GENERI MW363 User manual

GENERICOEP.COM
GENERICO ENTERTAINMENT PRODUCTS | 1 Aquarium Drive, Secaucus NJ 07094 ∙ 201.617.8900 |
1
MW363
MINI MOVING HEAD WASH
USER MANUAL

GENERICOEP.COM
GENERICO ENTERTAINMENT PRODUCTS | 1 Aquarium Drive, Secaucus NJ 07094 ∙ 201.617.8900 |
2
INDEX
SUMMARIZATION
3
SAFETY
4
OVERVIEW & PHYSICAL DIMENSIONS
5
MAIN FEATURES
6
DMX CONTROL FUNCTION
7
MENU MAP
8
FUSE REPLACEMENT
9
PHYSICAL INSTALLATION
10
XLR
11
TROUBLESHOOTING
12
TECHNICAL SPECIFICATIONS
13
PLEASE READ THIS MANUAL PRIOR TO OPERATING THE FIXTURE.

GENERICOEP.COM
GENERICO ENTERTAINMENT PRODUCTS | 1 Aquarium Drive, Secaucus NJ 07094 ∙ 201.617.8900 |
3
SUMMARIZATION
THANK YOU FOR PURCHASING OUR MW363 MINI MOVING HEAD WASH FIXTURE. PLEASE
READ THESE INSTRUCTIONS CAREFULLY BEFORE OPERATING THE FIXTURE. OPERATE
ACCORDING TO THESE INSTRUCTIONS TO AVOID ANY POSSIBLE DAMAGE AND
ACCIDENTS CAUSED BY MISUSE.
THIS PRODUCT USES 36 HIGH POWER 3 WATT RGB LEDS. INTERNATIONAL STANDARD
DMX 512 SIGNAL.
PACKING LIST
MW363 MINI MOVING HEAD WASH FIXTURE
POWER CABLE
DMX CABLE
(2) MOUNTING BRACKETS
USER MANUAL

GENERICOEP.COM
GENERICO ENTERTAINMENT PRODUCTS | 1 Aquarium Drive, Secaucus NJ 07094 ∙ 201.617.8900 |
4
SAFETY
SAFETY NOTES
! CHECK WITH TRAINED TECHNICIAN BEFORE ATTEMPTING ANY REPAIR. MOST REPAIRS
SHOULD BE PERFORMED BY A QUALIFIED REPAIR TECHNICIAN TO AVOID DAMAGING
THE UNIT.
! ALWAYS MAKE SURE TO DISCONNECT FROM POWER SOURCE BEFORE MOVING OR
ATTEMPTING TO TROUBLESHOOT OR REPAIR.
! AVOID DIRECT EYE EXPOSURE TO THE FIXTURE WHEN IT IS ON.
SAFETY INSTRUCTION
● MAKE SURE THE POWER SUPPLY VOLTAGE IS CONSISTENT WITH THIS FIXTURE. VERIFY
THAT VOLTAGE IS IN THE CORRECT RANGE FOR THE OPERATING PARAMETERS OF THIS
UNIT.
● BEFORE USING THE FIXTURE, CHECK THAT ALL POWER DISTRIBUTION EQUIPMENT AND
CABLES ARE IN GOOD WORKING CONDITION AND RATED FOR THE CURRENT
REQUIREMENTS OF ALL CONNECTED DEVICES.
● ALWAYS GROUND (EARTH) THE FIXTURE ELECTRICALLY.
● AVOID ANY IMPACT TO THE FIXTURE WHEN MOVING OR INSTALLING.
●BEFORE INSTALLATION, PLEASE CHECK THAT THE FIXTURE HAS BEEN RECEIVED IN
GOOD CONDITION AND HAS NO VISIBLE DAMAGE.
●THIS FIXTURE IS DESIGNED FOR INDOOR USE ONLY (IP20); WORKING TEMPERATURE
MUST BE KEPT UNDER 40° C/ 104° F.
●THE FIXTURES MAY BE MOUNTED IN ANY SAFE POSITION (OTHER THAN SIDEWAYS)
PROVIDED THERE IS ADEQUATE ROOM FOR VENTILATION. MAKE SURE THERE ARE NO
FLAMMABLE OR EXPLOSIVE ITEMS WITHIN 0.5 METERS/ 1.75 FEET.
●THE FIXTURES ON A SERIAL DATA LINK MUST BE DAISY CHAINED IN ONE SINGLE LINE.
TO COMPLY WITH THE EIA-485 STANDARD, NO MORE THAN 32 FIXTURES SHOULD BE
CONNECTED TO ONE DATA LINK. MAXIMUM RECCOMENDED SERIAL LINK DISTANCE IS
500 METERS / 1640 FEET.

GENERICOEP.COM
GENERICO ENTERTAINMENT PRODUCTS | 1 Aquarium Drive, Secaucus NJ 07094 ∙ 201.617.8900 |
5
OVERVIEW & PHYSICAL DIMENSIONS

GENERICOEP.COM
GENERICO ENTERTAINMENT PRODUCTS | 1 Aquarium Drive, Secaucus NJ 07094 ∙ 201.617.8900 |
6
MAIN FEATURES
36 X 3 WATT RGB LEDS
PAN: 540 / TILT 270
VARIABLE ELECTRONIC SHUTTER (STROBE)
VARIABLE MOTORIZED FOCUS
VARIABLE ELECTRONIC DIMMING (0-100%)
RGB MIXING (12X 3 WATT RED, 12X 3 WATT GREEN, 12X 3 WATT BLUE)
REMOTE FIXTURE RESET & VECTOR SPEED CHANNEL
BUILT-IN MACROS VIA DMX (AUTOMATED & SOUND)
STANDARD DMX-512 COMMUNICATION PROTOCOL

GENERICOEP.COM
GENERICO ENTERTAINMENT PRODUCTS | 1 Aquarium Drive, Secaucus NJ 07094 ∙ 201.617.8900 |
7
DMX CONTROL FUNCTION
THIS FIXTURE HAS A 12 CHANNEL MODE.
12 CHANNEL MODE
Channel
Value
Function
1
000-
255
Pan
2
000-
255
Tilt
3
000-
255
Speed (Fast-Slow)
4
000-
255
XY Macros
5
000-
255
XY Macros (Fast-Slow)
6
Strobe
000-
008
No Function
009-
016
Open
017-
249
Strobe (Slow-Fast)
250-
255
Open
7
Dimmer
000-
255
Closed-Open
8
000-
255
Red
9
000-
255
Green
10
000-
255
Blue
11
000-
255
LED Macros
12
000-
255
Reset

GENERICOEP.COM
GENERICO ENTERTAINMENT PRODUCTS | 1 Aquarium Drive, Secaucus NJ 07094 ∙ 201.617.8900 |
8
MENU MAP
DMX MODE: Select channel 1 - channel 512
Master mode: Master 1
Master mode: Master 2
Master mode: Master 3
Master mode: Master 4
Master mode: Master 5
Master mode: Master 6
Master mode: Master 7
Master mode: Master 8
Slave mode: slave 1
Slave mode: slave 2
Slave mode: slave 3
Slave mode: slave 4
Pan mode: Positive

Pan mode: Negative
Tilt mode: Positive

Tilt mode: Negative
LED READOUT: Default

LED READOUT: Inverted
RESET
RESTORE

GENERICOEP.COM
GENERICO ENTERTAINMENT PRODUCTS | 1 Aquarium Drive, Secaucus NJ 07094 ∙ 201.617.8900 |
9
FUSE REPLACEMENT
FUSE IS LOCATED IN A COMPARTMENT JUST BELOW THE IEC CONNECTOR. A SPARE FUSE
IS INCLUDED INSIDE THE COMPARTMENT.
WITH A FLAT HEAD SCREWDRIVER, WEDGE THE FUSE HOLDER OUT FROM ITS HOUSING.
REMOVE THE OLD FUSE FROM THE HOLDER AND REPLACE WITH A 3A 250V FUSE.
REPLACE THE FUSE HOLDER. RECONNECT POWER.

GENERICOEP.COM
GENERICO ENTERTAINMENT PRODUCTS | 1 Aquarium Drive, Secaucus NJ 07094 ∙ 201.617.8900 |
10
PHYSICAL INSTALLATION
THIS FIXTURE MAY BE PLACED ON A HORIZONTAL SURFACE SUCH AS A STAGE OR
CLAMPED TO A TRUSS OR SIMILAR RIGGING STRUCTURE IN ANY ORIENTATION USING A
RIGGING CLAMP. USE A “C” OR “O” TYPE CLAMP. (CLAMPS SOLD SEPERATELY).
WHEN SUSPENDING THE FIXTURE ABOVE GROUND LEVEL, VERIFY THAT THE STRUCTURE
CAN HOLD AT LEAST 10 TIMES THE WEIGHT OF ALL INSTALLED DEVICES.
NEVER INSTALL IN A LOCATION WHERE FIXTURE WILL BE EXPOSED TO RAIN, HIGH
HUMIDITY, EXTREME TEMPERATURE CHANGES, OR HAVE RESTRICTED VENTILATION.
VERIFY THAT ALL EXTERNAL COVERS AND RIGGING HARDWARE ARE SECURELY
FASTENED AND USE AN APPROVED MEANS OF SECONDARY ATTACHMENT SUCH AS A
SAFETY CABLE.
SAFETY CABLE ATTACHMENT POINT
MOUNTING BRACKET

GENERICOEP.COM
GENERICO ENTERTAINMENT PRODUCTS | 1 Aquarium Drive, Secaucus NJ 07094 ∙ 201.617.8900 |
11
XLR
XLR CABLE
THE STANDARD CONNECTION IS VIA 5 PIN XLR WIRED AS BELOW:
XLR
Signal
Pin 1
Signal Common
Pin 2
DMX Data -
Pin 3
DMX Data +
Pin 4
NC
Pin 5
NC

GENERICOEP.COM
GENERICO ENTERTAINMENT PRODUCTS | 1 Aquarium Drive, Secaucus NJ 07094 ∙ 201.617.8900 |
12
TROUBLESHOOTING
Problem CHECK
Make certain it is plugged in to a viable power source.
Check the power switch? Is it on?
Check the fuse
Is the DMX cable connected correctly?
Check if the DMX controller is outputting DMX
Check the DMX Cable for damage
Isolate fixture and test using DMX tester & different
cable.
Check if the lights is in DMX mode（d001）
Connect to power. Check if the switch and the
transformer has power
Check if the power input of the IC board is normal
Check the connections to the display
Change the main board to see if it is normal.
Change the display
Connect to power. Check if the switch and the
transformer has power
Check if the power input of the IC board is normal
Check the connections to the display
Change the main board to see if it is normal.
Change the display
Check if any LEDs are loose
Use a multimeter to check the LEDs
Check whether current limiting resistor is normal or
not
Check constant current IC is normal or not (compared
with the normal IC)
Check the switches to ensure they are set correctly.
Change the IC control board
Single color LED always
bright/not bright
Fixture does not light
DMX isn’t functioning
Display not on
LEDs do not light
Some of the LEDs do not
light
NOTE: ONLY PROFESSIONALS SHOULD TROUBLESHOOT & REPAIR THE FIXTURE.

GENERICOEP.COM
GENERICO ENTERTAINMENT PRODUCTS | 1 Aquarium Drive, Secaucus NJ 07094 ∙ 201.617.8900 |
13
TECHNICAL SPECIFICATION
RATED VOLTAGE: 100~240V
RATED FREQUENCY : 50/60HZ
POWER : 150W
LED: 36 X 3 WATT RGB LEDS
COLOR MIXING : RGB
BEAM ANGLE : 25°
PAN : 540°
TILT : 270°
CHANNELS : 12
CONTROL MODE : DMX512, MASTER/SLAVE, SOUND ACTIVATED
IP RATING : IP20
WORKING ENVIRONMENT : INDOOR
MAXIMUM ENVIRONMENT TEMPERATURE : -+40℃/104°F
DIMENSIONS : L25CM*W25.5CM*H36CM / 9.84IN*10.04IN*14.17IN
WEIGHT : 3 KG/6.62 LBS
REV 7/18//2012