Camplux TC02SS User manual
Visit Us: Camplux.com
3330-A Marathon Ct Charleston, SC 29418
PROPANE GAS COOKTOP
Instruction for Installation and Use
Model: TC02SS
www.camplux.com
1
1
Visit Us: Camplux.com
3330-A Marathon Ct Charleston, SC 29418
General Warnings
● This appliance shall only be connected to a 20lb cylinder with a POL cylinder
valve certified to CAN/CSA - B339.
● This appliance is designed for outdoor or ventilated kitchen use and must be
operated away from any flammable material or surfaces and materials.
● This appliance is to be stored in a dry and well-ventilated location free from
direct sunlight.
● Do not store when the valve is still connected to the cylinder.
● Make sure that the cylinder is disconnected and is stored in a well-ventilated
area, free from direct sunlight, heat, and ignition sources.
● If being stored indoors, ensure that the location complies with the standard
ANSI/NFPA 58.
● This appliance must only be serviced by an authorized service agent, return to
your place of purchase for service and repair.
DANGER!
● During operation, all surfaces will be extremely hot and should not be touched
or handled.
● Do not use the appliance if it is leaking, damaged, or does not operate properly.
● Handle with care even after brief use, always pick up using the handles, not the
cylinder.
● It may be hazardous to attempt to fit other types of gas containers or cartridges.
● Use only in well-ventilated areas.
● Always operate appliance a minimum of 24″ from flammable materials, walls
and 48″ from the ceiling.
● Do not use adaptors.
● Do not modify the appliance to fit other connectors or cylinders.
● Do not use multiple appliances to heat a single utensil.
● Children must be supervised by an adult at all times.
● Never leave the appliance unattended when operating.
● Use as a cooking appliance only, not to be used as a heater or modified for any
other reason.
● Avoid boil over and spills on to burners.
www.camplux.com
2
Visit Us: Camplux.com
3330-A Marathon Ct Charleston, SC 29418
CARBON MONOXIDE HAZARD
Using this appliance in an enclosed space may cause DEATH.
Do not use in caravans, tents, marine craft, cars, mobile
homes, or similar locations.
CALIFORNIA PROPOSITION 65:
WARNING: This fuel, and byproducts or combustion of this fuel,
contains Carbon Monoxide, which is known to the State of
California to cause cancer and birth defects, or other
reproductive harm. For more information go to
www.p65Warnings.ca.gov.
IMPORTANT
● Suitable for outdoor or ventilated kitchen.
● Keep children away at all times.
● CAUTION: Accessible parts may be very hot. Please take care when handling
or moving the appliance.
● The appliance is to be used on a stable, level, flat, non-flammable surface. The
appliance should be protected from direct drafts and in a well-ventilated place.
● Only cooking vessels with a minimum diameter of 4.72″ and a maximum of
8.66″ are to be used with this appliance.
● Take care that the primary air intakes, located on the burner tube of this
appliance are not obstructed, or that airflow is restricted by placing items or
other appliances close to or adjacent to the inlets.
● If you smell gas, immediately turn the gas off at the cylinder and move the
appliance and cylinder to a well-ventilated area outside, keeping well away
from sources of heat such as naked flames and pilot lights.
● Do not attempt to move or relocate the appliance when it is operating,
extinguish the burner and allow it to cool, disengage the gas cylinder then
move the appliance.
www.camplux.com
1
3
Visit Us: Camplux.com
3330-A Marathon Ct Charleston, SC 29418
CARBON MONOXIDE HAZARD
Using this appliance in an enclosed space may cause DEATH.
Do not use in caravans, tents, marine craft, cars, mobile
homes, or similar locations.
CALIFORNIA PROPOSITION 65:
WARNING: This fuel, and byproducts or combustion of this fuel,
contains Carbon Monoxide, which is known to the State of
California to cause cancer and birth defects, or other
reproductive harm. For more information go to
www.p65Warnings.ca.gov.
IMPORTANT
● Suitable for outdoor or ventilated kitchen.
● Keep children away at all times.
● CAUTION: Accessible parts may be very hot. Please take care when handling
or moving the appliance.
● The appliance is to be used on a stable, level, flat, non-flammable surface. The
appliance should be protected from direct drafts and in a well-ventilated place.
● Only cooking vessels with a minimum diameter of 4.72″ and a maximum of
8.66″ are to be used with this appliance.
● Take care that the primary air intakes, located on the burner tube of this
appliance are not obstructed, or that airflow is restricted by placing items or
other appliances close to or adjacent to the inlets.
● If you smell gas, immediately turn the gas off at the cylinder and move the
appliance and cylinder to a well-ventilated area outside, keeping well away
from sources of heat such as naked flames and pilot lights.
● Do not attempt to move or relocate the appliance when it is operating,
extinguish the burner and allow it to cool, disengage the gas cylinder then
move the appliance.
Checking for Gas Leaks
● Check that all connections are tight and that the gas cylinder connection has
been tightened before you turn the cylinder gas valve on.
● Never check for leaks with a flame or pilot light.
● Using soapy water, coat all connections, if bubbles appear turn the cylinder gas
control off and re-tighten the connection before retesting.
● Inspect the appliance regularly for signs of wear, leaks, or incorrect operation.
If symptoms such as flaring of the burner, issues with lighting, damages to
hoses or connections, or leaks from seals or gas controls are identified do not
attempt to repair, contact your dealer for service and maintenance.
Changing Gas Cylinder
● To check if gas remains in the cylinder, disconnect from the appliance and hold
the cylinder in a vertical position then shake from side to side, if there is a
sound or feel of liquid movement inside, the cylinder contains gas.
● When changing gas cylinders ensure this is conducted outside in a
well-ventilated location free from people, animals, and ignition sources such as
naked flames, pilot lights, and electrical equipment with heaters or elements.
www.camplux.com
4
Visit Us: Camplux.com
3330-A Marathon Ct Charleston, SC 29418
Safety Instructions
This appliance shall only be used in an above ground open air situation with
natural ventilation without stagnant areas, where gas leakage is rapidly dispersed
by wind and natural convection.
Any enclosure in which the appliance is
used should comply with one of the
following:
A. An enclosure with walls on all sides, but
with no overhead cover.
B. Within a partial enclosure that includes
an overhead cover and no more than
two walls.
C. Within a partial enclosure that includes
an overhead cover and more than two
walls, the following must apply:
1. At least 25% of the total wall area is
completely open.
2. 30% or more in a total of the
remaining wall side, back, and front
wall areas are open and unrestricted.
3. In the case of balconies, 20% or more
of the total wall, the area must remain
open and unrestricted.
The figures shown are diagrammatic
representations of outdoor areas.
Rectangular areas have been used in these
figures - the same principles apply to any
other shaped areas.
1
1
2
1
2
Visit Us: Camplux.com
3330-A Marathon Ct Charleston, SC 29418
www.camplux.com
1
5
Installation of Cooktop
●Install the appliance and use OUTDOORS OR VENTILATED KITCHEN. Do
NOT USE THIS APPLIANCE IN CONFINED SPACES. Also, make sure there
are NO FLAMMABLES near the appliance.
● Make sure that there is no dust attached to the gas inlet fitting. And screw the
gas regulator hose onto the gas inlet.
● Supply plenty of fresh air when using the appliance. Do not obstruct the flow of
combustion air or ventilation air.
● The appliance produces heat. Keep the appliance away from burnable
materials. Do not place the appliance any closer than 24″ to combustibles.
● Use a flat, level support surface where the appliance is safe from accidental
tipping.
● Use only propane fuel cylinders.
● Use only the regulator included with your appliance. Do not attempt to alter.
CAUTION: PROPANE FUEL IS HIGHLY FLAMMABLE AND UNDER
PRESSURE.
● Do not store in temperatures over 120°F/48.9°C.
● Never use a flame to check for leaks. Use soapy water.
● Keep out of the reach of children at all times.
Parts Identifcation
Top Plate Burner Tray
Ignition Knob
Tray
Visit Us: Camplux.com
3330-A Marathon Ct Charleston, SC 29418
www.camplux.com
6
How to Use
1. Turning on the unit
● Please ensure the ignition knob in the OFF position then turn on the stopcock
of the gas cylinder at full. Push the Ignition knob and turn it to the left until a
click is heard. Make sure that the burner has been lit.
● When the unit is used after having been left unused for a considerable period,
it sometimes happens that the burner fails to ignite. This is because air has
been trapped in the rubber tubing. Repeat turning the ignition knob a few times
until gas comes through.
2. Flame adjustment
● To adjust the flame turn the gas control knob suitable position between “ON”
and “OFF”.
● The flame can easily be adjusted to any degree from “high” to “low” by
adjusting the knob to rite desired position in one action.
● After the gas has been ignited, adjust the air damper inside the gas table until
slightly rounded. Vigorous blue flames are produced.
3. Turn off the unit
● Turn the ignition knob to its original position without pressing it.
● Do not fall to completely turn off the stopcock of the gas cylinder after use.
Outer flame
Core
Bad
Not Enough Air
Fig.k
Bad
Too Much Air
Good
Slightly Rounded Flame Centre
Air Damper
Visit Us: Camplux.com
3330-A Marathon Ct Charleston, SC 29418
www.camplux.com
1
7
After-sale Service
When you find something wrong with the appliance, contact Camplux for further
assistance.
Features
●Ignition knob is a ‘‘push and turn’’ design so children can not easily turn the
knob.
● Ignition produces powerful sparks which easily ignites the burner at all times.
● Jet type gas pipe can not be blocked by dirt.
● Control knob has many stages of micro-control, suitable for all kinds of
cooking.
● Specially designed burner and burner cap with high energy efficiency can lower
gas consumption.
Check up and Care of the Unit
●Be sure that the burner cap and the burner itself are in their correct positions.
● If the flames become uneven, remove the burner cap and wash it with water.
When the flame pores become clogged with dirt. Clean them with a brush or a
similar instrument.
● After washing the burner cap and the burner itself dry them thoroughly and
then replace them in their correct positions. Light the burner and ascertain
whether the burning is normal.
● To fit the burner connect its nozzle hole with the nozzle and insert the
projection at the back of the burner into the hole on the burner base.
● If the electrodes of the igniter are soiled, the burner cannot be igniter easily.
Inspect the electrodes carefully when you remove the boil-over receptacle and
if they are soiled, clean them with a dry cloth.
Visit Us: Camplux.com
3330-A Marathon Ct Charleston, SC 29418
www.camplux.com
8
Electrode part
Insulator
Nozzle
Correct Nozzle Position
Burner Base
Burner Cap
www.camplux.com
1
9
Visit Us: Camplux.com
3330-A Marathon Ct Charleston, SC 29418
Trouble Cause
Main gas stopcock in not
turned on
Turn off the appliance once and
then turn it on fully
Air remains in the gas piping
Bent or crusned rubber tubing Straighten it replace it
Dirty piezoelectric or insulator Clean it with a day cloth
Cracks or holes in the gas
regulator Replace it with a new one
Gas regulator not connected
properly Connect the gas regulator properly
Failure of the appliance Request the dealer to repair
Air supply is not properly
adjusted Adjust it properly
Burner is not titled properly Fix burner body properly
Flame outlet of burner is clogged Clean the clogged part
Nozzle is clogged Request the dealer to repair
Repeat igniting operation until all
air in the piping is purged out
completely
Remedial measures
Does not ignite
Smell of gas
Flame lifts off
from the burner
and burns in
flash back with
a roaring sound
Specifications
Trouble-shooting Guide
Model TC02SS
Item
Double Burners
19,600 BTU
28.15″x15.16″x5.31″
1.61 LB/HR
6.61 LB
TC01SS
Single Burner
9,800 BTU
14.96″x10.63″x3.94″
0.60 LB/HR
4.85 LB
Piezo-electric
Propane
Burner
Type of Gas
Heat Out Put
Dimension HxWxD
GAS Consumption
Weight
Ignition
Table of contents
Other Camplux Cooktop manuals
