Crestron CCS-TS-6500-MCK User manual

Crestron CCS-TS-6500-MCK
Mobile Cart Mount for 65” Display
Installation Guide

The specific patents that cover Crestron products are listed at patents.crestron.com.
Crestron and the Crestron logo are either trademarks or registered trademarks of Crestron Electronics, Inc. in the United States and/or other countries.
Other trademarks, registered trademarks and trade names may be used in this document to refer to either the entities claiming the marks and names or
their products. Crestron disclaims any proprietary interest in the marks and names of others. Crestron is not responsible for errors in typography or
photography.
This document was written by the Technical Publications department at Crestron.
©2013 Crestron Electronics, Inc.

Crestron CCS-TS-6500-MCK Mobile Cart Mount for 65” Display
Installation Guide – DOC. 7512A Contents •i
Contents
Mobile Cart Mount for 65” Display: CCS-TS-6500-MCK 1
Introduction ............................................................................................................................... 1
Setup .......................................................................................................................................... 2
Supplied Hardware ......................................................................................................2
Installation ................................................................................................................... 2
Resources...................................................................................................................................6
Further Inquiries .......................................................................................................... 6
Future Updates ............................................................................................................ 6
Return and Warranty Policies ....................................................................................................7
Merchandise Returns / Repair Service ........................................................................ 7
Crestron Limited Warranty.......................................................................................... 7

Crestron CCS-TS-6500-MCK Mobile Cart Mount for 65” Display
Installation Guide – DOC. 7512A Mobile Cart Mount for 65” Display: CCS-TS-6500-MCK •1
Mobile Cart Mount
for 65” Display:
CCS-TS-6500-MCK
Introduction
The CCS-TS-6500-MCK Mobile Cart Mount from Crestron®is designed to support
flat panel displays with up to 65” screens.
CCS-TS-6500-MCK Overall Dimensions
7.58 in
(193 mm)
27.98 in
(711 mm)
67.10 in
(1705 mm)
4.50 in
(115 mm)
4.50 in
(115 mm)
28.42 in
(722 mm)
30.09 in
(765 mm)

Mobile Cart Mount for 65” Display Crestron CCS-TS-6500-MCK
2•Mobile Cart Mount for 65” Display: CCS-TS-6500-MCK Installation Guide – DOC. 7512A
Setup
Supplied Hardware
The hardware supplied with the CCS-TS-6500-MCK is listed in the following table.
Supplied Hardware for the CCS-TS-6500-MCK
DESCRIPTION QUANTITY
Base 1
3” Casters (locking) 2
3” Casters (non-locking) 2
Support Tubes 2
Screw, M10 x 12 mm, Hex 4
Display Adapter 1
Screw, M8 x 10 mm, Set 6
Flat Washer, M10 4
Caster Wrench, 21 mm 1
Allen Wrench, M5 1
Allen Wrench, 5/32” 1
Installation
This section provides installation procedures for the base casters, support tubes and
display adapter. Be sure to review each procedure before starting.
WARNING: The floor structure must be capable of supporting at least 250 lb (114
kg). If not, the floor structure must be reinforced. Proper installation procedure by a
qualified service technician, as outlined in the installation instructions, must be
followed. Failure to do so could result in serious personal injury.
WARNING: Do not attach equipment weighing more than 75 lb (34 kg) above the
60” (~1.5 meter) marked line on the support poles. Doing so may cause the cart to tip
over, resulting in property damage and personal injury.
CAUTION: Do not install on a structure that is prone to vibration, movement or
chance of impact. Doing so could result in damage to the display or damage to the
mounting surface.
CAUTION: Do not install near heater, fireplace, direct sunlight, air conditioning or
any other source of heat. Doing so may result in damage to the display and could
increase the risk of fire.
CAUTION: When used in conjunction with a wall mount used to support a flat
panel display, such as the CCS-TS-6500-WMK, be certain to attach the display
adapter to the center mounting position of the wall mount. It is important to
distribute the weight of the display evenly to avoid damage to the display or damage
to the wall mount.

Crestron CCS-TS-6500-MCK Mobile Cart Mount for 65” Display
Installation Guide – DOC. 7512A Mobile Cart Mount for 65” Display: CCS-TS-6500-MCK •3
Base Caster Installation
To install the base casters:
1. Select the desired location for the CCS-TS-6500-MCK and place the base
on a flat surface.
NOTE: Ensure the two locking casters are attached to the rear legs of the
cart.
2. Insert each caster into the threaded mounting point located on the underside
of the base (refer to the following illustration). Turn each caster clockwise
to tighten. Ensure all four casters are tightened all the way until flush with
the base. Then tighten using the included 21 mm caster wrench.
Base Caster Installation
Locking Caster
Non-Locking Caster
Support Tube Installation
To install the support tubes:
1. Place the base on a flat surface.
2. Slide the support tubes over the mounting clamps on the cart (refer to the
following illustration).
NOTE: To perform the following step, ensure the access holes located at
the ends of the support tubes line up with the set screw holes in the
mounting clamps. The upper holes are used for cable management once the
display has been mounted on the support tubes.
3. Insert the set screws into each hole and tighten with the included M5 Allen
wrench.

Mobile Cart Mount for 65” Display Crestron CCS-TS-6500-MCK
4•Mobile Cart Mount for 65” Display: CCS-TS-6500-MCK Installation Guide – DOC. 7512A
Support Tube Installation
Support Tubes
Base
Allen Wrench, M5
Screws, M10 x 35 mm, Set
Mounting Clamps
Access Holes
Display Adapter Installation
To install the display adapter:
1. Slide the display adapter onto the support tubes.
2. Once the desired height has been determined, secure the display adapter by
tightening the four M8 x 10 mm set screws using the included 5/32” Allen
wrench.
Display Adapter Installation
Display Adapter
Support Tubes
Support Tubes
Allen Wrench, 5/32”

Crestron CCS-TS-6500-MCK Mobile Cart Mount for 65” Display
Installation Guide – DOC. 7512A Mobile Cart Mount for 65” Display: CCS-TS-6500-MCK •5
Wall Plate Installation
To attach a wall plate, such as the CCS-TS-6500-WMK, to the display adapter:
1. Install the display adapter as described on the previous page.
2. Attach the wall plate to the display adapter using the four supplied
M10 x 12 mm hex screws in the four holes at the center position of the wall
plate, as shown.
Wall Plate Installation

Mobile Cart Mount for 65” Display Crestron CCS-TS-6500-MCK
6•Mobile Cart Mount for 65” Display: CCS-TS-6500-MCK Installation Guide – DOC. 7512A
Resources
Further Inquiries
To locate specific information or resolve questions after reviewing this guide,
contact Crestron's True Blue Support at 1-888-CRESTRON [1-888-273-7876] or
refer to the listing of Crestron worldwide offices on the Crestron Web site
(www.crestron.com/offices) for assistance within a particular geographic region.
To post a question about Crestron products, log onto the Online Help section of the
Crestron Web site (www.crestron.com/onlinehelp). First-time users must establish a
user account to fully benefit from all available features.
Future Updates
As Crestron improves functions, adds new features and extends the capabilities of
the CCS-TS-6500-MCK, additional information may be made available as manual
updates. These updates are solely electronic and serve as intermediary supplements
prior to the release of a complete technical documentation revision.
Check the Crestron Web site periodically for manual update availability and its
relevance. Updates are identified as an “Addendum” in the Download column.