BOND MANUFACTURING HYMH20027-3 User manual

READ BEFORE USE!
USE PROPANE GAS ONLY!
-Do not store or use gasoline or other
flammable vapors in the
vicinity of this or any other appliance.
- Service must be performed
by a qualified installer, service agency or the gas
supplier.
- WHAT TO DO IF YOU SMELL GAS:
• Immediately shut off gas supply at tank.
--CAUTION--
During Ignition procedure, one should NEVER
get his/her face close to and or above the
Burner. In case of the unnoticed flame may
suddenly be lit up and causing injury.
WARNING
Improper installation,
adjustment,alteration,service or
maintenance can cause injury or property
damage. Read the owner's manual
thoroughly before installing or servicing this
equipment. If the information in this manual
is not followed exactly, a fire or explosion
may result causing property damage,
personal injury or loss of life.
OWNER'S MANUAL
Propane cylinders sold separately.
Factory No.: HYMH20027-3 Style No.: 65208
WARNING
For Outdoor Use Only!
Use Propane Gas Only !
The propane cylinder must be disconnected
when this firebowl is not use.
If the firebowl is stored indoors,
detach and leave propane cylinder outdoors.
WARNING
WARNING
For use with cylinders marked PROPANE
only.DO NOT connect to a remote gas supply.
WARNING
This firebowl must be attended at all
times!
WARNING
1

• Young children should be carefully supervised when they are in the area of the appliance.
• Clothing or other flammable materials should not be hung from the appliance, or placed on or near the appliance.
• Any guard or other protective device removed for servicing the appliance must be replaced prior to operating the appliance.
• Installation and repair should be done by a qualified service person. The appliance should be inspected before use
and at least annually by a qualified service person. More frequent cleaning may be required as necessary.
It is imperative that control compartment, burners and circulating air passageways of the appliance be kept clean.
DANGER
*Do not use this firebowl for cooking.
*Do not burn any other materials than are supplied with and intended for use in this firebowl.
*Do not pour water into firebowl.
*The installation of this product must conform with local codes or, in the absence of local codes, with either the National Fuel
Gas Code, ANSIZ223.1/NFPA 54, or CAN/CGA-B149.1, National Gas and Propane Installation Code.
*Do not use this firebowl if any part has been under water.
*Do not store a spare or disconnected propane cylinder under or near this firebowl.
*After a period of storage, and/or non use, the propane firebowl should be checked for gas leaks and burner obstructions before
use.
*Do not operate the propane firebowl if there is a gas leak present.
*Never use a flame to check for gas leaks.
*Combustible materials should never be within 48 inches of the top, back or sides of your propane firebowl.
*Do not put any other fireblow cover or anything flammable on, or beneath the firebowl.
*The propane firebowl should never be used by children. Children must be supervised when they are anywhere
neat the appliance.
*Users should be alerted to the hazards of high surface temperatures and keep a safe distance to avoid burning or
clothing ignition.
*Pay attention when operating the firebowl. It is hot in use and should never be left unattended. Do not transit it
while in operation.
*Should fire go out while burning, turn the gas valve off. Follow the instruction and wait five minutes before attempting to
relight.
*Never use charcoal or any other solid fuel in the fireblow. Never parch clothing or other flammable materials on or near
the firebowl.
*Never lean over the open firebowl or place hands or fingers on the upper portion of an operational unit.
*Keep ventilation openings in cylinder enclosure(FIREBOWL BODY) free and clear of debris.
WARNING
########################################################################################################
Failure to follow the Dangers, Warnings and Cautions contained in this Owner’s Manual may result in serious bodily
injury or death, or in a fire or an explosion causing damage to property.
2

*Any guard or other protective device removed for servicing this fire bowl must be replaced prior to operating this
appliance.
*The maximum supply pressure is the bottle pressure.
*This appliance is designed for use with a 16.40Z (1Lb) propane gas cylinder (disposable). The propane cylinder must
be constructed and marked in accordance with the specifications for Gas cylinders of the U.S. Department of
Transportation (DOT) or the National Standards of Canada, CAN/CSA-B339, cylinders, Spheres and Tubes for
Transportation of Dangerous Goods;and Commission,as applicable.
*Cylinders must be stored outdoors in well-ventilated area out of the reach of children.
*Disconnect cylinders must have valve caps tightly installed and must not be stored in a building or any other enclosed
area.
WARNING !
########################################################################################################
* Do not light or use gas unit if lava rocks are wet. Ensure lava rocks are completely dry before igniting as
intense heat could cause the rock to crack.
* Lava Rocks could hit somebody's face or eyes during initial start of this unit , so please keep away from the
firebowl for the first 20 minutes after it has been ignited.
3

ITEM
DESCRIPTION QTY
A LAVA ROCKS 1 BOX
BDOOR
1PC
C BODY 1PC
Accessories
A
B
C
4

ITE
M
SPECIFICATION QTY PARTS NO.
ITEM
NO.
SPECIFICATION QTY PARTS NO.
1 Body 1 B00501 7
M6 x 10 Screw 3 B00507
2 Door 1 B00502 8
M6 Nuts 3 B00508
3 Burner 1 B00503 9
Round head Nuts 2 B00509
4 Burner Plate 1 B00504 10
Knob 1 B00510
5
Venturi Tube 1 B00505 11 Regulator 1B00511
6
Heat Shield 1 B00506
5

ASSEMBLY INSTRUCTIONS
* Please keep this owner's manual for future reference.
STEP 3.
(I)Make sure the gas valve is turned "OFF" before
assembling. Check each part before using the product.
To set the gas tank in the firebowl, screw it to the
regulator inlet fitting inside the firebowl.
See Figure I.
(II) Place the lave rocks on the burner averagely. See
Figure II.
(III) After assembling the gas tank, push and turn the
Control Knob counter-clockwise, then use a match or a
lighter to light the firebowl. To adjust the flame, turn
the Control Knob. Push and turn the Control Knob
clockwise to turn the flame off. See Figure I and III.
STEP 2. Cut off the binding tape on the polyfoam and
remove all the polyfoam rounding the top of the firebowl.
See Figure STEP 2.
STEP 1.(1) Lift off the carton carefully
and be wary of the accessories inside
falling away. Take away the box
containing lava rocks.
(2) Take all the packing materials away
except for the polyfoam rounding the top of
the firebowl.
See Figure STEP 1.
*If you have opened the carton and removed all packages, please disregard the STEP 1 and 2.
See the STEP 3 directly.
6

TIPS: Before Beginning ●Read the instructions thoroughly.
●For future reference, save this owner's manual.
※Keep your firebowl free and clear from combustible materials.
※Visually inspect burner from obstructions, keep tank enclosure free and clear from debris.
※After the burner and lava rocks are completely cooled down, use a soft brush to get rid of the mild stains,
loose dirt and soil. Wipe with a soft cloth.
STUBBORN STAINS
TO EXTINGUISH
STEP 4. LEAK TEST
Perform leak test in a well ventilated area outside and where no source of spark can occur.
Connect cylinder to regulator. Turn the on/off valve at the unit to the ‘off’ position to pressurize the control system.
Use a soapy water solution to check all the connections leaks before attempting to light the appliance. If a leak is
found or you smell gas, disconnect cylinder and turn valve off and do not use the appliance until repairs can be
made.
●Check and make sure that all parts are present.
TO LIGHT
Before each use, inspect all parts.
*After assembling the gas tank, push and turn the Control Knob counter-clockwise, then use a match or a
lighter to light the fireblow. To adjust the flame, turn the Control Knob. Push and turn the Control Knob
clockwise to turn the flame off.
※Push the Control Knob and turn clockwise to the "OFF" position.
※Disconnect propane cylinder to close the gas supply if not for use in a long time.
ROUTINE CARE
※Be careful not let any powder or solvent come in contact with painted or plastic components as damage may
occur.
※Stubborn stains,discoloration and possibly rust pitting can occur from exposure to
harsh outdoor conditions。
7

※Store the firebowl in a cool dry place away from direct sunlight.
※Please contact the Manufacturer for information regarding replacement parts and lava rocks, etc.
www.bondmfg.com
BOND MANUFACTURING CO.
1700 West 4th Street Antioch, CA 94509 USA
1-866-771-BOND(2663) OR TO BETTER
EXPEDITE YOUR REQUEST FEEL FREE TO EMAIL US
[e-mail]
OR LOG IN TO OUR WEBSITE UNDER CUSTOMER SERVICE SUPPORT
PLEASE CALL BOND TOLL FREE #
MAINTENANCE
IF YOU HAVE QUESTIONS OR CONCERNS
※Use Manufacturer approved or supplied replacement parts and accessories only. Otherwise may void the warranty of
this product and result in a hazardous condition.
※The propane cylinder must be disconnected and removed from the firebowl before the appliance can be stored
indoors.
8