Electrolux 20604 G - 21604 User manual

Gaskookplaat
Table de cuisson
Gas hob
20604 G - 21604 G
11602 G - 21602 G
Gebruiksaanwijzing en Installatievoorschrift
Notice dutilisation et dencastrement
Operating and Installation Instructions
NL
FR
GB

36
ENGLISH GB
Important Safety Information
You MUST read these warnings carefully before installing or using the hob. If you need
assistance, contact our Customer Care Department on 87 5 35 35
Installation
lThis hob must be installed by qualified personnel, according to the manufacturers
instructions and to the relevant British Standards.
lAny gas installation must be carried out by a registered CO GI installer.
lemove all packaging before using the hob.
lEnsure that the gas and electrical supply complies with the type stated on the rating
plate, located near the gas supply pipe.
lDo not attempt to modify the hob in any way.
Child Safety
lThis hob is designed to be operated by adults. Do not allow children to play near or
with the hob.
lThe hob gets hot when it is in use. Children should be kept away until it has cooled.
lChildren can also injure themselves by pulling pans or pots off the hob.
During Use
lThis hob is intended for domestic cooking only. It is not designed for commercial or
industrial purposes.

37
lWhen in use a gas cooking hob will produce heat and moisture in the room in which
it has been installed. Ensure there is a continuous air supply, keeping air vents in
good condition or installing a cooker hood with a venting hose.
lWhen using the hob for a long period time, the ventilation should be improved, by
opening a window or increasing the extractor speed.
lDo not use this hob if it is in contact with water. Do not operate the hob with wet hands.
lEnsure the control knobs are in the OFF position when not in use.
lWhen using other electrical appliances, ensure the cable does not come into contact
with the hot surfaces of the cooking appliance.
lUnstable or misshapen pans should not be used on the hob as unstable pans can
cause an accident by tipping or spillage.
lNever leave the hob unattended when cooking with oil and fats.
lNever use plastic or aluminium foil dishes on the hob.
lPerishable food, plastic items and areosols may be affected by heat and should not
be stored above or below the hob unit.
Service
lThis hob should only be repaired or serviced by an authorised Service Engineer
and only genuine approved spare parts should be used.
Environmental Information
lAfter installation, please dispose of the packaging with due regard to safety and the
environment.
lWhen disposing of an old appliance, make it unusable, by cutting off the cable.
Keep this instruction book for future reference and ensure it is
passed on to any new owner.
{
This appliance is manufactured according to the
following EEC directives:
73/23 EEC - 90/683 EEC - 93/68 EEC -
89/336 EEC - 90/396 EEC,
current edition.

38
Contents
Important Safety Information ......................................................................................... 36
Instructions for the User ................................................................................................ 39
Description of the Hobs ................................................................................................... 39
Operation ........................................................................................................................ 40
Maintenance and Cleaning ............................................................................................. 41
The Hob Top ........................................................................................................ 41
Pan Supports ...................................................................................................... 41
The Burners ........................................................................................................ 41
Something Not Working? ................................................................................................ 42
Service and Spare Parts ................................................................................................. 43
Guarantee Conditions ..................................................................................................... 44
Instructions for the Installer......................................................................................... 45
Engineer technical data................................................................................................... 46
Important safety requirements ........................................................................................ 47
Location .......................................................................................................................... 47
Installation ....................................................................................................................... 48
Gas Connection .................................................................................................. 49
Cut Out Size ........................................................................................................ 50
Building In ........................................................................................................... 50
Building over a cupboard or drawer .............................................................. 50
Building over a kitchen unit with door ............................................................ 51
Fitting the hob to the worktop ........................................................................ 52
Electrical connections ..................................................................................................... 53
Permanent Connection ....................................................................................... 54
Wiring diagram .................................................................................................... 54
Fault Finding ...................................................................................................................55
Preliminary Electrical Systems Check ................................................................. 55
Ignition System / Gas Ignition.............................................................................. 57
Commissioning................................................................................................................ 58
Pressure Testing.................................................................................................. 58
Conversion from Natural Gas to LPG ............................................................................. 59
Guide to Use the instructions
The following symbols will be found in the text to guide you throughout the Instructions:
Safety Instructions
Step by step instructions for an
operation
Hints and Tips
Environmental information
F
{

39
1. Hob Top
2. Rapid Burner
3. Semi-rapid Burners
4. Auxiliary Burner
5. Control nob for bac right burner (semi-rapid)
6. Control nob for bac left burner (semi-rapid)
7. Control nob for front left burner (rapid)
8. Control nob for front right burner (auxiliary)
9. Electric Ignition Push Button
Description of the Hobs
INSTALLATION
Any gas installation must be carried out by a registered CORGI installer, and in
accordance with existing rules and regulations.
The relevant instructions are to be found in the second section of this manual.
Please, ensure that, once the hob is installed, it is easily accessible for the engineer
in the event of a breakdown.
Mod. 21602 G
9
5
6
8
9
3
3
3
12
4
3
5
6
7
8
4
12
7
Mod. 11602 G

40
HO URNERS
To light a burner, turn the relevant control knob anticlockwise to the maximum position. At
the same time push the electric ignition button which is marked with a little spark. Then
adjust the flame as required.
If the burner does not ignite, turn the control knob to zero, and try again.
When switching on the mains, after installation or a power cut, it is quite normal for the
spark generator to be activated automatically.
To ensure maximum burner efficiency, you should only use pots and pans with a flat
bottom fitting the size of the burner used (see table).
Burner minimum maximum
diameter diameter
Large (rapid) 160 mm. 240 mm.
Medium (semi-rapid) 120 mm. 220 mm.
Small (Auxiliary) 80 mm. 160 mm.
Operation
As soon as a liquid starts boiling, turn down the flame so that it will barely keep the liquid
simmering.
If you use a saucepan which is smaller than the recommended size, the flame will
spread beyond the bottom of the essel, causing the handle to o erheat.
Take care when frying food in hot oil or fat, as the o erheated splashes could easily
ignite
If the control knobs become difficult to turn, please contact your local AEG Ser ice
Force Centre.
WHEN THE HO IS FIRST INSTALLED
Once the hob has been installed, it is important to remove any protective materials,
which were put on in the factory.

41
Before any maintenance or cleaning can be carried out, you must DISCONNECT the
hob from the electricity supply.
The hob is best cleaned whilst it is still warm, as spillage can be removed more
easily than if it is left to cool.
The Hob Top
egularly wipe over the hob top using a soft cloth well wrung out in warm water to
which a little wasing up liquid has been added. Avoid the use of the following:
- household detergent and bleaches;
- impregnated pads unsuitable for non-stick saucepans;
- steel wool pads;
- bath/sink stain removers.
Should the hob top become heavily soiled, the following products are recommended:
- For stainless steel hobs use a proprietary stainless steel cleaner.
- For other hobs use Hob Brite or Bar Keepers Friend.
Pan Supports
The pan supports are dishwasher proof. If washing them by hand, take care when
drying them as the enamelling process occasionally leaves rough edges. If necessay,
remove stubborn stains using a paste cleaner.
The urners
The burner caps and crowns can be removed for cleaning.
Wash the burners taps and crowns using hot soapy water, and remove marks with
a mild paste cleaner. A well moistened soap impregnated steel wool pad can be
used with caution, if the marks are particularly difficult to remove.
After cleaning, be sure to wipe dry with a soft cloth.
Maintenance and Cleaning

42
Something Not Working?
If the hob is not working correctly, please carry out the following checks before contacting your
local AEG Service Force Centre.
SYMPTOM
nThere is n spark when lighting the
gas
nThe gas ring burns unevenly
SOLUTION
uCheck that the unit is plugged in and
the electrical supply is switched n
uCheck that the RCCB has n t tripped
(if fitted)
uCheck the mains fuse has n t bl wn
uCheck the burner cap and cr wn
have been replaced c rrectly, e.g.
after cleaning.
uCheck the main jet is n t bl cked
and the burner cr wn is clear f f d
particles.
uCheck the burner cap and cr wn
have been replaced c rrectly, e.g.
after cleaning.
If after all these checks, your hob still does not operate correctly, contact your local AEG Service
Force Centre.
Please note that it will be necessary to provide proof of purchase for any in-guarantee service
calls.
In-guarantee customers should ensure that the above checks have been made as the engineer
will make a charge if the fault is not a mechanical or electrical breakdown.

43
Service and Spare arts
When y u c ntact the Service Centre, they will need the f ll wing inf rmati n:
1. Y ur name, address and p st c de.
2. Y ur teleph ne number
3. Clear and c ncise details f the fault
4. The m del and the serial number (see rating label n the back f this instructi n
b klet)
5. Date f purchase
If y u require spare parts r an engineer c ntact y ur l cal Service F rce Centre by
teleph ning:
0870 5 929 929
Y ur call will be r uted t y ur l cal Service F rce Centre.
F r the address f y ur l cal Service F rce Centre and further inf rmati n ab ut Service
F rce, please visit the website at www.serviceforce.co.uk
CUSTOMER CARE
F r general enquiries c ncerning y ur AEG appliance and f r further inf rmati n n
AEG pr ducts, c ntact ur Cust mer Care Department by letter r teleph ne at the
address bel w r visit ur website at www.aeg.co.uk
Customer Care Department
AEG D mestic Appliances
55 - 77 High Street
Sl ugh
Berkshire
SL1 1DZ
Tel : [phone]*
* calls to this number may be recorded for training purposes.

44
Guarantee Conditions
Standard guarantee conditions
We, AEG, undertake that if within 12 months of the date of the purchase this AEG appliance or any part
thereof is proved to be defective by reason only of faulty workmanship or materials, we will, at our discretion
repair or replace the same FREE F CHARGE for labour, materials or carriage on condition that:
·The appliance has been correctly installed and used only on the electricity or gas supply stated on
the rating plate.
·The appliance has been used for normal domestic purposes only, and in accordance with the
manufacturers operating and maintenance instructions.
·The appliance has not been serviced, maintained, repaired, taken apart or tampered with by any
person not authorised by us.
·All service work under this guarantee must be undertaken by a Service Force Centre. Any appliance
or defective part replaced shall become the Companys property.
·This guarantee is in addition to your statutory and other legal rights.
·Home visits are made between 8.30am and 5.30pm Monday to Friday. Visits may be available
outside these hours in which case a premium will be charged.
Exclusions
This guarantee does not cover:
·Damage or calls resulting from transportation, improper use or neglect, the replacement of any light
bulbs or removable parts of glass or plastic.
·Costs incurred for calls to put right an appliance which is improperly installed or calls to appliances
outside the United Kingdom.
·Appliances found to be in use within a commercial environment, plus those which are subject to
rental agreements.
·Products of AEG manufacture which are not marketed by AEG.
European Guarantee
If you should move to another country within Europe then your guarantee moves with you to your new home
subject to the following qualifications:
·The guarantee starts from the date you first purchased your product.
·The guarantee is for the same period and to the same extent for labour and parts as exists in the new
country of use for this brand or range of products.
·This guarantee relates to you and cannot be transferred to another user.
·Your new home is within the European Community (EC) or European Free Trade Area.
·The product is installed and used in accordance with our instructions and is only used domestically, i.e.
a normal household.
·The product is installed taking into account regulations in your new country.
Before you move, please contact your nearest Customer Care centre, listed below, to give them details of
your new home. They will then ensure that the local Service rganisation is aware of your move and able
to look after you and your appliances.
France Senlis [phone]
Germany Nürnberg [phone]
Italy Pordenone [phone]
Sweden Stockholm [phone]
UK Slough [phone]