Cardinal Gates WG35 User manual

A
B
CE
F
G
J
I
1
6 ”
A
C or J
2
C or J
3
3X
E4
B
I
5
LOOSEN AT TOP AND
BOTTOM OF GATE TO
ADJUST GATE WIDTH
2X
6K
H
ONE-WAY
STOP BRACKET
OPTION
ASSEMBLY INSTRUCTIONS
1. Install hinge bracket
(A) to wall (stationary
side of gate) using
Phillips screw (C)
beginning 6 ” above
floor surface. (Use
ruler on left edge of
this sheet to measure
from floor).
OPTION: Long
screws (J) maybe be
used to attach gate to
stud through dry wall.
2. Install second
screw (C) in
top of hinge
bracket
securing it to
the wall.
NOTE: THIS SIDE OF GATE HAS
THREE (3) HOLESzz
3. Insert eye bolts with nut and washer (E)
through gate into threaded inserts (F).
(side with three holes). Use Allen wrench
(G) to assist in tightening to insure nuts
are tight.
4. Hang gate by inserting hinge rod (B), through top
of mounted hinge bracket (A), through both eye
bolts (E), and finally through bottom of hinge
bracket. To secure hinge, insert key ring (I) through
hole in end of hinge rod. Gate can be mounted at
angles up to 30 degrees.
5. Use flat head screwdriver to loosen
bracket screws to adjust gate to fit
desired width and tighten bracket
screws. DO NOT OVERTIGHTEN.
6. Mount latch assembly (K) to gate using 3/4” bolts with serrated
washers (D) and threaded inserts (F). Attach wall mount for
latch assembly (H) up into part (K) that is now secure on gate.
Slide gate out to mark holes for (K) on attaching wall.
(*OPTIONAL ONE WAY BRACKET INSTALLED HERE) Then
attach the wall mount of latch assembly to wall using Phillips
head screws (C).
GATE IS RECOMMENDED FOR CHILDREN BETWEEEN 6 AND 24 MONTHS.
WOOD GATE - MODEL WG35
D
H
KL
ONE-WAY
STOP BRACKET
OPTION
D
D
ONE-WAY
STOP BRACKET
OPTION
L
IF GATE IS INSTALLED AT TOP OF STAIRCASE:
Install one-way stop bracket (L) on one side of
wall mount latch to have gate open in only one
direction for maximum safety.
FOR OPENINGS 29.5” (75cm) - 49.25” (125cm)
SEE REVERSE
FOR GATE
OPERATION
INSTRUCTIONS
X5
F
F
F
G

GATE MAINTENANCE
GATE CARE & REMINDERS
GATE WARRANTY
Your Cardinal Gate is warranted to be free of manufacturing defects for a period of one year
from the date of purchase when used in homes, and according to manufacturers instructions.
When used commercially, such as day care centers, the warranty is 90 days.
Cardinal Gates, lnc. will either repair or replace, at our option, any parts necessary to correct
defects in material or workmanship during the warranty period. The warranty disclaims liabilty
for incidental, special and consequential damages of any nature.
TO EXERCISE WARRANTY:
Ship your gate in a protective carton, freight prepaid to:
CARDINAL GATES, INC.
79 Amlajack Way
Newnan, GA 30265
You must include the following:
1. Proof of purchase (store receipt, etc.).
2. Brief note describing problem with gate.
3. Full return address along with phone number.
FOR FURTHER ASSISTANCE
Call 1-800-318-3380
79 Amlajack Way
Newnan, GA 30265
770-252-4200
www.cardinalgates.com
GATE OPERATION
FOR OPENING: FOR CLOSING:
When approaching
gate, if latch is to your
left, use right hand.
Depress flip latches
simultaneously with
thumb and index
finger while lifting
gate with remaining
fingers of hand.
REMEMBER: Latch to right, use left hand; latch to left, use right hand
Grasp gate in
middle. Lift
gate and align
latch pins with
bracket holes.
Drop in place.
There is no
need to close
gate using flip
latches.
To clean, rinse with lukewarm water, wash gently with mild soap or detergent and lukewarm water,
using a soft cloth or sponge. Rinse again. Dry with a soft cloth or sponge to prevent water spotting.
DO NOT SCRUB or use brushes or squeegees.
At CARDINAL GATES, INC., we design what we believe to be the very best, and most user
friendly gates available. Our gates are built to last many years with proper use and care. Here
are a few suggestions...
• Close gates gently - do not slam - to prevent damage to latch mechanism.
• When closing, be sure safety bracket on gate frame engages as depicted in instructions.
• For safety, always close gate when not in use. Children should not be allowed to swing on an
open gate as this can damage hinge mount.
• Periodically check all screws, bolts, etc. for security and proper adjustment.
CARDINAL GATES, INC., offers many accessories such as extensions, stair kits, and other
safety products. Check with your dealer or call CARDINAL GATES, INC. at 1-800-318-3380.
We sincerely hope that you thoroughly enjoy many years of service from your CARDINAL GATE.