EV4 City Quad Instruction Manual

Battery installing guide for EV4 City Quad
Remove all side screws from the
battery cover
Remove the rear main bolt
from the battery cover

Remove the front main bolt
from the battery cover
Lift the battery cover and
remove it completely together
with the controller. The cables
are not connected.

On the front and rear of the battery
casing there are cables going into the
casing. Because the battery is a tight fit
you need to remove the cables with the
rubber protection and move them out of
the way.
The case is now ready to insert the
battery. The foam protection is very
important so make sure you place it
correctly. It’s good to wrap the bottom
of the battery with it before insertion.

This is how the battery looks after it is correctly inserted
Once the battery is inserted reinsert
the cables back into the casing making
sure that the rubber protection is in
place.
Next, attach the casing cover with the
front main bolt (picture on the right).
Tighten the nut for now to keep the
cover in upright position. This will
allow you to connect all cables without
having to hold the cover.

All relevant cables have been marked with numbers to help with proper connection.
Connect them carefully. Cables that don’t have a number don’t need to be connected
to anything.
We recommend using small amount of isolation tape to wrap all of the connectors.
This is to ensure that they don’t disconnect or short circuit during use.
Place the protection foam between the battery and
loose cables. The big sponge is placed in the open area
behind the cables.

Loosen the front main bolt
and close the cover.
Secure the cover with rear main
bolt. Don’t forget to tighten the
front one as well.

If the EV4 does not start please check if all cables were properly connected. Wires that haven’t a number
attached to them don’t need to be connected to anything. If the vehicle still does not start please refer to
the manual to check the fuse or contact the manufacturer for advice.
Last step is to reinsert all of the
side screws and enjoy the ride.