Caterlite J709-A User manual

Model:
J709-A / J722-A
Water Boiler
Instruction manual
J709-A_J722-A_A5_v2_20180327.indb 1 2018/3/27 17:33

2
AU Telephone Helpline: 1300225960
Safety Tips
• Position on a flat, stable surface.
• A service agent/qualified technician should carry out
installation and any repairs if required. Do not remove any
components on this product.
• Consult Local and National Standards to comply with the
following:
- Health and Safety at Work Legislation
- Fire Precautions
- Wiring Regulations
- Building Regulations
• Ensure the location for the appliance can support its weight
when full.
• DO NOT fill the appliance above the ‘MAX’ level.
• DO NOT move the appliance when full.
• DO NOT immerse the appliance in water.
• DO NOT leave the machine unattended during operation.
• DO NOT operate this appliance when less than one third full.
• DO NOT touch the outer surfaces of the appliance. They
become hot during use.
• Suitable for indoor use only.
• Always switch off and disconnect the power supply to the
appliance when not in use.
• This appliance is not intended for use by persons (including
children) with reduced physical, sensory or mental capabilities,
or lack of experience and knowledge, unless they have
been given supervision or instruction concerning use of the
appliance by a person responsible for their safety.
• Children should be supervised to ensure that they do not play
with the appliance.
• Keep all packaging away from children. Dispose of the
packaging in accordance to the regulations of local authorities.
J709-A_J722-A_A5_v2_20180327.indb 2 2018/3/27 17:33

3
AU
Telephone Helpline: 1300225960
• If the power cord is damaged, it must be replaced by a
Caterlite agent or a recommended qualified technician in order
to avoid a hazard.
• Caterlite recommend that this appliance is PAT tested on an
annual basis to ensure the product remains safe.
Product Description
• J709 - 8 litre Water Boiler • J722 - 20 litre Water Boiler
Introduction
Please take a few moments to carefully read through this manual. Correct maintenance and operation of
this machine will provide the best possible performance from your Caterlite product.
Pack Contents
The following is included:
• Caterlite Water Boiler • Instruction manual
Caterlite prides itself on quality and service, ensuring that at the time of packaging the contents are
supplied fully functional and free of damage.
Should you find any damage as a result of transit, please contact your Caterlite dealer immediately.
Operation
1. Remove the appliance from the packaging. Make
sure that all protective plastic film and plastic
coatings are thoroughly removed from all surfaces.
Note: Before using for the first
time, clean the interior of the
appliance and all parts in warm
soapy water, then rinse thoroughly.
2. Ensure the Temperature Control knob is set to ‘0’.
3. Remove the lid and fill the appliance to at least
half of its capacity.
4. Replace the lid. Twist to lock.
5. Connect to the mains power supply and turn the
power switch On (I). The Power Indicator light
illuminates.
6. Set the Temperature Control knob to the required
temperature. The Heat Indicator illuminates and
the appliance heats the water.
WARNING: Reduce the set
temperature if the water begins
to boil. DO NOT allow the water to
boil constantly.
Lid
Urn
Level indicator
Tap
On/Off switch
Warm Indicator
Thermal Cut-out reset switch
Temperature Control knob
Heat Indicator
J709-A_J722-A_A5_v2_20180327.indb 3 2018/3/27 17:33

4
AU Telephone Helpline: 1300225960
7. When the water has reached the set temperature the ‘Warm’ light illuminates and the water is ready
to be dispensed.
Note: Once the water temperature drops 5-10ºC then the appliance will reheat
the water.
Serving
1. Place a suitable vessel beneath the tap.
2. Pull the tap towards you to begin dispensing.
3. Raise the tap handle to close the tap.
Emptying the Appliance
Drain the appliance by using the tap to empty.
Thermal Cut-Out Reset
This appliance is fitted with a Thermal Cut-Out safety feature. Should the temperature exceed safe levels
the appliance will automatically cut power.
The Safety Cut-out switch is located on the underside of the appliance. To reset the appliance:
1. Empty the appliance and allow to cool.
2. Press the reset button until it clicks.
WARNING: Ensure the appliance has cooled down and is empty before resetting
the switch, as it may need to be tipped slightly to gain access to the switch.
3. The appliance is now reset and can be used as normal.
Cleaning, Care & Maintenance
• Always turn off and disconnect the appliance from the power supply before cleaning.
• Use soapy water and a damp cloth to clean the exterior of the appliance.
• Dry thoroughly after cleaning.
Descaling
• In hard water areas lime scale can build up within the appliance after prolonged use. A buildup of
scale can reduce the efficiency of the appliance and cause damage to the element.
• To descale the appliance follow the instructions provided with any suitable descaler.
Note: Always flush out the system thoroughly after descaling.
Caterlite recommend that this appliance is descaled every 3 months or more
frequently in hard water areas.
J709-A_J722-A_A5_v2_20180327.indb 4 2018/3/27 17:33

5
AU
Telephone Helpline: 1300225960
Troubleshooting
Fault Probable Cause Solution
The unit is not working The unit is not switched on Check the unit is plugged in correctly and
switched on
Plug and lead are damaged Call Caterlite agent or qualified technician
Fuse in the plug has blown Replace the plug fuse
Power supply Check power supply
Internal wiring fault Call Caterlite agent or qualified technician
Thermal cut-out switch has
activated
Reset Thermal cut-out switch
Power light comes on
but water does not
reach temperature
Thermostat fault Call Caterlite agent or qualified technician
Heating time has
increased
Buildup of scale Descale the appliance
The tap is leaking The tap has become loose Tighten the tap handle
Technical Specifications
Model Voltage Power Current Capacity Weight
(full)
Approx.
Heating Time
(Max. Temp.
when full)
Dimensions
H x W x D mm
J709-A 230-240V
50Hz 1800W 7.8A 8 litres 11.5kg 30 minutes 430 x 247 x 333
J722-A 230-240V
50Hz 2000W 9.6A 20 litres 24.1kg 40 minutes 560 x 304 x 387
J709-A_J722-A_A5_v2_20180327.indb 5 2018/3/27 17:33

6
AU Telephone Helpline: 1300225960
Electrical Wiring
The plug is to be connected to a suitable mains socket.
This appliance is wired as follows:
• Live wire (coloured brown) to terminal marked L
• Neutral wire (coloured blue) to terminal marked N
• Earth wire (coloured green/yellow) to terminal marked E
This appliance must be earthed.
If in doubt consult a qualified electrician.
Electrical isolation points must be kept clear of any obstructions. In the event of any emergency
disconnection being required they must be readily accessible.
Compliance
The WEEE logo on this product or its documentation indicates that the product must
not be disposed of as household waste. To help prevent possible harm to human
health and/or the environment, the product must be disposed of in an approved and
environmentally safe recycling process. For further information on how to dispose of
this product correctly, contact the product supplier, or the local authority responsible for
waste disposal in your area.
Caterlite parts have undergone strict product testing in order to comply with regulatory
standards and specifications set by international, independent, and federal authorities.
Caterlite products have been approved to carry the following symbol:
All rights reserved. No part of these instructions may be produced or transmitted in any form or by any means, electronic,
mechanical, photocopying, recording or otherwise, without the prior written permission of Caterlite.
Every effort is made to ensure all details are correct at the time of going to press, however, Caterlite reserves the right to
change specifications without notice.
J709-A_J722-A_A5_v2_20180327.indb 6 2018/3/27 17:33

J709-A_J722-A_A5_v2_20180327.indb 7 2018/3/27 17:33

J709-A_J722-A_A5_v1_20180327
J709-A_J722-A_A5_v2_20180327.indb 8 2018/3/27 17:33