BSL Impact Beam 17R User manual

1"
!
BSL!IMPACT!BEAM!17R!
USERS% GUIDE%
%
"
"
"
"
"
"
"
"
"
"
"
" "
"
"
"
"
"
"
"
"
"
"
"
" "
"
"
"
"
"

2"
1.%Product%Introduction:%
"
1.1"Before"unpack"the"fixture,"pls"make"sure"that"the"packing"is"in"good"condition,"following"items"will"be"found"in"the"
box:"
-The"fixture"
-This"users"guide"
-1.5m"power"cable"with"powercon"
-"Bracket"with"nuts"for"handing"installation"
-Safety"chain"
"
1.2"Specification"
Source"
l Light"source:"Osram"Sirius"HRI"280W"discharge"lamp"
l Lamp"life:"2.000"hours" "
l Luminous"Flux:"11165lumen,"170000lux@10m"
l Control:"Remote"on/off"via"DMX" "
l Ballast:"switching"mode"power"supply" "
Optical"System"
l Beam"angle:"1.3°" "
X/Y"
l Pan:"630°"(4.0"sec)"or"540°(3.58"sec),"Tilt:"265°"(2.8"sec)"
l 16-bit"resolution"
l Auto"repositioning"
Colors"
l 14+open,"interchangeable,"indexable"and"bidirectional"rainbow"effect"
l Color"bounce"
Gobos"
l Outside" ￠13.8mm,"inside" ￠6mm"
l 14+"open"static"gobos" "
l Real"indexable"and"gobo"shaking"
l Distinctive"gobo"animation"effect"
Features"
l DMX"channels:"11/13"
l Color"wheel:"13+1"colors"
l Static"gobo"wheel:"14+1"gobos"
l Motorized"focus"
l Full"range"0-100%"dimmer"
l Various"strobe"
l Forst"
l 8"facets"rotating"Effect"wheel"
l Software"upgrade"via"DMX"
l Hibernation"when"lost"DMX"for"preset"time"
l Indicate"temperature"info"of"base,"arm"and"lamp"
l Fan"speed"auto"change"according"to"temperature"
Display"
l COG"display"with"English"menu"
l Auto"lock" "

3"
l Flip"
l Back-up"communicating"IC"
"
"
1.3"Description"of"the"Device"
"
"
1. Project"lens"
2. Head"
3. Arm"
4. Base"
5. Display"
6. Foot"stand"
7. Operation"button"
"
"
"
"
"
"
" "
"
8."Mic"
"""""""""""""""""""""""""""""""""""""""""9."Mode/Esc"
"""""""""""""""""""""""""""""""""""""""""10."Down"button"
"""""""""""""""""""""""""""""""""""""""""11."Up"button"""""""""""""""""""""""""""""""""""""
12."Enter"button"
"""""""""""""""""""""""""""""""""""""""""13."Display"""""""""""""""""""""""""""""""""""""""""
14."3-pin"DMX"in""""""""""""""""""""""""""""""""""""""""
""""""""""""""""""15."3-pin"DMX"out"
"""""""""""""""""""""""""""""""""""""""""16."Powercon"in"
"""""""""""""""""""""""""""""""""""""""""17. Fuse holder" "
"""""""""""""""""""""""""""""""""""""""""18.Power"switch"
""""""""""""""""""""""""""""""""""""""""""
""""""""""""""""""""""""""""""""""""""""""
"
"
"
"
"
"
"
"
"
"
"
"
"

4"
"
1.4"Colors"and"Gobos"
"
"
Open"
"
1"
"
"
Red"
2"
"
Orange"
" 3"
"
Yellow"
" 4"
"
Blue"green"
" 5"
"
Amber"
" 6"
"
Light"bule"
" 7"
"
Green"
"8" "
"
UV"
"9" "
"
Light"red"
"10"
"
Megenta"
"11" "
"
Dark"green"
"12" "
"
Dark"yellow"
"13"
"
Blue"
"
"
"
"
"

5"
Static"gobo"wheel"
"
"
2.%Safety%and%maintenance%Information%
2.1"Safety"Info"
%%%
Before"operate"this"unit,"please"carefully"read"this"users"guide"and"keep"if"needed"in"future."It’s"
necessary"to"respect"following"rules."
%
The"disposal"of"the"device"after"lifecycle"could"damage"the"environment,"need"to"take"it"to"special"
company"for"recycling"or"return"to"authorized"dealer."
%
The"products"referred"to"in"this"manual"conform"to"the"European"Community"Directives"and"are"
therefore"marked"with"CE"logo."
%
Keep"this"device"away"from"children"and"unauthorized"users,"the"manufacturer"will"not"take"
responsibility"for"the"damage"due"to"any"disregard"of"the"information"provided"in"this"manual"and"
wrong"operation."
%
Before"operate"the"device,"pls"make"sure"the"fixture"is"in"good"housing,"ensure"pan"and"tilt"can"rotate"
in"its"complete"range."
%--0.5m%
Pls"make"sure"minimal"0.5m"distance"need"to"kept"between"the"fixture"to"any"flammable"material."
"
The"device"can"only"run"with"100-240v"voltage,"50/60Hz"power,"don’t"connect"to"any"other"wrong"
power."Disconnect"the"device"from"main"power"before"open"the"shield"or"maintenance."
"
The"device"is"designed"only"for"indoor"usage,"pls"keep"it"away"from"moisture."Do"not"expose"the"
device"under"the"sun"or"directly"to"any"other"lighting"source."
"
"
Never"look"directly"into"the"projecting"lens"when"the"fixture"is"power"on,"the"light"may"trigger"
epileptic"seizures"in"photosensitive"persons"or"persons"with"epilepsy."Especially"at"beam"effect,"
extreme"caution"and"observance"of"these"safety"instructions"is"mandatory."
%
Don’t"put"or"install"the"device"on"a"surface"that"subject"to"vibration"or"bumps."

6"
%Ta=4
5℃
%
The"device"is"supposed"to"work"in"the"temperate"range"-15°" C" and" +45°" C,"do"not"use"the"device"
when"the"temperate"exceed"this"range."
%
The"lens,"shield"need"to"be"replaced"when"obviously"broken,"never"use"the"device"when"the"shield"is"
not"completed"closed."
%
Safety"I"class"device,"need"to"be"earth"connected."
%
When"the"fixture"is"hanged"overhead,"the"safety"rope"must"be"fixed"to"the"bottom"of"the"device"to"
the"appropriate"fixing"point."
%
Always"carry"the"device"by"the"handles,"do"not"take"the"head"or"arm"directly"for"transportation."
"
"
2.2"Maintenance"
2.2.1"Operation"only"allowed"to"qualified"person,"damages"due"to"unprofessional"operation"or"remove"of"any"parts"
inside"will"not"be"considered"in"warranty"service."There"are"no"serviceable"parts"inside"the"device"or"package,"service"
only"leaves"to"authorized"dealers."
2.2.3"Never"allow"the"optical"components"contact"with"oil,"fat"or"any"other"liquid."
2.2.4"A"regular"clearance"of"the"device"is"needed"for"long-term"usage,"this"is"very"helpful"to"maintain"the"lifetime"and"
brightness"need"to"use"a"soft"and"lint-free"cloth"to"clean"the"optical"system,"fan"and"air"flowing"tunnel."
"
"
2.2.5."Trouble"Shooting"
Problems%
Possible%reasons%
Checking%or%solutions%
Device"not"power"up"
Powercon"or"power"cable"damaged"
Faulty"power"supply"
Change"a"good"power"cable"to"try"
Replace"new"power"supply"
Pan/Tilt"error"or"vibrate"
Faulty"Pan/Tilt"PCB"
Faulty"opto"sensor" "
Cable"loosen"
Replace"PT001"PCB"
Replace"opto"sensor"OP001"
Check"the"cable"connect"to"OP001"
Lamp"off"
Temperature"protection"
Fan"not"working"
Faulty"Lamp"
Dimmer"and"strobe"set"at"0"
Faulty"power"supply"
Check"the"temperature"from"menu"
Check"the"fan"speed"info"from"menu"
Replace"new"Lamp"
Set"dimmer"and"strobe"channel"at"255"
Replace"new"power"supply"
Device"not"response"to"DMX"
Faulty"communication"IC" "
Faulty"display"PCB"
Wrong"DMX"addressing"
Faulty"DMX"cable"
Replace"the"IC"with"back-up"one"in"the"display"PCB"
Replace"new"display"PCB"
Check"the"address"and"setting"
Change"to"a"good"DMX"cable"
"
2.2.6"Replacement"of"the"fuse"
Need"to"replace"with"same"type"and"rating,"which"originally"installed"in"the"device."
Step"One:"Unplug"power"cable"from"main"power."
Step"Two:"Unscrew"the"fuse"holder"out"of"the"housing"with"a"screwdriver."
Step"Three:"Remove"the"broken"fuse"and"replace"with"an"exact"same"type"of"new"fuse."
Step"Four:"Insert"the"fuse"holder"back"to"the"housing"and"screw"tight"and"reconnect"power."
%
%

7"
3.%Installation%
"
3.1"The"device"could"be"either"put"on"a"solid"and"
even"Surface,"or"mounted"upside"down"or"sideways"
like"left"picture."
""""""""""""""""""""""""""""""""""""""""""""""""""""""""3.2"The"mounting"place"must"be"sufficient"stable"
and"be"able"to"support"a"weight"of"10"times"of"the"
unit’s"weight."When"the"fixture"is"hanged,"always"
additionally"secure"the"device"with"the"safety"chain,"
fasten"the"safety"rope"at"a"suitable"position"so"that"
the"maximum"fall"of"the"projector"will"be"20"cm"
3.3"How"to"do"mounting"installation."
"
"
"
Step"one:"Installation"the"clamp"onto"the"bracket;"
Step"two:"Install"the"clamp"and"bracket"on"the"bottom"of"panel,"fasten"the"quick-locks;"
Step"three:"Install"the"whole"device"onto"appropriate"truss"and"fasten"the"clamps,"tight"the"safety"rope"with"the"truss"or"
other"fixing"point"at"a"suitable"position"that"drop"down"distance"not"exceed"20"cm."
%
%

8"
4.%Control%menu%
Default"setting"shadowed."Mark"with" ①can"be"basic"reloaded," ②"be"program"reloaded," ③can"be"private"reloaded."
Connect"
DMX"Addr"
XXX"
DMX"address"setting"
Slave"Rece"
"
Choose"Slave"mode"
Sequence"
Alon/Mast"
Choose"Sequence"
mode"
Music"
Alon/Mast"
Choose"Sound"mode"
Light"
Max"Temp"
80~130℃,"90℃"
Lamp"off"if"
temperature"
continuously"over"for"
5"minutes"
Lamp"Adjust"
CHxx=XXX….."
Adjust"value"of"each"
channels"
Information"
Lamp"Temp"
XXXC"
Temperature"of"driver"
Set"
Reset"
"
Reset"
Movement"
RPan"
RTilt"
Degr"
Enco"
Mode"
ON/OFF"
ON/OFF"
630/540"
ON/OFF"
Mod1/Mod2"
Pan"Reverse"
Tilt"Reverse"
Choose"Pan"Degree"
Encoder"wheel"on/off"
Choose"pan/tilt"mode"
UI"Set"
Mic"
Sign"
Fan"
Hibe"
Back"
Flip"
User"
0~99%,60%"
Close/Hold/Auto/Music"
Auto"Speed"/High"Speed"
OFF,"01M~99M，15M"
02~60m"02m"
ON/OFF"
Use1/Use2"
Sensitivity"of"Mic"
Mode"when"no"signal"
Fans"mode"
Sleeping"mode"
Show"backlight"time"
Display"180°reverse"
Users"mode"
Calibration"
Code"
CHxx"
XXX"
XXX"
Password:"050"
Calibrate"channel"
value"
Fixture"ID"
Rdm"Name"
-Password-"
PID"Code"
"
Name"
Password:"050"
Set"PID"of"RDM"
Software"V"
"
IC"Version"
Reload"Default"
Basic"Reload"
---Password---"
All"Reload"
ON/OFF"
XXX"
ON/OFF"
Basic"Reload"
Password:"050"
All"Reload"
"
%
%
%
%
%
%
%
%
%
%

9"
5.%DMX%connection%and%DMX%protocol%
"
5.1"DMX"addressing:" "
"
5.1.1"The"device"is"controlled"by"universal"DMX"512"protocol,"DMX"address"is"the"start"channel"used"to"receive"
instructions"from"the"external"controller."For"independent"control,"each"fixture"must"be"assigned"its"unique"address"
control"channels."For"example,"this"device"has"four"channel"modes:"11/13,"if"we"set"the"mode"at"standard"13"channels"
mode,"and"there"are"several"models"need"to"be"independently"controlled,"we"just"simply"address"first"fixture"at"1,"and"
second"fixture"at"12,"third"one"at"23,"etc." "
If"the"devices"have"the"same"address,"they"will"behave"synchronically." "
DMX"addressing"is"limited,"don’t"set"the"address"so"high"that"without"enough"control"channels"for"the"fixtures."
Display"is"flashing"when"no"DMX"signal"is"received."
"
5.1.2"This"device"is"equipped"with"3-pins"DMX"in"and"out"sockets"only."
"
"""""""""""""""""""""""""""""""""""Pin"1"="GND"
"""""""""""""""""""""""""""""""""""Pin"2"="Signal"(-)"
"""""""""""""""""""""""""""""""""""Pin"3"="Signal"(+)"
"
5.1.3"The"termination"is"prepared"by"soldering"a"120Ω"resistor"between"pins"2"and"3."
"
"
"
"
"
"
"
5.1.4"Connection:"us"DMX"cable"with"3-pin"XLR-plugs"to"connect"the"controller"with"the"fixture"or"one"fixture"with"
another."
5.2"DMX"chart"
Channel"
name"
function"
Min"DMX"
Max"DMX"
St"
Ex"
1"
1"
Pan"
Pan"Coarse"
0"
255"

10"
"
2"
Pan"fine"
Pan"Fine"
0"
255"
2"
3"
Tilt"
Tilt"Coarse"
0"
255"
"
4"
Tilt"fine"
Tilt"Fine"
0"
255"
3"
5"
Movment"Speed"
fastest"to"Slowest"
0"
247"
Movement"With"Backout"
248"
255"
4"
6"
Shutter"
Shutter"closed"
0"
31"
No"function"(shutter"open)"
32"
63"
Strobe"effect"slow"to"fast" "
64"
95"
No"function"(shutter"open)"
96"
127"
Pulse-effect"in"sequences"
128"
159"
No"function"(shutter"open)"
160"
191"
Random"strobe"effect"slow"to"fast"
192"
223"
No"function"(shutter"open)"
224"
255"
5"
7"
Dimmer"
Dimmer(Close"to"Open)"
0"
255"
6"
8"
Color"
Indexed"
"
"
Position"1"(Open)"
0"
1"
Position"2"
2"
3"
Position"3"
4"
5"
Position"4"
6"
7"
Position"5"
8"
9"
Position"6"
10"
11"
Position"7"
12"
13"
Position"8"
14"
15"
Position"9"
16"
17"
Position"10"
18"
19"
Position"11"
20"
21"
Position"12"
22"
23"
Position"13"
24"
25"
Position"14"
26"
27"
Indexed"With"Backout"
"
"
Position"1"(Open)"
28"
29"
Position"2" "
30"
31"
Position"3" "
32"
33"
Position"4" "
34"
35"
Position"5" "
36"
37"
Position"6" "
38"
39"
Position"7" "
40"
41"
Position"8" "
42"
43"
Position"9" "
44"
45"
Position"10" "
46"
47"
Position"11" "
48"
49"
Position"12" "
50"
51"
Position"13" "
52"
53"
Position"14" "
54"
55"
Indexed"With"Bounce"
"
"
Position"1"
56"
67"