLQVSHFWHGSHULRGLFDOO\IRUWHDUVFUDFNVDQGVHDODQWFRQGLWLRQV$UHDVUHTXLULQJPDLQWHQDQFHVKRXOG
be resealed with a high quality sealant similar to that used in the trailer manufacturing process.
6SHFLDOFDUHVKRXOGEHWDNHQWRHQVXUHWKHQRUPDORSHUDWLRQRIWKHVOLGHRXWGHYLFH(DFKWLPHWKHVOLGHRXWGHYLFHLV
XVHGLWVKRXOGEHFKHFNHGWRHQVXUHSURSHURSHUDWLRQDQGVHDOLQJ6OLGHRXWJDVNHWVVKRXOGEHFKHFNHGWRHQVXUHSURSHU
VHDOLQJRIVOLGHRXWRSHUDWLRQ
,WLVLPSRUWDQWWRUHPHPEHUWKDWFRYHUDJHDUHDRIWKHWUDLOHULVVLJQLƉFDQWO\VPDOOHUWKDQWKDWRIDVLQJOHIDPLO\KRXVH7KLV
IDFWDORQHZLOOLQFUHDVHUHODWLYHKXPLGLW\EHFDXVHWKHUHLVOHVVDLUWRKHOSDEVRUERUGLVVLSDWHPRLVWXUH)RUH[DPSOHVKRZHULQJ
DQGFRRNLQJPD\FUHDWHDORWRIKXPLGLW\LQDVPDOODUHD,QWKHVHFDVHVWKHRSHUDWLQJH[KDXVWIDQVDQGRSHQZLQGRZVFDQ
UHGXFHUHODWLYHKXPLGLW\HVSHFLDOO\IRUSURORQJHGUHVLGHQFHLQWKHWUDLOHU
)RUSURORQJHGXVHRIWKHWUDLOHULQKDUVKHQYLURQPHQWVVXFKDVH[WUHPHO\FROGRUKRWKXPLGFOLPDWHVH[WUDFDUHDQG
PDLQWHQDQFHDUHUHTXLUHGWRDYRLGPRLVWXUHUHODWHGSUREOHPV
,QH[WUHPHO\FROGDQGKRWKXPLGFOLPDWHVPRUHDWWHQWLRQQHHGVWREHSDLGWRFRQWUROOLQJUHODWLYHKXPLGLW\LQVLGHWKHWUDLOHU
,WPD\DOVREHQHFHVVDU\WRNHHSUHODWLYHKXPLGLW\ZLWKLQDFFHSWDEOHOLPLWVZLWKDSRUWDEOHGHKXPLGLƉHU
&DUHPXVWEHWDNHQWRHQVXUHWKDWZHWDLUVRXUFHVDUHDGGUHVVHGGXULQJWKHWLPHZKHQWKHWUDLOHULVQRWLQXVH$QHQFORVHG
FOLPDWHFRQWUROOHGHQYLURQPHQWLVLGHDOIRUWKHVWRUDJHRIDWUDLOHU
,IWKLVHQYLURQPHQWLVLPSRVVLEOHWKHIROORZLQJVWHSVVKRXOGEHWDNHQIRUPRLVWXUHFRQWURO
·6KXWRƈDOOZDWHUVRXUFHV
·7XUQRƈDOOFRPEXVWLRQDSSOLDQFHV
·Empty the water tank.
·Empty the water heater.
·2SHQDOOFORVHWVFDELQHWGRRUVDQGGUDZHUV
·&ORVHDOOZLQGRZVDQGDFFHVVGRRUV
·2SHQWKHYHQWVIRUOLPLWHGDLUƊRZVSUHYHQWUDLQRUVQRZIURPHQWHULQJ
·8VHGHKXPLGLƉHUVWKDWRSHQWRWKHRXWVLGHWRFRQWUROWKHKXPLGLW\LQVLGHWKHWUDLOHULQWKHHYHQWRIVWRUDJHLQKLJK
KXPLGLW\FOLPDWHVUHODWLYHDPELHQWKXPLGLW\LVDERYHDOO\HDUORQJ
$UHDVH[SRVHGWRZDWHUVSLOOVRUOHDNVVKRXOGEHGULHGDVVRRQDVSRVVLEOHZLWKLQKRXUV5DSLGGU\LQJPLQLPL]HV
WKHFKDQFHRIPRLVWXUHUHODWHGGDPDJHDQGSRVVLEOHPROGZKLFKPD\EHJLQWRIRUPFRORQLHVZLWKLQKRXUV
'U\LQJPD\EHIDFLOLWDWHGLQWKHIROORZLQJPHWKRGV
·Vacuum to remove excess water.
·8VHDGHKXPLGLƉHU
·8VHSRUWDEOHIDQVWRƊRZDLURYHUWKHVXUIDFH
·7DNHDOOVLJQVRIFRQGHQVDWLRQDQGRYHUƊRZVHULRXVO\DQGWUHDWWKHPSURPSWO\DVPRLVWXUHLVWKHNH\WRPROGJURZWK
)DLOXUHWRGHDOZLWKPRLVWXUHSUREOHPVLQDWLPHO\PDQQHUPD\OHDGWRPRUHVHULRXVSUREOHPVWKDWGLGQŇWH[LVWLQWKH
ƉUVWSODFHRUPDNHVPDOOSUREOHPVZRUVH
·/HDUQWRUHFRJQL]HWKHVLJQVRIPROG'RQRWFRYHUXSVXVSLFLRXVGLVFRORUDWLRQXQWLO\RXDUHVXUHLWLVQRWPROG$ƈHFWHG
VXUIDFHVPXVWƉUVWEHFOHDQHGDQGGULHG
·$VSDUWRI\RXUFOHDQXSEHVXUHWRXQGHUVWDQGDQGHOLPLQDWHVRXUFHVRIZDWHUEXLOGXS2WKHUZLVHWKLVSUREOHPZLOOKDSSHQDJDLQ
·&OHDQLPPHGLDWHO\ZKHQWKHUHLVDVPDOODPRXQWRIPROG&OHDQVPDOOPROGDUHDVZLWKVWDLQUHPRYHURUVRDSVROXWLRQ
RUDSSURSULDWHKRXVHKROGFOHDQHUV&OHDQHGDUHDVVKRXOGEHGULHGWKRURXJKO\'LVFDUGDQ\VSRQJHVRUUDJVXVHGWR
clean mold.
6(59,&($1'0$,17(1$1&( 11
$IWHUSXUFKDVLQJDQHZWUDLOHUDQGXVLQJLWIRUDSHULRGRIWLPH\RXPD\QRWLFHVRPHVWURQJRGRUVDQGIHHOVRPHFKHPLFDO
VHQVLWLYLW\,WLVQRWDWUDLOHUSUREOHP0DQ\GLƈHUHQWSURGXFWVDUHXVHGWREXLOG\RXUWUDLOHU6RPHRIWKHVHPDWHULDOVVXFK
DVFDUSHWVOLQROHXPSO\ZRRGLQVXODWLRQDQGXSKROVWHU\PD\ʼnGLVFKDUJHŊGLƈHUHQWFKHPLFDOV7KLVGLVFKDUJHLVSDUWLFXODUO\
HYLGHQWZKHQWKHPDWHULDOVDUHQHZRUH[SRVHGWRKLJKWHPSHUDWXUHDQGRUKXPLGLW\%HFDXVHRIDPXFKVPDOOHUVL]HRI
WKHWUDLOHUFRPSDUHGWR\RXUKRXVHDQGORZHUIUHTXHQF\RIDLUH[FKDQJHLQVLGHWKHWUDLOHUWKHFRQFHQWUDWLRQRIWKHVH
FKHPLFDOVLQWKHWUDLOHULVPRUHSURQRXQFHG7KLVVLWXDWLRQPD\GLVDSSHDURYHUWLPH+RZHYHULQH[WUHPHFDVHV\RXFDQ
RSHQGRRUVZLQGRZVDQGYHQWVIRUDLUYHQWLODWLRQIRUVHYHUDOKRXUV
6(59,&($1'0$,17(1$1&( 12
19501 E. Walnut Dr South City of Industry,CA 91748 USA
ADDRESS:
Website:
www.blackseries.net
Tel.:
(833) 822-6737
Email:
&+$37(5,,1752'8&7,21 6
Table of contents
