Elkay LKAV71 Series Operating instructions

WrenchGroove joint pliers Screwdriver Sealant TapePlumber's Putty
(2) 1/2 in Supply Lines
SAVE FOR CONSUMER
Filtered Beverage Faucet LKAV71F
Part # 2000000474
INSTALLATION / OWNER'S MANUAL
2000000475
2000000476
(LKAV71**)

STEPS:
WARNING: Please carefully read and properly follow the instructions for installation found in this manual.
Before installation, shut off water supplies,
remove old faucet. Remove the nut (4),
metal washer (3) and rubber washer (2)
from shank (1).
4
2
3
1
1
3
4
5
6
7
2
Place faucet (1) through
Secure the faucet (1) to the countertop using
the rubber washer (3) and the metal washer (4)
provided, Tighten the nut (5), do not overtighten.
Then tighten one end of the connector (6) joint
at the bottom of the shank (2) and connect the
other end to the pipe (7).
the hole in countertop.
Green
2
1
2
2
3
4
1
2
2
6
5
Connect the end of the hose (2) with the quick
connector to the angle valve(1). Push the quick
connector with the green tab on the hose (2)
firmly upward and attach it to the receiving block
with green on the angle connector (1). Pull
moderately to ensure the connection has been
made. If it is necessary to remove the quick
connector, squeeze the tabs on the quick
connector and then pull to disconnect.
Connect the other end (3) with inlet indicated by
the tag of the hose (2) into the end (4) with inlet
indicated of the filtration manifold (5). Pull
moderately to ensure the connection has been
made.
Install the filter set (6) onto the filtration manifold
(5). After the thread of the filter set (6) is
completely screwed into the filtration manifold (5),
it cannot be rotated manually.
Connect the bottom of pipe (1) into the
end (2) with outlet indicated of the filtration
manifold (3). Pull moderately to ensure the
connection has been made.
After installation is completed, turn on water
supply, turn the handle in a counterclockwise
direction. Flush the water lines for at least
one minute.
Important: This flushes away any debris that
could cause damage to internal parts. Check
for leaks.
Open
1
1
3
1
2
1
(4N. m
Max)
5

FOR CARE AND MAINTENANCE:
·The water in certain areas of the world can be very caustic -
standing water around the product can cause damage. Be
sure to remove standing water with a dry, soft cloth as soon
as possible.
·For polished brass finishes, as often as once a week, you
can apply a paste wax or special, non-abrasive, brass
coating (DO NOT APPLY POLISH).
·Before applying a protective coating, gently brush the entire
fixture using a soft tooth brush. This will remove any dirt or
deposit build-up.
·These simple steps will add temporary protective coating to
your faucet and extend the life of the finish.
Failure to follow care and cleaning will void your warranty.
For additional information, please visit elkayusa.com .
Congratulations on your purchase of an Elkay product.
Although your product is extremely durable, attention should
be given to the care, cleaning and maintenance of this
product. Cleaning agents and abrasives may cause damage,
which may result in oxidation and discoloration.
By following these simple guidelines for proper care and
cleaning, it will give you years of enjoyment:
TO CLEAN: Simply wipe gently with a damp cloth and blot dry
with a soft towel. A common rule of thumb is: when you dry off,
dry off your product.
·Avoid build-up of soap, toothpaste or mineral deposits, as
these tend to have an adverse effect on the appearance of
the product.
·NEVER use cleaning products of any kind on this product -
especially those containing ammonia, bleach or alcohol - or
those with anyform of abrasive.
CARE AND CLEANING INSTRUCTIONS
CARTRIDGE REPLACEMENT
Loosen cartridge (1) by turning it counter-clockwise
and lift it out. Insert new cartridge. Reinstall the
handle.
Shut off water supply. Remove index (1) and unscrew
the set screw (2) on the handle (3). Remove handle (3)
and loosen the screw (4) from valve stem. Loosen
the inverter (5).
1
2
3
4
5
1

Elkay
elkayusa.com
©2022 Elkay
REPLACEMENT PARTS
P38111 Set Screw
WARRANTY
ELKAY LIMITED LIFETIME WARRANTY
ELKAY LIMITED LIFETIME WARRANTY
Elkay warrants that all parts and finishes of the Elkay Residential brand
faucets are free from defects in materials and workmanship for the life of
the product, if purchased after 1996. This warranty covers the
original consumer purchaser of the product only.
If the product should leak or drip during normal use, Elkay will provide,
free of charge, a replacement cartridge. For other defects in material or
workmanship, Elkay will, at its option, supply replacement parts (or if no
longer available a comparable product). Elkay reserves the right to
examine product in question and its installation prior to replacement.
What you must do to obtain warranty service:
Either write to Elkay Manufacturing Company, attention Consumer Care,
1333 Butterfield Road, Suite 200 Downers Grove, Illinois 60515 or call
1-800-223-5529. Please provide date of purchase and installation,
description of nature of the defect, and model number or description of
model and/or component part.
THIS LIMITED WARRANTY IS EXPRESSLY IN LIEU OF ANY
OTHER WARRANTIES, EXPRESSED IMPLIED, ARISING BY LAW
OR OTHERWISE, INCLUDING WITHOUT LIMITATION, ANY
IMPLIED WARRANTY OF MERCHANTABILITY OR FITNESS FOR
A PARTICULAR PURPOSE. THIS LIMITED WARRANTY MAY NOT
BE ALTERED, VARIED, OR EXTENDED, EXCEPT BY A WRITTEN
INSTRUMENT EXECUTED BY ELKAY. THE REMEDY OF REPAIR
OR REPLACEMENT AS PROVIDED UNDER THIS LIMITED
WARRANTY IS EXCLUSIVE. IN NO EVENT SHALL THE
MANUFACTURER BE LIABLE FOR ANY CONSEQUENTIAL OR
INCIDENTAL DAMAGES TO ANY PERSON, WHETHER OR NOT
OCCASIONED BY NEGLIGENCE OF ELKAY, INCLUDING WITHOUT
LIMITATION DAMAGES FOR LOSS OF USE, COSTS PROPERTY
DAMAGE OR OTHER MONETARY LOSS.
Some states do not allow the exclusion or limitation of incidental or
consequential damages or limitations on how long an implied warranty
lasts, so the above limitations or exclusions may not apply. This
warranty gives you specific legal rights and you may also have other
rights which vary from state to state.
This warranty covers product installed in the United States and Canada.
What is not covered:
1. Damage caused by accident, negligence, misuse, abuse, improper
installation or operation or failure to follow care or installation instructions
enclosed with your product.
2. Damage occurring during shipment of the product (claims must be
presented to the carrier).
3. Normal wear and tear.
4. Labor charges, costs of removal and reinstallation, and any damages
to other property.
5. All industrial, commercial and business use whose purchasers are
hereby extended a limited lifetime on mechanical parts and 5 years on
finish.
Part # 2000000474
(Rev. date: 02/2022)
2000000475
2000000476
(LKAV71**)