Burco CTGD01 User manual

Electric Griddle
These instructions cover the Burco electric griddle model CTGD01, SKU 444449316
CTGD01
SKU 444449316
Glen Dimplex Professional Appliances
Stoney Lane, Prescot, Merseyside, L35 2XW
Tel: [phone]
www.burco.co.uk
User Instruction Manual

INTRODUCTION.
To ensure you obtain full benets from your new griddle:
• Please read this instruction booklet carefully, and follow all instructions.
• If you are unsure of any aspect of the installation, use or performance of your
appliance, please contact the after sales number shown on the back page.
SPECIFICATIONS
Model CTGD01
SKU Number 444449316
Dimensions Height 275 mm
Width 600 mm
Depth 600 mm
Weight 55 kg
Voltage 230 V ~50 Hz
Power rating 2.9 kW
INSTALLATION
Installation Requirements
It is essential that this appliance is installed correctly. Installation should comply with all
local electrical, and health and safety requirements.
Before Connection to Power Supply:
Remove all packaging.
Check the griddle for damage. Report any damage immediately to the carrier or supplier.
Remove any protective plastic coating from the outer panels.
Check the available power supply corresponds to that shown on the griddle rating label.
Location:
This griddle is for indoor use only.
Do not install the griddle in a cabinet, it is for counter top use only. Allow at least these
clearances - top 500mm, rear 100mm, sides 100mm.
The appliance is only to be installed in locations where its use and maintenance is
restricted to trained personnel.
The mains lead should reach from the mains socket without straining the connections.
Do not let the mains lead hang over the edge of the table or counter, and keep it away
from any hot surfaces.
Do not let the mains lead run across an open space
Do not place the appliance where the mains lead could fall into a sink.
Do not place the appliance near a hot gas or electric burner.
Ensure the appliance is installed on a level, rm surface that is capable of supporting
the weight of the appliance.Do not place on surfaces or near any wall, partition or
kitchen furniture unless they are made from non-combustible material, or clad with non-
combustible heat insulating material.
Important:
DO NOT OBSTRUCT VENTILATION AROUND THE FRONT AND REAR OF THE
APPLIANCE.

Electrical Connection:
Fitting a plug
The mains lead of this appliance will already be tted with a BS1363 13A plug. If the fuse
has to be replaced, use a 13 amp fuse complying with BS 1362.
If the plug is not suitable for your socket then the plug must be cut off and disposed of safely.
An appropriate plug should be tted as follows:
IMPORTANT: The wires in the mains lead are coloured in accordance with the following
code:
Green and Yellow - Earth
Blue - Neutral
Brown - Live
The wire which is coloured green and yellow must be connected to the terminal in the plug
which is marked with the letter E or the earth symbol or coloured green or green and yellow.
The wire which is coloured blue must be connected to the terminal which is marked with the
letter N or coloured black or blue.
The wire which is coloured brown must be connected to the terminal which is marked with
the letter L or coloured red or brown.
Make sure that the connections are tight and that there are no loose strands of wire and no
insulation trapped under the terminals. Tighten the clamp in the plug making sure that it grips
the outer covering of the cord. If tting a BS 1363 13A fused plug then t a 13A fuse. Tighten
the plug cover securely. If you are in any doubt, consult a qualied electrician.
IMPORTANT: if the supply cord is damaged, it must be replaced by the manufacturer,
service agent or similar qualied person in order to avoid a hazard. The supply cord may
become warm when the appliance is in use.
WARNING - THIS APPLIANCE MUST BE EARTHED
Electrical connection: 230V ~ 50Hz, 12.5A, 2.9kW
Before Use:
Operate the appliance for approximately 30 minutes at the highest temperature, to remove
any fumes or odour which may be emitted - this is due to oil used during manufacture, but
is not harmful.

USER GUIDE
DURING USE THE APPLIANCE BECOMES VERY HOT. BE CAREFUL NOT TO TOUCH
HOT SURFACES.
TURN OFF THE POWER SUPPLY AND REMOVE THE PLUG WHEN NOT IN USE,
BEFORE CLEANING, AND BEFORE REPLACING ANY PARTS.
Controls:
• The green power indicator will be illuminated whenever power is connected to the
griddle.
• Turn the thermostat to the desired temperature.
• The amber heating indicator will be illuminated whenever the element is on.
• Once the unit is up to temperature, shown by the amber heating indicator cycling on
and off, load the griddle with product.
• The fat collection tray in the front of the appliance must be emptied periodically.
Cleaning:
ALWAYS TURN OFF THE POWER SUPPLY AND REMOVE THE PLUG BEFORE
CLEANING
THIS APPLIANCE IS NOT WATERPROOF
DO NOT USE A WATER JET SPRAY TO CLEAN THE INTERIOR OR EXTERIOR OF
THE APPLIANCE, OR USE A WATER JET IN THE VICINITY OF THE APPLIANCE
Clean with a good quality stainless steel cleaning compound. Do not use harsh abrasive
cleaners as this could damage the surface nish.
Trouble-shooting:
Fault Possible Cause Remedy
The appliance does
not operate.
No power to the
appliance.
Thermostat or element
faulty.
Check supply socket is switched on.
Check fuse and circuit breaker.
Check green power indicator is
illuminated.
Replace thermostat or element.
At end of unit life, dispose of appliance and any replacement parts in a safe
manner, via a licenced waste handler. Units are designed to be dismantled
easily and recycling of all material is encouraged whenever practicable.
Heating indicator (amber)
Power indicator (green)
Thermostat

GUARANTEE
This griddle is guaranteed against defective materials or faulty workmanship, for a period
of 12 months on labour and 36 months on parts.
This guarantee is given subject to the appliance being used in accordance with the
instructions supplied, and on the supply voltage marked on the rating label. The guarantee
is subject to fair wear and tear conditions.
The guarantee does not cover consequential damage arising out of any failure
acceptable under guarantee, nor does it cover damage resulting from misuse, accident or
unauthorised alterations to the oven.
Proof of purchase will be required.
In any communication with the supplier or manufacturer, quote the model and serial
number marked on the oven rating label.
This guarantee does not affect your statutory rights.
The products are intended for commercial use as detailed in these instructions.
The Company has a policy of continuous improvement in product quality and design. The
Company therefore reserves the right to change the specication at any time.
FAQ’s

SPARES LIST
ALWAYS TURN OFF THE POWER SUPPLY AND REMOVE THE PLUG BEFORE
REPLACING ANY PARTS
Part Number Description Qty
082639027 SHELF GUIDE 302110181 2
082626793 COOKING grid 30071 1
082626794 GRID handle 30072 2
082639028 DRIP TRAY assy 20112038002 1
082626789 ELEMENT 30066 1
082626790 CONTROL knob 30068 1
082626791 ENERGY regulator 30069 1
082639029 NEON yellow 301130005 1
082626792 RUBBER feet set 30070 4
082639030 BLOCK terminal 301070050 1
082639031 POWER CORD 301050007 1
Handbook 1

Customer helpline
For spares and after-sales service please contact
Burco on:
T: 0844 815 3755
F: 0844 815 3748
E: [email protected]
Glen Dimplex Professional Appliances
(A Division of Glen Dimplex Home Appliances)
Stoney Lane,
Prescot,
Merseyside L35 2XW
www.burco.co.uk