Chevrolet Suburban C1500 2004 User manual

DVD PLAYER REPLACEMENT (2ND ROW)
Tools Required
J 38778 Door Trim Pad Clip Remover. See Special Tools and Equipment.
Removal Procedure
1. Move the screen to the open position.
2. Remove the rear screw cover using a flat bladed tool.
3. Remove the four retaining bolts (2).
4. Insert the J 38778 between the headliner and the DVD player assembly. See Special Tools and
Equipment.
5.
With 1 hand holding the DVD player assembly, pry the retainer from the bracket.
IMPORTANT: Components of the DVD player cannot be serviced separately. Replace as an
assembly.
2004 Chevrolet Suburban C1500
2004 ACCESSORIES & EQUIPMENT Entertainment - C/K SUV
2004 Chevrolet Suburban C1500
2004 ACCESSORIES & EQUIPMENT Entertainment - C/K SUV
many waters gallery
Saturday, February 07, 2009 11:12:27 AM Page 1 ©
2005 Mitchell Repair Information Company, LLC.
many waters gallery
Saturday, February 07, 2009 11:12:33 AM Page 1 ©
2005 Mitchell Repair Information Company, LLC.

Fig. 83: Removing DVD Player Assembly Retaining Bolts (2nd Row)
Courtesy of GENERAL MOTORS CORP.
6.
Allow the DVD player assembly to come to rest on the hook.
2004 Chevrolet Suburban C1500
2004 ACCESSORIES & EQUIPMENT Entertainment - C/K SUV
many waters gallery
Saturday, February 07, 2009 11:12:27 AM Page 2 ©
2005 Mitchell Repair Information Company, LLC.

Fig. 84: Allowing DVD Player Assembly To Rest On Hook (2nd Row)
Courtesy of GENERAL MOTORS CORP.
7. Disconnect the wire connector (1).
8. Slightly lift up the DVD player assembly so that the hook can be removed from its resting position.
9.
Remove the DVD player from the vehicle.
IMPORTANT: Observe the routing of the wiring harness (2).
2004 Chevrolet Suburban C1500
2004 ACCESSORIES & EQUIPMENT Entertainment - C/K SUV
many waters gallery
Saturday, February 07, 2009 11:12:28 AM Page 3 ©
2005 Mitchell Repair Information Company, LLC.

Fig. 85: Disconnecting DVD Player Wire Connector (2nd Row)
Courtesy of GENERAL MOTORS CORP.
Installation Procedure
1.
Install the DVD player hook (1) into the hook opening.
2004 Chevrolet Suburban C1500
2004 ACCESSORIES & EQUIPMENT Entertainment - C/K SUV
many waters gallery
Saturday, February 07, 2009 11:12:28 AM Page 4 ©
2005 Mitchell Repair Information Company, LLC.

Fig. 86: Installing DVD Player Hook (2nd Row)
Courtesy of GENERAL MOTORS CORP.
2. Connect the wire connector (1) to the DVD player assembly.
3.
Install the harness retainer to the panel.
IMPORTANT: Ensure the harness is routed to the right side of the large plastic pin as
shown (2).
2004 Chevrolet Suburban C1500
2004 ACCESSORIES & EQUIPMENT Entertainment - C/K SUV
many waters gallery
Saturday, February 07, 2009 11:12:28 AM Page 5 ©
2005 Mitchell Repair Information Company, LLC.

Fig. 87: Connecting DVD Player Wire Connector (2nd Row)
Courtesy of GENERAL MOTORS CORP.
4. Swing the rear part of the assembly to the headliner so that the retainer is seated.
5. Install the two rear retaining bolts.
Tighten:
Tighten the 2 rear retaining bolts to 9 N.m (80 lb in).
NOTE: Refer to Fastener Notice in Cautions and Notices.
2004 Chevrolet Suburban C1500
2004 ACCESSORIES & EQUIPMENT Entertainment - C/K SUV
many waters gallery
Saturday, February 07, 2009 11:12:28 AM Page 6 ©
2005 Mitchell Repair Information Company, LLC.

6. Move the screen to the open position.
7. Install the 2 front retaining bolts (2).
Tighten: Tighten the 2 front retaining bolts to 9 N.m (80 lb in).
8. Install the rear screw cover.
Fig. 88: Installing DVD Player Assembly Retaining Bolts (2nd Row)
Courtesy of GENERAL MOTORS CORP.
2004 Chevrolet Suburban C1500
2004 ACCESSORIES & EQUIPMENT Entertainment - C/K SUV
many waters gallery
Saturday, February 07, 2009 11:12:28 AM Page 7 ©
2005 Mitchell Repair Information Company, LLC.