Dual XR4115 Operating instructions

AM/FM/MP3/WMA Receiver with Detachable Face
XR4115
INSTALLATION/OWNER'S MANUAL

Preparation
MOUNTING SLEEVE
REMOVAL KEYS
TYPICAL FRONT-LOAD DIN MOUNTING METHOD
XR4115 INSTALLATION
Please read entire manual before installation.
Before You Start
•Disconnectnegativebatteryterminal.Consultaqualifiedtechnicianforinstructions.
•Avoidinstallingtheunitwhereitwouldbesubjecttohightemperatures,suchasfrom
directsunlight,orwhereitwouldbesubjecttodust,dirtorexcessivevibration.
Getting Started
•

Insertthesuppliedkeysintotheslotsasshown,andslidetheunitoutofthemounting
sleeve.
•Installmountingsleeveintoopening,bendingtabstosecure.
•Connectwiringharnessandantenna.Consultaqualifiedtechnicianifyouareunsure.
•Certainvehiclesmayrequireaninstallationkitand/orwiringharnessadapter(sold
separately).
•Testforcorrectoperationandslideintothemountingsleevetosecure.
•Snaptrimringintoplace.

10 AMP
AGC Fuse
Rear RCA Output
Antenna Connector
Right (Red)
Left (White)
Wiring Diagram
FUSE
Whenreplacingthefuse,
makesurenewfuseisthe
correcttypeandamperage.
Usinganincorrectfuse
coulddamagetheradio.The
XR4115usesone10amp
AGCfuselocatedin-line.
XR4115 INSTALLATION

Control Locations - Receiver
Release
Preset1/Play/Pause
Power
Volume Knob
Preset2/Intro
Tune/TrackDown
Preset3/Repeat
Tune/TrackUp
EQ
SDSlot
1
2
3
4
5
6
7
8
USBPort
AuxiliaryInput
Mute
Display
AS/PS
Band/Info
Mode
Preset6/FolderUp
Preset 5 / Folder Down
Preset 4 / Random
9
10
11
12
13
14
15
1
XR4115 OPERATION
11
12
20
16
92 43 5 6 7 8
17
18
19
20
10
17 16 15 14 13
1819

XR4115 OPERATION
Control Locations - Remote
Power
Tune/TrackDown
VolumeUp
Select
Volume Down
Tune/TrackUp
AS/PS
Display
Preset3/Repeat
1
2
3
4
5
6
7
8
EQ
Preset6/FolderUp
Mute
Preset 4 / Random
Preset 5 / Folder Down
Preset1/Play/Pause
Preset2/Intro
Mode
Band
9
10
11
12
13
14
15
16
17
18
1 2 4 3 5 6
7
8
9
10
11
12
18
17
16
15
14
13

XR4115 OPERATION
General Operation
Press RELEASEandpullawayfromtheleftsideto
remove.Tore-install,insertrightsideoffaceplatefirst
thenpushleftsidetosecure.
Press or any other button to turn the unit on. Press
againtoturntheunitoff.
Press MODE toselectbetweenAM/FM,USB,SDor
auxiliaryinputmodes.Modesofoperationareindicatedin
thedisplay.SDandUSBmodeswillnotappearunlessan
SDCardisinsertedoraUSBdeviceisconnected.
Theradiofrequency(tunermode)orMP3/WMAtitle/track
information(USBandSDmodes)willbeshownbydefault.
Press DISPtodisplaytheclock.Thedefaultdisplaywill
return after five seconds.
WheninUSBorSDmode,thedisplaywillalternate
betweentracknumber/elapsedtimeandavailableMP3/
WMAinformation,includingfilename,songtitle,artist
name,albumnameandfoldername.
Press RESETuponinitialinstallationorifabnormal
operationoccurs.Resetbuttonislocatedbehindthefront
panel.
Press DISP todisplaytheclock,thenpressandholdDISP
until the hours will flash. Rotate the volume knobtoadjust
the hours. Press the volume knob,andtheminuteswill
flash. Rotate the volume knobtoadjusttheminutes.
Inserta3.5mmconnectorinthefrontpanelAUXport.
Connecttheotherendofthe3.5mmconnectortothe
headphoneoutputofanaudiodevice,MP3player,etc.
Adjustvolumeusingthe volume knob(00-40).
Press EQtoselectbetweenthefollowingpreset
equalizationcurves:FLAT,POP,JAZZ,ROCKandOFF.
Note:AbilitytomanuallyadjustBassandTreblesettings
isdisabledwhenapresetequalizationcurveisselected.
Settingequalization curves to OFF enables manual Bass
andTreble
Faceplate Removal
Power On/Off
Mode
Display
Reset
Set the Clock
Auxiliary Input
Volume
Preset EQ Curves

General Operation
Press the volume knobtoselectbetweenBass,Treble,
Balance,Fader,Loudness,DistanceandStereo.
Press the volume knob until BASappears.
Rotate the volume knobleft/righttoadjust.
(-7minimum/+7maximum)
Press the volume knob until TRE appears.
Rotate the volume knobleft/righttoadjust.
(-7minimum/+7maximum)
Press the volume knob until BALappears.
Rotate the volume knobleft/righttoadjust.
10L (left)to10R(right)."L=R"representsequalbalance.
Press the volume knob until FADappears.
Rotate the volume knobleft/righttoadjust.
10R(rear)to10F(front)"F=R"representsequalbalance.
Press the volume knob until LOUD ON or LOUD OFFappears,
then rotate the volume knobtoselectdesiredoption.
Activatingthisfeaturewillenhancethebassandtreble
frequencieswhenlisteningtomusicatlowvolumes.
Fromtunermodeonly,pressthevolume knob until DX
or LOCALappears,thenrotatethevolume knob to select
desiredoption.SelectingLOCALprogramstheunittostopat
onlystrongstationswhenseektuning.
Fromtunermodeonly,pressthevolume knob until STEREO
or MONOappears,thenrotatethevolume knob to select
desiredoption.SelectingMONOcanimprovelisteningin
areaswithaweakFMsignal.
Press and hold the volume knobuntilBEEPONorBEEP
OFFappears,thenrotatethe volume knob to select desired
option.Activatingthisfeatureprogramstheunittobeepeach
timecertainbuttonsarepressed.
Fromtunermodeonly,pressandholdthevolume knob
untilBEEPONorBEEPOFFappears.Pressthevolume knob
againtodisplayAREAUSAorAREAEURO,thenrotatethe
volume knobtoselectoptionappropriateforyourlocation.
Theclockwilldisplay12-hourAM/PMtimeinUSAfrequency
spacingmode(PM10.00).InEuropeanfrequencyspacing
mode,theclockwilldisplay24-hourtime(22.00).
Audio / Menu
Bass
Treble
Balance
Fader
Loudness
Distance Tuning
Stereo / Mono
Audible Beep
Area Selection
12/24-Hour Clock
XR4115 OPERATION
BASS TREBLE BALANCE
FADER LOUDNESS DISTANCE STEREO

XR4115 OPERATION
Press TUNE
nn
or TUNE
ll
for more than 2 seconds to
seekthenextstrongstation.
Press TUNE
nn
or TUNE
ll
momentarilytochangeone
radiofrequencyatatime.Pressandholdtoadvancequickly.
Press BANDtoselectbetweenFM1,FM2,FM3andAM1,AM2
bands.Sixpresetscanbesavedineachband.
Upto18FMstationsand12AMstationscanbestored.
Tostoreastation,selectthedesiredbandandstation.
Pressandholdthedesiredpresetbuttonformorethan2
seconds.Whenstored,thepresetnumberwillappearinthe
display.Thestationcanberecalledanytimebypressingthe
correspondingpresetbutton.
Press AS/PSformorethan2secondstoautomaticallystore
allstrongeststationsinthecurrentband.
Afterthesixstrongeststationsareset,ascanofeachstored
presetwillbegin.PressAS/PS or TRACK
ll
to cancel.
Press AS/PSmomentarilytoscanpresetstationsforfive
secondseach.Toselectastationduringthescan,press
AS/PSagainorpressthecorrespondingpresetbutton.
Seek Tuning
Manual Tuning
Band
Storing and Recalling
Station Presets
Automatically Store
Stations
Preset Scan
Tuner Operation

XR4115 OPERATION
SD Card / USB Operation
PlayMP3/WMA/WAVfilesfrommanymassstoragedevices
byconnectingthemtotheXR4115'sUSBport.
ToplayMP3/WMA/WAVfilesfromanSDcard,insertanSD
cardintotheXR4115'sSDcardslotwiththelabelfacingleft.
Itwillclickintoplacewhenproperlyinserted.Toremove
thecard,pressinuntilitclicks,thenpulltoremove.
WhenaUSBorSDcarddeviceisfirstconnected,playback
willbeginautomatically.Dependingonthenumberoffiles
andfolders,thedevicemaytakeseveralsecondstobegin
playback.IfnovalidMP3/WMA/WAVfilesaredetected,"NO
FILE"willbedisplayed.
Press TRACK
ll
toskiptothebeginningofthenext
track.PressTRACK
nn
toreturntothebeginningofthe
previoustrack.
Press and hold TRACK
ll
or TRACK
nn
to fast
forwardorreverseatrack.
Press
l
/ II totemporarilystopplayback.
Press
l
/ II againtoresumeplayback.
Press toselectthepreviousfolder.
Press toselectthenextfolder.
Press INTtoplaythefirst10secondsofeachtrack.Press
INT againtocancel.
Press RPTtocontinuouslyrepeatthecurrenttrack.Press
RPT againtocancel.
Press RDMtoplayallthetracksinrandomorder.Press
RDMagaintocancel.
Intro,RepeatandRandomfunctionswillbekeptinmemory
whenselectingbetweenmodesorwhentheunitisturned
off/on.
Connecting a USB Device
(sold separately)
Inserting an SD Card
(sold separately)
Playing Music
Track Select
Fast Forward and Reverse
Pause
Folder Access
Intro
Repeat
Random

XR4115 OPERATION
SD Card / USB Operation
Thefollowingtypesoffilesarecompatible:
•MP3audio
•WMAaudio
•WAVaudio
Thefollowingtypesoffilesarenotcompatible:
•WMAfilesthatareprotectedbyDRM(DigitalRights 
 Management)
•WMAlosslessformat
•MP3PROformat,MP3playlists
•AAC,protectedAAC,M4Aformat
Playbacksequencebeginsintherootfolder.Anyempty
foldersorfoldersthatdonotincludecompatiblefilesare
skipped.Dependingonyoursoftware,theplaybackorder
mayvary.
•Maximumnumberoffiles:9999
•Maximumnumberoffolders:999
•Maximumnumberoffolderlevels(subfolders):8
Note:Ifthenumberoffiles/foldersexceedsthemaximum
outlinedabove,theadditionalfiles/folderswillbeignored.
USBdeviceandSDcardcapacity:<32gigabytes.
DuetothedifferencesofUSBdevicesandSDcards,some
devicesandcardsmaynotbecompatible.USBdevicesand
SDcardsmustbe‘massstorageclass’andformattedtothe
FATorFAT32filesysteminordertoensurecompatibility.
8kHz~48kHz
8kHz~48kHz
44.1kHz
8kbps~320kbps
32kbps~384kbps
1,411kbps
Note:Somefilesmaynotplayorbedisplayedcorrectly
dependingonsamplingfrequencyratesandtransferbit
rates.
Media Compatibility
Playback Order
Playback Capacity
Device Compatibility
Sampling Frequency Rates
MP3
WMA
WAV
Transfer Bit Rates
MP3
WMA
WAV

XR4115 OPERATION
SD Card / USB Operation
Whenafileisaccessed,thedisplaywillalternatebetween
tracknumber/elapsedtimeandavailableMP3/WMA
information,includingfilename,songtitle,artistname,
album name and folder number.
Thisiconwillilluminatewhenthefilenameisdisplayed.
Thisiconwillilluminatewhenthesongtitleisdisplayed.
Thisiconwillilluminatewhentheartistnameisdisplayed.
Thisiconwillilluminatewhenthealbumnameisdisplayed.
Thisiconwillilluminatewhenthefoldernameisdisplayed.
Press toselectthepreviousfolder.
Press toselectthenextfolder.
FolderaccessisonlyavailableonUSBdevicesandSD
cards that include more than one folder.
SongTitle,ArtistandAlbumiconswillonlybedisplayedif
the information is included with the MP3/WMA file.
OnlyMP3fileswithfilenameextension(.mp3)canbe
played.OnlyWMAfileswithfilenameextension(.wma)can
beplayed.OnlyWAVfileswithfilenameextension(.wav)
canbeplayed.Donotattempttoplaynon-audioMP3/WMA/
WAVfileswiththe.mp3/.wma/.wavextension.
Displaying Information
File Icon
Song Title Icon
Artist Icon
Album Icon
Folder Icon
Folder Access
Notes

XR4115 WARRANTY
Troubleshooting
Problem Cause Action
Unit will not turn on
(no power)
Yellowwirenotconnectedorincorrectvoltage
Redwirenotconnectedorincorrectvoltage
Checkconnectionsforproper
voltage(11~16VDC)
Blackwirenotconnected Checkconnectiontoground
Fuse blown Replacefuse
Unit has power
(but no sound)
Speakerwiresnotconnected Checkconnectionsatspeakers
Oneormorespeakerwirestouchingeach
otherortouchingchassisground
Insulateallbarespeakerwiresfrom
eachotherandchassisground
Unit blows fuses
Yelloworredwiretouchingchassisground Checkforpinchedwire
Speakerwirestouchingchassisground Checkforpinchedwire
Incorrectfuserating Usefusewithcorrectrating
"SD ERR" or "USB ERR"
appears on display USBorSDcardcompatibilityissue
Devicecapacitymustbelessthan
32GB.
Filesystemisincompatible-itmust
beFATorFAT32.

XR4115 OPERATION
Specifications
Tuningrange: 87.5MHz-107.9MHz
Usablesensitivity: 10dBf
50dBquietingsensitivity: 25dBu
Stereoseparation@1kHz: >30dB
Frequencyresponse: 30Hz-18kHz
Tuningrange: 530kHz-1710kHz
Usablesensitivity: <42dBu
Frequencyresponse: 80Hz-2kHz
Speakeroutputimpedance: 4~8 ohms
Lineoutputvoltage: 1.5 Volts RMS
Dimensions: 7" x 2" x 5" (178 x 50 x 130 mm)
Designandspecificationssubjecttochangewithoutnotice.
FM Tuner
AM Tuner
General

DUAL CAR STEREOS
XR4115 OPERATION
FCC Compliance
ThisdevicecomplieswithPart15oftheFCCRules.Operationissubjecttothefollowing
twoconditions:
(1)thisdevicemaynotcauseharmfulinterference,and
(2)thisdevicemustacceptanyinterferencereceived,includinginterferencethatmay
causeundesiredoperation.
Warning:Changesormodificationstothisunitnotexpresslyapprovedbytheparty
responsibleforcompliancecouldvoidtheuser’sauthoritytooperatetheequipment.
Note:ThisequipmenthasbeentestedandfoundtocomplywiththelimitsforaClassB
digitaldevice,pursuanttoPart15oftheFCCRules.Theselimitsaredesignedtoprovide
reasonableprotectionagainstharmfulinterferenceinaresidentialinstallation.This
equipmentgenerates,usesandcanradiateradiofrequencyenergyand,ifnotinstalled
andusedinaccordancewiththeinstructions,maycauseharmfulinterferencetoradio
communications.However,thereisnoguaranteethatinterferencewillnotoccurina
particularinstallation.Ifthisequipmentdoescauseharmfulinterferencetoradioor
televisionreception,whichcanbedeterminedbyturningtheequipmentoffandon,the
userisencouragedtotrytocorrecttheinterferencebyoneormoreofthefollowing
measures:
• Reorientorrelocatethereceivingantenna.
• Increasetheseparationbetweentheequipmentandreceiver.
• Connecttheequipmentintoanoutletonacircuitdifferentfromthattowhichthe
receiver is connected.
• Consultthedealeroranexperiencedradio/TVtechnicianforhelp.
CAR AUDIO SYSTEMS