Calflame BBQ11963 User manual

LTR50001102, Rev. G
2/11/20

Copyright 2020 LMS. All rights reserved.
Duplication without written consent is
strictly prohibited.
Cal Flame ® is a registered trademark.
Due to continuous improvement programs,
all models, operation, and/or specications
are subject to change without prior notice.
LTR50001102, Rev. G
2/11/20
250-443
CONTACT INFORMATION
For customer service, please contact
your authorized dealer immediately. If
you need additional information and/or
assistance, please contact:
Customer Service Department
1462 East Ninth Street
Pomona, CA 91766
Toll Free: 1-800-225-7727
Fax: [phone]
www.calamebbq.com
I. Performinventory   1
II. Sinkcut-outtemplate  3
III.Assemblyandinstallation 4
TableofContents
WARNING! Proposition 65 Warning: Handling the brass
material on this product exposes you to lead, a chemical
known to the State of California to cause cancer, birth
defects or other reproductive harm. (Wash hands after
handling this product.)
This product and the fuels used to operate this product
(propane or natural gas), and the products of combus-
tion of such fuels, can expose you to chemicals includ-
ing Benzene, which is known to the state of California
to cause cancer and birth defects or reproductive harm.
For more information go to www.P65Warnings.ca.gov.

Parts Inventory
1
Drop-in Sink BBQ11963
LTR50001102, Rev. G www.calamebbq.com
I. Performinventory
PartGroup Item
1 Drain Drain stop
Drain plate top
Drain plate
bottom
Top gasket
Bottom gasket
Drain connector
pin
2Sink Sink
Hold-down
clamps
Clamp screws
Cut-out
template
3 Faucet Faucet
Gasket
Tie down

2
Parts Inventory
Drop-in Sink BBQ11963
LTR50001102, Rev. G
www.calamebbq.com
4Soap
dispenser
Box with soap
dispenser
contains:
Soap spout
Dispenser base
Bottle
Gasket
Tie down
Plastic straw
5Drain
tube
Drain tube
Drain tube
connector
Flat gasket
Beveled gasket
6Trap Trap T
Trap
Trap at gasket
7Drain
elbow
Drain elbow
Drain elbow
connector
Beveled gasket

Cut-out Template
3
Drop-in Sink BBQ11963
LTR50001102, Rev. G www.calamebbq.com
II. Sinkcut-outtemplate
Use the template provided with the sink to create the cut-out.
When you create the cut-out, it is important that you ensure the cor-
ners are rounded, as shown in the template, and not square.
3.00
1.50
14.25
14.25
R1.50
1.50
SINK CUT-OUT TEMPLATE

4
Assembly and Installation
Drop-in Sink BBQ11963
LTR50001102, Rev. G
www.calamebbq.com
Note: Number in brackets refer to part groups listed in the parts ta-
ble.
1. Attach drain assembly (1) to sink (2):
a. Set top gasket and drain plate top inside sink.
b. Hold the drain plate bottom in place and insert the drain pin
connector. Tighten in place using a coin or a washer. Center
and adjust as needed.
III.Assemblyandinstallation

Assembly and Installation
5
Drop-in Sink BBQ11963
LTR50001102, Rev. G www.calamebbq.com
2. Attach faucet (3). Ensure gasket is directly under faucet base.
3. Attach base for the soap dispenser (4).

6
Assembly and Installation
Drop-in Sink BBQ11963
LTR50001102, Rev. G
www.calamebbq.com
4. Install sink (2) in cut-out. Note: Sink has been removed for these
pictures.
a. Place sink in cut-out.
b. Insert the screws in the hold-down clamps.
c. Slide the clamps in place under the sink.
Use a total of 8 hold-down clamps.

Assembly and Installation
7
Drop-in Sink BBQ11963
LTR50001102, Rev. G www.calamebbq.com
d. Tighten the clamps with a standard screwdriver.
5. Connect water line to the faucet. Depending on your water line,
you may need an adaptor. The faucet requires a ½” connecter.
Note: An adaptor is not in-
cluded with your sink. You
will need to provide one for
the size of your water line
connection.

8
Assembly and Installation
Drop-in Sink BBQ11963
LTR50001102, Rev. G
www.calamebbq.com
6. Attach drain tube (5) to drain.
7. Attach trap (6) to drain.
8. Attach drain elbow (7).

Assembly and Installation
9
Drop-in Sink BBQ11963
LTR50001102, Rev. G www.calamebbq.com
9. Attach the soap dispenser bottle under the sink.
10. Insert the straw in the dispenser head.
11. Place soap dispenser head in dispenser base.
Note: You can add
liquid soap to the
dispenser by pour-
ing it directly into
the dispenser base
after the bottle has
been attached.

LTR50001102, Rev. G
2/11/20
WARNING! Proposition 65 Warning: Handling the brass
material on this product exposes you to lead, a chemical
known to the State of California to cause cancer, birth
defects or other reproductive harm. (Wash hands after
handling this product.)
This product and the fuels used to operate this product
(propane or natural gas), and the products of combus-
tion of such fuels, can expose you to chemicals includ-
ing Benzene, which is known to the state of California
to cause cancer and birth defects or reproductive harm.
For more information go to www.P65Warnings.ca.gov.