Electrolux WT830EAG User manual

ENGLISH
3
A GENERAL RECOMMENDATIONS.......................................................... Page 6
A1 HANDLING......................................................................................................................Page 6
A2 UNPACKING....................................................................................................................Page 6
A3 DISPOSAL.......................................................................................................................Page 6
A4 TECHNICAL DATA ..........................................................................................................Page 7
B INSTRUCTIONS FOR THE INSTALLER/MAINTENANCE PERSON..... Page 8
B1 WATER CONNECTION...................................................................................................Page 8
B2 ELECTRICAL CONNECTION .........................................................................................Page 8
B3 WARNING MESSAGES DISPLAYED ON THE CONTROL PANEL................................Page 9
B4 DETERGENT/RINSE-AID DISPENSERS AND SETTING..............................................Page 9
B5 SETTING THE DISPENSERS.........................................................................................Page 10
B6 MAINTENANCE...............................................................................................................Page11
C INSTRUCTIONS FOR THE USER........................................................... Page 12
C1 STARTING.......................................................................................................................Page 12
C2 WASH CYCLES...............................................................................................................Page13
C3 OPERATION....................................................................................................................Page 13
C4 END OF WORK AND DAILY CLEANING........................................................................Page 14
C5 WARNING MESSAGES DISPLAYED ON THE CONTROL PANEL................................Page 14
D TROUBLESHOOTING............................................................................. Page 15
GB CONTENTS

4
INSTALLATION DIAGRAM WT830EAG / PW1EAG
Fig. 1.a
IMPORTANT
if the appliance is not installed against a wall, suit-
able protection must be provided for the move-
ment of the hood.
Legend Fig. 1.a
B- Water inlet pipe with Ø 3/4” G fittings
C- Threaded waste outlet pipe connector 1” 1/2 G
(Ø 47 mm)
I- Power supply
S- Pipe inlet for detergents
P- Open / close hood
Q- Unipotential screw

5
ENGLISH
INSTALLATION DIAGRAM WT850EAG / PW2EAG
Fig. 1.b
IMPORTANT
If the appliance is not installed against a wall, suit-
able protection must be provided for the move-
ment of the hood.
Legend Fig. 1.b
B- Water inlet pipe with Ø 3/4” G fittings
C- Threaded waste outlet pipe connector 1” 1/2 G
(Ø 47 mm)
I- Power supply
S- Pipe inlet for detergents
P- Open / close hood
Q- Unipotential screw

6
WARNING
CAREFULLY READ THE INSTALLATION, OPERAT-
ING AND MAINTENANCE INSTRUCTIONS BEFORE
INSTALLING THIS APPLIANCE. INCORRECT
INSTALLATIONS, ADAPTATIONS OR ALTERATIONS
COULD CAUSE DAMAGE TO PROPERTY OR INJURY
TO PERSONS. MALICIOUS DAMAGE, DAMAGE DUE
TO NEGLIGENCE, OR TO FAILURE TO COMPLY
WITH INSTRUCTIONS AND REGULATIONS, OR TO
INCORRECT CONNECTIONS OR UNAUTHORISED
TAMPERING INVALIDATE ANY WARRANTY AND
RELIEVE THE MANUFACTURER OF ALL LIABILITY.
1. Carefully read this instructions booklet, as it con-
tains important advice for safe installation, opera-
tion and maintenance.
Keep this booklet to hand in a safe place for future
reference by other operators.
2. Installation should be carried out by qualified
engineers, in accordance with current regula-
tions and with the manufacturer’s instructions.
3. The appliance should only be used by persons spe-
cifically trained in this operation.
4. Switch off the appliance in the event of failure or
malfunctioning.
Only have the appliance repaired by a service centre
authorised by the manufacturer and ask for original
spare parts.
A1 HANDLING
Use suitable means to move the appliance: a lift truck
or fork pallet trucks (the forks should reach more than
halfway beneath the appliance).
A2 UNPACKING
Wear protective gloves to unpack.
Fig. 2
Lift the appliance using a lift truck (be careful about the
water connections under the appliance), remove the
base and position the appliance where it is to be
installed.
Fig. 3
Remove the protective film and ensure that the pack-
aging material is disposed of correctly in compliance
with the regulations in force in the country where the
product is to be used.
Fig. 4
A3 DISPOSAL
All the packaging materials are environment friendly.
They may be kept without danger, recycled or burned
in a special waste incineration plant. Recyclable plastic
components are marked as follows:
Wood and cardboard components may be disposed of
according to local regulations in force. Appliances that
have reached the end of their service life should be
suitably disposed of. The appliance should be disman-
tled according to regulations in force. All metal parts
are in stainless steel (AISI 304) and are removable.
Plastic parts are marked with the symbol of the mate-
rial.
A GENERAL RECOMMENDATIONS
polyethylene external wrapping film,
instruction bag.
polypropylene top packaging panels,
straps.
polystyrene
foam protective surround elements.
PE
PP
PS

7
ENGLISH
A4 TECHNICAL DATA
Standard cycle time may vary should the inlet water temperature be different from that indicated above.
MODEL WT830EAG / PW1EAG WT850EAG / PW2EAG
Supply voltage: V 400...415- 3N~ 400...415- 3N~
Frequency Hz 50 o 60 50 o 60
Max. power input kW 13,5 / 20,5 (*) 15,5 / 26 (*)
Boiler heating elements kW 10,5 10,5
Tank heating elements kW 7 10,5
Water supply press. kPa [bar] 50...700 [0,5...7] 50...700 [0,5...7]
Water supply temp. °C 50 50
Water supply hardness °fH [°dH] 14 [8] max 14 [8] max
Rinse cycle water consumption l 6,2 7,7
Boiler capacity l 16 16
Tank capacity l 95 110
Standard cycle time with water supply at 50°C sec. 180-360-540 180-360-540
Legal noise level Leq dB(A) <70 <70
Protection ratinge IPX4 IPX4
Net weight kg 200 310
Power supply cable H07RN-F H07RN-F
(*) = If activated by software, coincidence of tank and boiler heating elements.
Table 1
400...415V 3N
CS
13.5 kW 5X4 25A 3P+N
20,5 kW 5X6 40A 3P+N
15,5 kW 5X6 40A 3P+N
26 kW 5X10 50A 3P+N
C = Power supply cable
S = On/Off switch
Table 2