Camplux TC01GB User manual
Visit Us: Camplux.com
8350 Patriot Blvd STE B, North Charleston, SC 29420
PROPANE GAS COOKTOP
Instruction for Installation and Use
Model: TC01GB / TC02GB / TC03GB
IMPORTANT: Read these instructions for use carefully. Familiarize yourself with the a
ppliance before connecting it to its gas tank. Keep these instructions for future reference.
www.camplux.com
1
1
Visit Us: Camplux.com
8350 Patriot Blvd STE B, North Charleston, SC 29420
General Warnings
● This appliance shall only be connected to a 20lb cylinder with a POL cylinder
valve certified to CAN/CSA - B339.
● The appliance is to be used on a stable, level, flat, non-flammable surface. Use
only in well-ventilated areas, such as the outdoor or ventilated kitchen.
● This appliance is designed for outdoor or ventilated kitchen use and must be
operated away from any flammable material or surfaces and materials.
● This appliance must only be serviced by an authorized service agent and
returned to your place of purchase for service and repair.
DANGER!
● During operation, all surfaces will be extremely hot and should not be touched
or handled.
● Do not move the appliance during use.
● Do not use other adaptors.
● Do not use it in confined spaces.
● Do not use the appliance if it is leaking, damaged, or does not operate properly.
● Do not modify the appliance to fit other connectors or cylinders.
● Do not use multiple burners to heat a single utensil.
● Do not attempt to move or relocate the appliance when it is operating,
extinguish the burner and allow it to cool, disengage the gas cylinder then move
the appliance.
● Always operate appliances a minimum of 24″ from flammable materials, walls,
and 48″ from the ceiling.
● Turn off the gas supply of the gas cylinder after use.
● Keep away from any sources of ignition when changing the gas cylinder.
● Never leave the appliance unattended when operating.
● When transporting, not using, or storing appliances, always disconnect gas
cylinders.
● Children should be supervised to ensure that they do not play with the
appliance.
● Use as a cooking appliance only, not to be used as a heater or modified for any
other reason.
● Avoid boilover and spills onto burners.
● When you receive the product, please check the bottom whether the air intake
adjustment board and the burner are aligned.
The air intake adjustment board and burner must be aligned, otherwise air
leakage will occur. See the picture below for details.
www.camplux.com
2
Visit Us: Camplux.com
8350 Patriot Blvd STE B, North Charleston, SC 29420
If the above situation occurs, manual adjustments can be made to align the air
intake adjustment board and the burner.
If the air intake is broken, please contact customer service.
CARBON MONOXIDE HAZARD
Using this appliance in an enclosed space may cause DEATH.
Do not use in caravans, tents, marine craft, cars, mobile homes, or similar
locations.
CALIFORNIA PROPOSITION 65:
WARNING: This fuel, and byproducts or combustion of this fuel, contains Carbon
Monoxide, which is known to the State of California to cause cancer and birth
defects, or other reproductive harm. For more information go to
www.p65Warnings.ca.gov.
Wrong Connection
The air intake adjustment board
and burner are completely
separated, mustn't be used
Wrong Connection
The air intake adjustment
board and burner are
misaligned, mustn't be used
Correct Connection
The air intake adjustment
board and burner are perfectly
connected, no gap can be
used normally
www.camplux.com
1
3
Visit Us: Camplux.com
8350 Patriot Blvd STE B, North Charleston, SC 29420
Safety Instructions
This appliance shall only be used in an above-ground open-air situation with
natural ventilation without stagnant areas, where gas leakage is rapidly dispersed
by wind and natural convection.
The following figures are diagrammatical representations of outdoor areas:
A. With walls on all sides, but without overhead cover.
B. With overhead cover and no more than two walls.
C. With overhead cover, at least 25% of the total wall area is completely open, and
30% or more a total of the remaining wall area is open and unrestricted.
Both ends open
30% or more in a total of the
remaining wall area is open
and unrestricted
Open side at least
25% of total wall area
www.camplux.com
4
Visit Us: Camplux.com
8350 Patriot Blvd STE B, North Charleston, SC 29420
Caution
● If your appliance is getting hard to light or the flame is weak, check and clean
the venturis and burners.
● Spiders or small insects are known to create “flashback” problems by building
nests and laying eggs in the barbeque’s venturi or burner, obstructing the flow
of gas.
● The backed-up gas can ignite behind the control panel. This flashback can
damage your appliance and cause injury.
● To prevent flashbacks and ensure good performance, the burner and venturi
tube assembly should be removed and cleaned whenever the appliance has
been idle for an extended period of time.
Parts Identifcation
30% or more in a total of the
remaining wall area is open
and unrestricted
Open side at least
25% of total wall area
Burner
Bracket
Tray
Ignition Knob
Top Plate
Bracket
www.camplux.com
1
5
Visit Us: Camplux.com
8350 Patriot Blvd STE B, North Charleston, SC 29420
Assembly Instructions
Step 1: Put the appliance on a flat surface outdoor.
Step 2: Ensure the burner control knobs are in the "OFF" position.
Step 3: Connect the provided gas regulator to the appliance fitting clockwise. USE
TWO WRENCHES TO TIGHTEN THE CONNECTOR. Do not over-tighten,
over-tightening may break.
Step 4: Connect the gas regulator to the propane gas cylinder clockwise. HAND
TIGHTENS ONLY.
Step 5: Follow "Gas Leak Testing" instructions on page 7 of this manual.
Installation of Cooktop
● Install the appliance and use OUTDOORS OR VENTILATED KITCHEN. DO
NOT USE THIS APPLIANCE IN CONFINED SPACES. Also, make sure there
are NO FLAMMABLES near the appliance.
● Make sure that there is no dust attached to the gas inlet fitting. And screw the
gas regulator hose onto the gas inlet.
● Supply plenty of fresh air when using the appliance. Do not obstruct the flow of
combustion air or ventilation air.
● The appliance produces heat. Keep the appliance away from burnable
materials. Do not place the appliance any closer than 24″ to combustibles.
● Use a flat, level support surface where the appliance is safe from accidental
tipping.
● Use only propane fuel cylinders.
5-20lbs
LPG cylinder
(Not included)
Attach: Clockwise
Detach: Anti-clockwise
Use two wrenches to
tight the connector
www.camplux.com
6
Visit Us: Camplux.com
8350 Patriot Blvd STE B, North Charleston, SC 29420
● Use only the regulator included with your appliance. Do not attempt to alter.
CAUTION: PROPANE FUEL IS HIGHLY FLAMMABLE AND UNDER
PRESSURE.
● Do not store in temperatures over 120°F/48.9°C.
● Never use a flame to check for leaks. Use soapy water.
● Keep out of the reach of children at all times.
How to Use
1. Turning on the unit
● Please ensure the ignition knob is in the OFF position then turn on the
stopcock of the gas cylinder at full. Push the Ignition knob and turn it to the left
until a click is heard. Make sure that the burner has been lit.
● When the unit is used after having been left unused for a considerable period,
it sometimes happens that the burner fails to ignite. This is because air has
been trapped in the rubber tubing. Repeat turning the ignition knob a few times
until gas comes through.
2. Flame adjustment
● To adjust the flame turn the gas control knob suitable position between “ON”
and “OFF”.
● The flame can easily be adjusted to any degree from “high” to “low” by
adjusting the knob to rite desired position in one action.
● After the gas has been ignited, adjust the air damper inside the gas table until
slightly rounded. Vigorous blue flames are produced.
Outer flame
Core
Bad
not enough air
Fig.k
Bad
too much air
Good
slightly rounded flame centre
Air damper
www.camplux.com
1
7
Visit Us: Camplux.com
8350 Patriot Blvd STE B, North Charleston, SC 29420
3. Turn off the unit
1. Turn the knob to the "OFF" position after use.
2. Do not put the gas cylinder upside down, and close the gas valve of the gas
cylinder after use.
Cookware Diameter
To ensure maximum burner efficiency, it is best to use pots and pans with a flat
bottom fitting the size of the burner used (see table).
Warning:
● As soon as a liquid starts boiling, turn down the flame so that it will barely keep
the liquid simmering. If the control knobs become difficult to turn, please
contact your local service center.
● Users could not use the cooking vessels on the appliance that overlap its edges.
Gas Leak Testing
1. Turn all appliance control knobs to the “OFF” position.
2. Be sure that the gas regulator is tightly connected to the gas cylinder.
3. Turn on the gas valve. If you hear a rushing sound, turn the gas off immediately.
There is a major leak at the connection. Connect properly before proceeding.
4. Brush soapy solution (mixture of half soap and half water) onto hose
connections.
5. If growing bubbles appear, there is a leak. Turn the gas valve of the cylinder off
immediately and check the tightness of all the connections. If the leak cannot be
stopped, do not try to repair it. The best solution is to replace the part.
6. Always turn the gas valve of the cylinder off after performing a leak test.
Warning: Turn off the gas supply in event of a gas leak.
Middle burner
Model
3.9-6.2″
Right burner
7-10.2″
7-10.2″
Left Burner
7-10.2″
7-10.2″
7-10.2″
TC01GB
TC02GB
TC03GB
Pan Diameter
Burner
www.camplux.com
8
Visit Us: Camplux.com
8350 Patriot Blvd STE B, North Charleston, SC 29420
Maintenance and Cleaning
Before any maintenance or cleaning, always keep the knobs in the “OFF” position.
The appliance is best cleaned while it is still warm, as spillage can be removed
more easily than let it cool.
1. The burners
● The burner caps and crowns can be removed for cleaning.
● Wash the burner caps and crowns by using hot soapy water, and remove marks
with a mild paste cleaner.
● If the marks are particularly difficult to remove, a well-moistened
soap-impregnated steel wool pad can be used with caution.
● After cleaning, be sure to wipe dry with a soft cloth.
2. Ignition electrode
● Keep ceramic "electrodes" and metal electrodes clean, to avoid lighting
difficulties.
● Check that the burner crown holes are not obstructed.
Check-up and Care of the Unit
● Be sure that the burner cap and the burner itself are in their correct positions.
● If the flames become uneven, remove the burner cap and wash it with water.
When the flame pores become clogged with dirt. Clean them with a brush or a
similar instrument.
● After washing the burner cap and the burner itself dry them thoroughly and then
replace them in their correct positions. Light the burner and ascertain whether
the burning is normal.
● To fit the burner connect its nozzle hole with the nozzle and insert the projection
at the back of the burner into the hole on the burner base.
● If the electrodes of the igniter are soiled, the burner cannot be ignited easily.
Inspect the electrodes carefully when you remove the boil-over receptacle and if
they are soiled, clean them with a dry cloth.
www.camplux.com
1
9
Visit Us: Camplux.com
8350 Patriot Blvd STE B, North Charleston, SC 29420
Storage Conditions
● Please make sure the appliance is turned off and disconnected from the gas
cylinder before storing the appliance.
● This appliance is to be stored in a dry and well-ventilated location free from
direct sunlight, heat, and ignition sources.
● If stored indoors, ensure that the location complies with the standard
ANSI/NFPA 58.
● Cover appliance if stored outdoors.
Note: Do not store when the valve is still connected to the cylinder.
After-sale Service
When you find something wrong with the appliance, contact Camplux for further
assistance.
Electrode part
Insulator
Nozzle
Correct nozzle position
Burner base
Burner cap
www.camplux.com
10
Visit Us: Camplux.com
8350 Patriot Blvd STE B, North Charleston, SC 29420
Trouble Cause
Main gas stopcock in not
turned on
Turn off the appliance once and
then turn it on fully
Air remains in the gas piping
Bent or crusned rubber tubing Straighten it replace it
Dirty piezoelectric or insulator Clean it with a day cloth
Cracks or holes in the gas
regulator Replace it with a new one
Gas regulator not connected
properly Connect the gas regulator properly
Failure of the appliance Request the dealer to repair
Air supply is not properly
adjusted Adjust it properly
Burner is not titled properly Fix burner body properly
Flame outlet of burner is clogged Clean the clogged part
Nozzle is clogged Request the dealer to repair
Repeat igniting operation until all
air in the piping is purged out
completely
Remedial measures
Does not ignite
Smell of gas
Flame lifts off
from the burner
and burns in
flash back with
a roaring sound
Specifications
Trouble-shooting Guide
Model TC02GB
Item
Double burners
9,500 BTUx2
28.5x15.2x5.1
15.9
TC03GB
Triple burners
9,500 BTUx2+2,600 BTU
28.5x15.2x5.1
17.0
TC01GB
Single burner
9,500 BTU
15.4x12.2x5.7
8.0
Piezo-Ignition
Propane
Burner
Type of gas
Heat out put
Dimension
HxWxD (INCH)
Weight (LB)
Ignition
This manual suits for next models
2
Table of contents
Other Camplux Cooktop manuals
