Ezgo RXV ELECTRIC User manual

OWNER’S MANUAL / PŘÍRUČKA MAJITELE
GAS /
ZÁŽEHOVÝ
607748-CZ
RXV FLEET
FREEDOM
®
SHUTTLE
™
2+2
ISSUED FEBRUARY 2008
VYDÁNO V ÚNORU 2008

SAFETY
(NOTES, CAUTIONS AND WARNINGS CONTINUED ON INSIDE OF BACK COVER)
For any questions on material contained in this manual, contact an authorized representative for clarification.
Read and understand all labels located on the vehicle. Always replace any damaged or missing labels.
On steep hills it is possible for vehicles to coast at greater than normal speeds encountered on a flat surface. To prevent
loss of vehicle control and possible serious injury, speeds should be limited to no more than the maximum speed on level
ground. See GENERAL SPECIFICATIONS. Limit speed by applying the service brake.
Catastrophic damage to the drivetrain components due to excessive speed may result from driving the vehicle above
specified speed. Damage caused by excessive speed may cause a loss of vehicle control, is costly, is considered abuse
and will not be covered under warranty.
For towing/transporting vehicle, refer to “TRANSPORTING VEHICLE”.
Signs similar to the ones illustrated should be used to warn of situations that could result in an unsafe condition.
Be sure that this manual remains as part of the permanent service record should the vehicle be sold.
WASH HANDS
AFTER HANDLING!
Battery posts,
terminals and related
accessories contain
lead and lead compounds,
chemicals known
to cause cancer and
reproductive harm.
BATTERY WARNING
WASH HANDS
AFTER HANDLING!
WARNING: Battery posts, terminals and related
accessories contain lead and lead compounds,
chemicals known to cause cancer and reproductive harm.
BATTERIES
CONTAIN LEAD
AND RELATED PARTS
!
<
14
˚
25
%
DO NOT
DRIVE ACROSS
SLOPES IN
EXCESS OF 14˚
Throughout this guide NOTE, CAUTION,WARNING and
DANGER will be used.
ANOTE indicates a condition that should be observed.
A CAUTION indicates a condition that may result in
damage to the vehicle.
A WARNING indicates a hazardous condition
that could result in severe injury or death.
A DANGER indicates a hazardous situation
that could result in death or serious injury.
Observe these NOTES, CAUTIONS,WARNINGS &
DANGERS; be aware that servicing a vehicle requires
mechanical skill and a regard for conditions that could be
hazardous. Improper service or repair may damage the
vehicle or render it unsafe.
Engine exhaust from this product contains
chemicals known, in certain quantities, to
cause cancer, birth defects, or other reproduc-
tive harm.
The exhaust emissions of this vehicles’ engine complies with
regulations set forth by the Environmental Protection Agency
(EPA) of the United States of America (USA) at time of manu-
facture. Significant fines could result from modifications or tam-
pering with the engine, fuel, ignition or air intake systems.
Battery posts, terminals and related accesso-
ries contain lead and lead compounds. Wash
hands after handling.
This spark ignition system meets all requirements of the Cana-
dian Interference-Causing Equipment Regulations.
DANGER
Ce système d'allumage par étincelle de véhicule respecte
toutes les exigences du Règlement sur le matériel brouilleur
du Canada.

Page i
Owner’s Guide
OWNER’S MANUAL AND SERVICE GUIDE
GASOLINE POWERED
FLEET GOLF CARS
RXV GOLF CAR
STARTING MODEL YEAR 2008
ISSUED OCTOBER 2007 REVISED FEBRUARY 2008
E-Z-GO Division of TEXTRON, Inc. reserves the right to make design changes without obligation to make these changes on units previously sold and the infor-
mation contained in this manual is subject to change without notice.
E-Z-GO Division of TEXTRON, Inc. is not liable for errors in this manual or for incidental or consequential damages that result from the use of the material in this
manual.
TO CONTACT US
NORTH AMERICA:
TECHNICAL ASSISTANCE & WARRANTY PHONE: [phone], FAX: [phone]
SERVICE PARTS PHONE: 1-888-GET-EZGO (1-888-438-3946), FAX: [phone]
INTERNATIONAL:
PHONE: [phone], FAX: [phone]
E-Z-GO DIVISION OF TEXTRON, INC., 1451 MARVIN GRIFFIN ROAD, AUGUSTA, GEORGIA USA 30906-3852

Page ii
GENERAL INFORMATION
Owner’s Guide
The use of non Original Equipment Manufacturer (OEM) approved parts may void the
warranty.
Overfilling the battery may void the warranty.
Tampering with or adjusting the governor to permit vehicle to operate at above factory
specifications will void the vehicle warranty.
When servicing engines, all adjustments and replacement components must be per original
vehicle specifications in order to maintain the United States of America Federal and State
emission certification applicable at the time of manufacture.
BATTERY PROLONGED STORAGE
All batteries will self discharge over time. The rate of self discharge varies depending on the
ambient temperature and the age and condition of the batteries.
A fully charged battery will not freeze in winter temperatures unless the temperature falls
below -75° F (-60° C).

SECTION TITLE PAGE NO.
TABLE OF CONTENTS
Page iii
Owner’s Guide
SAFETY.................................................................................................... Inside Covers
GENERAL INFORMATION............................................................................................ ii
SAFETY INFORMATION ...............................................................................................v]
VEHICLE LABELS AND PICTOGRAMS...................................................................... ix
SERIAL NUMBER LOCATION ...................................................................................... 1
BEFORE INITIAL USE....................................................................................................2
CONTROLS AND INDICATORS.................................................................................... 2
KEY SWITCH.........................................................................................................3
DIRECTION SELECTOR .......................................................................................3
ACCELERATOR PEDAL........................................................................................3
COMBINATION SERVICE BRAKE & PARK BRAKE PEDAL.................................3
CHOKE..................................................................................................................3
FUEL GAUGE........................................................................................................3
LOW OIL PRESSURE INDICATOR.......................................................................3
HEADLIGHT SWITCH............................................................................................4
TURN SIGNAL SWITCH........................................................................................4
HORN ....................................................................................................................4
OPERATING THE VEHICLE.......................................................................................... 4
RUN-IN ..................................................................................................................5
COLD STARTING..................................................................................................5
STARTING AND DRIVING.....................................................................................5
STARTING VEHICLE ON A HILL...........................................................................6
COASTING ............................................................................................................6
FUEL......................................................................................................................6
BATTERY ..............................................................................................................7
STARTING A VEHICLE WITH A DISCHARGED BATTERY ..................................7
LABELS AND PICTOGRAMS ................................................................................7
SUN TOP AND WINDSHIELD ...............................................................................7
VEHICLE CLEANING & CARE.......................................................................................7
VEHICLE CLEANING.............................................................................................7
REPAIR...........................................................................................................................8
LIFTING THE VEHICLE.........................................................................................9
WHEELS AND TIRES.....................................................................................................9
TIRE REPAIR.........................................................................................................9
WHEEL INSTALLATION......................................................................................10
LIGHT BULB REPLACEMENT.....................................................................................10
HEADLIGHT BULB REPLACEMENT..................................................................10
TURN SIGNAL BULB REPLACEMENT ...............................................................11
TAIL LIGHT/BRAKE LIGHT BULB REPLACEMENT............................................11
TRANSPORTING THE VEHICLE .................................................................................11
TOWING ..............................................................................................................11
NEUTRAL LOCK..................................................................................................12
HAULING.............................................................................................................12