Dockmate Twist User manual

Wireless Joystick Control
EASY TO USE
EASY TO INSTALL
100% SAFE
2User manual V6

1
V1-04-17
Dockmate (by PPA-Electronics)PostPress Advisersb.v.b.a. –Albert Geudensstraat 4 –2800 Mechelen –BELGIUM
Tel. [phone] –Mob. [phone]
www.ppa-electronics.com –[e-mail] –www.dockmate.eu
VAT: BE 0891.773.260

2
V1-04-17
Dockmate (by PPA-Electronics)PostPressAdvisersb.v.b.a. –Albert Geudensstraat 4 –2800 Mechelen –BELGIUM
Tel. [phone] –Mob. [phone]
www.ppa-electronics.com –[e-mail] –www.dockmate.eu
VAT: BE 0891.773.260
DOCKMATE TWIST transmitter
This device complies with part 15 of the FCC Rules.
Operation is subject to the following two conditions:
(1) This device may not cause harmful interference, and
(2) this device mustaccept any interference received, including interference that may
cause undesired operation.
Changes or modifications not expressly approved by the party responsible for
compliance could void the user’s authority to operate the equipment.
DOCKMATE receiver
Information to the User (Part 15.105 (b))
Note: This equipment has been tested and found to complywith the limits for a Class B digital device,
pursuant to part 15 ofthe FCC Rules. These limits are designed to provide reasonable protection
against harmful interference in a residential installation.This equipment generates, uses and can
radiate radio frequency energy and, ifnot installed and used in accordancewith the instructions, may
cause harmful interference to radio communications.However, there is no guarantee that interference
will not occur in a particular installation. Ifthis equipment does cause harmful interference to radio or
television reception, which can be determined by turning the equipmentoff and on, the user is
encouraged to try to correct the interference by one or more ofthe following measures:
--Reorient or relocate the receiving antenna.
--Increase the separation between the equipmentand receiver.
--Connect the equipment into an outlet on a circuit different from that to which the receiveris
connected.
--Consult the dealer or an experienced radio/TV technician for help.
Changes or modifications not expressly approved by the party responsible for
compliance could void the user’s authority to operate the equipment.
This in particular is applicable for the antenna which has been delivered with the
DOCKMATE receiver.

3
V1-04-17
Dockmate (by PPA-Electronics)PostPressAdvisersb.v.b.a. –Albert Geudensstraat 4 –2800 Mechelen –BELGIUM
Tel. [phone] –Mob. [phone]
www.ppa-electronics.com –[e-mail] –www.dockmate.eu
VAT: BE 0891.773.260
Congratulations on your purchase of a DOCKMATE system. Please read the
following instructions carefully before getting started.
DOCKMATE is a wireless system that enables you to maneuver your ship. With your
fingertips you can control the engines, horn, bow- and stern thruster and anchor
winch.
IMPORTANT:
Readthe Precautionssectionbeforethe firstuse!
Contents
1. What’s in the box ?
2. Precautions
3. Installation
4. Use of the DOCKMATE
5. Charging the batteries
6. Turning on the transmitter
7. Maintenance
8. Troubleshooting
9. Technical specifications
10. Environmental Information
11. Product registration
12. Warranty
13. Declaration of Conformity

4
V1-04-17
Dockmate (by PPA-Electronics)PostPressAdvisersb.v.b.a. –Albert Geudensstraat 4 –2800 Mechelen –BELGIUM
Tel. [phone] –Mob. [phone]
www.ppa-electronics.com –[e-mail] –www.dockmate.eu
VAT: BE 0891.773.260
1. What’s in the box ?
- This user manual
- Installation manual
- The DOCKMATE receiver
- The DOCKMATE TWIST transmitter
- Lanyard
- All necessary wiring cut to length
- Antenna
- Battery charger
2. Precautions
To avoid damage to your DOCKMATE and hurting yourself or others, you
should read the following safety precautions before using the device. Keep
these safety instructions in an area where all users can read them.
When in doubt, contact PPA-Electronics regarding the use or operation of the
unit.
PPA-Electronics is not responsible for injuries or damage caused as a result of
improper use or installation by a non-qualified technician.
2.1. The transmitter is sensitive to magnetic fields. Keep
it at least 1m from any devicesthat generate
magnetic fields like compasses. Otherwise the
operation of the joystick can be disturbed.
2.2. Do not put the transmitter that is switched on
onto the wireless charger. Always switch it off first,
before charging. The charger generates a magnetic
field, that will disturb the joystick when it is turned on.
2.3. Switch off the receiver when malfunctioning.
If you notice smoke, or when an unusual smell escapes from the
receiver, switch it off. Make sure not to get burnt. Continuing using the
device may lead to injury. The receiver should be checked by an
authorized dealer after shutdown.
2.4. Do not disassemble the transmitter or receiver.
Touching the internal parts may lead to injuries. Repairs may only be
performed by licensed technicians.
2.5. Do not use near flammable gases or liquids.
This may cause an explosion or fire.

5
V1-04-17
Dockmate (by PPA-Electronics)PostPressAdvisersb.v.b.a. –Albert Geudensstraat 4 –2800 Mechelen –BELGIUM
Tel. [phone] –Mob. [phone]
www.ppa-electronics.com –[e-mail] –www.dockmate.eu
VAT: BE 0891.773.260
2.6. Keep out of reach of children.
The devices contain small parts which can be swallowed by children.
Beware for suffocation by plastic packaging.
2.7. The DOCKMATE may only be used by persons who have the
necessary skills of maneuvring a yacht.
2.8. Be careful with the lanyard.
Keep it away from small children (choking hazard).
2.9. Do not use the DOCKMATE when the transmitter or receiver have been
immersed in water. The units may be damaged beyond repair. Test
both devices before use with the boat in a safe environment.
Contact your DOCKMATE dealer when any abnormality is detected.
2.10. Make sure you can operate the DOCKMATE like an expert before
actually using it in a crowded harbor.
2.11. In very exceptional circumstances,the communication between the
transmitter and receiver can be disturbed by radio frequency
transmitters in the immediate neighborhood.
2.12. Never use the DOCKMATE if you are not on the ship. Remember that
the use of the DOCKMATE from ashore or the jetty is a criminal offense
in several countries.
2.13. Batteries should be charged as soon as the orange LED signal on the
transmitter lights.
2.14. Please note that when the system is in operation each involuntary push
on the buttons of the transmitter has an action as a result.
2.15. The transmitter and receiver may only be opened by an authorized
technician.

6
V1-04-17
Dockmate (by PPA-Electronics)PostPressAdvisersb.v.b.a. –Albert Geudensstraat 4 –2800 Mechelen –BELGIUM
Tel. [phone] –Mob. [phone]
www.ppa-electronics.com –[e-mail] –www.dockmate.eu
VAT: BE 0891.773.260
3. Installation
The installation has to be done by a qualified engineer.
Our system consists of two major components; a transmitter and a receiver. These
have already been paired so they recognize each other.
3.1. Installation of the receiver
Dimensions :22 x22 x5,4 cm.
Install the receiver in a dry, not too warm area.
Install the receiver free of vibrations.
Place the receiver close to the dashboard, as close as possible to the controls of
the parts to be controlled (throttles, horn, anchor winch, bow- and stern
thrusters).
Please note that one-time settings are needed at the receiver.
(accessible by screwdriver?)

7
V1-04-17
Dockmate (by PPA-Electronics)PostPressAdvisersb.v.b.a. –Albert Geudensstraat 4 –2800 Mechelen –BELGIUM
Tel. [phone] –Mob. [phone]
www.ppa-electronics.com –[e-mail] –www.dockmate.eu
VAT: BE 0891.773.260
4. Use of the DOCKMATE
Activates engines,
thrusters, horn.
.
Joystick
On/Offbutton
Take Command/
Mode Select button
BowThrusterbuttons
Stern Thruster buttons
Link andSatus LED
Indicators
Lanyard
Anchorbuttons

8
V1-04-17
Dockmate (by PPA-Electronics)PostPressAdvisersb.v.b.a. –Albert Geudensstraat 4 –2800 Mechelen –BELGIUM
Tel. [phone] –Mob. [phone]
www.ppa-electronics.com –[e-mail] –www.dockmate.eu
VAT: BE 0891.773.260
We recommend that you always wear the lanyard around your neck while using the
DOCKMATE.
The transmitter has the following features :
LINK LED
Shows the status of connection with the receiver.
Status LED
Shows the status of the transmitter
BUZZER
Indicates no communication or low battery.
Keys anchor winch
By pressing the upper button you lower the anchor.
By pressing the lower button, you go anchor up. When pressed together, you can
choose between windlass 1 and 2 (2 or 4 beeps) if the Dockmatereceiver is fitted
with AnchorX2 module.
On / Off button
Press and hold to turn the transmitter on. Press 3 times quickly or hold for 3s to
shut it off.
NOTE: When this button is pressed other signals are inhibited for safety, so the
boat controls go to neutral, regardless of the position of the joystick.
Take Command button
Pressing this button makes the Dockmate the active steering position.
NOTE: With the Gearbox driver installed it has no effect –Dockmate is always
active then.
Keys bow thruster:
By pressing the left button (port) the bow thruster gives thrust to the right so the
bow is moving to the left.
By pressing the right button (starboard) the bow thruster gives thrust
to the left so the bow is moving to the right.
Keys stern thruster :
By pressing the left button (port) the stern thruster gives thrust to the
right so the stern is moving to the left.
By pressing the right button (starboard) the stern thruster gives thrust
to the left so the stern is moving to the right.
Joystick:
By moving the joystick forwards, both engines (or one in single engine
configuration) are switched forward.
By moving the joystick rearwards both engines are switched to the rear.
Moving the joystick to the left makes both (if installed) thrusters move the boat to

9
V1-04-17
Dockmate (by PPA-Electronics)PostPressAdvisersb.v.b.a. –Albert Geudensstraat 4 –2800 Mechelen –BELGIUM
Tel. [phone] –Mob. [phone]
www.ppa-electronics.com –[e-mail] –www.dockmate.eu
VAT: BE 0891.773.260
the left.
Moving the joystick to the right makes both thrusters move the boat to the right.
Moving the joystickforwards and right in a 45º angle causes the left engine to go
forward and makes the boat steer to the right.
The other 45º angle positions on the joystick work on the same basis.
The Dockmate Twist can be fully programmed by your dealer so that combining
engines and thrusters in any position of the joystick is possible.
Twisting the joystick knob to the right causes the boat to rotate to the right (left
engine switched forward, right engine switched rearward).
Twisting the joystick knob to the left will do the opposite.
Pressing the knob of the joystick will sound the horn.
When a “SpeedCtrl” Module is installed in the Dockmate receiver you can
control the engines throttle by varying the pressure on the joystick.
When the thruster modules with SpeedCtrl are installed in the Dockmate
receiver you can control the thrusters’power by varying the pressure on
the joystick