DKB HEAT 3 burner bbq User manual

HEAT 3 BURNER BBQ 30 MBAR
OWNERS MANUAL:
USE OUTDOORS ONLY.
Read the manual before using the bbq.
WARNING:
Accessible parts may be very hot.Keep young children away.

2
DANGER
If you smell gas:
1. Shut off gas to the bbq
2. Extinguish any open flame
3. If odor continues keep away from the bbq and immediately call
your gas supplier or your fire department.
Failure to follow these instructions could result in fire or explosion
which could cause property damage,personal injury or death.
DANGER
1. Never operate this bbq unattended.
2. Never operate this bbq within 10 feet(3.05 m) of any other gas
bottle.
3. Never operate this bbq within 25 feet(7.5 m) of any flammable
liquid.
4. Heated liquids remain at scalding temperatures long after the
cooking process.
5. If a fire should occur,keep away from the bbq and immediately call
your fire department.Do not attempt to extinguish an oil or grease
fire with water.
Failure to follow these instructions could result in fire or explosion or
burn hazard,which could cause property damage,personal injury or
death.
Only persons who understand and follow the instructions should use
or service this outdoor bbq.
DANGER
CARBON MONOXIDE HAZARD
• This bbq can produce carbon monoxide which has no odor.
• Using it in an enclosed space can kill you.
• Never use this bbq in an enclosed space such as a camper,tent,car,
or home.
CAUTION
• The use of alcohol,prescription or non-prescription drugs may
impair your ability to property assemble or safety operate the bbq.
• When cooking with oil/grease,fire extinguishing materials shall be
readily accessible.In the event of an oil/grease fire,do not attempt
to extinguish with water.UseType BC dry chemical fire extinguish-
er or smother fire with dirt,sand or baking soda.Immediately call
the fire department.
• In the event of rain or other forms of precipitation while cooking
with oil/grease,cover the bbq immediately and turn off the bbq
burners and gas supply.Do not attempt to move the bbq or bbq.
• When cooking,the bbq must be on a level,stable surface in an area
clear of combustible material.
• Do not leave the bbq unattended.Keep children and pets away
from the bbq at all times.
• Do not move the bbq when in use.
• This bbq is not intended for and should never be used as a heater.
This manual contains important information about the assembly,
operation and maintenance of this outdoor propane/ butane bbq.
General safety information is presented on this page and is also located
throughout these instructions.Particular attention should be paid to
information accompanied by the safety alert symbol
DANGER WARNING CAUTION
Keep this manual for future reference and to educate new users of this
product.This manual should be read in conjunction with the labeling
on the product.
Safety precautions are essential when any mechanical or propane /
butane fueled equipment is involved.These precautions are necessary
when with the respect and caution demanded will reduce the possibili-
ties of personal injury or property damage.
DANGER
EXPLOSION-FIRE HAZARD
• Never store propane/ butane near high heat,open flames,pilot
lights,direct sunlight,other ignition sources or where temperatures
exceed 120 degrees F (49°C).
• Propane/ butane gas is heavier than air and leaking propane / pro-
pane will sink to the lowest level possible.It can ignite by ignition
sources including matches,lighters,sparks or open flames of any
kind many feet away from the original leak.If you smell gas,leave
the area immediately.
• Never install or remove propane / butane tank while outdoor bbq
is lighted,near flame,pilot lights,other ignition sources or while
outdoor bbq is to hot to touch.
• During operation,this product can be a source of ignition.Never
use the bbq in spaces that contain or may contain volatile or
airborne combustibles,or products such as gasoline,solvents,paint
thinner,dust particles or unknown chemicals.Minimum distance
from sides and back of unit to walls or railings is 12 inches (30.5
cm).Do not use under overhead unprotected combustible con-
struction.
• Provide adequate clearances around air openings into the combus-
tion chamber.
• DO NOT use gas bbq indoors or in garages,breezeways,sheds or
enclosed areas.
• Do not obstruct the flow of combustion and ventilation air.
WARNING
We cannot foresee every use which may be made of our products.
Check with your local fire safety authority if you have questions
about use.
Other standards govern the use of fuel gases and heat producing prod-
ucts for specific uses.Your local authorities can advise you about these.
• This bbq is not intended to be installed in or on recreational
vehicles and/or boats.
• Do not alter parts sealed by manufactor.
• Any modification of the bbq may be dangerous.
• Use protective gloves when handling particularly hot components.
DANGER &WARNINGS

3
DANGER
CARBON MONOXIDE HAZARD
• This bbq is a combustion bbq.All combustion bbqs produce car-
bon monoxide (CO) during the combustion process.This product
is designed to produce extremely minute,non-hazardous amounts
of CO if used and maintained in accordance with all warnings and
instructions.Do not block air flow into or out of the bbq.
• Carbon Monoxide (CO) poisoning produces flu-like symptoms,
watery eyes,headaches,dizziness,fatigue and possibly death.You
can not see it and you can not smell it.It’s an invisible killer.If these
symptoms are present during operation of this product get fresh
air immediately!
• For outdoor use only.If stored indoors,detach gas bottle out-
doors.
• Never use inside house,camper,tent,vehicle or other unven-
tilated or enclosed areas;this bbq consumes air (oxygen).Do
not use in unventilated or enclosed areas to avoid endangering
your life.
WARNING
• This product is fueled by propane gas.Propane / butane gas is
invisible,odorless,and flammable.An odorant is normally added to
help detect leaks and can be described as a“rotten egg”smell.The
odorant can fade over time so leaking gas is not always detectable
by smell alone.
• Use only propane /butane gas set up for vapor withdrawal.
• Propane / butane gas should be stored or used in compliance with
local ordinances.
Turn off propane and disconnect gas bottle when not in use.
• Gas bottles must be stored out of reach of children.
• Only use gas bottles in upright position.Never use gas bottles in
horizontal position.
• The gas pipe must be of a type that is approved in relation to
national regulations and requirements and may never be more
than 1.5 meters in length.The gas pipe should be renewed when
national legislation requires this.If the gas bottle is placed outside
the grill the gas pipe should be inserted through the hole in the
base in order to ensure that it is not damaged in the door.
WARNING
BURN HAZARD
• Never leave bbq unattended when hot or in use.
• Keep out of reach of children.
VENTILATION
• When using the grill with gas bottle mounted in the cabinet leave
the door open during operation to ensure sufficient air flow.
DISCLAIMERS
• High temperature can and will affect corrosion-resistant steel to a
give it a slightly darker shade.This condition cannot be reversed
and is not covered by the guarantee.
• Scratches and other damage to the surface treatment will cause
corrosion of the subjacent material. Such damage is not covered
by the product guarantee. Seal any scratches and scrapes with
heat-resistant lacquer stick or spray paint in the correct colour.
• Guarantee is given in accordance with local legislation.
• Keep all connections and fittings clean.Inspect propane /butane
gas bottle and bbq propane / butane connections for damage
before attaching.
• During set up,check all connections and fittings for leaks using
soapy water.Never use a flame.Bubbles indicate a leak.Check that
the connection is not cross-threaded and that it is tight.Perform
another leak check.If there is still a leak,remove the gas bottle and
contact your dealer for service or repairs.
• Use as a cooking bbq only.
• Clean bbq frequently to avoid grease accumulation and possible
grease fires.
SERVICE SAFETY

4
Model Total Heat output Total gas input Injector size
HEAT 3
burner
bbq
12,7 Kwh / 44.000 BTU 900 g/t U-pipe burner:
1,1mm
Side burner:
1,0 mm
For use in Category Supply pressure
Butane Supply pressure Propane
GB I3+(28-30/37) 28-30 mbar 37 mbar
FR I3+(28-30/37) 28-30 mbar 37 mbar
BE I3+(28-30/37) 28-30 mbar 37 mbar
LU I3B/P+(30) 30 mbar 30 mbar
NL I3B/P+(30) 30 mbar 30 mbar
DK I3B/P+(30) 30 mbar 30 mbar
ES I3+(28-30/37) 28-30 mbar 37 mbar
PT I3+(28-30/37) 28-30 mbar 37 mbar
IT I3+(28-30/37) 28-30 mbar 37 mbar
SE I3B/P+(30) 30 mbar 30 mbar
NO I3B/P+(30) 30 mbar 30 mbar
FI I3B/P+(30) 30 mbar 30 mbar
CH I3+(28-30/37) 28-30 mbar 37 mbar
IE I3+(28-30/37) 28-30 mbar 37 mbar
IS I3+(28-30/37) 28-30 mbar 37 mbar
GR I3B/P+(30) 30 mbar 30 mbar
Gas bottles up to and including the 15 kg size may be used.Do not
use gas bottles larger than 15 kg. The bbq can be mounted with a 5kg
cylinder in the trolley.The 5kg cylinder is secured with the enclosed
rubber strap.Cylinders larger than 5kg are placed beside the bbq.
Always treat a gas bottle with care.Never store it on its side because
the valve could become damaged,resulting in a leak which could be
serious.Always use the gas bottle upright.Horizontally,liquid fuel
could get into the supply pipes with damaging results.
Always place the gas bottle in an accessible location to facilitate
changing and emergency shut off.Always disconnect the gas bottle
before moving the bbq.
Never subject a gas bottle to heat.The pressure inside the gas bottle
could build up and exceed the designed safety limit.
Never store gas bottles in cellars,adjacent to open drains and base-
ment areas or below ground level.Propane is heavier than air.If there
is a leak,the gas will collect at low level and become dangerous in the
presence of a spark or flame.
Never store butane or propane gas bottles indoors.
STORAGE
Please be aware that insects and spiders often nest inside the bbq
and could alter and obstruct the gas flow and cause failure and safety
hazards.
Please see cleaning procedure in general and in specific the proce-
dure for cleaning burner pipe.
SERVICING
This gas bbq should not be altered or interfered with,(except for
burner flame adjustment as directed in the instructions).Any adjust-
ment or servicing should be carried out by a qualified engineer.
Regular maintenance is recommended.See maintenance instructions.
GAS BOTTLESPECIFICATIONS
1.
2.
3.
4.
5.
6.
7.
1. Grid
2. Flame shield
3. Grease tray
4. 2 U-pipes
5. 1 side burner
6. Adjusting buttons
7. Door

5
SET UP Remove the compo-
nents from the carton
(Fig.1)
Open the right side door
and install the grease
tray (Fig.2)
Mount the 2 flame
shields (Fig.3)
Install the grid (Fig.4)
The gas pipe must be of
a type that is approved
in relation to national
regulations and require-
ments and may never
be more than 1.5 me-
ters in length.The gas
pipe should be renewed
when national legisla-
tion requires this.If the
gas bottle is placed
outside the grill the gas
pipe should be inserted
through the hole in the
base in order to ensure
that it is not damaged
in the door.(Fig.5)
When using 5 kg gas-
bottle place the bottle in
the bottle hole and use
rubberstraps to fix bottle.
(Fig.6)
Assemble the gas hose
on the pre-assembled
pipe connection or the
1/4 link thread (Fig.7)
INSTALLATION

6
CHANGING A GAS BOTTLE – BUTANE
This bbq may be used with butane at an operating pressure of 28 - 30 mbar.
NEVER use an unregulated gas supply or a regulator for other operating pressures.
WARNING:Changing a gas bottle must be carried out in a flame free environment.
BUTANE gas bottles have various types of connections.
Leak test all connections before operating the bbq.
A) SCREW-ON CONNECTION.
The most important part is the black sealing washer.Always check
that it is present and not damaged when changing gas bottles.Some
screw on connections have a hand wheel to tighten and some require
a spanner to tighten.Tighten firmly (left hand thread).When using a
spanner,do not over tighten as this can damage the washer.
CONNECTING A GAS BOTTLE
Screw-om connection Switch-om connection
1.Check that the gas bottle valve
is OFF by turning clockwise. 1.Remove the orange safety cap by pulling the lanyard out,
then up.
Do not
use tools,
leave the
cap hanging.
2.Remove protective cap and
keep for later use.
3.Inspect the black washer for
damage before connecting.
2.Make sure that:
– All taps on the gas bbq are
closed.
–The switch is
in the off
position.
4.Fit the connecting nut to the
gas bottle,using the correct
spanner or connecting hand
wheel.(Left hand thread).
Do not over tighten Butane
gas bottle connectors.
3.Place the“Quick On”regula-
tor on to the valve and push
down firmly.A“click”sound
should be heard to ensure the
switch is
securely
latched.
5.When gas is required turn the
gas bottle
valve
anti-
clockwise.
4.When gas is required turn the
switch upward to
the ON
(12 o’clock)
position.
B) SWITCH-ON CONNECTION.
No tools are required for this type.On/Off control of the gas supply
is provided by a switch on the Regulator or on a special adapter.If
you use an adapter with an old type threaded regulator,please
ensure that the union nut is tightened firmly to the adapter with a
spanner.
DISCONNECTING A GAS BOTTLE
Screw-om connection Switch-om connection
1.Turn the gas bottle valve OFF
(Clockwise rotation). 1.Turn the switch to the OFF (3 o’clock) position.
2. Turn off the gas taps on the bbq. WAIT until the burner has gone
out.
IFTHE FLAME DOES NOT GO OUT-TURNTHEVALVE OR SWITCH
BACKTO ON.LEAVE THE APPLIANCE ALIGHT AND CALLYOUR
GAS SUPPLIER.
3.NEVER REMOVE the regulator
(or connecting nut) with the
gas bottle valve open.
4.REMOVE the regulator (or
connecting nut) with the
spanner or connecting hand
wheel. (Left hand thread).
3.Remove the“Quick On”regula-
tor by pressing horizontally
on the switch and pulling
upwards at the same time.
4.REPLACE the plug or cap onto
the empty
gas bottle
or part
full cylin-
der if not in
use.
4.REPLACE the seal cap onto the
empty cylin-
der,or part full
gas bottle if not
in use.

7
CHANGING A GAS BOTTLE – PROPANE
This bbq may be used with propane at an operating pressure of 30-37 mbar.
NEVER use an unregulated gas supply or a regulator for other operating pressures.
WARNING:Changing a gas bottle must be carried out in a flame free environment.
Propane gas bottles have various types of connections. If a sealing washer is used in the connection,
check that it is present and not damaged when changing gas bottles. Some connectors have a handwheel
to tighten and some require a spanner to tighten. Always use the correct size spanner and fully tighten,
(left hand thread).
Leak test all connections before operating the bbq.
CONNECTING A GAS BOTTLE
1.Check that the gas bottle valve is OFF by turning clockwise.
Remove protective plug and keep to replace later.
2.Inspect the connection for damage before connecting.
Fit the connecting nut (left hand thread) to the gas bottle.
a. Connecting Nut for use with Spanner – Using the correct
spanner,tighten the connecting nut as tight as possible.
b. Handwheel Connecting Nut – Using hand pressure,tighten
the connecting nut firmly. Do not use a spanner on a hand-
wheel connection.
After fitting the regulator it may have assumed a position out of the
horizontal,this is not important,DO NOTTWISTTHE REGULATOR.
3.When gas is required,turn the
gas bottle valve anti-clockwise.
DISCONNECTING A GAS BOTTLE
1.Turn the gas bottle valve OFF (clockwise rotation). Check that the
burner flame has gone out.
2.Remove the Regulator connecting nut (left hand thread) with
spanner or handwheel. Replace protective plug into valve outlet.
Place empty gas bottle in a safe place.

8
All factory-made connections have been thoroughly tested for gas
leaks and the burners have been flame tested.However,shipping and
handling may have loosened a gas fitting.
AS A SAFETY PRECAUTION:
• TEST ALL FITTINGS FOR LEAKS BEFORE USING
YOUR GAS BARBECUE.
• TESTTHE GAS BOTTLE VALVE FOR LEAKS EACHTIME
THE GAS BOTTLE IS FILLED.
WARNING
• Perform leak test outdoors.
• Extinguish all open flames.
• NEVER leak test when smoking.
• Do not use the outdoor bbq until connection is testet and found
safe.
TOTEST FOR LEAKS
1 Detach shield before leak test of the entire gas system.
2. Connect the flexible tube and regulator to a full gas bottle.
3. Check that all control knobs are turned to“OFF”.
4. Prepare a soap solution of one part water,
one part liquid detergent.
5. Open gas bottle valve all the way.
6. Brush the soap solution on each connection.
7. A leak is identified by a flow of bubbles from the area of the leak.
8. If a leak is detected,close the gas bottle“shut-off”valve,tighten the
connection and retest.
9. If the leak persists,contact your barbecue dealer for assistance.
Do not attempt to operate bbq if a leak is present.
• Before use open battery compartment in the buttom of the bbq
and insert a AA/LR6 battery 1,5 V.
Open the door at the right side of the bbq.
Open the battery door mounted on the rear side of adjusting but-
tons and insert the battery.
• Close battery compartment.
• To light bbq push knob and turn knob onto symbol.
• Keep knob pushed in until flames are stabil and the thermo
safety devise is hot enough to maintain gas flow.
• Please note that while knob is pushed in the clicking sound from
the electronic lightning devise is normal.
When thermo safety devise has switched on turn knob to high
or low setting and you are ready to bbq.
The bbq will be hot during and after use.Use insulated oven mitts
or gloves for protection from hot surfaces or splatter from cooking
liquids.
• NEVER LEAVE GRILL UNATTENDED WHEN HOT OR IN USE.
• KEEP OUT OF REACH OF CHILDREN.
CORRECT GAS FLAME:
A good flame should be blue with minimal yellow tip.Some yellow
tips on flames are acceptable as long as no carbon or soot deposits
appear.
If flames do not comply with below picture clean burner
pipes and try again.
If this does not correct the problem please contact your dealer.
Note:Yellow flame for the first 2 min.is considered normal.
LEAKTESTING ELECTRONIC LIGHTING
SYSTEM
LIGHTING

9
The bbq is equipped with 3 burners which may be adjusted individu-
ally – two U-pipe burners and one side burner respectively.
U-pipe burners may be set to a temperature in the range of 80-350
degrees
The side burner may be set to a temperature in the range of 150-450
degrees
The temperatures are approximate as they can vary with the outside
temperature and the amount of wind present.
The side burner may be used for pots and pans or to close the pores
of meat before finishing the cooking over the U-pipe burners.To close
the pores of the meat choose a high temperature for the side burner
and turn the meat quickly on the grid and move it over the tube
burner to finish cooking.
TO CLEAN
• Make sure grill is cold.
• Detach regulator from gas bottle.
• Wipe clean with soft cloth and mild dish detergent.
Do not use abrasives.
CLEANING OF U-PIPE BURNERS
To clean U-pipe burners loosen connection at burner pipe and detach
pipe.Clean outside of pipe with cloth and inside with a bottle cleaner.
When done attach burner pipe and fasten connection.
After cleaning always perform leak test.
COOKING
TEMPERATURES MAINTENANCE
80-350˚C
80-350˚C
150-450˚C

10
TROUBLE SHOOTING
Problem Possible cause Corrective action
SMELL OF GAS SHUT OFF LP GAS BOTTLE VALVE AT ONCE.
DO NOT USETHE APPLIANCE UNTIL LEAK IS SEALED.
Leak detected at gas bottle,regulator or
other connection. 1. Regulator fitting loose. 2. Gas leak in hose/regulator or control
valves.
1. Tighten fitting and“LeakTest”.
2. See authorized service centre.
Flame flashback beneath control panel. 1. U-pipe burner blocked. 1. Remove burner,clean burner pipe.
See“Cleaning of U-pipe burners”.
Burner will not light. 1. Out of Gas.
2. Ignitor wire(s) not connected.
3. Ignitor electrode misaligned on burner.
4. Ignitor malfunction.
5. Regulator is not fully connected to the
gas bottle valve.
6. Burner valve left open while gas bottle
valve was opened causing excess flow
device to activate.
7. A leak in the system causing the excess
flow device to activate.
8. U-pipe burner blocked.
9. U-pipe burner not aligned with valve
orifice.
10. Orifice blocked.
11. Hose is twisted.
1. Refill Gas bottle.
2. Connect electrode wires.
3. Realign electrode.
4. Use“Manual Lighting”Procedure.
5. Tighten the regulator hand wheel.
6. Close burner and gas bottle valves.
Open gas bottle valve slowly,then open
burner valve to light.
7. Leak test connections to determine loose
fitting. Tighten fitting. Leak test system.
8. Remove burner,clean U-pipe burner.
See“Cleaning of U-pipe burners”.
9. Realign U-pipe burner to orifice.
See“Cleaning of U-pipe burners”.
10. Remove burner,clean orifice with a pin or
fine wire. Do not attempt to drill orifice.
11.Straighten hose.
Decreasing heat,“popping sound”. 1. Out of Gas.
2. U-pipe burner blocked. 1. Refill Gas bottle. 2. Remove burner,clean U-pipe burner.
See“Cleaning of U-pipe burners”.
Hot spots on cooking surface. 1. U-pipe burner blocked. 1. Remove burner,clean U-pipe burner.
See“Cleaning of U-pipe burners”.
“Flare-ups”or grease fires. 1. Excessive grease buildup.
2. Excessive heat. 1. See“Maintenance”. 2. Turn burner controls to a lower setting.
Humming noise from regulator. 1. Gas bottle valve turned on too quickly. 1. Turn gas bottle valve on slowly.
Yellow Flame. 1. Some yellow flame is normal. If it
becomes excessive the U-pipe burner
may be blocked.
2. Burner ports blocked.
1. Remove burner,clean U-pipe burner.
See“Cleaning of U-pipe burners”.
2. Remove burner & clean with soft bristle
brush.

Table BBQ ▲Walmounted gas heater ▲
OTHER
PRODUCTS BY
HEAT cover for 4 burner BBQ ▲HEAT Cover for Walmounted gas heater ▲
HEAT cover for gasbottle ▲HEAT cover for gasbottle ▲
HEAT cover forTable BBQ ▲
HEAT R Gas ▲HEAT R Charcoal ▲Cube 53 BBQ ▲
Firepit ▲Mini Cube ▲4 Burner BBQ ▲

WARNING:
Accessible parts may be very hot.Keep young children away.Use outdoors only.
Read the instructions before using the appliance.
ACHTUNG:
Teile des Gerätes können bei Gebrauch sehr heiss werden.Vorsicht mit Kindern.
Nur im Freien zu verwenden.Unbedingt Gebrauchsanleitung vor Inbetriebnahme beachten.
ADVARSEL:
De tilgængelige dele kan være meget varme.Hold derfor små børn på afstand.
Må kun benyttes udendørs.Læs brugsvejledningen før brug.
OPGELET:
Onderdelen kunnen bij gebruik erg heet worden.Kinderen op afstand houden.
Alleen voor gebruik buitenshuis.Lees de gebruiksaanwijzing alvorens het toestel te gebruiken.
ATTENTION!
Les pièces accessibles peuvent être très chaudes.Tenez les enfants à distance.
N’ulilisez l’appareil qu’à l’extérieur.Lisez les instructions attentivement avant l’utilisation.
ADVERTENCIA:
Las piezas accesibles pueden estar muy calientes.Mantenga alejados a los niños pequeños.
Sólo para uso al aire libre.Lea estas instrucciones antes de usar la barbacoa.
www.lundgren.dk · 3378
DKB Household Switzerland AG Eggbühlstrasse 28 Postfach CH-8052 Zürich www.HEATbbq.com