GLOWEN GLRB 1.1 User manual

INSTRUCTIONS
FOR USE
Glowen Raptor Gas
burner Model: GLRB 1.1
2022
www.glowen.si

TABLE OF CONTENTS
IMPORTANT INFORMATION ...........................................................................................1
GENERAL INSTRUCTIONS ............................................................................................ 2
Before first use
FIRE ................................................................................................................ 3
CARBON MONOXIDE................................................................................................. 3
PRODUCT INFORMATION ............................................................................................4
GAS SAFETY......................................................................................................... 5
CONNECTING THE GAS PART .........................................................................................7
GAS LEAK ...........................................................................................................9
FIRST FIRING ....................................................................................................... 10
CLEANING & MAINTENANCE. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
STORAGE ...........................................................................................................11
SAFE USE ...........................................................................................................12
WARRANTY .........................................................................................................13
What does the warranty cover?
What does the warranty not cover?
Warranty Claims
EU DECLARATION OF CONFORMITY ................................................................................. 14
01
02
03
04
05
06
07
08
09
10
11
12
ENGLISH

1
01
IMPORTANT
IMPORTANT INFORMATION
ENGLISH
Your safety is most important, therefore read the attached
instructions carefully and save them for later use.
Glowen Raptor is designed for outdoor
use, therefore do not use it indoors. Never use the oven without supervision.
Do not use the oven in strong wind. Always use heat-resistant gloves
when using the oven.
Do not put hands and other limbs
inside the oven.
Do not touch the exterior of the oven
while using it.
Blowing into the oven is
strictly forbidden.
Keep children and animals away
from the oven while using it.

2
WARNING
02
Failure to follow the instructions and observe the alerts provided in this operating
manual could result in serious bodily injury or damage to property. Please read the
complete manual before assembly or operating your Glowen Raptor.
GENERAL INSTRUCTIONS
This appliance has to be installed on a secure
level base prior to use.
WARNING:
This appliance will become very hot, do not move
it during operation.
ENGLISH
BEFORE FIRST USE
Before starting with your culinary creations with the new Glowen Raptor
oven, carefully read the instructions to familiarize yourself with the
oven’s features and save them for any questions you may have later.

3
03
CARBON MONOXIDE
Carbon monoxide is a colorless, flammable,
and highly toxic odorless gas.
It is the main product of incomplete
combustion of carbon and carbon-
containing compounds.
May cause symptoms such as headache,
dizziness, weakness, nausea, vomiting…
Therefore, please note that the stove is
intended for OUTDOOR USE and should
never be used indoors.
FIRE
Most fires are caused by a grease build-
up or (if using gas) an improper gas
connection. Ensure all people and pets are
kept as far away as possible.
If you are able, turn the gas off at the
cylinder or the on/off valve.
Use a fire extinguisher if possible.
If water is the only fire retardant available,
thoroughly soak the area around the
appliance.
When spraying water on the Raptor itself,
do not use a strong jet of water, as this may
cause splashing of burning grease.
ENGLISH

4
04
PRODUCT INFORMATION
Glow Seven d. o. o.
Ljutomerska cesta 22, 2270 Ormož, Slovenia
Appliance Name: Glowen Raptor Gas Burner
Model/Type No.: GLRB 1.1
Trade Name: Glowen Raptor
Total nominal heat input: 8,2 kW (600 g/h) for I3B/P(30), I3+(28-30/37)
8,5 kW (621 g/h) for I3B/P(50)
Injector Size: 1,5 mm 1,5 mm 1,5 mm 1,25 mm
Gas Category: I3+(28-30/37) I3B/P(30) I3B/P(50)
Gas Type: Butane Propane Butane, propane or their mixture Butane, propane or their mixture
Gas Pressure: 28-30 mbar 37 mbar 28-30 mbar 50 mbar
Destination
Countries:
BE, FR, IT, LU, IE, GB, GR, PT, ES, CY, CZ, LT,
SK, CH, SI, LV
LU, NL, DK, FI, SE, CY, CZ, EE, LT, MT, SK,
SI, BG, IS, NO, TR, HR, RO, IT, HU, LV AT, DE, SK, CH, LU
Pin code:
Use outdoors only. Read the instructions before using the appliance.
WARNING! Do not use spirit or petrol for lighting or re-lighting!
1837-22
1837GU0415
ENGLISH

5
GAS SAFETY
05
Check the stove and burner before use.
If the device shuts down, reduce the gas
supply to the regulator and turn off the gas
valve, wait 5 minutes and try again.
The warranty does not cover damage
caused by fat.
If a fat fire occurs, immediately shut off the
gas supply to the cylinder and remove all
food from the oven.
Before use, check the valves for leaks
before each removal.
Do not disconnect
the gas connections
during the operation
of the appliance.
Check all pipes and
connections for gas
installations.
Do not store gas
cylinders indoors.
Keep the fuel hose
away from heated
surfaces or direct
sunlight.
ENGLISH

6
ENGLISH
Do not use any
additional flammable
substance while
operating with gas.
A regulator which
complies with
EN16129 must be
fit between the gas
cylinder and the oven.
Maximum length of
hose cannot exceed
1.5m. In Finland, hose
length cannot exceed
1.2m.
Do not touch! The
Raptor can get
extremely hot when
in operation. Wear
protective gloves.
Do not position the
gas cylinder under
the oven.
National requirements
state how often to
replace the hose.
Please review this for
your area.
Do not connect
multiple gas cylinders
to Raptor. Store a
spare with in the
same vicinity.
Do not use natural
gas! It can damage
the oven.
Make sure the flexible
hose is not twisting
when the oven is in
operation.
Keep the gas cylinder
out doors in it’s up
right position.
Never use a naked
flame to check for gas
leaks.
Never fill the cylinder
beyond 80 percent
full.

7
CONNECTING THE GAS PART
06
2. Please make sure you turn the tap of gas burner in
clockwise direction until it stops.
4. Please make sure you put the tube to the end.
3. Push the tube on the tap inlet.
5. Tighten the clamp in clockwise direction.
1. Please make sure you have the suitable gas and gas regulator for your country.
ENGLISH

8
6. Push the tube on the gas regulator.
8. Tighten the clamp in clockwise direction.
7. Make sure you push the tube to the end.
9. Screw thread gas regulator.
Ensure the gas is turned off
on the bottle by twisting the
handle anticlockwise. Whilst
aligning the regulator with
the gas bottle twist the handle
and ensure a tight fit has been
made.
ENGLISH

9
10. When all connections are made and tested with water and soap you can
open the walve on the gas bottle.
11. When the gas is open test for the leaks.
Use a mixture of soap and water to test for
gas leaks. Apply the mixture to all joints
and areas where any cracks appear. If no
bubbles appear on the joints, the joints
are well sealed. If bubbles appear, the
tightness is poor, and you need to fill them
better.
Each time you disconnect and reconnect
the gas connection, you must check
all gas connections. Do not ignite the
burner when checking for leaks. Do not
use an open flame to check for leaks.
Replacement of the gas cylinder must be
carried out away from any ignition sources.
Recheck for leaks with soap and water
solution. If leakage persists after re-
tightening, turn off the gas and DO NOT
USE THE OVEN.
GAS LEAK
07 ENGLISH

10
FIRST FIRING
08
TIP For the rst ring after purchasing we highly recommend ring the oven at it’s lowest
temperature for 30 minutes before setting it to high ame this will help cure the oven.
12. Screw the bolts in three holes like on the picture.
14. Push the lighter in the hole on the gas burner.
13. Light the lighter outside the oven.
15. Make sure the lighter is burning. Then twist the
tap anticlockwise.
ENGLISH

11
CLEANING & MAINTENANCE
09
For the gas burner to operate at optimum efficiency, we recommend cleaning and
inspecting the burner before each use. Remove the cooled burner and clean it with a
brush and blow it out with the help of compressed air.
General cleaning: Make sure the holes on the picture are always clean from food and
other things.
STORAGE
Glowen Raptor provides an outstanding
modern baking experience for you, your
family, and your friends. Handle the stove
with all the love and tenderness because
only then will it last forever.
Where do I store Glowen Raptor?
Glowen Raptor is stored in a dry and
closed place to protect against weather
conditions. Glowen Raptor must be
completely dry and cooled before storage.
Suppose you are near the sea or store
saltwater, Glowen Raptor indoors / sheds,
so sea salt does not damage the oven.
No chemicals. No
abrasive methods. No
fuss.
Protect the Raptor
from the adverse
weather. including
rain and high winds.
ENGLISH

12
SAFE USE
10
• Glowen Raptor should only be used outdoors or in a well-ventilated area (terraces, balconies).
• Do not use in a tent.
• Glowen Raptor is not suitable for use in vehicles or trunks of any vehicle.
• Do not use the Glowen Raptor on enclosed balconies.
• Place the stove on a flat, non-combustible surface with no residual combustible materials.
• Do not attempt to use burners with other stoves. This means voiding the warranty.
• Do not use burners not owned by Glowen Raptor or unapproved third-party burners to burn Glowen Raptor stoves.
• Before using gas burners, check all components for damage.
• Tighten all gas fittings with a wrench and do not overtighten.
• Before using the oven, check the joints for leaks with soap. Never check for leaks with a free flame.
• Before use, make sure that the burner is securely and correctly installed.
• Never try to disconnect the gas regulator during use.
• Do not remove burners while using.
• Do not smoke near the stove and gas supply.
• It is always necessary to use a gas regulator for gas supply.
• Do not store gas cylinders indoors.
• Always keep gas cylinders upright.
• Do not use more than one cylinder for gas supply.
• Do not use natural gas, only propane or butane.
• Do not use additional flammable substances.
• Do not store flammable materials near the Glowen Raptor.
• Do not attempt to insert flammable liquids into the oven during operation.
• Make sure that the gas hose is not twisted during operation.
• Always wear heat-resistant gloves when using the Glowen Raptor oven.
ENGLISH

13
WARRANTY
What does the warranty cover? What does the warranty not cover? Warranty Claims
11
The warranty applies to the Glowen Raptor
Burner.
This warranty is not transferable and
only applies to the original purchaser. An
original invoice is required to enforce the
warranty.
Glow seven d.o.o. guarantees that the
products (hereinafter the product) will
not have defects in workmanship and
materials.
The warranty is valid for 2 years from the
date of purchase. If Glow seven d.o.o finds
irregularities, the product or spare part will
be replaced free of charge.
We ensure maintenance and provision
of spare parts for the product within the
statutory period (Article 18 of the Slovenian
Consumer Protection Act).
The warranty does not apply in cases
where the customer has not complied
with the enclosed instructions.
The warranty does not cover damage or
defects resulting from normal wear and
tear of the product, misuse, negligence,
improper maintenance, accident or
discolouration of the product. The warranty
does not cover damage to the product due
to use for purposes other than intended.
It also does not apply if the product has
been tampered with by an unauthorized
or unprofessional person.
The warranty does not cover damage
to products purchased at unauthorized
points of sale, including third parties
and retailers from Bolha, Amazon, eBay
websites.
The warranty does not apply to clay stones.
All warranty claims must be submitted
directly to Glow seven d.o.o, namely to
[e-mail] with the subject “Warranty
claim during the warranty period” with
the original invoice attached and an
explanation of the defect on the product.
Incomplete returns will not be accepted.
When Glow seven d.o.o. receives your
warranty claim, it confirms or rebuts
it (usually 7-10 business days). After
confirming the complaint, you will be
able to return the damaged product at
the expense of the company by registered
mail. You are responsible for the customs
duties and taxes that arise. Glow seven
d.o.o. is not responsible for products lost
during transport.
ENGLISH

14
EU DECLARATION OF CONFORMITY
12
Manufacturer’s Name: Glow Seven d.o.o.
Manufacturer’s Address: Ljutomerska cesta 22, 2270 Ormož, Slovenia
Product: Glowen Raptor plinski gorilnik
Model(s)/Type(s): GLRB 1.1
Tradename: Glowen Raptor Gas burner
Is in conformity with the following harmonized standards have been
applied: EN498:2012
ENGLISH

STAY WITH US!
Follow us on our social networks
We love to see what you create in our ovens, therefore feel free to
tag us when posting your photos with #glowen #glowenoven
If you have any questions or comments,
email us at [e-mail]
glowenoven&
www.glowen.si