Elkay LK3000 Operating instructions

Screwdriver
SAVE FOR CONSUMER
Groove joint pliers (2) 1/2 in Supply Lines
Wrench Sealant TapePlumber's Putty
OPTIONAL 2.2GPM
AERATOR INSERT
INSTALLATION / OWNER'S MANUAL
You choose the flow rate!
This faucet ships with an
eco-friendly 1.5GPM flow regulator
installed.
If you desire higher flow rate, a
2.2GPM flow regulator has also
been included in the box.
Switching the flow regulator is
simple! See the "Flow Regulator
Replacement" section for details.
Important!
Single Handle Kitchen Faucet
Model # LK3000

Make connections to water lines. Use
1/2" I.P.S. faucet connections (1) or
use coupling nuts (3) with 3/8"
O.D.ball-nose riser(2).Use
wrenches totighten connections.
Do not overtighten.
Shut off water supplies. Place spout
through mounting hole in sink.
Secure spout with rubber washer (1),
metal washer (2) and nut (3).
WARNING: Please carefully read and properly follow the instructions for installation found in this manual.
1
STEPS:
3
2
1
Attach the hose to the connection
beneath the faucet by aligning the tabs
on quick connectors. Push quick
connectors housing firmly upward and
snap onto receiving tube tabs. Pull
down moderately to ensure connection
has been made.
If it is necessary to remove the quick
connectors, squeezetabs on hose
between index finger and thumb, then
pull down to disconnect.
Important: After installation is
completed, remove aerator assembly.
Turn on hot and cold water supplies.
Turn handle tofull open position for
one minute. Checkfor leaks.
Replace aerator.
3
2
Place handle assembly through side
hole in sink. Secure handle assembly
with washer (1) and nut (2). Make
sure that the slot on nut is facing up.
Make sure handle is facing forward
and it swings equally in both
directions.
2
1
2-Ø1 3/8" (Ø35mm)

FOR CARE AND MAINTENANCE:
The water in certain areas of the world can be very caustic -
standing water around the product can cause damage. Be
sure to remove standing water with a dry, soft cloth as soon
as possible.
For polished brass finishes, as often as once a week, you
can apply a paste wax or special, non-abrasive, brass
coating (DO NOT APPLY POLISH).
Before applying a protective coating, gently brush the entire
fixture using a soft tooth brush. This will remove any dirt or
deposit build-up.
These simple steps will add temporary protective coating to
yourfaucet and extend the life of the finish.
Failure tofollow care and cleaning will void your warranty.
For additional information, please visit elkayusa.com .
CARE AND CLEANING INSTRUCTIONS
FLOW REGULATOR REPLACEMENT
Thisfaucet ships with a 1.5GPM aerator installed. An
optional 2.2GPM aerator is also included in the box.
To switch the flow rate of the faucet:
1. Disassemble aerator assembly by separating the
aerator shell (1), aerator (2) and washer (3). Remove
existing aerator (2) and install the new aerator.
(2.2GPM=Red, 1.5GPM=Green)
2. Reinstall the aerator assembly.
Congratulations on your purchase of an Elkay product.
Although your product is extremely durable, attention should
be given tothe care, cleaning and maintenance of this
product. Cleaning agents and abrasives may cause damage,
which may result in oxidation and discoloration.
By following these simple guidelines for proper care and
cleaning, it will give you years of enjoyment:
TO CLEAN: Simply wipe gently with a damp cloth and blot dry
with a soft towel. A common rule of thumb is: when you dry off,
dry off your product.
Avoid build-up of soap, toothpaste or mineral deposits, as
these tend to have an adverse effect on the appearance of
the product.
NEVER use cleaning products of any kind on this product -
especiallythose containing ammonia, bleach or alcohol - or
those with anyform of abrasive.
Shut off water supply. Remove set screw plug (1).
With valves in "closed" position, unscrew set screw
(2) and remove handle (3) from valve stem (4).
Loosen the screw (7) from valve stem (4). Loosen
the cap (5) from the cartridge nut (6).
3
1
2
6
4
Loosen cartridge nut (1) by turning it
counter-clockwise and lift out the cartridge (2).Insert
new cartridge and retighten the cartridge nut. Reinstall
the handle.
CARTRIDGE REPLACEMENT
1
7
5
32
2
1

What is not covered:
1. Damage caused by accident, negligence, misuse, abuse, improper
installation or operation or failure tofollow care or installation instructions
enclosed with your product.
2. Damage occurring during shipment of the product (claims must be
presented tothe carrier).
3. Normal wear andtear.
4. Labor charges, costs of removal and reinstallation, and any damages
to other property.
5. All industrial, commercial and business use whose purchasers are
hereby extended a limited lifetime on mechanical parts and 5 years on
finish.
THIS LIMITED WARRANTY IS EXPRESSLY IN LIEU OF ANY
OTHER WARRANTIES, EXPRESSED IMPLIED, ARISING BY LAW
OR OTHERWISE, INCLUDING WITHOUT LIMITATION, ANY
IMPLIED WARRANTY OF MERCHANTABILITY OR FITNESS FOR
A PARTICULAR PURPOSE. THIS LIMITED WARRANTY MAY NOT
BE ALTERED, VARIED, OR EXTENDED, EXCEPT BY A WRITTEN
INSTRUMENT EXECUTED BY ELKAY. THE REMEDY OF REPAIR
OR REPLACEMENT AS PROVIDED UNDER THIS LIMITED
WARRANTY IS EXCLUSIVE. IN NO EVENT SHALL THE
MANUFACTURER BE LIABLE FOR ANY CONSEQUENTIAL OR
INCIDENTAL DAMAGES TO ANY PERSON, WHETHER OR NOT
OCCASIONED BY NEGLIGENCE OF ELKAY, INCLUDING WITHOUT
LIMITATION DAMAGES FOR LOSS OF USE, COSTS PROPERTY
DAMAGE OR OTHER MONETARY LOSS.
Some states do not allowthe exclusion or limitation of incidental or
consequential damages or limitations on how long an implied warranty
lasts, so the above limitations or exclusions may not apply. This
warranty gives you specific legal rights and you may also have other
rights which vary from state to state.
This warranty covers product installed in the United States and Canada.
Elkay
elkayusa.com
©2011 Elkay
Model # LK3000
P99353 (Rev. date: 09/2021)
REPLACEMENT PARTS
ELKAY LIMITED LIFETIME WARRANTY
Elkay warrants that all parts and finishes of the Elkay Residential brand
faucets are free from defects in materials and workmanship for the life of
the product, if purchased after 1996. This warranty covers the
original consumer purchaser of the product only.
If the product should leak or drip during normal use, Elkay will provide,
free of charge, a replacement cartridge. For other defects in material or
workmanship, Elkay will, at its option, supply replacement parts (or if no
longer available a comparable product). Elkay reserves the right to
examine product in question and its installation prior to replacement.
WARRANTY
What you must do to obtain warranty service:
Either write to Elkay, attention Customer Care, 2222 Camden Court,
Oak Brook, IL 60523 or call 1-800-223-5529. Please provide date of
purchase and installation, description of nature of the defect, and
model number or description of model and/or component part.
ELKAY LIMITED LIFETIME WARRANTY
P05138* 1.5GPM Aerator (Green)
P05139* 2.2GPM Aerator (Red)
RP64158 Wearable Ring
P48059 Hose
2000000431 Optional 11.5” Round End Hose
P35304 Rubber Washer
P35305 Metal Washer
P36167 Nut
LK3000 Spout Base
P37142 O-Ring
P46466 Block
1000005444 Optional Round Block
P35299 Washer
P36166 Nut
P37142 O-Ring
P46466 Block
1000005444 Optional Round Block
P29247 Cartridge
LK3000 Handle Base
RP70023 Clip
RP60008 O-Ring
Spout
P36163 Screw
RP80004* Cap
RP70085 Cartridge Nut
P38111 Set Screw
P38112 Set Screw Plug
P01296* Handle
P01297* Handle Kit