Blue Creek CCE9300 series User manual

INSTALLATIONINSTRUCTIONS
Built-In Electric Cooktops -CCE9300 Series
l
4" 221/4"
(10.16crn)51crn)
\
41" i -- SEEINSTALLATIONTEMPLATE
TDETAIL.
3913/16"R_::_'::_.::i_..,,,,
(101,12cm)
21/4"
(5.72cm)
"/POSITIONINSTALLATION
TEMPLATEASSHOWN
Units provided with 3/8" (.95 cm) flexible cable 48"(121.9 cm) long with 6" (15.2 cm) wire leads at end,
furnished and installed by manufacturer (connect to 240/120 volt electrical service).
IMPORTANT:
Electric Hook Up- Theunit should be properly circuit protected andwired according to local
electricalcodes. See electricat wiring information onback. Unit power
requirementsare located on the data plate:
Unit may be installed in combustiblecountertop and adjacent to (0" from) combustiblewalls,
IMPORTANT: Save for local electrical inspector's use.

INSTALLING CABINETRY OVER YOUR ICAUTION
COOKTOP I Warrantyisvoidon equipmentinstalledother
A=30"(76.2cm)MinimumclearancebetweenIthanas:recommendedbymanufacturer.
thetopofthecooktopandthebottomofan
unprotectedwoodormetalcabinet.
A=24"(60.96cm) Minimumwhenbottomof PROPER ELECTRIC SUPPLY
woodormetalcabinetis protectedbynot Youmustprovidean adequateelectricalsupply
lessthan1/4"(0.635cm). FLAME systemasrequiredforyourcooktop.Allwire
RETARDANTmillboardcoveredwithnotless connectionsmustbeinaccordancewithlocal
thanno.28 MSGsheetsteel,0.015"(0.038 codesandproperlyinsulated.Checkwithlocal
cm)stainlesssteel,0.024"(0.061cm) utilityforgroverningelectricalcodesand
aluminumorcopper, ordinances.Intheabsenceof localelectrical
codes,the NationalElectricalCode,NFPANo.
70,governingelectric rangeinstallationsmust
befollowed.A copy ofthe NationalElectrical
Code,NFPANo.70, can be obtainedby writing
to:
_t,*National Fire Protection Association
J___ BatterymarchPark
L__ 4 " Quincy,Massachusetts02269
A two-wire,single phase,A.C. 240 volt 60 cycle
*Toeliminatetheriskofburnsorfirebyreachingover electricalsystem (properlycircuitprotectedto
heatedsurfaceunits,cabinetstoragespacelocated
abovethesurfaceunitsshouldbeavoided.Ifcabinet meetLocalCodesof NFPANo.70) mustbe
storageistobeprovided,theriskcanbereducedby provided. Unitmustbe properlygroundedin
installingarangehoodthatprojectshorizontallya accordancewith localwiring code.The chart
minimumof5inchesbeyondthebottomofthecabinets,below recommendsthe minimumcircuit
protectorandwire size if theappliance isthe
only uniton the circuit.If smallersizes ofwire
areused,the unit efficiencywill be reducedand
INSTALLATION SUGGESTIONS afire hazardmaybe created. Itis advisablethat
1.Chamferall exposededgesof decorative the electricalwiring and hookupbe
laminatetopreventdamagefromchipping, accomplishedby a competentelectrician.
2.Radiuscornersof cutoutandfileto insure
smoothedgesand preventcorner cracking.RECOMMENDEDMINIMUM
K.W.RATING CIRCUffPROTECTIONWIRESIZE
3.Roughedges, insidecornerswhich havenot ONSERIALPLATE INAMPERS (AWG)
beenroundedandforcedfitscancontributeto 0-4.9 20 12
crackingofthecountertoplaminate. 5.0-6.9 3010
7.0 - 9.9 408
4.Countertop mustbe supportedwithin3" (7.62 10.0-11.950 8
cm)of cutout. 12.0- 14.9606
8101 P247-60
(11-96-00)

C_storre,Se_',ic_ __
240EdwarssStreet,8E
ClevelandTennessee37311
Tel:423i72-3333
Fax:¢23-478-6710
30" COOKTOP WITH COIL ELEMENTS
If cooktop isto besecured to countertop, removemain top and attach burner box to countertop at four(4)
Coolers .
To removemain top fromburner box,removeall four (4) surface units and drip bowls. Removethefour (4)
mounting screws from main top. (Tabs on sideof element openings). CAUTION: Do not removegreen
ground wirefrom maintop.Whenreplacingmain top, use caution to be sure wires arenotpinched under 6_J,_c Lt_DS
switch shield. _._._
,qdrzttlt.£G_t/gt.x
FIGURE1o._ ,,'_',ts._o,,_
OF fCO_V_;T TO 240,*t20.voLT
2_
¢ot_lltT Jl¢ W'IRI_
36"COOKTOP WITH COIL ELEMENTS
Ifcooktopistobe securedtocountertop,liftthehingedmaintop.Attachtheburnerbox tocountertopatfour
(4) corners.

240EdwardsStreet,SE
Cleveland.Tennessee37311
TeE423-472-33S3
Fax:423_78-57_0
30" GLASS COOKTOP WITH SOLID ELEMENTS
INSTRUCTIONS TO APPLY FOAM TAPE
1. Remove the glasstop unit from the carton and place it upside down over two soft pads making sure control
knobs do not interfere with any surface.
2. Peeloff the backing paper from thefoamgasketprovided withthe unitandstick the adhesive backed tape
to the glassalong its edge. Installcooktop.
FIGURE3
../_OETAIL
_lflr,lu_
FI6UAE 4/--.../..
I21"30"6"WIRE LEADS
2 $/4"
DEPTH I/2"FL[XiBLE CASLE 48"LONG
FL_NISHEO ANOINSTALLED BY
MANL_ACTURER(CONNECT TO
240/120 VOLT ELECTRICAL SERVICE]
Of UNIT
2l/8'
MIN